HomeMy WebLinkAboutProduct Approvalfftoricane Mastor by DAB Mdl# 824
+50psf -bopsf
Max. size 9Y' x I &`o"
MIAM MIAMI -DADS COUNTY
PRODUCT CONTROL SECTION
11805 SW 26 Street, Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES (RER) Miami, Florida 33175-2474
.BOARD AND CODE ADMINISTRATION DIVISION T(786)315-2590 F(786)315-2599
NOTICE OF ACCEPTANCE (NOA) www.misrnidade.r)ovftconomv
DAB Door Company, Inc.
12195 NW 98' Avenue
Hialeah Gardens, FL 33018
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction materials. The
documentation submitted has been reviewed and accepted by Miami -Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction (AHI).
This NOA shall not be valid after the expiration date stated below. The Miami -Dade County Product Control Section (in
Miami Dade County) and/or the AHI (in areas other than Miami Dade County) reserve the right to have this product or
material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, the
manufacturer will incur the expense of such testing and the AHJ may immediately revoke, modify, or suspend the use of
such product or material within their jurisdiction- RER reserves the right to revoke this acceptance, if it is determined
by Miami -Dade County Product Control Section that this product or material fails to meet the requirements of the
applicable building code.
This product is approved as described herein, and has been designed to comply with the Florida Building Code,
including the High Velocity Hurricane Zone.
DESCRIPTION: Hurricane Master Model 824/811 Steel Sectional Garage Door up to 9'4" Nide rv/
Window Lite Option (DP +50.0,-60.0 PSF)
APPROVAL DOCUMENT: Drawing No. 01-09, titled "Sectional Garage Door", sheets l through 5 of 5,
dated 02/01/2001, with last revision K dated 03/21/2016, prepared by Al-Farooq Corporation, signed and
sealed by Javad Ahmad, P.E_, bearing the Miami -Dade County Product Control renewal stamp with the
Notice of Acceptance number and expiration date by the Miami -Dade County Product Control Section.
MISSILE IMPACT RATING: Large and Small Missile Impact Resistant
LABELING: A permanent label with the manufacturer's name or logo, manufacturing address, model
number, the positive and negative design pressure rating, indicate impact rated if applicable, installation
instruction drawing reference number, approval number (NOA), the applicable test standards, and the
statement reading `Miami -Dade County Product Control Approved' is to be located on the door's side track,
bottom angle, or inner surface of a panel.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance of this product.
TERMENATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials, use, and/or manufacture of the product or process. Misuse ofthis NOA as an endorsement of any product, for
sales, advertising or any other purposes shall automatically terminate this NOA_ Failure to comply with any section of
this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami Dade County, Florida, and followed by the
expiration date may be displayed in advertising literature. If any portion of the NOA is displayed, then it shall be done
in its entirety.
INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official_
This NOA renews NOA # 15-0317.02 and consists of this page 1 and evidence pages E-1 and E-2, as well as
approval document mentioned above.
The submitted documentation was reviewed by Carlos M. Utrera, P.E.
NOe. No. August
9, 0.22
°E Expiration Date: August 9, 2021
Approval Date: June 23, 2016
QG1$ (dl L Page 1
DAB Door Comi3anv. Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBNHTTED
A. DRAWINGS
1. Drawing No. 01-09, titled "Sectional Garage Door", sheets 1 through 5 of 5, dated
02/01/2001, with last revision K dated 03121/2076, prepared by Al-Farooq Corporation,
signed and sealed by Javad Ahmad, P.E.
B. TESTS "Submitted under NOA # 09-0128.04"
1. Test reports on 1) Uniform Static Air Pressure Test, Loading per FBC TAS 202-94
2) Large Missile Impact Test per FBC, TAS 201-94
3) Cyclic Wind Pressure Loading per FBC, TAS 203-94
4) Forced Entry Test, per FBC 2411 3.2.1, TAS 202-94
along with marked -up drawings and installation diagram of a DAB 824 24 GA
Sectional Garage Door with Fixed Windows, prepared by Hurricane Engineering &
Testing, Inc, Test Reports No_ HETI-08-2149A/B, dated 06/27/2008, signed and
sealed by Candido F. Font, P.E.
"Submitted underNOA # 09-0128.04"
2. Test report of Tensile Test per ASTM E 8, Report No. HETI 08-T182, prepared by
Hurricane Engineering & Testing, Inc., dated 12123/2008, signed and sealed by
Candido F. Font, P.E.
"Submitted under NOA # 01-0516.03"
3. Test report of large missile impact test per PA 201 and cyclic wind pressure test per
PA 203 on "Sectional Residential Garage Door", prepared by Hurricane Engineering
& Testing, Inc., Report No. HETI 01-974A, dated 01/29/2001, signed and sealed by
Hector M. Medina, P.E.
4. Test report of Uniform Static Air Pressure Test per PA 202 and Force Entry
Resistance Test on "Sectional Residential Garage Door", prepared by Hurricane
Engineering & Testing, Inc., Report No. HETI 01-969, dated 0111812001, signed and
sealed by Hector M. Medina, P.E.
