The URL can be used to link to this page

Home My WebLink About16x7 dab 48-52 highlighted 14fbc �M I�A M�I•DADE MIA.MI-DADE COUNTY ti�:illlill PRODUCT CONTROL SECTION 11805 SW 26 Street,Room 208 DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(RER) Miami,Florida 3 3 17 5-2414 BOARD AND CODE ADMINISTRATION DIVISION T(796)315-2590 F(786)315.2599 NOTICE OF ACCEPTANCE(NOA) www.mlamldad&j2vleconemv DAB Door Company,Inc. 12195 NW 981h Avenue Hialeah Gardens,FL 33018 SCOPE:This NOA is being issued under the applicable rules and regulations governing the use of construction materials.The documentation submitted has been reviewed and accepted by Miami-Dade County RER-Product Control Section to be used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction(AHJ). This NOA shall not be valid after the expiration dale stated below.The Miami-Dade County Product Control Section(In Miami Dade County)and/or the AHJ(in areas other than Miami Dade County)reserve the right to have this product or material tested for quality assurance purposes.If this product or material fails to perform in the accepted manner,the manufacturer will incur the expense of such testing and the A14J may immediately revoke,modify,or suspend the use of such product or material within their jurisdiction. RER reserves the right to revoke this acceptance,if it is determined by Miami-Dade County Product Control Section that this product or material fails to meet the requirements of the applicable building code. This product is approved as described herein, and has been designed to comply with the Florida Building Code, including the High Velocity Hurricane Zone. DESCRIPTION:Hurricane Mater Made]8241811 Steel Sectional Garage Door up to 16'-21,wl Window Lite Option(DP+48.0,-52.0 PSF) APPROVAL DOCUMENT:Drawing No.98-05,titled"24 GA.Roll Formed Steel Sectional Garage Door",dated 02123/1998,with last revision L dated 03/0512015,sheets 1 through 6 of 6,prepared by Al- Farooq Corporation,signed and sealed by Favad Ahmad,P.E.,bearing the Miami-Dade County Product Control renewal stamp with the Notice of Acceptance number and expiration date by the Miami-Dade County Product Control Section. MISSILE IMPACT RATING:Large and Small Missile Impact Resistant LABELING:A permanent label with the manufacturer's name or logo,manufacturing address,modellseries number,the positive and negative design pressure rating,indicate impact rated if applicable,installation instrue6on drawing reference number,approval number(NOA),the applicable test standards,and the statement reading`Miami-Dade County Product Control Approved'is to be located on the door's side track, bottom angle,or inner surface of panel. .RENEWAL.of this NOA shall be considered after a renewal application has been filed and there has been no change in the applicable building code negatively affecting the performance of this product. TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the materials,use,and/or manufacture of the product or process.Misuse of this NOA as an endorsement of any product,for sales,advertising or any other purposes shall automatically terminate this NOA.Failure to comply with any section of this NOA shall be cause for termination