The URL can be used to link to this page

Home My WebLink AboutProduct Approval EXTERIOR RESEARCH St DESIGN,I.I.C. Certificate of Authorization 119503 Q0T1VN' 1TYJERD 353 CHRISTIAN STREET,UNIT#13 OXFORD,CT 06478 (203)262-9245 EVALUATION REPORT RECEIVED Owens Corning Evaluation Report 037940.02.12-118 One Owens Corning Parkway AUG 1 6 2018 Date of Issuance:022/06/20FL /06/20122 1 Toledo,OH 43659 (740)404-7829 ST. Lucie County, Permitting Revision 8: 10/09/2017 SCOPE: This Evaluation Report is issued under Rule 61G20-3 and the applicable rules and regulations governing the use of construction materials in the State of Florida.The documentation submitted-has been reviewed by Robert Nieminen, P.E. for use of the product under the Florida Building Code and Florida Building Code, Residential Volume. The products described herein have been evaluated for compliance with the,6u' Edition (2017) Florida Building Code sections noted herein. DESCRIPTION: Owens Corning Asphalt Roof Shingles LABELING: Labeling shall be in accordance with the requirements the Accredited Quality'Assurance Agency noted herein and FBC 1507.2.7.1/R905.2.6.1. CONTINUED COMPLIANCE: This Evaluation Report is valid until such' time as the named product(s) changes, the referenced,Quality Assurance documentation changes, or provisions of the Code that relate to the product change. Acceptance of this Evaluation Report by the named client constitutes agreement to notify Robert Nieminen,P.E. if the product changes or the referenced Quality Assurance documentation changes. Trinity)ERD requires a complete review of this Evaluation Report relative to updated Code.requirements with each Code Cycle. ADVERTISEMENT: The Evaluation Report number preceded by the words "Trinity)ERD Evaluated" may be displayed in advertising literature. If any portion of the Evaluation Report is displayed,then it shall be done in its entirety. INSPECTION:Upon request,a copy of this entire Evaluation Report shall be provided to the user by the manufacturer or its distributors and shall be available for inspection at the job site at the request of the Building Official. This Evaluation Report consists of pages 1 through 8. Prepared b rou/npr, 41.. ..l 110 0.0 .tip Q?•�' ,,SS�"'''^'' :}; The facsimile seal appearing was authorized by Robert Robert J.M.Nieminen,P.E. l4 Florida Registration No.59166,Florida DC4ANE1983 ++ Nieminen,P.E.on 10/09/2017.This does not serve as an ,.. electronically signed document. CERTIFICATION OF INDEPENDENCE: 1. Trinity IERD does not have, nor does it intend to acquire or will it acquire, a financial interest in any company manufacturing or distributing products it evaluates. UJ 2. Trinity)ERD is not owned,operated or controlled by any company manufacturing or distributing products it evaluates. 3. Robert Nieminen,P.E.does not have nor will acquire,a financial interest in any company manufacturing or distributing products for which the evaluation reports are being issued. ®� 4. Robert Nieminen,P.E.does not have,nor will acquire,a financial interest in any other entity involved in the approval process of the LL product. 5. This is a building code evaluation. Neither Trinity I ERD nor Robert Nieminen, P.E.are,in any way,the Designer of Record for any project on which this Evaluation Report,or previous versions thereof,is/was used for permitting or design guidance unless.retained specifically for that purpose. s TRINITY 1ERD ROOFING SYSTEMS EVALUATION: 1. SCOPE:. Product Category: Roofing Sub-Category: Asphalt Shingles Compliance Statement: Owens Corning Asphalt Roof Shingles,as produced by Owens Corning,have demonstrated compliance with the following sections of the 6th Edition (2017) Florida Building Code and Florida Building Code, Residential Volume through testing in accordance with the following Standards. Compliance is subject to the Installation Requirements and Limitations/Conditions'of Use set forth herein. 