5. Test report on Salt Spray (Corrosion) Test per ASTM B 117 of a painted G-40 steel
panels, prepared by Celotex Corporation, Test Report No. 258592, dated 08/17/1998,
signed by W_ A. Jackson, P.E.
Carlos M. Utrera, P:E.
Product Control Examiner
NOA No. 16-0330.02
Expiration Date: August 9, 2021
Approval Date: June 23, 2016
E-1
DAB Door Comnanv. Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
C. CALCULATIONS "Submitted under NOA # 14 OSI4.04„
1. Anchor verification calculations prepared by Al-Farooq Corporation, dated 09/22/2014 and
07/24/2014, signed and sealed by Javad Abmad, P.E.
"Submitted under NOA # 09-012& 04"
2. Anchor verification calculations prepared by AI-Farooq Corporation, complying with F.B.0
2007, dated 12/19/2008, signed and scaled by Humayoun Farooq, P.E.
D. QUALITY ASSURANCE
1. Miami -Dade Department of Regulatory and Economic Resources (RF.R)
E. MATERIAL, CERTIFICATIONS
1. Notice of Acceptance No. 15-0915.08, issued to SABIC Innovative Plastics, for their Lexan
Polycarbonate Sheet Products, approved on 12/10/2015 and expiring on 07/17/2018.
2. Notice of Acceptance No. 14-0311.08, issued to Insulfoam, LLC, for their
Insulfoam Expanded Polystyrene Insulation, approved on 08/14/2014 and expiring on
11/2912017.
3. Notice of Acceptance No. 11-0926.07, issued. to Dyplast Products, LLC, for their Expanded
Polystyrene Block Type Insulation, approved on 11/10/2011 and expiring on 01111/2017.
4. Notice of Acceptance No. 11.0926.06, issued to Dyplast Products, LLC, for their
Dyplast 180-C 1 Polyisocyanurate Insulation, approved on 11/10/2011 and expiring on
01/11/2017.
5. Notice of Acceptance No. 15-.12.03.04, issued to Cellofoam North America Inc, for
their Expanded Polystyrene Block Insulation, approved on 03/17/2016 and
expiring on 02124/2021.
"Submitted under NOA ## 05-0225.021"
6. Test Report on Accelerated Weathering Eking Xenon Arc Light Apparatus Test per
ASTM G155 of "PVC Extrusion Material", prepared by Hurricane Engineering &
Testing, Inc., Report No. HETI 04-,A.002, dated 09/27/2004, signed and sealed by Rafael E_
Droz-Seda, P.E.
7. Test Reports on Tensile Test per ASTM D638 of "PVC Extrusion Material", prepared by
Hurricane Engineering & Testing Inc., Report No. HETI "T251, dated 11/2912004 signed
and sealed by I_ Ghia, P -E.
S. Test Report on Self -Ignition Temperature Test, Rate of Burn Test and Smoke Density
Test of"REHAU non -foam PVC extrusion material", prepared by ETC Laboratories,
Report No. 04-761-15019.0, dated 05/0612004, signed and sealed by J. L. Doldan, P.E.
F. STATEMENTS
1. Statement letter of code conformance to the 5* edition (2014) FBC and of no financial interest
issued by Al-Farooq Corporation, dated 03/21/2016, signed and sealed by Javad hmad, P.E.
Carlos NYL Utrera, P.E.
Product Control Examiner
NDA No. 16-0330.02
Expiration Date: August -9,2021
E -Z Approval Date: June 23, 2016
JWN7 4 -11ON5 ) I-
7-1/2' X 3' X ,071' OALV. STEEL
END ROLLER I+NOF
W/ (5) 114 X 5/5' sMs
WITHOUT DELRO14 SIEEVC (STD.
WITH CRAON SLEEVE (OPTIONAL
TOP NMRE 5-1/2' x 2-3/4" X 0.1'
STEEL PLATE WITH ONE 5/18-15 IS W/ NUT
FASTENED TO ENO STN.E WITH OPTIONAL DOOR NEWER
(6) #14 X 3/4' SELF OMUJNG SCREWS TO BE INSTALLED AT
CENTER SOLE
---1 CENTER STILE
1
� I
' 7-1 2" X a-1 4' X .011' 11
1` • OM.V. STEEL GAITER "CC
W/ (4) 114 X 5/5" SMS
WITH DELRON SLEEVE (OPTIONAL)
Im,
21 oaoR
Ir V 1' W x .15^ THK. LATCH T _' low
I 1
i STANDARD LOCK=Fz` ,r __,
SPRfNO L04WO SLIDE BOLT (BOTH SIDES)
FASTENED W/ (4) 114 X 1/2' S.A.S. "� ' >'
5/5" MIN, LOCK ENGAGEMENTvt
CONFORMS TO SECTION 1005 REGARDING
GA�AO� ODORS +I{{+
655 ,EDix QALY. AIRECSRSAFT TYPE
W/ MIN. 5 TOC SAFELY FA�CTUO
1
e'x3'x0.1• '
Wail PLOT 1 1 •
WITH (2) 114 X 5/8' SMS '
BRACKET
STD, LIFT DOOR
1
O �
OPTIONAL VENT
•`� ` (3) Y NIDE AT 7' O.C. MAX.
