Loading...
HomeMy WebLinkAboutProduct ApprovalMIAMI•RUE MIAMI -DARE COUNTY PRODUCT CONTROX. SECTION 11805 SW 26 Street, Room 208 DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES (RER) I\'liami, .Florida 33175-2474 BOARD AND CODE ADMINISTRATION DIVISION T(796)315-2590 F(78611-115-2599 NOTICE OF ACCEPTANCE (NOA) www.miamidade.aovreconom DAB Door Company, Inc. 12195 NW 98' Avenue Hialeah Gardens, FL 33018 SCOPE. This NOA is being issued under the applicable rules and regulations governing the use of construction materials. The documentation submitted has been reviewed and accepted by Miami -Dade County RER-Product Control Section to be used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction (AHJ). This NOA shall not be valid alter the expiration date stated below. The Miami -Dade County Product Control Section (in Miami Bade County) and/or the AHJ (in areas other than Miami Dade County) reserve the right to have this product or material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, the manufacturer will incur the expense of such testing and the AHJ may immediately revoke, modify, or suspend the use of such product or material witbin their jurisdiction. RER reserves the right to revoke this acceptance, if it is determined by Miami -Dade County Product Control Section that this product or material fails to meet the requirements of the applicable building code. This product is approved as described herein, and has been designed to comply with the Florida Building Code, including the High Velocity Hurricane Zone. DESCRIPTION: Hurricane Masten Model 8241811 Steel Sectional Garage Door 16'-2" Wide with Window Lite Option (DP +36.0,44-0 PSF) APPROVAL DOC'umwNT: Drawing No. 02-21 Rev L, titled "24 GA., Roll Formed Steel Sectional Garage Door", dated 09/10/2002 and last revised on OCT 05, 2017, sheets 1 through 5 of 5, prepared by Al- Farooq Corporation, signed and sealed by Javad Ahmad, P -E., bearing the Miami -Dade County Product Control Revision stamp with the Notice of Acceptance number and expiration date by the Miami -Dade County Product Control Section. MISSILE IMPACT RATING: Large and Small Missile Impact Resistant LABELING: A permanent label with the manufacturer's name or logo, manufacturing address, model/series number, the positive and negative design pressure rating, indicate impact rated if applicable, installation instruction drawing reference number, approval number (NOA), the applicable test standards, and the statement reading `rami -Dade County Product Control Approved' is to be located on the door's side track, bottom angle, or inner surface of a panel. RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change in. the applicable building code negatively affecting the performance of this product. TERMINATION of this MOA will occur after the expiration date or if there has been a revision or change in the materials, use, and/or manufacture of the product or process. Misuse of this NOA as an endorsement of any product, for sales, advertising or any other purposes shall automatically terminate this NOA. Failure to comply with any section of this NOA shall be cause; for