and removal of NOA. ADVERTISEMENT:The NOA number preceded by the words Miami-Bade County,Florida,and followed by the expiration date may be displayed in advertising literature. If any portion of the NOA is displayed,then it shall be done in its entirely. INSPECTION:A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and shall be available for inspection at the job site at the request of the Building Official. This NOA renews NOA#14-0814.08 and consists of this page 1 and evidence pages E-1 and E-2,as well as approval document mentioned above. The submitted documentation was reviewed by Carlos M.Utrera,P.E. NOA No.15-0302.01 140,141-DADECOUMTY Expiration Date:July 21,2020 Approval Date:April 23,2015 Jl�f�p15 Page i xaa s x laxx axi xxx ai eI x `�„ E'e`„; 3 I d II&�s A slA A35� sl�ls Yl� �B a�eS aal9a aex � & �� n.' '£�� Y �. s:"av nl mill o, PS G \ '£ €R o �- gas a `%729 ' 1 L Y55555 I' S. — _ «� �I a��a�Aa�s� 'R as l� 1Ys� g � A 6lga'Blu Y a go Re oo ]4 G ROLL f91ElEfl 51'-' SiRIpUL OR.-fN AL FAROOO CORPo 014 I a DWRS INC DAB o ,I i 2195 N.W. 98 ii. AVE. p U HWF5N CTRDENS GL. 33018 f [l, 1FL(]OS`S56-66Ea GVinGE\96-]5 aoso-as a aomvaxax aw I +zsz sss Isx)vi �� N � mxwHzvi oe®++x 11 6l0£C li 'SN3atlr' HV31rH �a ��-- - O -�� LTetw II� 3M�Il B6-Mh c6lLL x 3 anrt sxcc �NI Stl004 Btl0 f of rw.wanira ua I m eI`NOLLtlMOdbW a00bVf'Itl �w TXM mau>a�_1s amvc+-we�I t a.71a 3 e . 4 a5 E c C_ 9 e E yy p `3 gg o� .3 G. 1 tlG I a IxL eiarne�sas�x.e ouiesvz tcoU�.,,�I 'atOt "� 'Sh9d'iM`J 1" 4LiEE adlaOli'IYMW 3hY �'-'1 gs MN $61Z4 3nv ce nn s srzs _ ':NI S800a ova a = c .-- g Of) ? uuwa��3+laa lJaoP4d R5l139N�u3' I-._ r ci�Ta � r. er-rz-eo .�w 111 cr) < NoavmOdmoo C-O%IV=I-1V .kG 30flM-YNbL035 IBIS 03i�bOJ T1ba Y7 roL.. - - e ui dl gr aPM �� V N +�i 4 Cp 1y n _ -oo vi €g !� at -ate —�- � � ;� =�� M�� -� = I�1 rova•n b, `off V r o_ xR 9NN-86 r sL59 (SR]-Til r •. cyoclmzl ova oesawilmu ,I d10Cf "IA 'SN3ai'vJ HV31nH b ° ea �6EE Wa1011 Mi r 3 V Hi 06 MN SSIZI I aw saooa e a m e HOLLtltlOdMOO bbbMtld'ltl III,JillYO d9Nl:TN6iU35 ial5 Q3140d TDY Y]{Z L .v�= LI.�•.. s `gam IR Ee {0{0 EGu:wwuo B C S YE aR ensa es\3mn� _ �" avr ess(cxl-u man ewe ms.wm I(nI1r— .-- - ' veeeaveme-- -uo�e.re tson J RIOCC 'li 'SN30tiv`)Htl31MH i` my,..K, II O ..7 ir.owem avmw r 3 - l 8fi MN S6l O p. a tl 3 l JNI MN 9e,J ' NOLLYCOdMO'J b00lftlJ l0 I'�:3'.MM T1bLL'IE 15315 6#k01 lILW l`J K vet rn u° uase v £ S \im C � ' lox I, gi3`a a x° s \ I5 io6o€sa �� »mob i \x' >t�o � r\ Ig 3 � a ,c y€ < € »m € E 54 ,gSoo ia ,. x5a ep, -28 = a ss — o w mas, size gaga � ..y. E - ewso-eevo+a.� rma ecs(cxl w I � '° �� v�crmuwa+� mu+x a� � BlOff U 'SN30tiv9 x��N O eGSE[m W 3AY 'H1 08 N'N SBi2l �� m = I �� u<wamworxraaul�srsc 'ONI SM000 9V41� �_i�_ `� ,� NOLLYINOdNO'J bOOtltltltl I�I:EO_3T'd!J TNCIUE P.31S P311tlJ31Xitl M�Z I _ s e -�1 T a s c o r n it II �g Sew444- Eli 1111I I al wig it �II Sad - I € Ilu xm�tOx gi /I t p s$ §o s Sig U w a 3IV2016 Florida Build rig Code Online �x ..