• i I NINfT AREA NOT 70 EXCEED
120 SO. IN.
BRACKET
LOW HEADROOM
DOOR OPTION
7-7 5 x 3-1/8' X .010'
STEEL PISTE
CENTER STILE WON (4) 11+ X 3/4" SOS
OUTSIDE
HANDLE ENO STILE
LOCK BAR GLIDES
Im
NSTALLED ON END STILL
Will (4) 114 X 5/5' SMS
Q X ,owLOCK BAR
GES IN TRACK
ON EACH SIDE OF DOOR
OUTSIDE KEYED LOCA (OPTIONAL
LOCK BAR LOCK•10 SHOWN
ALTERINATE TO SPRING LOADED SLIDE BOLT
LOOKS SHOWN ABENE
L — A
COLONIAL OESIGN
MAX. ODOR WIDTH
INSIDE ELEVATION
RAISED PANEL EMBOSSED DOOR
11
1LIEU SELF
x RIL SMS MAY BE USED
THIS PRODUCT IS RATED FOR LARGE MISSILE NMPACTI
900& -Am
L THIS PRODUCT H115 BEEN DESIGNED AND TESTED TO COMPLY WITH THE
REQUIBEMEN, OF THE 1014 3THFLONXM 91ALOWIC LOAE INCLUDING
HIGH VELOCITY HURRIOWE ZONE (HVi+1
2. ANCHORS SHALL BE AS LISTED. SPACED AS SHOWN ON DE'TAilLS.
ANCHOR EMEEOMENT TO BASE MATERIAL SHALL BE BEYOND WALL
DRESSING OR STUCCO.
9. ALL BOLTS, NUTS AND WASHERS SHALL BE ZINC PLATEO CARBON STEEL.
4, ANCHORING OR LOADING CONOITNJNS OTHER THAN THOSE SHOWN IN
THESE DUAKS ARE NOT PART OF THIS APPROVAL.
5, A LOAD DIRNTIOV INCREASE IS USED 14 DESIGN OF ANCHORS INTO WOOD ONLY,
I W TEMO IN
!I ACCOR6WCC WITH THE RU WDAM OF FLORIDA T 201, TAS -20i k TAS -203 FOR HVN1 AND
ASTM Et515-0E/A25TM C1991-09,
OPBONAL Fl11SH FACE
WOOD GRAIN OESICXX
DAD DOORS INC.
Hurricane Master® Madol 824/811
Max. 5Ixe 9'-4•' X 76* -0' High
With Window Lxo Option
DESIGN PRESSURE RATING 4 + 50.0 PSF
- 80.0 PSF
PRODUCT REHRWED
eP eomPCydny with the PJorip
aaualnq Code
koA-N0. 16-083Q.0.'
IIXPueUaAOBMW202'
•y
Ilam raaYckr: hU•1
ap
UJI .G Lj
c3R?� cl
Pm
mG W
g
8 �
i
drawing no.
01-09
19hoe( 1 of 3 1
t !D24' BTL PANEL
OUTSIDE OF DOOR
DUCK BRACKET FASTENED SOLID BRASS QQQR VIEWER
7D JAMB WR4 BY 'SCHLACE SECURITY HARDWARE'
X 1-5/8" UO SCREW INSTALLED IN 9/16" OLA, HOLES IN CENTER STILE
BHBwADKDr POSITIONED AT EYE LEVEL
BYDSOW INs�fALLwULDINC
FOR CDNNEOTWN OP ' BUCK
TO MASONRY SEE NOTE ON SHEET 4
_ 414 R 0/0"HNG 6A15 364" X 2' X 1-1/2" X IS CA. STECL
8 PER HINGE f11D STILE. comL T TO PANELS wrH__
SOUTHERN PINE . 1/2" X 1-3/4' X OSS' F'ORWO STEEL runs AND 3/18' ALUM RIVETS
0.86 S.G.. A E t7A5Y'" -OLLKD TC PANEL AND SECURED TO SCE DETAIL ABOVE
11 040 "LE WITH 3/10' POP RIVETS 0 12' O.C.
2-8"B' K .046" STEEL
C 3YIL GLUED AND fGVEfEP
\j I YO PANEL. WJ (4) 5/11' RIVETS
1 1/3" MIN. }\l POP RNEr5
��-2/16•
1.S" X 2.19" X 3.D" X .102"
STEEL TRACK BRACKETS
SEE SHEET 3 FOR SPACING
7/18' PUSHNUT
INSTALLM ON ROLLER SHAfT
STEP. TRACK
14 GA. X 2-1/1' X 1' (STANDARD
12 QA X 3-5/16' X 1-1/2' (BPFIONN.)
FASRM TO TRACK PLATO
W/ 1/4-20 K 8/8" TRUSS- 1W.
Sl0 0 N.3, k TACK NUN
l
7•-1/2" X .071" CAW. STEEL
CENTER HINGE
SECTION R
INTERIOR SIDE
7-1/2" X r X ,071".
ENO ROLLER HINGE
t,82' DIA. X .30' STEEL ROL
1.52' CIA. X .SD' NYLON ROLLERS
2.75" DA. X .50" STEEL. ROLLERS
2.7S' IX►. X .SO" NYLON ROLLERS
24 GA, STEEL. PANEL
3/16" ALUM RIVETS
I
RIMS BENT OVER PANEL--\ t
IN
1/2" PUNCHED HOLES_
D 4" O.C.