termination and removal of NOA. ADVERTISEIVIENT: The NOA number preceded by the words Miami -Dade County, Florida, and followed by the expiration date may be displayed in advertising literature. If any portion of the NOA is displayed then it shall be done in its entirety_ INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and shall be available for inspection at the job site at the request of the Building Officiat This MOA revises NOA # 15-0304.01 and consists: of this page 1 and evidence pages E-1, E-2 and E-3, as well as approval document mentioned above_ The submitted documentation was reviewed by Ishaq 1. Chanda, P.E. WM"H]ADE CO NOA No. 17-1018.12 Expiration Date. July 21, 2020 Approval Date: December 14, 2017 Page 1 DAB Door Company, Inc. NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED 1. Evidence submitted in previous files A. DRAWINGS 1. Drawing No. 02-21, titled "24 GA. Roll Formed Steel Sectional Garage Door", dated 49/10/2002, with last revision K dated 03/09/2015, sheets 1 through S of 5, prepared by Al- Farooq Corporation, signed and sealed by Javad Ahmad, P.E. B_ TESTS "Submitted tinder N0,4 # 11-0414.12- L Test Report on Uniform Static Aix Pressure Test, Loading and Forced Entry Test per FBC, TAS 202-94, of "DAB 824 Sectional Residential Garage Door" prepared by Hurricane Engineering & Testing Inc., Report No. HETI-07-42110, dated 05/42/2007, signed and sealed by Candido F. Font, P.E. 2. Test Report on Large Missile Impact Test per FBC, TAS 201-94 and Cyclic Wind Pressure Test per FBC, TAS 203-94, of "DAB 824 Sectional Residential Garage Door", prepared by Hurricane Engineering & Testing Inc., Deport No. HETI-11-3204, dated 01/20/2011, signed and sealed by Candido F. Font, P.E. 3. Test Report on Tensile Test per ASTM E8-08 of "Sectional Residential Door (skim)", prepared by hurricane Engineering & Testing Inc, Report No. HETI-11-TI00, dated 01/21/2011, signed and sealed by Candido F. Font, P.E. "Subrnided under NOA # 05-0228.02„ 4. Test Report on Large Missile Impact Test and Cyclic Wind Pressure Test, of "Sectional Residential Door with Windows", prepared by Hurricane Engineering &. Testing Inc., Report No. HETI 03-1328, elated 07/15/2003, signed and sealed by Rafael E. Droz-Sella, P.E. 5. Test Report on Uniform Static Air Pressure Test, of "Sectional Residential Door" prepared by Hurricane Engineering & Testing Inc., Report No. HETI 03-1329, dated 07/15/2403, signed and sealed by Rafael E. Droz-Sella, P.E. G. Test Report on Tensile Test per ASTM E-8 of "Sectional Residential Door (skin}y', prepared by Hurricane Engineering & Testing Inc, Report No. HETI 03-TO78, dated 10131/2003, signed and sealed by Rafael E. Droz-Sella, P.E. "Submitted under NOA # 03-0210.04" 7. Test report on Salt Spray (Corrosion) Test per ASTM B 117 of a painted G-40 steel panels, prepared by Celotex Corporation, Test Report No. 258592, bated 08/17/1998, signed by W. A. Jackson, P.E. C. CALCULATIONS "Submitted under NOA # 14-0814.10„ 1. Anchor verification calculations prepared by Al-Farooq Corporation, dated 09/22/201=1 and 07/24/2014, signed and sealed by Javad Ahmad, P.E. SG`. k- C a,�, Ishaq