HomeMy WebLinkAboutNotice of Acceptance (2) i
MIAMF E MLAMI-DADE COUNTY
MIMI PRODUCT CONTROL SECTION
11805 SW 26 Street;Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(ICER) Nflami,Florida 33175-2474
BOARD AND CODE ADMINISTRATION DMSION T(786)315-2590 F(786)315-2599
NOTICE OF ACCEPTANCE (NOA) www.miamidade.eov/economy
DAB Door Company,Inc.
12195 NW 98'Avenue
Hialeah Gardens,FL 33018
,SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction materials.The
documentation submitted has been reviewed and accepted by Miami-Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction(AHJ).
This NOA shall not be valid after the expiration date stated below.The Miami-Dade County Product Control Section.(In
Miami Dade County)and/or the AHJ(in areas other than Miami Dade County)reserve the right to have this product or
material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner,the
manufacturer will incur the expense of such testing and the AHJ may immediately revoke,modify,or suspend the use of
such product or material within their jurisdiction. RER reserves the right to revoke this acceptance, if it is determined
by Miami-Dade County Product Control Section that this product or material fails to meet the requirements of the
applicable building code.
This product is approved as described herein, and has been designed to comply with the Florida Building Code,
including the High Velocity Hurricane Zone.
DESCRIPTION:Hurricane Master Model 824/811 Steel Sectional Garage Door up to 914"Wide w/
Window Lite Option(DP+50.6,-60.0 PSF)
APPROVAL DOCUMENT:Drawing No.01-09,titled"Sectional Garage Door",sheets 1 through 5 of 5,
dated 02/01/2001,with last revision K dated 03/21/2016,prepared by Al-Farooq Corporation,signed and
sealed by Javad Ahmad,P.E.,bearing the Miami-Dade County Product Control renewal stamp with the
Notice of Acceptance number and expiration date by the Miami-Dade County Product Control Section.
MISSILE IMPACT RATING:Large and Small Missile Impact Resistant
LABELING:A permanent label with the manufacturer's name or logo,manufacturing address,model
number,the positive and negative design pressure rating,indicate impact rated if applicable,installation
instruction drawing reference number,approval number(NOA),the applicable test standards,and the
statement reading`Miami-Dade County Product Control Approved'is to be located on the door's side track,
bottom angle,or inner surface of a panel.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials,use,and/or manufacture of the product or process.Misuse of this NOA as an endorsement of any product,for
sales,advertising or any other purposes shall automatically terminate this NOA.Failure to comply with any section of
this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami-Dade County,Florida,and followed by the
expiration date may be displayed in advertising literature. If any portion of the NOA is displayed,then it shall be done
} in its entirety.
INSPECTION:A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official.
This NOA renews NOA#15-0317.02 and consists of this page 1 and evidence pages E-1 and E-2,as well as
approval document mentioned above.
The submitted documentation was reviewed by Carlos M.Utrera,P.E.
NOA No.16-0330.02
M►aMinaoecov►urr Expiration Date:August 9,2021
Approval Date:June 23,2016 �
Page 1
i
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
A. DRAWINGS
1. Drawing No.01-09,titled"Sectional Garage Door",sheets 1 through 5 of 5,dated
02/01/2001,with last revision K dated 03/21/2016,prepared by Al-Farooq Corporation,
signed and sealed by Javad Ahmad,P.E.
B. TESTS "Submitted under NOA#09-0128.04"
1. Test reports on 1)Uniform Static Air Pressure Test,Loading per FBC TAS 202-94
2)Large Missile Impact Test per FBC,TAS 201-94
3)Cyclic Wind Pressure Loading per FBC,TAS 203-94
4)Forced Entry Test,per FBC 2411 3.2.1,TAS 202-94
along with marked-up drawings and installation diagram of a DAB 824 24 GA
Sectional Garage Door with Fixed Windows,prepared by Hurricane Engineering&
Testing,Inc,Test Reports No.HETI-08 2149A/B,dated 06/27/2008, signed and
sealed by Candido F.Font,P.E.
"Submitted under NOA#09.0128.04"
2. Test report of Tensile Test per ASTM E 8,Report No.HETI 08-T182,prepared by
Hurricane Engineering & Testing, Inc., dated 12/23/2008, signed and sealed by
Candido F. Font,P.E.