LEND snLE K cO
iq
ANCFCOR9 AT TRACK BRACKET: g
.n • eu. aaxla-cGLT Rf 'gs' Lv
2' NMI. EMSEO INTO CONCRETEfiQ
1-7/6' MIN. EDGE DISTANCE
B) 3/B' 0L4. IL.I` VCR: HY 'ILLY' ZZ 2{
1-1/4' NMI. EMBED WtO CONCRETE OR FILLED NOCK m W 1
1-6/6' MIN. EDGE DISTANCE Wo CONCRETE
4.
MIN. EDGE DSrANCE INTO FILLED BLOCK Q Z
EDGE CONCRETE Fc . 5000 PSI MIN. `�' M1
�DKTAMCE C-90 GROVE FILLED NOCK I'm 2000 PSI NTN.
lv
NCNOR TYPE A OR B
]] PG1 BRACKET
SNF.ET 3 FOR BRACKET SPACING
4__l_1/4--20 SS BOLT h NUT
u1 R A Y
Ai{ Y
(STD.
PRODUCT
pRENEWED �, 4
?1DNAL) u mmigelp With the Flows g 1
JJ 1N k
mONAL)~ ,Na"M. 18-0950.02 -
" STEM ftPleatlon 4ftis 08/0912021
IX drawing no.
MN>anx-YA "t Can
tral � 4 —09 1
2" POP ,;a
1/2" K 3" X .104'
/'"\
'.'�
5/18' X 1-5/8" LAG SCREWS INTO WOOD OR
5/16' SLEEVE ANCHORS
CALV.45TEEL
.... TOP ROLLER OIIACNEI ON EACH SIDE
l(\
WITH 1-1/4' EMSEO WTO MASONRY 1
_ FASTENED W/ (5) 0 14 X S/6" S.M.S.
_. _
3 PER BRACKET
ABS
'LUEb TO PANEL. AND FASTENED TO
RALV, SEEE1.
SIDE FA3TENED TO BRACKCr
(2) 3/16" POP RIVETS
2-1/2" X 4�-1/4" X 13 GA. SEEEL PLATES
W/ S/16-78 X 3/4" HEX HEAn
\
LOW HEADROOM ODOR OPTION
WELOEO TO 1-1/2' X 1-1/2' X 14 OA. ANOLE
M. SCREWS Al NUT&
-a TOP BRACKET
7d�Ca
FASTENED TO TRACK
WITH (4) 1/4-20 SS. BOLT &NUTS
(STANDARD)'
-
TOP BRACKETJ
V
4"
(OFR
ADONIAL%
LOW HEADROOM DOORR
1lN $;
HDR170NTAL REINFORCEMENT
�Y T
1/2' X 1-3/4" X ,059' FORNED STEEL
2' % a -Y/2" X .104'
'LUEb TO PANEL. AND FASTENED TO
RALV, SEEE1.
VERTICAL STILES WITH FASTF11E0 W/ !4) i 14 X 6/6" SU.S.
(2) 3/16" POP RIVETS
i0D ROU.ER BRACKET FOR
N
LOW HEADROOM ODOR OPTION
HORIZONTAL RDNFORCQIENT
I/3" X 1-3/4" X 059' FORMED STEEL
1 1111'AL SPANS WAOD LR{ FASTENED TO
`(2) 1/16" POP RIVETS
S/1 S.
MEETING RIB
1.52" DIA. X .50' ROLLERS
Q lW/ .44 DIA. X 4-1/4" $TEM
jig
HORN. TRACK SUPPORT,
CENTOI SUPPORT REDO, ON DOORS
EXE' ING 8 R. IN HPOW
�j "`7
A—J
TRACH LENGTH . OPENING HEIGHT PLUS 12" _
GA. GALV STEEL TRACK
2 X 2%IIB' NOR A0GLE
3
I
I
OPTIONAL INSULATIONS;EPO
V
4"
WITH TWO WEIM AT 1-1/2" APART
1lN $;
tZOpL� i I N
CIPS -EXPANDED POLYSTYRENE
�Y T
REST AT a" O.C.
CONNECTED TO FLAG EFiACKET ANCLE
Z m r
DENSITY .1 ,05 PCF
%
f'
R.O.A. /11-0826.07
N
i
OR
7d�Ca
A
130-26 POLY-ISOCYANURATE
O4
04s
N . PCF
,o
09
N.0ORA j11-0826.08
BY 'CFi1nfCAM NORM AMS
DENSITY • 1.07 PCF
NO.A. 115-1203.04
...
on
8Y 'IN1Lf0Au
DENSITY . 0.92 PCF
N.OA #14-0311.08
14 CA, GLV, STEEL
ROLLO HINGES FASTENED
.