I. Chanda, P.E. Product Control Examiner NOA No- 17-1018.12 Expiration Date: July 21, 2020 Approval Date: December 14, 2017 E-1 DAB Door Compativ, Inc. NOTICE OF ACCEPTANCE. EVIDENCE SUBNI1TTED C. CALCULATIONS (Cont.) "Submitted under NOA # II -4414.12„ 2. Anchor verification calculations prepared by Al-Farooq Corporation, complying with F.B.0 2007, elated 04/07/2011, signed and sealed by Javad Ahmad, P.E. 3. Anchor verification calculations prepared by AI-Farooq Corporation, complying with F.B.0 2007, dated 12/19/2008, signed and sealed by Humayoun Farooq, P.E. "Submitted under NOA # 09-0128.02 " D. QUALITY ASSURANCE 1. Miami -Dade Department of Regulatory and Economic Resources (RER) E. MATERIAL CERTIFICATIONS 1. Notice of Acceptance No. 13.0717.01, issued, to SABIC Innovative Plastics, for their Lexan Sheet Products, approved on 11/28/2013 and expiring on 07/17/2018. 2. Notice of Acceptance No. 14-0311.08, issued to Insulfoam, LLC, for their Insulfoarn Expanded Polystyrene Insulation, approved on 08/14/2014 and expiring on 11/29/2017. 3. Notice of Acceptance No. 11-0926.07, issued to Dypiast Products, LLC, for their Expanded Polystyrene Block Type Insulation, approved on 11/10/2011 and expiring on 01/11/2017. 4. Notice of Acceptance No. 11-0926.06, issued to Dyplast Products, LLC, for their Dyyplast ISD -C 1 Polyisocyanurate Insulation, approved on 11/10/2011 and expiring on 01/11/2017. 5. Notice of Acceptance No. 10-1129.04, issued to Cellofoam North America Inc, for their Expanded Polystyrene Block Insulation, approved on 02/24/2011 and expiring on 02/24/2016. "Submitted under NOA # 05-0228.02" 6. Test Report on Accelerated Weathering Using Xenon Arc Light Apparatus Test per ASTM G155 of "PVC Extrusion Material", prepared by Hurricane Engineering & Testing, Inc., Report No. HETI 04-A002, dated 09/27/2004, signed and sealed by Rafael E. Droz-Seda, P.E. 7. Test Reports on Tensile Test per .ASTM D638 of "PVC Extrusion Material", prepared by Hurricane Engineering & Testing Inc., Report No. HETI 04-T251, dated 11/29/2004 signed and sealed by 1. Ghia, P.E. 8. Test Report on Self -Ignition Temperature Test, Rate of Burn Test and Smoke Density Test of "RE.HAU non -foam PVC extension material", prepared by ETC Laboratories, Report No. 04-761-15-119.0, dated 05/06/2044, signed and sealed. by J. L. Doldan, P.L. R STATEMENTS "submitted under NOA # 14-om.10" 1. Statement letter of code conformance to the 5s' edition (2014) FBC and no financial interest issued by Al-Farooq Corporation, dated 05/13/2014, signed and seated by Javad Ahmad, P.E. Ishaq 1. Chanuda, P.E. Product Control Examiner NOA No. 17-1018.12 Expiration. Date. July 21, 2020 Approval Date: December 14, 2017 E -2 DAB Door Companty, Inc. NOTICE OF ACCEPTANCE: EVIDENCE SUB 2. New Evidence submitted. A. DRAWINGS 1. Drawing No. 02-21 Rev L, titled "24 GA. Roll Formed Steel Sectional Garage Door", dated 09/10/2002 and last revised on OCT 05, 2017, sheets l through 5 of 5, prepared by Al-Farooq Corporation, signed and sealed by Javad Ahmad, P.E. Note; This revision consist of editorial changes to comply with FBC 2017. B. CALCULATIONS 1. None C. QUALITY ASSURANCE 1. Miami Dade Department of Regulatory and Economic Resources (RER). D. MATERIAL CERTIPIC ATIONS 1. Notice of Acceptance No. 17-4221.06, issued to Insulfoarn, LLC, for their Insulfoam Expanded Polystyrene Insulation, expiring on 11/29/2022. 