"Submided under NOA # 01-0516.03"
3.. Test report of large missile impact test per PA 201 and cyclic wind pressure test per
PA 203 on"Sectional Residential Garage Door",prepared by Hurricane Engineering
&Testing,Inc.,Report No.HETI 01-974A,dated 01/29/2001, signed and sealed by
Hector M.Medina,P.E.
4. Test report of Uniform Static Air Pressure Test per PA 202 and Force Entry
Resistance Test on"Sectional Residential Garage Door",prepared by Hurricane
Engineering.&Testing,Inc.,Report No.HETI 01-969,dated 01/18/2001, signed and
sealed by Hector M:Medina,P.E.
5. Test report on Salt Spray(Corrosion)Test per ASTM B 117 of a painted G40 steel
panels,prepared by Celotex Corporation,Test Report No.258592,dated 08/17/1998,
signed by W.A.Jackson,P.E.
i
Carlos M.Utrera,P.E.
Product Control Examiner
NOA No.16-0330.02 s
Expiration Date:August 9,2021
Approval Date:June 23,2016
E-1
i
r
DAB Door Company,Inc.
l
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
C. CALCULATIONS "SubmWed under NOA#14-0814.04"
1. Anchor verification calculations prepared by Al Farooq Corporation,dated 09/22/2014 and
07/24/2014,signed and sealed by Javad Ahmad,P.E.
"Submitted under NOA#09-0128.04"
2. Anchor verification calculations prepared by A1=Farooq Corporation,.complying with F.B.0
2007,dated 12/19/2008,signed and sealed by Humayoun Farooq,P.E.
D. QUALITY ASSURANCE
1. Miami Dade Department of Regulatory and Economic Resources(RER)
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 15-0915.08,issued to SABIC Innovative Plastics,for their Lexan
Polycarbonate Sheet Products,approved on 12/10/2015 and expiring on 07/17/2018.
2. Notice of Acceptance No. 14-0311.08,issued to Insulfoam,LLC,for their
Insulfoam Expanded Polystyrene Insulation,approved on 08/14/2014 and expiring on
11/29/2017.
3. Notice of Acceptance No.11-0926.07,issued to Dyplast Products,LLC,for their Expanded .
Polystyrene Block Type Insulation,approved on 11/10/2011 and expiring on 01/11/2017-
4. Notice of Acceptance No.11-0926.06,issued to Dyplast Products,LLC,for their
Dyplast ISO-Cl Polyisocyanurate Insulation,approved on 11/10/2011 and expiring on
j 01/11/2017 .
f 5. Notice of Acceptance No.15-1203.04,issued to Cellofoam North America Inc,for
their Expanded Polystyrene Block Insulation,approved on 03/17/2016 and
expiring on 02/24/2021.
"Submitted under NDA#05-0228:02"
6. Test Report on Accelerated Weathering Using Xenon Are Light Apparatus Test per
ASTM G155 of"PVC Extrusion Material",prepared by Hurricane Engineering&
Testing,Inc.,Report No.HETI 04-A002,dated 09/27/2004,signed and sealed by Rafael E.
Droz-Sella,P.E.
7. Test Reports on Tensile Test per ASTM D638 of"PVC Extrusion Material",prepared by
Hurricane Engineering&Testing Inc.,Report No.HETI 04-T251,dated 11/29/2004 signed
and sealed by L Ghia,P.E:
S. Test Report on Self-Ignition Temperature Test,Rate of Burn'Test and Smoke Density i
Test of"REHAU non-foam PVC extrusion material",prepared by ETC Laboratories,
Report No.04-761-15019.0,dated 05/06/2004,signed and sealed by J.L.Doldan,P.E.
F. STATEMENTS
1. Statement letter of code conformance to the 5th edition(2014)FBC and of no financial interest
issued by Al-Farooq Corporation,dated 03/21/2016,signed and sealed byJavad hmad,P.E.
Carlos M.Utrers,P.E.
Product Control Examiner
NOA No.16-0330.02
Expiration Date:August 9,2021
Approval Date:June 23,2016
E-2
3
i
,i
5 ,
` � � � - � �
' S
`. �. - y
t � � � r
'I 't2-,7-M ''{.'t" _•I�.._q'e. N4 Wa1R Y �,14�
wwg�=� s%�4 �°aw�w =gym
71 -II ,
1t �• : q .. `��`
BBB F�jy ty
UNP
B8
13
Will
o
it
44 0 1 WEI
IQs� n�
ir k .". -L,
t�••7I' IS{� �(� TW SEC117N.
