HomeMy WebLinkAboutProduct Approval (2) RECEIVED
JAN Q 9 2018
ST, Lucie CE►0_n_lav Permitting
M® �
MIAMI-DADE COUNTY
PRODUCT CONTROL SECTION
11805 SW 26 Street,Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(RER) Miami,Florida 33175-2474
BOARD AND CODE ADMINISTRATION DMSION T(796)315-2590 F(786)315-2599
NOTICE OF ACCEPTANCE (NOA) %ww.miamidade.¢ov/econoniv
DAB Door Company,Inc. FILE COPY
12195 NW 98's Avenue
Hialeah Gardens,FL 33018
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction materials.The
documentation submitted has been reviewed and accepted by Miami-Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction(AHJ).
This NOA shall not be valid after the expiration date stated below.The Miami-Dade County Product Control Section(In
Miami Dade County)and/or the AHJ(in areas other than Miami Dade County)reserve the right to have this product or
material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, the
manufacturer will incur the expense of such testing and the AHJ may immediately revoke,modify,or suspend the use of
such product or material within their jurisdiction. RER reserves the right to revoke this acceptance, if it is determined
by Miami-Dade County Product Control Section that this product or material fails to meet the requirements of the
applicable building code.
This product is approved as described herein, and has been designed to comply with the Florida Building Code,
including the High Velocity Hurricane Zone.
DESCRIPTION:Hurricane Master Model 824/811 Steel Sectional Garage Door up to 9'-4"Wide w/
Window Lite Option(DP+50.0,-60.0 PSF)
APPROVAL DOCUMENT: Drawing No.01-09,titled"Sectional Garage Door",sheets 1 through 5 of 5,
dated 02/01/2001,with last revision K dated 03/21/2016,prepared by Al-Farooq Corporation,signed and
sealed by Javad Ahmad,P.E.,bearing the Miami-Dade County Product Control renewal stamp with the
Notice of Acceptance number and expiration date by the Miami-Dade County Product Control Section.
MISSILE IMPACT RATING:Large and Small Missile Impact Resistant
LABELING:A permanent label with the manufacturer's name or logo,manufacturing address,model
number,the positive and negative design pressure rating,indicate impact rated if applicable,installation
instruction drawing reference number,approval number(NOA),the applicable test standards,and the
statement reading`Miami-Dade County Product Control Approved' is to be located on the door's side track,
bottom angle,or inner surface of a panel.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials,use,and/or manufacture of the product or process.Misuse of this NOA as an endorsement of any product,for
sales,advertising or any other purposes shall automatically terminate this NOA.Failure to comply with any section of
this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami-Dade County, Florida,and followed by the
expiration date may be displayed in advertising literature. If any portion of the NOA is displayed,then it shall be done
in its entirety.
INSPECTION:A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official.
This NOA renews NOA#15-0317.02 and consists of this page 1 and evidence pages E-1 and E-2,aswell as
approval document mentioned above.
The submitted documentation was reviewed by Carlos M.Utrera,P.E.
NOA No.16-0330.02
Expiration Date:August 9,2021
Approval Date:June 23,2016
pb�i¢.�Z4/G Page 1
DAB Door Companv,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
A. DRAWINGS
1. Drawing No. 01-09,titled"Sectional Garage Door", sheets 1 through 5 of 5, dated
02/01/2041,with last revision K dated 03/21/2016,prepared by Al-Farooq Corporation,
signed and sealed by Javad Ahmad,P.E.
B. TESTS "Submitted under NOA #09-0128.04"
1. Test reports on 1)Uniform Static Air Pressure Test, Loading per FBC TAS 202-94
2)Large Missile Impact Test per FBC,TAS 201-94
3)Cyclic Wind Pressure Loading per FBC,TAS 203-94
4)Forced Entry Test,per FBC 2411 3.2.1, TAS 202-94
along with marked-up drawings and installation diagram of a DAB 824 24 GA
Sectional Garage Door with Fixed Windows,prepared by Hurricane Engineering&
Testing, Inc,Test Reports No. HETI-08-2149A/B, dated 06/27/2008, signed and
sealed by Candido F. Font,P.E.