>v�.. - _ BCIS M^-me tog Ir Jssr 4eqstrenon HO[iopts SUOmn Surcl,arye Sfafs&Fags puOlre::�nz •BC Sian BCIS sate Map Business, Product Approval Professional USER rIHaeu• >AppllCMbn GetaO FL# FL15371-R2 Application Type Revision Code Version 2014 - Application Status Approved "Approved by DBPR.Approvals by DBPR shall be reviewed and ratified _y by the POC and/or the Commission if necessary. t Comments 5r'deM Archived µ }, Product Manufacturer DAB Doors Company,Inc. Address/Phone/Email 12195 NW 98 Avenue Hialeah Gardens,R 3301B „.�. (305)822-7870 RBerger5l6@hotmaii.com x. Authorized Signature lavad Ahmad alfarooq@afceng.com X� Technical Representative Allen Berger Address/Phone/Email 12195 NW 98 Avenue s Hialeah Gardens,R 33018 rberger518@hotmaiLmm F? quality Assurance Representative Address/Phone/Email Category Exterior Dpnrs Subcategory Sectional Exterior Door Assemblies Compliance Method Certification Mark or Listing (4 Certification Agency Miami-Dade BCCO-CER Validated By Miami-Dade BCCO-VAL Referenced Standard and Year(of Standard) Standard Year TAS 201 1994 TAS 202 1994 c w TAS 203 1994 M. we _ Equivalence of Product Standards r CertiNetl By Product Approval Method Method 1 Option A Data Submitted 07/09/2015 httos:;Niww figidabuildirg.orypr/pr app_dd.aspx1pavan=wGEVXQvtDgIHB572WdWIYOW8.3UxeLtDBeej4 TODQXjj31FeDO%3d/e3d 14 314l2016 Florida Building Code Online „ gqDate Validated 07/10/2015 Date Pending FBC Approval Date Approved 07/20/2015 n_F �°,� - Summar�Products FL fF Model,Number or Name Description ' 5371.1 Hurricane Master Model 6241811 -Large missile impact resistant 16'-2"x 16'steel sectional Steel Sectional Garage Door 16'-2" garage door. ;;^ - ----- Wide w/Window Lite Option Limits of Use Certincation Agency Certificate Approved for use in HVHZ:Yes FL 537 R2 C CAC of`�Ga•ace Door Lhil 15-030�.01 Approved for use outside_ VHZ:Yes d - H 8-05.odf Impact Resistant_ Quality Assurance Contract Expiration Date S'- 07/21/2020 Design Pressure: 48f-32- Other:See attachedtfim f+lt ns of use for Installation Installation Instructions R2 11 16xI6 Garage Door LMI115-0302.01 dw instructions. FL15371 # +r 98-05:odf FLr 5371 Ra II Limitations Of Use_odf . •: l_ Verified By:Miami-Dade BCCO-CFR Created by Independent Third Party: Evaluation Reports Created by Independent Third Party: _ 15371.2 Hurricane Master Model 824/811 Large missile impact resistant 16'-2"x 16'steel sectional Steel Sectional Garage Door 16'-2" garage door. wide w/Window Lite Option - _�- Limits of Use f Certification Agency Certificate Approved for use in HVHZ:Yes FLi'377 R2 C CAC 16x!6 Garaae Door LMI f 1S-03 4.01 Approved for use outside HVHZ:Yes dwo 02-21.12df � a Impact Resistant:Yes Quality Assurance Contract Expiration Date Design Pressure:+36/-44 07/21/2020 ` -: other:See attached lim itat9ons of use for installation Installation Instructions FL 15371 R2 11 16x 16 Garage Door LM1f15-0304.01S dw instructions. Oz 2 FL15371371 R2 I[._imitations OF Use.ndf Verified By: Mlame-Dade BCCO-CER > Created by Independent Third Party: Evaluation Reports Created by Independent Third Party: 7' 15371.3 Hurricane Master Model 824/811 Large missile impact resistant 16'-2"x 16'steel sectional -- z Steel Sectional Garage Door 16'-Z" garage door. Wide w!window Lite Option Limits of Use Certification Agency Certificate Approved for use in HVHZ:Yes FL15371 R2 C CAC 16x16 garage Door LMI f 15-030-2.021 _ Approved for use outside HVHZ:Yes diva 00-16.vcl '. Impact Resistant:Yes Quality Assurance Contract Expiration Date Design Pressure:+56/-64 02/22/2020 Other:See attached limitations of use for installation installation Instructions �:.