2. Notice of Acceptance No. 16-1108.04, issued to Dyplast Products, LLC, for their Dyplast ISO -C1 Polyisocyanurate Insulation, expiring on 01/11/2022. 3. Notice of Acceptance No. 15-1203.04, issued to Cellofoarn North America Inc, for their Expanded Polystyrene Bloch Insulation, expiring on 02124/2021. 4. Notice of Acceptance No. 15-0915.08, issued to SABIC Innovative Plastics, for their Lexan Sheet Products, expiring on 07/17/2018. E. STATEMENTS 1. Statement letter of conformance to F°BC 2014 (51b Edition) and F'BC 2017 (61h Edition), prepared by Al Farooq Corporation, dated 10/05/17, signed and sealed by Javad Ahmad, P.E_ F. OTHER 1_ This NOA revises NOA #15-0304.01, expiring 07/21/20. 1sha41. Chaada, P.E. Product Control Fxaminer NOA No. 17-1018.12 Expiration Date: July 21, 2020 Approval Date: December 14, 2017 E -3 I 'B' BM ALL nWPS m an czi�x �n �''n an o x z 4r � cm w 0 a lit bit I0 � C Azo A�r0 v y e ` N ^ O � a xy®y iz� N N a� a sw 71- � 1 a I 'B' BM ALL nWPS m an czi�x �n �''n an o x z 4r � cm w 0 a n- ',777I1i€1115 1 C) P m -_ dr. kry- M tr.A 1' M] F qj gri . ..--'---- 9360 SUNSET DRIVE, SUITE 22( A.M. 353E I eon 29 GA_ Wli FORIO SM SECTIONAL GARAGE DR. AL-FAROOQ CORPORA-noN ce Lrns sn�r DAB Door Company. Inc. —NEER5 m PRODUar DISIELORMENi a 3 rt n a s is 12195 M.W. 98th Ave. MUM, FLORIDA 33173 ) C m mn r9c Hialeah Gardens, Fl- 33018 TEL- (305) X48100 FAY (30r)262697& Tel: (806). 257-2016 Fmc (305) 362-9272--` GAf2AGE\02-21 ReA I0 Azo A�r0 v �l A O � a xy®y iz� n- ',777I1i€1115 1 C) P m -_ dr. kry- M tr.A 1' M] F qj gri . ..--'---- 9360 SUNSET DRIVE, SUITE 22( A.M. 353E I eon 29 GA_ Wli FORIO SM SECTIONAL GARAGE DR. AL-FAROOQ CORPORA-noN ce Lrns sn�r DAB Door Company. Inc. —NEER5 m PRODUar DISIELORMENi a 3 rt n a s is 12195 M.W. 98th Ave. MUM, FLORIDA 33173 ) C m mn r9c Hialeah Gardens, Fl- 33018 TEL- (305) X48100 FAY (30r)262697& Tel: (806). 257-2016 Fmc (305) 362-9272--` GAf2AGE\02-21 ReA .' A `� � � � w �ryry 90TMM SECTION E Wrrh REINFORCING V W j } �+z i2 -oy k, 19 ¢ Q;jxm b wyJr �� P�fol ['s nXn�Cu �4=T F i \ymam ���Zy 9 b 8 z m8X i v - - �� Fn�� y Ca. � F yyq��!` w% EA moo fq w # ALA O , M (T U! _ I _, 9 S. N p S r o ml: x�g A A k �Z yZy yyZ� $+v D.v G"'xN At �'1 Q Qa ten» , z R 4 I Z ° k i w _- yn O?? W Z,lj r*t rn m rn� O C, Q fl a� t2 {ni -T�om� �.+ • :rmd�g�:i '� 3o�zQ- n� „oY- Y=Qn?Y __ mOrzH =4 'Pt n "Omy o�Oyrn 9t111ft!!';1l, e 7'E Enr2edt �n^ $ a In o O r-- ll�lt2ilktl`t� � nl mI Q ae-ta kat I1 24 isioe n an G4 ROLL FOWED 9EE1 SEGrK WiL GAWRA E R AL-FAROOQ CORPORATION N _ s 9o.,a., , s sH� 17149 Door Company, Inc. ENGINEERSPROW1Ct DEver t7nmeNt J t1A7,t WS FHS SFIEE3 I 93160 SUNSET DRIVE, SUi7E 220 a 12195 NV- 38th Ave. MIAMI, nDRk0A=173 � ''E• bY% tAtltRl I< 03.U3.'S uo (YM6GE THS 564°7 (C,A-F. 3538) i o ,o.vs:, c um o •,znc Hialeah Gardens, FI, 33018 Teacanstztsaexaa vAx.t� 5)2GZ4MM Tel: {800} 257-2016 For, (305) 362-4272 GARAGE\02-27 