"Submitted under NOA #09-0128.04"
2. Test report of Tensile Test per ASTM E 8,Report No. HETI 08-T182,prepared by
Hurricane Engineering & Testing, Inc., dated 12/23/2008, signed and sealed by
Candido F. Font,P.E.
"Submitted under NOA # 01-0516.03"
3. Test report of large missile impact test per PA 201 and cyclic wind pressure test per
PA 203 on "Sectional Residential Garage Door",prepared by Hurricane Engineering
&Testing, Inc.,Report No. HETI 01-974A, dated 01/29/2001, signed and sealed by
Hector M.Medina, P.E.
4. Test report of Uniform Static Air Pressure Test per PA 202 and Force Entry
Resistance Test on"Sectional Residential Garage Door",prepared by Hurricane
Engineering&Testing, Inc.;Report No. HETI 01-969, dated 01/18/2001. signed and
sealed by Hector M. Medina,P.E.
5. Test report on Salt Spray(Corrosion)Test per ASTM B 117 of a painted G-40 steel
panels,prepared by Celotex Corporation, Test Report No. 258592, dated 08/17/1998,
signed by W.A. Jackson,P.E.
)� �ZQ 14
0411¢1
Carlos M.Utrera,P.E.
Product Control Examiner
NOA No. 16-0330.02
Expiration Date:August 9,2021
Approval Date:June 23,2016
E-1
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
C. CALCULATIONS "Submitted under NOA#14-0814.04"
1. Anchor verification calculations prepared by Al-Farooq Corporation,dated 09/22/2014 and
07/24/2014,signed and sealed by Javad Ahmad,P.E.
"Submitted under NOA #09-0128.04"
2. Anchor verification calculations prepared by Al-Farooq Corporation,complying with F.B.0
2007,dated 12/19/2008,signed and sealed by Humayoun Farooq,P.E.
D. QUALITY ASSURANCE
1. Miami-Dade Department of Regulatory and Economic Resources(RER)
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 15-0915.08, issued to SABIC Innovative Plastics,for their Lexan
Polycarbonate Sheet Products,approved on 12/10/2015 and expiring on 07/17/2018.
2. Notice of Acceptance No. 14-0311.08, issued to Insulfoam,LLC,for their
lnsulfoam Expanded Polystyrene Insulation,approved on 08/14/2014 and expiring on
11/29/2017.
3. Notice of Acceptance No. 11-0926.07,issued to Dyplast Products,LLC,for their Expanded
Polystyrene Block Type Insulation,approved on 11/10/2011 and expiring on 01/11/2017.
4. Notice of Acceptance No. 11-0926.06,issued to Dyplast Products,LLC,for their
Dyplast ISO-Cl Polyisocyanurate Insulation,approved on 11/10/2011 and expiring on
01/11/2017.
5. Notice of Acceptance No. 15-1203.04,issued to Cellofoam North America Inc,for
their Expanded Polystyrene Block Insulation,approved on 03/17/2016 and
expiring on 02/24/2021.
"Submitted under NOA#05-0228.02"
6. Test Report on Accelerated Weathering Using Xenon Arc Light Apparatus Test per
ASTM 0155 of"PVC Extrusion Material",prepared by Hurricane Engineering&
Testing,Inc.,Report No.HETI 04-A002,dated 09/27/2004,signed and sealed by Rafael E.
Droz-Seda,P.E.
7. Test Reports on Tensile Test per ASTM D638 of"PVC Extrusion Material",prepared by
Hurricane Engineering&Testing Inc.,Report No.HETI 04-T251,dated 11/29/2004 signed
and sealed by I.Ghia,P.E.