W1 (4) #14 X 5/6" SMS
I
MW. ,024' ROLL FORMED STEEL PANEL
DRAWING OUALITY C-40
i
MIH, YIELO STRENGTH • 34 HS
NIM PRIMER AND T1mm-014
POLYSTER PAWTI TOP CMT
APPUEO TO BOTH SAES OF 5TEEL
.
d7°
1122 000AM DALV, STEL
8
7
1Y/ (4) 14CX a�sms
85EOE
SECTION A -A
SHEETA4 OPTIOM3
jig
HORN. TRACK SUPPORT,
CENTOI SUPPORT REDO, ON DOORS
EXE' ING 8 R. IN HPOW
�j "`7
A—J
TRACH LENGTH . OPENING HEIGHT PLUS 12" _
GA. GALV STEEL TRACK
2 X 2%IIB' NOR A0GLE
3
f +1
SPOT WELDED TO NO RiL TRACK
V
4"
WITH TWO WEIM AT 1-1/2" APART
1lN $;
FIRST AT 3' D.C.
�Y T
REST AT a" O.C.
CONNECTED TO FLAG EFiACKET ANCLE
Z m r
GTO ASPRNG S/Ew78GLYDE wf1N
(2) ?/4-20 X 6/8' BOLT 4 NUT
%
f'
VERTICAL TRACK
7d�Ca
2-1/5" X I. It .080'
SECTION A -A
O4
04s
DOOR 4 SECTION HIODHTS BRADKET PLACEMENTS In i
' HEIGHT 1ST 2NO 3110 4TH 5TH 81 I 02 83 84 H5 85 87 BB � .5 �
e-0' 16" 1B" 16" 16" TO 2'+11-3/4' 23" 34' 45' 56" 67' - r
W-6' 21" 16' 15' 21" A i" TO 2" 11-1 23" Jr 45' 56" 67' -
7'-D' 21' 21" 21" 21' (A 1" TO 2' 11-�}/4 73' 34" 45" 88" 6T -
7'-6' 18' 18' 1a' 16' 1 ' 1" TO 2" 11-3/4' 23' 34" 45' 5e"
8'-0" 21" 18' 18' 18' 21-1- 70 2' 11,v" y3' 34' 45' ae" 57" 76-{/4
4-SECTIM ARE &UM86'REL STAING A7 E AOT10M w ao
FOR ODORS MORE THAN 8 FT. HIGH, USE ADDITIONAL TRACK BRACKETS AT 10' O.C. R
�.
>a
�II
TRACK CONFIGURATION
L TRACQK BR3i1CSIETS c* OW" . cf) 9
/fa" WOH2t
.IECTED It TRACK WITH
1/4' BOLTS R NUTS,
U E3 a n
4 V)
'p
VERTICAL LIFT S ,4TAAIDARD I -I Low HEADROOM
DOUBLE TRACK
AVAILA13LE TRACK OPTIONS
Y
PRODUCT RENEWED
as complying
orn � g with the Plorklauding
."CIA -10a. A 16-0930.02
6X-08/06/2021 s
OFdrowlnG no.
Mieml tlucl Cenlrol , ��ON
!01-09
�aC3
ll1(eheei 3
��
a=
��o� a a
� gR$ q
dopa ':iii •:_� ,� a.
a4- �n goo `pn SgTI
gc
.a$
ige i�'4d9$
2 n
mi�� saf m Fz
n
U�prN�4f T}'
nm
��GO
-6o
ppppaT��' w
Cyd
?I iF
NN
iy
iyt
�� om
pi o-+zi P;
K
w
p '!A
raA� •4 n
3
N f
�ketx
- Nnf
N � Y
�a38m
]i
G 7
�o
Fame �
a E
Nov
IMP A
^17a E
B� gg
� r �
b
u
?E
a�w
. SEMN& GWAGE DOOR
t]t/
H 90.10.1 '• _ .. N�R10R.. p � 641 D65R WCi.
X11 W 12185 N.W. 38 TH. AVE.
d {U11B, 94fI7 � �1 A(�p
w awm T m sm HIALEAH WOWS. FL Mole
- 1 u TEC- (305} 558 - Gm4
INOW
_ J AL-FAROOQ CORPORATN IO
OVlPMNEENS & PRODUCT DMNE'LOP%T � i
9380 SUNSET DRfVL Sum. 22O
MI, FLORMA 33173 (C.d.}/, SSS6)
RL CaGM "c -cam . ___., FA L (s '�8II-OgTp Rr
L
FRI
act
a�
mK
n
U�prN�4f T}'
nm
��GO
ppppaT��' w
Cyd
�
K
w
p '!A
raA� •4 n
�a38m
]i
G 7
�o
Fame �
a E
Nov
IMP A
^17a E
B� gg
� r �
b
u
?E
a�w
. SEMN& GWAGE DOOR
t]t/
H 90.10.1 '• _ .. N�R10R.. p � 641 D65R WCi.
X11 W 12185 N.W. 38 TH. AVE.
d {U11B, 94fI7 � �1 A(�p
w awm T m sm HIALEAH WOWS. FL Mole
- 1 u TEC- (305} 558 - Gm4
INOW
_ J AL-FAROOQ CORPORATN IO
OVlPMNEENS & PRODUCT DMNE'LOP%T � i
9380 SUNSET DRfVL Sum. 22O
MI, FLORMA 33173 (C.d.}/, SSS6)
RL CaGM "c -cam . ___., FA L (s '�8II-OgTp Rr
3/4' $w
9" FROM ENCS
O.C. MAX.