2. STANDARDS: Section Property Standard Year 1507:25,R905.2.4 Physical Properties ASTM D3462 2010 1507.2.7.1,11905.2.6.1 Wind Resistance ASTM D3161 2016 1507.2.7.1,R905.2.6.1 Wind Resistance ASTM D7158 .2011 3. REFERENCES: Enti Examination Reference Date UL LLC(CER9626) Physicals&Wind Resistance File R2453,Vol.3 02/15/2007 UL LLC(CER9626) Physicals&Wind Resistance 20120516-R2453 05/16/2012 UL LLC(TST9628) Physical Properties .•06CA20263 04/18/2006 UL LLC(TST9628) Wind Resistance 11CA34308 02/18/2012 UL LLC(TST9628) Physicals&Wind Resistance 4786093137 02/01/2014 UL LLC(TST.9628) Wind Resistance 4786126532 02/10/2014 UL LLC(TST9628) Physical Properties Classification letter 02/13/2014 UL LLC(TST9628) Physical Properties Classification letter 10/02/2015 Miami-Dade(CER1592) FBC HVHZ Compliance Various NOAs 'Various UL LLC (QUA9625) Quality Control Service Confirmation Exp.05/16/2020 4. PRODUCT DESCRIPTION: 4.1 Asphalt Shinsles: 4.1.1 Classic and Supreme'are fiberglass reinforced,3-tab:asphalt roof shingles. 4.1.2 Berkshire"are fiberglass reinforced,4-tab asphalt roof shingles. 4.1.3 DevonshireT-are fiberglass reinforced,5-tab asphalt roof shingles. 4.1.4 Duration*, TruDefinition Duration, Duration Premium Cool, Tru Definition Duration Designer Color Collection, Tru Definition Oakridge, Oakridge and WeatherGuard HP are fiberglass reinforced, laminated asphalt roof shingles. 4.2 Hip&Ridge Shingles: 4.2.1 Berkshire Hip& Ridge Shingles, High Ridge, WeatherGuardo HP Hip& Ridge Shingles, ProEdge Hip& Ridge Shingles and DuraRidgeTm Hip&Ridge Shingles are fiberglass reinforced,hip and ridge asphalt roof shingles. 4.3 Accessory Starter Strips: 4.3.1 Starter Strip.Shingle,Starter Strip Plus and Starter Shingle Roll are starter strips for asphalt roof shingles. S. LIMITATIONS: 5.1 This is a building code evaluation. Neither TrinityJERD nor Robert Nieminen, P.E. are, in any way, the Designer of Record for any project on which this Evaluation Report,or previous versions thereof,is/was used for permitting or design guidance unless retained specifically for that purpose. 5.2 This Evaluation Report is not for use in FBC HVHZ jurisdictions.- 5.3 Fire Classification is not part of this Evaluation Report,refer to current Approved Roofing Materials Directory for fire ratings of this product. Exterior Research and Design,LLC. Evaluation Report 037940.02.12-R8 Certificate of Authorization#9503 6EDITION(2017)FBC NON-HVHZ EVALUATION FL10674-R13 Owens Coming Asphalt.Roof Shingles Revision 8:10/09/2017 Page 2 of 8 TRINITY ERD 5.4 Wind Classification: 5.4.1 AII'Owens Corning asphalt shingles noted herein are Classified in accordance with FBC Tables 1507.2.7.1 and R905.2.6.1 to ASTM'D3161,Class F and/or ASTM D7158,Class H,indicating the shingles are acceptable for use in all wind zones up to Vasd = 150 mph (Vr,lt = 194 mph). Refer to Section 6 for installation requirements to meet this wind rating. 5.4.2 All Owens Corning hip & ridge shingles, Starter Strip Shingle and Starter Strip Plus noted herein are Classified in accordance with FBC Tables 1507.2.7.1 and R905.2.6.1 to ASTM D3161,Class F, indicating the shingles are acceptable for use in all wind zones up to Vasa=150 mph(V„It=194 mph). Refer to Section 6 for installation'requirements to meet this wind rating. 