8. Test Report on Self-Ignition Temperature Test,Rate of Burn Test and Smoke Density
Test of"REHAU non-foam PVC extrusion material",prepared by ETC Laboratories,
Report No.04-761-15019.0,dated 05/06/2004,signed and sealed by J.L.Doldan,P.E.
F. STATEMENTS
1. Statement letter of code conformance to the 5'h edition(2014)FBC and of no financial interest
issued by Al-Farooq Corporation,dated 03/21/2016,signed and sealed by Javad Ahmad,P.E.
OG�14�ZO/C
Carlos M.Utrers,P.E.
Product Control Ezaminer
NOA No.16-0330.02
Expiration Date:August 9,2021 i
Approval Date:June 23,2016
E-2 s
7-1/2-X 3'X 071-GALV.STEEL TOP FDRDRE 6"1/2'x 2-3/4'X 0.1' r 1
f
END ROLLER RME __ SXM PLATE MAIN ONE 3/16-18 YS W/NOT �R
W/(6)/14 X 5/8'SMS- v^® FASTENED TO END STILE WITH OPTIONAL DOOR VIEWER
UT
W THODEtRON SLEEVE(STD.) (6)/t4 x 3/+'SELF DRf3.wc SCREWS TO 8E INSTALLED AT
WITH DUSRON SLEEVE(OPTIONAL) �: CENTER STILE ..
O 0 CENTER STILE f,
F
F
- - �oa ilk
6 41� C3 U- 1 I 1 I v „ li
6 7-1/2'x 2-1/4•x .Wi• 1 r g° xp
GALV. S1EEL CENTER HwCE a�
y� 3f
W/(4)(i14 X 5/8"SNS I
qqx
WITH DEL"SLEEVE(OPIIDIW,) 8
2/oaoRW
w '
�' 1•W x.15'THIK.LATCH i --aa?"K mIx
3TANOMO LOC( •^'— �
SPRING LOADED SLIDE BOl.7 (BOTH SIDES)
FASrENED W/(4)/14 x 1/2' --
__ 3/6'MN4.LOCK EtrAGEMENT
�.WNF'OIMAS TO SECTION 1008 REGARDING GAWC DOORS
yJ
10
ODOR/EIGHT CORSSTS OF �```\\ • 1\\ t --- --__. _..__ 1111-.- '.,
I
-i' 2 SEC M 1 2 YCTItrLS 21' t DIA CNALLVV..-AIRRECR'YPE 1 �1L i \\ _ II OPTIOt♦N,VENT tY
s 1 SECTION,r 3 3Ec110Ns 11- Wf'S4�.:f TO 1 SAFETv FARM 1 1 L A 3
Y 1 BfCigN57 2,'- N '1 (3)NI WILE AT 7. TO MAX. L �01'ROINL FLUSH FACE z
�• _ I OPENING AREA NCT TO EXCEED WOOD GRAIN DESIGN Iy
- 1 • j 120 SO.IN. [COLONIAL DESIGN N „
5 SECTIONS Is,
1 3EGTIDn e^x 3'X o.T' 1 `( ,1 /
SIM PLATE • `\ MAX.DDDR WIDTH x
eIr 2 se SECTIONS 21 WITH(2)it4 x 3/8'SMS , • • /� 9'-4' - --
e 41 11 SECTION 1r 4 SECIQ45—a1 `
6'-r _.S SECTIONS 21•- BRACKET ORACKEt INSIDE ELEYATION
6 kciiiis_�e`=` STD. UFT DOOR LOW HEADROOM RAISED PANEL EL48OSSED DOOR