MSHER
DOOR PANG
24 OA. (.074) STEEL MIN.
* PLASTIC COMPLIES WITH
CHAPTER 26 OF FBC
SEE EVIDENCE PAGE
2) iLAX.3/4"
WOW. WIOM
-ml
' * EXTERIOR EAu S
d
7a 1/a" RIGID PVC ONE PIECE INJECTION
ltA 7=4
= o
11
ElT m J
.250
1
.800
* WERIOS FRAME
RIGID PVC ONE PIECE INJECTION
INSIUL ELEVATION
RAISED PANEL EMBOSSED DOOR WITH OPTIONAL WINDOWS
C WINDOW LITES CAN BE IN ANY LOCATION IN DOOR SECTION
ye X 3/4' sus
O 3/11' FROM ENDS- i75 X .067 DEEP
ANO 4-1/2' O.C. k". CROOK
r- -
_.,- =.1._~�._,., - . _ =.. PRoouW�crneNeweo
— - 1 W Cmwith ther1wwA
�- NOA-N 16-0390.02
DOOR P= EXTERIOR mIP mmon 08/0912027
24 DA (.024) sTFn. MW: 1a/+a' INN.
D.I. oPD. is
OLAZINO LIRE - IR1n11 Lot CMbW
WINDOW WIDTH
f o► drow+ng nO,
�... 01-0s
t AInt1 eheet g of b
DOOR PANEL
%-'
24 nA (,024) STEEL MIN,
I
-7/76' DIA WASI#R
w
+6 % J"/4. DMS
II II
q 3/6 FROM 111105
A
ANO 7` O.C. MA%.
t
II!! 4
(4) I#6 X 3/4" SMS
Il
` 0 1-3/6' PROM ENDS
l
` AND e -1/Y O.C. MAX.
I IIj I
i
I
176 X ,062 OEEP
I I
ILII
CROOK
rill
1/4" POLYCARBONATE LEMN
I 'SA6q INNOJATMrt PLASTIC'
I,!, �NW 115- R15,00
y
Illi
IIS!
fl
Ijll
i
lil
I'1
I, I,
IIIi
j ! j
176 X .0112 DEEP
i j I,
OROfriE
it 111
-
�i
11
/a X S/4' SMS
1-J/e'
I,! r
p i l i l i
lr FROM END.
ANn a—t/r O.C. MAX.
3/4' $w
9" FROM ENCS
O.C. MAX.
MSHER
DOOR PANG
24 OA. (.074) STEEL MIN.
* PLASTIC COMPLIES WITH
CHAPTER 26 OF FBC
SEE EVIDENCE PAGE
2) iLAX.3/4"
WOW. WIOM
-ml
' * EXTERIOR EAu S
d
7a 1/a" RIGID PVC ONE PIECE INJECTION
ltA 7=4
= o
11
ElT m J
.250
1
.800
* WERIOS FRAME
RIGID PVC ONE PIECE INJECTION
INSIUL ELEVATION
RAISED PANEL EMBOSSED DOOR WITH OPTIONAL WINDOWS
C WINDOW LITES CAN BE IN ANY LOCATION IN DOOR SECTION
ye X 3/4' sus
O 3/11' FROM ENDS- i75 X .067 DEEP
ANO 4-1/2' O.C. k". CROOK
r- -
_.,- =.1._~�._,., - . _ =.. PRoouW�crneNeweo
— - 1 W Cmwith ther1wwA
�- NOA-N 16-0390.02
DOOR P= EXTERIOR mIP mmon 08/0912027
24 DA (.024) sTFn. MW: 1a/+a' INN.
D.I. oPD. is
OLAZINO LIRE - IR1n11 Lot CMbW
WINDOW WIDTH
f o► drow+ng nO,
�... 01-0s
t AInt1 eheet g of b
Comments
Archived
Product Manufacturer DAB Doors Company, Inc.
Address/Phone/Email 12195 NW 98 Avenue
Hialeah Gardens, FL 33018
(305) 822-7870
RBergerSl8@hotmaiLcom
Authorized Signature
Javad Ahmad
F4 � d r
mktq
•
+
O i
Professional
12195 NW 98 Avenue
f'•
kl
r
Quality Assurance Representative
A.
SCIS Home Log Yn � User Registration Hot Topics
Submh Surcharge Stats & racts
publications Y FBC Staff SCIS Site Map
Links Search
d
�'Product
proWal
USER: PulsliC User
U
Product Anoroval Menu > Product or Auolication Search> Application
List > Application Detail
FL
FL15371-R3
Application Type
Revision
Code Version
2014
Application Status
Applied For
Comments
Archived
Product Manufacturer DAB Doors Company, Inc.