5.4.3 Classification by ASTM D7158 applies to exposure category B or C,as defined in FBC 1609.4.3,and a mean . roof height of 60 feet or less. Calculations by a qualified design professional are-required for conditions outside these limitations.,Contact the shingle manufacturer for data specific to each shingle. 5.4.4 Refer to Owens Corning published information on wind resistance and installation limitations. 5.5 All products in the roof assembly shall have quality assurance audit in accordance with F.A.C.Rule 61G20-3. 6. INSTALLATION: 6.1 Underlavment: 6.1.1 Underlayment shall be acceptable to Owens Corning and shall hold current Florida Statewide Product Approval,or be Locally Approved per Rule 61G20-3,per FBC 1507.2.3,1507.2.4 or R905.2.3. 6.2 Asphalt Shinsles: 6:2.1 Installation of asphalt shingles shall comply with the Owens Corning current published instructions, using minimum four (4) nails per shingle in accordance with FBC 1507.2.7 or R905.2.6, with the following exceptions: Berkshire shingles require minimum five(5)nails per shingle. ➢ WeatherGuard HP shingles require minimum six(6)nails per shingle. ➢ Devonshird'shingles require minimum six(6)nails per shingle. ➢ Starter Strip Shingle and Starter Strip Plus require minimum five(5)nails per strip. Refer to Owens Corning published information on wind resistance and installation limitations. 6.2.2 Fasteners shall be in accordance with the manufacturer's published requirements, but not less than FBC 1507.2.6 or R905.2.5. Staples are not permitted. 6.2.4 . Where the roof slope exceeds 21 units vertical in 12 units horizontal, special methods of fastening are required. See figures below for details. 6.2.5 Minimum Nailing—Starter Strip Shingle and Starter Strip Plus: Felt undedayment Deck Fef<umlerhymerd Oaek SWedhered Weatherlock8 Self-adhered undedayment WeatherLocko underlayment �.. Drip edge DSP— Drip edge Orly edge edge located ' Nails located ' 2'-'fromeave 21-3`from eave Instagfirst Self-searing adhesive NsmgfirstStainer Strip Plus Starter Stripp positioned along eave With V remmmil g shingle with `\ 6"removed Starter Strip shingle overhangs eaves and rakes 1,V4e Starter stnp Nus overhangs naves and rakes 1/4—31V Exterior Research and Design,U.C. Evaluation Report 037940.02.12-R8 Certlricate a/Authorfiotlon#9503 6'EDITION(2017)FBC NON-HVHZ EVALUATION FL10674-R13 Owens Coming Asphalt Roof Shingles Revision 8:10/09/2017 Page 3 of 8 s \\JTRINITYIERD 6.2.6 Minimum Nailing—Classic®&Supreme: Normal Mansard or Area para Normal Mansard or Area para Wind Areas Htgfi Wind desvanes V Wind Areas High Wind deavanes y Area para want.normeles Areas viantas Tootles Arm pore vientos normaiss Areas vientos fuertes �t• ( 1� rs, ,IBF x• r t° �tA) t' t' z' �,L161��Y,}�°x' 1'. t2 =f t S'Exposure 6 6J8*'Facpasara Esposklifn Expoalci6n 6.2.7 Minimum Nailing—Berkshire4l:, seatant stdp Stalantsuip Lafbadese9ador Laf&adeseffador 8Vz" 9 9 V 8Vf f '`�*8%- 8W 8W 8W } 1° t*J i r Standard Fastening Pattern 6-(Vail Fastening Pattern Seabntstdp La fire do silkdor 00 a Yr t P Asphalt roofing cement Cemeoto do Iocho do asiaho Mansard or Steep Slope Fastening Pattern c Exterior Research and Design,I.I.C. Evaluation Report 037940.02.12-R8 Certificate of Authorization#9503 6T"EDITION(2017)FBC NON-HVH2 EVAWATION FU0674-R19 Owens Coming Asphalt Roof Shingles Revision 8:10/09/2017 Page 4 of 