f'-3---S tECTI01d 16`1 56710M 21• DOOR OPTION EI
,r 1 acnoNs 1e 2 7-- 2i �j
3 SYME07 d,e'3'SECm'rs 2, T i s'x 3-t/e x.oTo' 1111
1Q le•4 SECTIONS 21'
PLATE DAB DOORS INC. ---
0- K SEC104 CENTER STI.ET WIFN(4)/14 X 3/4.844
i0'-6' StY.710144.11•- HuRSCOne MofterW Modal 824/811 F24T
Mml. SIrs 9'-4'X 18'-0"High
To 4 socrio E it i SECTMN it^ ouT.r /14x3/4•ffLF ORLLING SCREWS MAY BE USED With WinOoW Uta tion
HANOLE� -END STRd w LEU a/14 SE s/B`sus 4 9 4
t1 �sECT10RsNNW"
i 1 -_.--
,1- i,I 3 scCiai1 DESIGN PRESSURE RATING - + 5010 PSF
11 2 SELi1ASt- `LOCK BAR GUIDE'S TMS PRODUCT 6 RATED FOR LARGE MISSILE IMPACT - 60.0 PSF
11- I SECTIONS SECTIONS *6 SM71ONS_-1 • INSTALLED ON END STRF Y 4 Yf
l2 4 SECrKNs 16 2 6EriIDwc si WITH(4)/14 z 5/6'SNS PRODUCT RENEWED ¢]
!1 St�� NOTES
1R 6 SEWION6 i'f-S SCCTKINS 21 • a lar X.6W LOCK BAR as complYlnB with tho FIoM.
1 ♦SELTDNi le 1 SEL'Ix1N15 21 ENGAGES W TRAGIC L THIS PRODUCT HAS BEEN DESIGNED AND TESTED TO COMPLY WITH THE Bu0d1aB Gede ON EACH SIDE OI'DOOR REMRREYENTS OE THE 2014(5TH EDITION)FLORIDA BUILDING CODE INCLUDING NCA-Na. 16-0330.02 ` l
1 -3' 3 SELTONS 10 6 FECTWMS 21 HIGH VELOCITY HURRICANE ZONE(/MR).
I z sEctXlNs,e f SEC 21 l.piratbw 0810 9/2 0 21 ,�`• �_
li-f 1 SECTION IB T SECTIONS 21 2, ANCHORS SHALL BE AS LISTED• SPACED AS SHOWN ON DETANLS.
OUTSIDE KEYED LOCK (OPTIONAL) ANCHOR EMBEDMENT 70 BASE MATERIAL SHALL BE BEYOND WALL �• � `
1;?-- e SECOWK 21 i- LOCK BAR LOCKING SHLVM DRESSINC OR STUCCO.
1.-0 A SST101G_Ns 3 So""21 ALTERNATE TO SPRING LOADED SLIDE BOLT 3. ALL BOLTS,NUTS AND WASMEM SHALL BE ZINC PIA-FD CARBON STEEL. N6n p,.*..t Cd/
-r4--F—6 SiC1WF6 1!';eFLTXINS 21 LOCKS SHOWN ABOVE 4. ANCHORING OR LOADING CONDITIONS OTHER THAN THOSE SHOWN IN 1• �;{7 j y
u 3ECM$4 If'6 SECTIONS 2� "f
Sir 3 SSCDKMs 16 6 scctans zl A L DETAILS ARE NOT IE IS S This APPROAat. _
Is- z sec tONe le 7 fEcT10Ns 21 s. A LOW DOPA wN acRFA6E a L1sEo w OEAQ!OF A110NOR5 W1T0 11000 aWLY. OF lrowklq r10.