Address/Phone/Email 12195 NW 98 Avenue
Hialeah Gardens, FL 33018
(305) 822-7870
RBergerSl8@hotmaiLcom
Authorized Signature
Javad Ahmad
a lfarooq @afceng. corn
Technica€ Representative
Alien Berger
Address/Phone/Email
12195 NW 98 Avenue
Hialeah Gardens, FL 33018
rberger5l8@hotmaii.com
Quality Assurance Representative
Address/Phone/Email
Category Exterior Doors
Subcategory Sectional Exterior Door Assemblies
Compliance Method Certification Mark or Listing
Certification Agency Miami -Dade BCCO - CER
Validated By Miami -Dade BCCO - VAL
Referenced Standard and Year (of Standard) Standard Year
TAS 241 1994
TAS 202 1994
TAS 203 1944
Equivalence of Product Standards
Certified By
Product Approval Method
Date Submitted
Bate Validated
Summary of Products
Method i Option A
07/20/2016
FL # Model, Number or Name Description
15371.1 Hurricane Master Model 824/811 Large missile impact resistant 16'-2" x 16' steel sectional
Steel Sectional Garage Door 16'-2" garage door.
Wide w/ Window Lite Option
Limits of Use Certification Agency Certificate
Approved for use in HVHZ: Yes FL15371 R3 C CAC 16x16 Garare Door LMI (15-0302.011
Approved for use outside HVHZ: Yes dwo 48-13S.Ddf
Impact Resistant: Yes Quality Assurance Contract Expiration Date
Design Pressure: +48/-52 07/21/2020
Other: See attached limitations of use for installation Installation Instructions
instructions. FLIS371 R3 II 16x16 Garaoe Door LMI (15-0302.01) dwo
15371.2 Hurricane Master Model 824/811
Steel Sectional Garage Door 16'-2"
Wide w/ Window Lite Option
j Limits of Use
Approved for use in HVHZ: Yes
Approved for use outside HVHZ: Yes
Impact Resistant: Yes
Design Pressure: +36/-44
Other: See attached limitations of use for installation
instructions.
15371.3 I Hurricane Master Model 8241811
Steel Sectional Garage Door 16'-2"
Wide w/ Window Lite Option
Limits of Use
Approved for use in HVHZ: Yes
Approved for use outside HVHZ: Yes
Impact Resistant: Yes
Design Pressure: +56/-64
Other: See attached limitations of use for installation
instructions.
15371.4 Hurricane Master Model 824/811
Steel Sectional Garage Door 16-2"
Wide w/ Window Lite Option
Limits of Use
Approved for use in HVHZ: Yes
Approved for use outside HVHZ: Yes
impact Resistant: Yes
Design Pressure: +27/-30
Other: See attached NOA #16-0330.03 and Limitations of
Use for installation instructions.
15371.5 Hurricane Master Model 824/811
Steel Sectional Garage Door 18'-2"
Wide w/ Window Lite Option
Limits of Use
Approved for use in HVHZ: Yes
Approved for use outside HVHZ: Yes
Impact Resistant: Yes
Design Pressure: +55/-64
Other: See attached limitations of use for installation
instructions.
98-05.odf
FL15371 R3 11 Limitations Of Use.odf
Verified By: Miami -Dade BCCO - CER
Created by Independent Third Party:
Evaluation Reports
Created by Independent Third Party:
Large missile impact resistant 16'-2" x 16' steel sectional
garage door.
Certification Agency Certificate
FL15371 R3 C CAC 16x16 Garaoe Door LMI (15-0304.01)
dwo 92-21.odf
Quality Assurance Contract Expiration Date
07/21/2020
Installation Instructions
FL15371 R3 I1 16x16 Garaoe Door LMI (1S-0304.01) dwo
02-21.odf
FL15371 R3 Ii Limitations Of Use.odf
Verified By: Miami -Dade BCCO - CER
Created by Independent Third Party:
Evaluation Reports
Created by Independent Third Party:
Large missile Impact resistant 16'-2" x 16' steel sectional
garage door.
Certification Agency Certificate
FL15371 R3 C CAC 16x16 Garare Door I -Ml (15-0304.02)
dwo 00-18.ndf
Quality Assurance Contract Expiration Date
02/22/2020
Installation Instructions
FL15371 R3 II 16x16 Garaoe Door LMI 115-0304.02) dwo
QQ-18j)df
FL15371 R3 T1 I_irr ir�kions Of Use.Ddf,
Verified By: Miami -Dade BCCO - CER
Created by Independent Third Party:
Evaluation Reports
Created by Independent Third Party:
Large missile impact resistant 16'-2" x 16' steel sectional
garage door.
Certification Agency Certificate
FL15371 R3 C CAC 16ft-2:n Steel Garace Door LMI (+27.
-30) - NOA 16-0330.03.od`
Quality Assurance Contract Expiration Date
08/14/2021
Installation Instructions
FL15371 R3 II 16ft-2in Steel Garaoe Door LMI (+27. -30)
- NOA 16-0330.03.odf
FL15371 R3 II Limitations Of Use.odf
Verified By: Miami -Dade BCCO - CER
Created by Independent Third Party:
Evaluation Reports
Created by Independent Third Party:
Large missile impact resistant 18'-2" x 16' steel sectional
garage door.