1 . w evuone• SECTONAf.GARAGE DOOR AL-FAROOQCORPORATION �a
Al n� lu e� ,e�w wry
•pde,1/1ti1•O• II M.10.,•'� Q� [t0EIR5 INC. 924OG RR&PRWMGUr GVCLAPt6ENT
( n' -ME
I Ila+.,e I,o cerxc[bug Rr 1111AW UNSET O 331Ta IfG 710
y' er.6n Iwrn +usn+, qo nes acn 12195 NRA.OE 7H.AVE. MDMA FLOR10A331T0 (CJ.N.—7. c
NULEAFI GARDENS,FL 33018 Enos,aasmoo euc wee,7acnre �r
a me.sr M.(los)ss6-6624 a6aAo w-naoAR
IE M SMEL PANU N
Ims I CON
F� o
2
. ilAFa SSW D'AiR FAME_ Mgt
O� ^
1/Y w.wxn IxxE; O o'�,Sm- r
• .asr sM v:RFL o c nc C a
OuTsim or DDD 0.l
Ga
SO.3
' E ;
MU TRKM SUMO r FAe'ENED SOFro I3RA155 DDDR V(E}'¢$
TO�4w YTIR E'T'SCIBAGE SECDpJTY FLVIdWrt� i
5/ts'x t-5/61AD 5 x I,V51h'IED lV 9/16-DIA.HOLES IN CFMER STLE CL =..E ¢ m t
Dtw.Y TRaTADrD)
at PFR BRN�it POSDI0.VFD AT MLEVEL p o
AT-CHDRS AT Ti'tdLR BRAQQ,I�, a hf. '
DPfNP
S
GWR IAlAf2NC SAY Du v ta-Rdr Bf YerF_RS 1
BT CDDR 8181A1EER
IDR Owd sTx Cf C m BDa( 1 MN.£YBED 4180 IIGCa 4
l0 6u5DIWF SFE xOtE W SLR{ 1-]/B-!9l¢>Z=D69JIC� x
flak 3/8.94 ]/t•k 1.2 Y-1/Y Y IB G4 5"E[l. �Z~vi� �
6 PtR NtxE EIID SBF.mwerrr TU PAx73 tBN B)1/e•me Inr al�rr M'uv1Y m i
//Y x t-]/.•x.0$S•rafDED S rr'd FIAt a A1111]118•AUIx RptlS 1-t/a•Yda CT3D MO CCWVETE CR fi1lIIl HDLX N®ell.
SDUL1m PAC -. SEE DEOa AF!D17= 1-s B-Ifh,wm D6r. NS EDR:REtE � ¢
D1RD FD PAVEL 1TD WW B)10 / <
py.... I Ela SIDE Atpl 5/16•FW'IDIES6 0 IY O.0. L'f6R.tMt fbrA`IEE NfD FUD BDOI Oto
V
"-".rr_ i-I/B•%I-6/S'X b1S SiFA EDQ Wh nw fc a]6lD n wt.
• cFAigl St1E,G111ED J RSUL —M bsD 6aD FYSID tRDCIt rm n 2Do P9 EQl
E l0 PAWL B/(Q 5/16 RhE 5 phTASE
I II i/I'111H I ir1P fQ�
111 x SirME.
'/ �6J_ •Yt-J/T O
1 Z
�AVCWR t1FEA B -
I9•%I]B•%TR < x_1G-10M. 1 (1 PER DPK9CCT 3 q 3 i
STEEL RCY FA4GfQ6 SiDtT 3 FISI.F/tAU[Ff SPADAD D 3 8
gL SM_ET 3 IDR SPACIND t
i r
1
v
a/ISECIM e-a OiD ixT1ER tWGE _
s' �DAR ;
IxSTIIIm OII RW1LR 5lWi t _ (� Ijt
INTERIOR SEDS t.B2•D'A..W mn R xxm tsMj PRODUCT RENEWED
9 0.TI 2x 918-k 1-�SfNUWa) a
2.7r"W z 3�D•SAM FMM(oD7tmRat) eoR"mc® ewa m.s>er;e. _ •�, s -
tz u x]�s/1s-x f-1/T.(mlwlw) FOUIRnaA-IFw 18-0330A2 ! ' s 3 E
FATTB44D N TRIOL AAIfS z.TS lxA.Y Jf xYIDEI RDLLFTS rvntl Se SET"
(
n 1 Fm x s/n•Tmess la' elplttm[[gq�08109r1D21 i `
OS Q 1Db[Mif q Dp Q Broking rA.