t3' 1 SECTION,a a CIgMs 21 CDR rEsrm w ACC014]NILE WITH THE RmuREME3rts a naRDA aBo!+:
01-09
13 33L710NS 31 - 6UNDIMC CODE.TAS-202,TAS-201 k TAS-303 Pmt HUM J0O �M•..•_.•
1 • If 4 9EC1ION5 21 I ASTM F1696-03/ASTU Ei696-00. //•�L U\ Shfet t O7 5
60—!D iaovel t+t,��iAA
1 � � � ...-O•��i pyYe�1Oapoy Wa1p
OIYO
1 W OUJ.MD p n� O NH x00 i'S'A 03UO1S
' Tki
_ •. "mt-ld ° r131s.9 wnnal ssruu.9/s x oz-r/L A
� r (1WNOILJO S83TMU"MAN.09' x'Vfa.SCz (1-o".).1pj-Idx.1 SO{x VD ZZ; (aavaNVLs).l x.e/I-z x vD.l�MU o g� (WNCUAO SITYMS 1:331.5,09"X1110.9L'L(1VNOUdO)Slfd10U NOWT.0s' X'VIO.z9'tawamaa ionaoad (ms)saTm ms.0s-x„w.zrlHats HOTH21KIx7VY1�331s
LRHS Whoa NO 037001510�S 03'1Caw gilt
-OU IN3 `1
,Ito” X.f x.z/L-t 304IH M32430
pp rMIS 'AMI ILO'X-Z/t-L
-- m Am Al 1'101 66
as TA 1
b$$o ll SNWdS UOI s 133HS 335
WNdS AXWde tl0!f 13]HS 33$ _ ___.__ 1 WxOVUB>tww THIS
Mfyyi Nf Ay€R! 13%7rY9 Yid M I .601 x,f"C x.612%.6:1
61 Rg� 9 W V3dU UOIOW
j � I
9t/C"l • .f' a 'B•WS.9/s x rl#... 1
. `� �•s13va eon 3M.C/t t
`x N o I soma 9llf(r)/M t3Nre o1 I
'WR ISd OOOZ -W,)N7O1B 03Trif If1.O6-O �37NV1510_ 0313NY"'"m•3.19 131130] r.
ISd oOOC--1 30JON0 3963 MIS.00*X.9/s-Z%y/L-t
�.G9 Z O Q xvie aims OW 3owisia f.A3'NIR,f •3.0.ZI O ILMH dOd.3L/f HLM 31US ON3 :JSiO
01 0310035 0NV 13NVd OS CC311'0 -. . ��SSO
�' 3131700:)01M 30NV19O 3Oa3'N91.9/s-1 3ACOV 10130 339 3NId HU3H3f105
I m.U) )Oole 0311!so 3i3Y7N07 o1N a3YR3'WA.t/L-t _Si3AW M"�513NId WC01 OW'S� ON3 73315 0382x)!.69D'%,1/s-1 X.L/l
$N Z �e T331S YJ 91 x,7 t-L X.Z X../f 3ONW Yid 0
. y SRS.B/S X tl/
S. 371 J90 3003 'HM.9/L-I t 173K5 No 3WN 335 AM40S'N 01
1 y L)1 313110100 a1lX 031103'NIA,Z tl31TIi5Ni 2f000 AIB X"OOOM 0011730007 YW
rn7f N 7NIOYIOR d015 1)MOUdO
o I g z�svag>�-egc ie-sa���ue
I O 13131 343 1V 03No1115Od 13x0"8 Yid 300 /
C. 3�IL5 z 0111- (03OY3UH1 ATVL!) J
31LLS U31WO NI IMOH "NO ,91/6 NI OBT.VISN1 931O5 OVI-9/9-1 X.9t/s-
,32IVm0UVH Amn33S 33YIH'aS. AB HUM BTM'aOOM 01
03N31S!J-WVNO X7Vd1 13315
e .
l' 900!D=1'15100
D2��9 Y 1
p1 Z'O p 1 •0'0.y• 13NVd'LS.rio'J
y c i SM Mo.,L/l
w
� � 1 13NVd N'VAO 1038 SdVi!
O 1
9 Z
slaw mw
gl n� I 1zNw vats vo+c
�1. �RHES 2 x 2 X i/8"HORZ.ANGLE t•
I 5/IB'X 1-5/B"LAO SCREWS WTO WOOD OR HOMZ.TRACK SUPPORT, SMT WELDED TO FIDRIZ.TRICK F-0
a .