Certification Agency Certificate
FI_15371 R3 C CAC 18x16 Garace Door LMI (15-0317.051
dwci 99-24.ndf
Quality Assurance Contract Expiration Date
03/10/2018
Installation Instructions
FL15371 R3 11 18x16 Garare Door LMI (15-0317.05) dwo
15371.6 J Hurricane Master Model 824/811
I{ Steel Sectional Garage Door 18'-2"
Wide w/ Window Lite Option
Limits of Use
Approved for use in HVHZ: Yes
Approved for use outside HVHZ: Yes
Impact Resistant: Yes
Design Pressure: +40/-44
Other: See attached limitations of use for installation
instructions.
15371.7 Hurricane Master Madel 824/811
Steel Sectional Garage Door 9'-4'
Wide w/ Window Lite Option
Limits of Use
Approved for use in HVHZ: Yes
Approved for use outside HVHZ: Yes
Impact Resistant: Yes
Design Pressure: +50/-60
Other: See attached NOA #16-0330.02 and Limitations of
Use for installation instructions.
15371.8 Hurricane Master Model 824/811
Steel Sectional Garage Door 9'-4"
Wide w/ Window Lite Option
Limits of Use
Approved for use in HVHZ: Yes
Approved for use outside HVHZ: Yes
Impact Resistant: Yes
Design Pressure: +62/-70
Other: See attached NOA #16-0330.04 and Limitations of
Use for installation instructions.
15371.9 Model 924 Steel Sectional Garage
Door 12'-4" Wide
99-24. Ddf
1`1_1�371 R3 II Limitations Of Use.odf
Verified By: Miami -Dade BCCO - CER
Created by Independent Third Party:
Evaluation Reports
Created by Independent Third Party:
Large missile Impact resistant 18'-2" x 16' steel sectional
garage door.
Certification Agency Certificate
FL15371 R3 C CAC 18x16 Garaae Door LMT (15-0317.01)
dwa 05-03.Ddf
Quality Assurance Contract Expiration Date
03/29/2017
Installation Instructions
FLIS371 R3 1I 18x16 Garaoe Door LMI (15-0317.01)dwd
05-03.Ddf
FLIS371 R3 II Urnitations Of Use.odf
Verified By: Miami -Dade BCCO - CER
Created by Independent Third Party:
Evaluation Reports
Created by Independent Third Party:
Large missile impact resistant 9'-4" x 16' steel sectional
garage door.
Certification Agency Certificate
FL5371 R3 C CAC 9ft-4in Steel Garaae Door LMI f+50.
-6n) - NOA 16-0330.02.Ddf
Quality Assurance Contract Expiration Date
08/09/2021
Installation Instructions
FL15371 R3 11 9ft-4in Steel Garaae Door LMI (+50. -601 -
NDA 16-0330.C2.Ddf
FL15371 R3 I1 Limitations Of Use.odf
Verifled By: Miami -Dade BCCO - CER
Created by Independent Third Party:
Evaluation Reports
Created by Independent Third Party:
Large missile impact resistant 9'-4" x 16' steel sectional
garage door.
Certification Agency Certificate
FL15371 R3 C CAC 9ft-4.n: Steel Garane Door LMT (+62.
-701 - NOA 16-0330.04.Ddf
Quality Assurance Contract Expiration Date
10/04/2021
Installation Instructions
FL15371 R3 II 9ft-4in Steel Garaae Door LMI (1.62. -701 -
NOA 16-0330.04.ndf
FL15371 R3 11 Limitations Of ilse.odf
Verified By: Miami -Dade BCCO - CER
Created by Independent Third Party:
Evaluation Reports
Created by Independent Third Party:
Large missile impact resistant 12'-4" x 18' steel sectional
garage door.
Limits of Use Certification Agency Certificate
Approved for use in HVHZ: Yes ft 15371 R3 c-. CAC ;`x1g Geraae Door LMI (15-0317.06)
Approved for use outside HVHZ: Yes dwC1 04-0Ladi
Impact Resistant: Yes Quality Assurance Contract Expiration Date
Design Pressure: +60/-65 07/14/2020
Other: See attached limitations of use for installation Installation Instructions
instructions. FL15371 R3 11 12x18 Garaae Donr LMI (15-0317-06) dwo
04-01.odf
FL15371 R3 II Limitations Of Use.ndf
Verified By: Miami -Dade BCCO - CER
Created by Independent Third Party:
Evaluation Reports
Created by Independent Third Party:
Contact Us:: 2601 Blair Stone Road, Tallahassee FL 32399 Phone: 850-487-1824
The State of Florida is an AA/EEO employer. CoPyrloht 2007-2023 State of Florida., :: Privacv Statement :: Accessibility Statement :: Refund Statement
Under Florida law, email addresses are public records. If you do not want your e-mail address released In response to a public -records request, do nut send electronic
mail to this entity. Instead, contact the office by phone or by traditional mail. If you have any questions, please contact 850.487,1395. *Pursuant to Section 455.275
(1), Florida Statutes, effective October 1, 2012, licensees licensed under Chapter 455, F.S. must provide the Department with an email address if they have one. The
email$ provided may be used for official communication with the licensee. However email addresses are pubFc record. If you do not wish to supply a personal address,
please provide the Department with an email address which can be made available to the public. To determine if you are a licensee under Chapter 455, F.S., please
dick here ,
P[roodduct Approval Accepts:
I'll J
Credit Card
Safe