8 C)o TRINITY I ERD 6.2.8 Minimum Nailing—Devonshirem: 1 y 711 8„ g" 8" 7" i 7 n fit 'v �_�• davos Nails • •• t• r a r 5" r exposure Sedant location Exposlci6n de 5"5/8 pulg Ubiced6n del sellador sx• Ten 11"Spots of As hak Roof Cemein Standard 6-Nati Fastening Pattern Mansard or Steep Slope Fastening Pattem 6.2.9 Minimum Nailing — Duration®, TruDefinition® Duration, Duration® Premium Cool & TruDefinitione Duration Designer Color Collection: 4-Nell Fastening Pattern Mall Fastening Pattern SumNail®fashN„g oma VAtlM Sur@NM Wtv Mo amaW dh NA7 WCW Na%typinl •-p..".cu�,wm,.�=a 1;..vr.: ,.•qr.�v.:.<„.;:c.^w awm":-.c�.::.:: >+ta..m wwvasvwwia ..arz>-:+ . meo :;:a;ta".mcmto a;:;..+. Standard Fastening Pattern 6-Nail Fastening Pattern Fastening for Slopes Greater Than 21:12 SunNaR9(W.M.9 oma MtlM Na4 TV*X socrosmer>:-.:.:.>;x:x cwa...o s;:•:".n x--ar• • t-tm”5510^ s� Faur1"S"afbpMtR-r gC*w.t Mansard or Steep Slope Fastening Pattern Exterior Research and Design,U.C. Evaluation Report 037940.02.12-RB Certificate of Authorization#9503 6EDITION(2017)FBC NON-HVHZ EVALUATION F1.70674-1113 Owens Coming Asphalt Roof Shingles Revision 8:10/09/2017 Page 5 of 8 s TRINITY I ERD 6.2.1 Minimum Nailing—TruDefinition Oakridge®,Oakridge®: 4 Nail Pattern 6 Nail Pattern Esquema con 4 davos Esquema con 6 dams r r 5616"Exposure 5 5/S"Exposure. Nags Erposid6nde6618pufg. Nags clavas Fxposid6nde6618pafg Nags 55/8"Eg6U[e s 56/8"Exposuw Erpos1ddnda66/8pulg Exposk0nde 66/Bpulg. Standard Fastening Pattern 6-Nail Fastening Pattern Fastening for Slopes Greater Than 21:12 sum"""funning an.Wdth w47WCW ' 1• 1P F. 11" 1" 7.71 ry .. Four1•SpoholbpMlt Rooting C. t" Mansard or Steep Slope Fastening Pattern 6.2.1 Minimum Nailing—WeatherGuard®HP: FWft llwtgt FFA lin' MO.MtFl i*WKv Exterior Research and Design,L.I.C. Evaluation Report 037940.02.12-R8 Certijfcate of Authorization#9503 6'"EDITION(2017)FBC NON-HVHZ EVALUATION FL30674-R13 Owens Coming Asphalt Roof Shingles Revision 8:10/09/2017 Page 6 of 8 . r TRINITY 1 ERD 6.3.5 Minimum Nailing-ProEdge Hip&Ridge Shingles:. Prevailing Standard Wind DirectionFastening Sealant Strip Pattern 6'Exposure 12• 1 Sealont Fasten 7'h' 7�Ih• 6"Exposure Cover Exposed Eastman with Roof Cement 6.3.6 Minimum Nailing—DuraRidg4e'Hip&Ridge Shingles: Note:The drawings below pertain to minimum,as-tested attachment requirements. Refer to Owens Corning published installation instructions for their minimum requirements. Dincti n dwri na dcn Yue en plain Dinaiond4NWM tre*Ml II_ Vkwsuperlor I_I Dirocd6n dal dttrrto prttdamTtnttro ICK • =I, ° WtcpsCatingSu2N�' �. C°1O O�toi� ' 1 I I I— tin 1 I 7. LABELING: 7.1 Labeling shall be in accordance with the requirements the Accredited Quality Assurance Agency noted " herein. 7.2 Asphalt shingle wrappers shall indicate compliance with one of the required classifications detailed in FBC. Table 1507.2.7.1/R905.2.6.1. 8. BUILDING PERMIT REQUIREMENTS: As required by the Building Official or Authority Having Jurisdiction in order to properly evaluate the installation of this product. 9. MANUFACTURING PLANTS: Contact the named OA entity for information on which plants produce products covered by Florida Rule 9N-3 QA requirements. 10. QUALITY ASSURANCE ENTITY: UL LLC QUA9625;(631)546-2458;Kanchi.Agrawala-Dokania@ul.com END OF EVALUATION REPORT- Exterior Research and Design,I.I.C. Evaluation Report 037940.02.12-R8 Cerd lcate ofAuthoriration#9503 6T"EDITION(2017)FBC NON-HVH2 EVALUATION FL10674-1113 Owens Coming Asphalt Roof Shingles Revision 8:10/09/2017 Page 8 of 8