4•X 5-1/2'X 3'X.104' 5/18'SLEEVE ANCHORS CENTER SUPPORT REDD.ON DOORS WrP#7110 WEDS d 1-1/2'MART Tp,
i OALV.STEiI WITH 1-1/4•EMBED KTO IMLSONRY EX M 8 PT.W MST AT 3'D.C.
TOP ROIAER BRACKET ON
GLCH SIDE 3 PER BRICNET A RESTOIC.
/FAS7ENE0 W/(e)/14%5/B'S►E5. -- 1 CONNECTED TO MO°RACKET ANGLE Z qq�
000 THX.GALV.STEEL ADJUSTABLE _. AND To°sPmNo'/sWF7 cuoE Wmf 3
SLIDE FASTENED TO BRACKET 2-1/2•X 4-1/4'X 13 GA STFEI PLATES _ A J ND 1/4-20%S/B'BOLT!NUT +C lY7
W/5/11-18 x 3/4'HEX HEAD WE DEO TO 1-1/2'X 1-1/2'X 14 CA.ANGLE -
M.SCREWS a NITTS. FASTENED TO TRACK -
TOP BRALT♦tf WITH(4)1/4-20 SS.BOLT a NUTS\ -- HORLZ.TRACK L040H-OPENING HEIGHT PLUS
j
(STANDARD) - - q
I! TOP BRACKET rr
UFRfIGL TR so- , g
LOW HEADROOM DOOR 14 GA.GALV,
STEEL.TRACK 2-1/B'%1'x.010•J
g \HORIZONTAL R[WFORco¢Nr SECTION A-a
1/Y x 1-J/4•X.059•FORMED STEEL 2-X 5-1/2'x.104' Q a
�+ GLUED TO A4,AND FASTENED TO GKV.STEL (q
VERTICAL STILES 11TM FASTO E9%P).&14 X
(2)J/11•POP RTVE15 (ER LRLACKE7 FOR �- BRACKET PLACE?IEN15
LOW HEADROOM DOOR OPTWR DOOR
_._ - g
HOIWZONTAL REINFORCp1DR MEXIHT 1ST 2ND RH STN Bl BZ B3 B4 85 80_ 87 Be Sx
t//Y 11,10-3/4'%A59"FORMED STEEL 1'-0' 18.18' 18 16 A 1'TO 11-3/i 23 34 45• -
fiLUED PANEL AHO FASTE3IE0 TO 6'-8' 21'18" -
/ (2 e-Pop 7'-0• 21Wmi '2T 21 21' A 1'_70 2"11-5 4 2]' J4' 45' -
-_
iB'18" 18'18_' 34' 48' SB' 67"
_.5/11'MEEnNG RIB21'18• tM/0'21'1'TO 2'11-J/4 23' 31' 45' 86 67" 73-1/4-
2
1.82.OLA.X.50'ROLLER' tt t _ '-SECTIONS ARE NUMBERED SIARRNO AT THE BMW
O. W/.44 OLA.X 4-1/4'"TEM FOR DOORS MORE THAN 8 FT.HIGH.USE ADORWNAL TRACK BRACKETS AT 10.O.C. o
O OPIXINAL 09SLMATIONS: "FF 7 <a1
Ncr r
+ocov+E i5iT, 1.8//x 219 X �S.osa'DENSITY-1.05 PCFIIOZ
A+11-0921.07 m CON41GC/EO TO TRACH Wff�i 1
- 190-25 POLY-ISOCYAMMA7F ) 1/4•DOLTS a NUTS.