- instructions. FL1537' R2 H 16x 16 Garaae Doo-Lt-11(15-0304.021 dwo 00-18 odf x` - R 1�371 R2 I1 Limitations Of Use odf 1 --: a. ,'> >•�i„I:= Verified By:Miami-Dade BCCO-CER Created by Independent Third Party: Evaluation Reports �a ,•,:� Created by Independent Third Party: -15371.4 Hurricane Master Model 824/811 Large missile impact resistant LS'-2"x 16'steel sectional -,- Steel Sectional Garage Door 16'-2" garage door. Wide w/Window Lite Option Limits of Use Certification Agency Certificate Approved for use in HVHZ:Yes FL15371 R2 C CAC 16x16 Garage Door LM[f 15-0317 031 Approved for use outside HVHZ:Yes dwo 03-06 odf Impart Resistant:Yes Quality Assurance Contract Expiration Date Design Pressure:+27/-30 08/14/2016 •s: Other.See attached limitations of use for installation Installation Instructions instructions. FL15371 12 Ii 16x16 Garage Door LM1(15-D317..07]9A9 03-06,odf 915 7I R2 11 Limitatinrs Of use. f Verified By:Miami-Dade BCCO-CER Created by Independent Third Party: Evaluation Reports Created by Independent Third Party: `15371.5 T Hurricane Master Model 624/811 Large missile impact resistant 18'-2"x 16'steel sectional Steel Sectional Garage Door 18'-2" garage door. _ Wide w/Window Lite Option ! Itltps/4ww.floridabuilding.orgipripr_app dll.aspx?param=wGEVXQwtDqtH8572gvdWlYeQI8d3UxeuhDBea+gmTQoQX113fFeDQ%3d,.3d 214 DAB Door Company,Inc. NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED A. DRAWINGS 1. Drawing No.98-05,titled"24 GA.Roil Formed Steel Sectional Garage Door",dated 02123/1998,with last revision L dated 03105/2015,sheets 1 through 6 of 6,prepared by AI- Farooq Corporation,signed and sealed by davad Alunad,P.E. B. TESTS "Submitted under NOA#11-0414.13" 1. Test Report on Uniform Static Air Pressure Test,Loading and Forced Entry'rest per FBC, TAS 202-94,of"DAB 624 Sectional Residential Garage Door"prepared by Hurricane Engineering&Testing Inc.,Report No.I3ETI-07-4267,dated 06/29/2007,signed and sealed by Candido F.Font,P.E. 2. Test Report on Large Missile Impact Test per FBC,TAS 201-94 and Cyclic Wind Pressure Test per FBC,TAS 203-94,of"DAB 824 Sectional Residential Garage Dour",prepared by Hurricane Engineering&Testing Inc.,Report No.HETI-11-3206,dated 02/10/2011,signed and sealed by Candido F.Font,P.E. 3. Test Report on Tensile Test per ASTM E8-08 of"Sectional Residential Door(skin)', prepared by Hurricane Engineering&Testing Inc-,Report No.HETI-114101,dated 01/2912011,signed and sealed by Candido F.Font,P.E. "Submitted under NOA#05-0217.02- 4, Test Report on Large Missile Impact Test and Cyclic Wind Pressure Test,of"Sectional Residential Door with Windows"prepared by Hurricane Engineering&Testing Inc.,Test Report No.HETI 03-1328,dated 07115/2003,signed and sealed by Rafael E.Droz-Seda,PE. 5. Test Report on Uniform Static Air Pressure Test,of"Sectional Residential Door"prepared by Hurricane Engineering&Testing Inc.,Test Report No.F ETI 03-1329,dated 07115/2003 signed and sealed by Rafael E.Droz-Seda,P.E. 6. Test Report on Tensile Test per ASTM E-8 of"Sectional