oAs enm R1 U+ a t�PS am m�q N wn a "n x sCf dq yf.. .IrNK rv�iw uu W6l c N 2 A� E7 e6 _ 84 ES B2 R M © O N e to" 24 GA ROLL FORMED WR SECWAAL GARAGE OF raw rw4rev. tl C'.1 OtWE .R§S j DRB Door Company, Inc. 12199 N.W. 98th Ave. ! Hialeah Gardens. Fl. 33018 Tel: (WO) 257-2016 Fug: (305) 382-3272 tr• br• TnRn NO SR$Ef rc aa.cv.ls Rton� s� o mcw W E9 dY l S0.4i,.1 LMhfl=.b 7J 2U1? X N � Cl Ooh 1 � • V_ a\ m � � Nd N S � % a y9NO- T9 OO- r1 \ P\ O C „4 fn m g c=x 9 W .mg invgZm a h oda�C[=a5 .d.j -iy4 NN.�mN.j O �y�i1 O21 LLII Z 2ZGTi 'p0 nOm LF 3- $3!F4FnbIH. n Y AL-FAROOQ CORPORATION a ENGINEERS ✓ . PRODUCT DEVELOPMENT Asa SUMET DRIvF,sUlTE 220 MIAMI, FLOR WA 331" (C-A.N. 3538) 4 TEL (3081264431M FAX (305) 282 MB ctav�z �O9aomm dao = 65TRATE mad$ SYOOf1 navaa �1�r Phi S` i-ac�'-t "onn� - a �Q zcnR�Qoo� !q9g 8" , 1/ _ MIN. �rzvcor�`�o'a� c�ioam c EM $e4,_r0� mwS vp Qpm - ar znFsn� nF �ZvR�m� zzz i ao opo 00 ov a mR ;9 my mom. m�F y�y 4b 00 F. uu 1m ��m 2 1-1/2- M o U{{ �0Qz z o dwh 28Y z c � � \ lvaon/eta Om Po ; 5 oFX z Sin 17 n W zz � I rn 4o�r pC� p mA Q N Sri m m s- � ti N Am NN � # c W W L mo�aw'r7 ' ®mWWm o - v Z Q ®��'-_ .r#��: ��yr� z N =N •�,9 1i ��€gym a � m�e', ov �vx � n Y � X v �v fV n av- ne�nsioe cn on 24 G4. RM FORM STEEL SECTIONA CAILiGE OR. AL-FAR00Q CORPORATION a 9..- - 1]V61NfER5 & PRODUCT DEVELOPMENT fJ � `�+s�1-� �� �= DAV RooT Company, Inc. 93Ea StJNSEr flRtS�, SUT[E 2zfl J 19,O7.14 fIEV. PER RB coYi�um 12195 N.W. 98th Ave- i MFAM1, FLORIDA 33173 (C.A,N. 3598) N dr.bY. TgRfa L 10.a 11 e6lTaD'IWI ex 1ao11wom Hioeah Gardens, FI. 33oia i TEI-C2W)2Ga-81O0 FAX(3as>2e24W7S L 1.03.1 1}P]pSpD D 'LOf] FBG ad�.1>1: _ fret: (8ao) 257-2015 Tax; (3(15) 3&Z-3272 GW7AGE\02-210A8,, P i I - -.. _ o.l ORI � EXTERIOR W � Ijl j 4 Itl' I 1 II7 I!1[ 1 I m Lu I �f \ z�� " A a�� 3,lry �N P; fw v fY ©un D Z N X � � � � �f�fltilli'1 � oa I K7 N 4r. by� rAsq v � o .ink 7ry+: IN 14 1/4" MAX. 14tik. HEIGHT �10 5/8- MAX 1.F cn C) a m O zwa n � mp 0 -u n'U mn x Z0�Ij 2 i. 0 4 d r � III 2 ► .��.: �\\ � a:.\fit :\�\. 1 �� n c r. S.' = o z Ins: xq fn. ROLL [OWED STEEL S UnNk C.4RRGE DR] AFAROOQ CORPORATION i a sli r,,,,AB Door Company, Inc, ENAINISERS & PRODucr DEwt,aPmENr ICY. PER tteR peAlltF,yis8364 SUNSET ORNF, SURE 22O 3.7 NO CH{RGE tA� Se4-'EP 195 �. 9$}h Ave- !' MIAMI. FLORIDA 331.73 {C.41C 9338) C a.tt UNWIPrex2MFec aieoh Gardens, F#. 3301$ TIT.tsOM294-ts3AD FAX (3W \� Tal: (900) 757-20le F— (305) 362-9272 —`- — - -----._ -. 1 i rrr Y i 131 1 W � Ijl j 4 Itl' I 1 II7 I!1[ o r'r 111, m Lu I �f � � �f�fltilli'1 � oa I K7 N 4r. by� rAsq v � o .ink 7ry+: IN 14 1/4" MAX. 14tik. HEIGHT �10 5/8- MAX 1.F cn C) a m O zwa n � mp 0 -u n'U mn x Z0�Ij 2 i. 0 4 d r � III 2 ► .��.: �\\ � a:.\fit :\�\. 1 �� n c r. S.' = o z Ins: xq fn. ROLL [OWED STEEL S UnNk C.4RRGE DR] AFAROOQ CORPORATION i a sli r,,,,AB Door Company, Inc, ENAINISERS & PRODucr DEwt,aPmENr ICY. PER tteR peAlltF,yis8364 SUNSET ORNF, SURE 22O 3.7 NO CH{RGE tA� Se4-'EP 195 �. 9$}h Ave- !' MIAMI. FLORIDA 331.73 {C.41C 9338) C a.tt UNWIPrex2MFec aieoh Gardens, F#. 3301$ TIT.tsOM294-ts3AD FAX (3W \� Tal: (900) 757-20le F— (305) 362-9272 —`- — - -----._ -.