SSS DENSM-20 PCF a�j 2
Dj --N.OA#11-0925.08 W
OR N
n d 9V CELL AMFR&&
m
OE1LWT, 1.07 PCF
N.O.A.#15-1203.04
OR - l
0.92 PCF
N.OA 114-0311M aFLU
O 11,14 Cil CALV.STEEL. ffT
ROLLER)HINGEXS 5��SMS I Imo i
I i
MM.424'ROLL FORMED STEEL PANEL - - -- -
DRWTWO QUALITY 9-40
MW.YIELD STRENGTH-74 K51 TRACK CON FIGURAT)d4
KM PRIER AND BMW-ON
POLYSTER PARKED TOP COA7
APPLIED TO BOTH SIDES OF STEEL
Cl
� VEJ7FICJLL LIFT' ,�(�LQ STANDARD LIFE LOW FEADROOM !3 N^
DOUBLE TWIG(
AVA.R ABL F TRACK OPTIONS
12 GA.OALV.STEEL
��`` ♦ L 1 (?
WBO/7T(04L)J
I 1�5/D"!6 Q I•RODUCT RMEWED s 1
s .Na a.Pwnm1 ]j y
O30.02
BOTTOM
SHEET AL OP7f0"s mac 'llwosloaa021
a L�d;roimqCECMN A_A r ' 5
REINFORCEMENT f 1j
3 4- \
/,-,162X
1 MED STEEL %.056'
F IJ
01ST. SELF DRILLING SCFIEIA9 -�- /B X 1' 1��-. o
R z V 1-1/2'MIN. OR JAI
LF DRILLING SCREWS Z q
$ E OIS7. $0 3/16''RNEX'STEEL RIVETS- C
j R p•
` \ / \ / ` MlA1GF7P W/A�a o�c ULinORIP%ooME 1�D5
i I \ 48'O.C. S
REXFORCEAENf
1/2'X I-3/4'x OSB• o p�
..�._ FORMED STEEL 0 Gµ
\\ �� 1/4'DIA LAC SCRENS 1 1/4'Ow.LAC SCREWS� g��j{ AT 6•:WON ENDS � AT 6•FAON ENDS /VTR
WOOD/ 1 1 ANO 19'O.C. M4%. N000 11 K 1 ' \\ AND 19'O.C.LLUL ! -_1 p? 14
q1`
+ i T W'STRIP ADAPTER _ -`WSTOP ACAFIFR
Wa(C t9 V
�- AMINUM STEEL. O u xqpup
RUBBER W'STRIPPING- RUBBER WSOLPPW Q i
050- _ IL Z
-
.21E .534 .700 � Q w s 2 C
i
BOTTOM SEAL NATIONS
OPTION 'A' OPTION
ro I
WOOD BUCK CONNECTION TO WOOD SUBSTRATE (WOOD SPEgflC GRAY"SG-0.55 ANN.)
THE INSTALLATION METHODS SHOWN ABOVE SHOWS 2X6 SYP WOOD PUCK ATTACHMENT T
TO WOOD STRUCTURES.IF THESE METHODS ARE FOLLOWED No ND ADDITIONAL CALCULATIONS/DESIGN `a!
WILL BE REOUMtEO FON DESIGN OF GARAGE DOOR NKHOW�E —.—__...-AUCItOR -__ Z H
FOR DOOR REPLACEMENT APPLICATIONS WIT+NO ENGINEER OF RECORD.INSTALLATION MAY BE j— ----' •I
VERIFIEO AND APPROXID 01'THE BLALCWG OFFICIAL UPON INSPECTION_ y1
_ Ikd Sl` 111E CONE._..i-1/I ,8 1- cn Obi 21
_3 ,MIC BY M4.iT 'T"1- 4•
_3 T Dixuaa n
STEEL STRUCTURE BY Oi HENS 3 T '!TW FILLED N M(1-1 =a" 2-1 4 $
5/16'x 1-5/8' - LT BY'POWERS I fSC. I
LAG SCREWS- /^-MUST SUPEORT THE LOADS IMPOSED -�f'-�M,SO�
AT 12" C. �.RY DOOR SYSTEM _. ._ _. ..._ ar
/ �\ CONCRETE!�a SODD PSI W. N
C-90 CROAT FLLED BLOCKMYen 2000 PSI V N. / ^'
5/16'OK BOLTS L _
"WITH WASHER 6'NUT
waoo eucK CONNECTION To MASONRY .`'. Ar;r D.G.u.X. DIST. i Q
PRESSURE TREATED 2X6 SYP WOW IAMBS WHICH SHALL BE ANCHORED TO 4
GROUTED R04FORCED MASONRY BLOCK WALL OR CONC.COWMN WIN
1/4'ULTRACON BY'ELCO'WITH SPACING OF '
16'O.C.am OROUt-ILEO BIOCI(WAIL.WON2-I/4'WN.EMBED
IM 3000 PSI CONCRETE WITH 1-3/4'MIN.EMBED 1-I/4'X 2-1/2'X 14 GA
2-1/z6' •O.C.Mw.IEDGE OISIANCE 111-1/2• 1_1/2' I ..__-OM.STEEL ANGLE l/2�
1/4'TAPPER BY'POWERS'WITH SPAC'.NO OF
\r-j\+`Y -..17 GA.GALV. SIffi.—_.-._..___._.__.