' NIY PIaERGEkvWtl V C' a� ���—�9 E
j III, Iht6 6neet DI S�
f
I
F '
' te•ag zt' +5•o z+• +o•en 2
�ANR XO"GH('�I f'NiFl FIflBNT PIWR BN)
[il(i�iai!iiNEeliii N '
as N
CMN9'iF7NR
OOaR R51aXT � s
B
PIN
fl) 1'��N �Fql pa
}}110
Bf
rr
L. J
Fn c —'"� LDLs K l
Wo
+ I + Ir
. ku
pill,
P ian� ox•u+•9f rens one: SEGRCNAL GARAGE-DOOR AL-FAROOQ CORPORATION a� ,
Q d a a. ou Y I pµptNEM A PfMOUCT DfiVil MCNT p
3 .mi_ x w.tf.fn raw xo-rev. DAB DOORS INC. I B3ooFUNnatONN¢S.UI1e 920
w — —•—_ t n,om rn nB gran 12195 NA 98 TH.AVE, MIA881,FLORIDA 391 R
(.73 Cd9398) /r�r
�•1YXNf9 vita, FNirSY SL4 t09DN Nq[9 C
3 o' •aur., wawa,warzo HIALFIJ(GARDENS,FL 11048 Tm.pogzosefm emct99efz9ze ,
UtIto
P NL W. 1D.(3D51 559-9574 CAR-In'
.v ,K@� g lip'988 fp pp 'Z'pp�� u 1g� uasmnTe ,
a 03§1 13yy�¢ d yap y "� 1-1/ YIN. _
BE
6i
MAI
5�
.� ,Y
R
All
—
Is'
�- es
� o
111
o
T1 9
1
— 9 IdINL
•• !� Y 1 Wi!m m� Y
fSL ° ,•^�-01-a1 I f8Y$D D -- SECTIONAL GNNGC DOOP AL-FAROOQ CORPORATION
SL m,t4t1 urabeS xNC[D D� DORS INC. 6NC1N4s&MODYROEVELOPM
a � .mm_ I 11A7.1 rn.rcn acD CkNYt'tl 12189 N.W. B8 71{.AVE aa3O 6YNSCY WPM.SVITC 22o
�•til•INWD 1 W.D415 00110Y 6YL MTON NWW MIAMI,FLORIGq 33173 (Cd.N.9RYtl
°-+ HWXM GARDENS, FL 33018 Ci
,N (moo y�;t 11.1c Wckwce r.9 MR TW.(404)OBiSY.BE .f�DARBMB�e
RO
-
TEL(765)556-'"a 6ARAG RI-OB�
- 1
WWOOW NflCNT_ -. �
O M.CFO,
O `
EXTERIOR
21 .
v ;m
All & ' � � gigs
Nil `
Sam
�M
gig
� 1 l
I
SII i' O
1 illi 1
I. �1 u 1/a•AtA&
'ill II `� WDa.HgORf
i I z kl
T p 15�
�I1D I I S yy El
U
-W "Al
as
MC] dTir
evN]
.L 6" )til]
10 II
A
. a C oF
R,�m aa4> I e]ZS]'
{ 6 M y
' r 2
e m-01-01 ons: SECTIONAL GARAGE DOOR
O � AL-FA Q C0RP0RA410N a�l
v!a_ M o0.tt.f� a 2iN66MC[t 92MItE'ASd PAODUCUrT2220 PMENf
DAB DOORS 1NC" D360 gUN3¢TDgIVE,6UR¢240
1iD"', "`"Apt°Ap" 12195 N.W.98 TH.AVE, MIAMI,FLORIDA 33173 (cA» araaJ
lill
FF
g p 0 +oim.1 u0 as ee»1s N17T HW.EAH GARDENS,FL 33018 � Cr
N dA.Eyl K G.21f L9Wi eWYdiJ TCL(DD01206DiDD PN613062Z02aTe
. .. TEL(3051 06.8D1� E\OI-0DOA3