Residential Door(skin)"prepared by Hurricane Engineering&Testing Inc,Test Report No.HETI 03-T078,dated 1013112003, signed and sealed by Rafael E.Droz-Seda,P.E. "Submitted under NOA#03-0210.04" 7. Test report on Salt Spray(Corrosion)Test per ASTM B 117 of a painted G-40 steel panels, prepared by Celotex Corporation,Test Report No.258592,dated 08/17/1998,signed by W.A. Jackson,F.E. C. CALCULATIONS "Submitted under NOA#14-0814.08" 1. Anchor verification calculations prepared by Al-Farooq Corporation,dated 09/22/2014 and 07/2412014,signed and sealed by Javad Ahumd,P.E. 44lief v Carlos M.Uirera,P.E. Product Control Examiner NOA No,15-0302.01 Expiration Date:July 21,2020 Approval Date:April 23,2015 E-1 DAB boor Company,Inc. NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED C. CALCULATIONS(Cont.) "Submitted under NOA#09-0128.01" I. Anchor verification calculations prepared by Ai-Farooq Corporation,complying with F.B.0 2007,dated 0410512011,signed and sealed by Javad Ahtnad,P.E. "Submitted under NOA#09-0128,01" 2. Anchor verification calculations prepared by Al-Farooq Corporation,complying with F.B.0 2007,dated 12/19/2008,signed and sealed by Humayoun Farooq,P.E. D. QUALITY ASSURANCE 1. Miami-Dade Department of Regulatory and Economic Resources(RER) E. MATERIAL CERTIFICATIONS 1. Notice of Acceptance No.13-0717.01,issued to SABIC Innovative Plastics,for their Lexan Sheet Products,approved on 11/28/2013 and expiring on 07/17/2018. L Notice of Acceptance No.14-0311.08,issued to lnsulfoam,LLC,for their Insulfaam Expanded Polystyrene Insulation,approved on 08/14/2014 and expiring on 11/29/2017. 3. Notice of Acceptance No.11-0926.07,issued to Dyplast Products,LLC,for their Expanded Polystyrene Block Type Insulation,approved on 11110/2011 and expiring on 01/11/2017. 4. Notice of Acceptance No.11-0926.06,issued to Dyplast Products,LLC,for their Dyplast ISO-Cl Polyisocyanurate Insulation,approved on I1/10t20tI and expiring on 0111112017. 5. Notice of Acceptance No.10-1129.04,issued to Cellofoam North America Inc,for their Expanded Polystyrene Block insulation,approved on 02/24/2011 and expiring on 02124/2016. "Submitted under NOA#05-0228.02" 6. Test Report on Accelerated Weathering Using Xenon Are Light Apparatus Test per ASTM G155 of"PVC Extrusion Material",prepared by Hurricane Engineering& Testing,Inc.,Report No.HET104-A002,dated 09/27/2004,signed and sealed by Rafael E. Droz-Seda,P.E. 7. Test Reports on Tensile Test per ASTl41 D638 of"PVC Extrusion Material",prepared by Hurricane Engineering&Testing Inc.,Report No.IIETI 044251,dated 11/29/2004 signed and sealed by I.Ghia,P.E. 8. Test Report on Self-Ignition Temperature Test,Rate of Burn Test and Smoke Density Test of"REHAU non-foam PVC extrusion material",prepared by ETC Laboratories, Report No. 04-761-15019.0,dated 05/06/2004,signed and sealed by J.L.Doidan,P.F, F. STATEMENTS"Submitted under NOA#14-0814.08" 1. Statement letter of code conformance to the 50 edition(2014)FBC and no financial interest issued by AI-Farooq Corporation,dated 05/13/2014,signed and sealed by Javad Ahmad,P.E. d¢ 15 Carlos M.Utrers,P.i. Product Control Examiner NOA No,15-0302.01 Expiration Date:July2t,2020 Approval Date:April 23,2015 E-2