14'O.C.MO GRJUE FlLLEO BLOCK WALL WITH 1-1/2'NW.EMBED --I 2-1/fC X I•X 14 CA
16'O.C.NT0 3000 PS CONCRETE,WTN 1-'/4'NIX.EMBED 1/16•%2-1 MT BRACKENS f3'LWiC GALVV. TEL 17LEG1(
3'MM EDGE D67ANCE nLLET NF1D5 AT 12'O.C.IN DOOR OPNG. �FASTENED TO TRACK PLATES
AT 12'G.C.MAX. AT 1B•OIC,ABOVE DOOR OPNG. W/ Z 1/4-20X51N'TRUSS H0.
'3 CO/FIEX BY T=O'DR CONNECTED TO CONT ANGLE "� 1111 B.6 LIAbCCXK NUF
7/B lDT 8Y'ITWF WITH SPACING OF W/(3)SPOT WELDS AT EACH SIDE -
24 0.C.9R0 3000 PSI CONCRETE.KM 2-I/2'MIN.EMBED .6
2"MIN,EDGE DISTANCE (�INT?F t`ND F TRA,;K RMRSE_L4d'JS CO ANCIF TFAfK � a 4~
3/B'NLG SLEEVE BY'HXTI'"SPACNG OF To wOQO BI N M-�EL TO CON(YLFTT"AND FII LED R_Q�(
B'O.C. kTTO GROUT FILLED BL.00If WALL.WITH f-1/4'MIN.ENDED,4'MIN fD[ 01ST.
1N'OC.INTO 3000 PS CONCRETE.WITH I-I/4'MN.EMBED AND &TERN.ATE TS^K INST + ATI
GE ON
2-1/2•MIN.EDDISTANCE OTO
Al
PREPARATION Of
NMB$ BY OTHER c PRODUCT RENEWED 9 I
FOR NEW CONSIRUCM/N ENGINEER OF RECORD OR ARCHITECT 70 VTIOiY as wmptgM�p HFI U.PIRNida
ACEgUACY OF SUPPORTING STRUCTURE TO SUPPORT LGAUS IMPOSED SoLl�n9 Cede ASW k a
BY DOOR SYSTEM. No"*. 76-0330.02 {t�• {L. ��;"r I 1 d 1�
FOR CUOR REPLACFUAEM W RETROFIT BUILDINGS WITH NO ENGINEER OF 4
RECORD.DOOR INSTALLATION MAY BE REVIEWED ANO APPROVED BY ERpkeUon b OSl08lZO21 -+
BISLNNG OFFY_LAL UPON INSPECTION. AQ drOWirtq rro.
,O� 01-09
MAXIMUM EXTERIOR(+)LOAD PER JAMB-(9.33'X 50 PSF)/2- 233.3 Lbs per FL aloin E ' .:�QYONAL
I4vtMUM INTERIOR(-)LOAD PER ANIS-(9.33'X 80 PSF)/2-270.9 La.W Ft IM 1� sheet 4 of 5