HomeMy WebLinkAboutProduct Approval L:ElED
lli9 EXTERIOR RESEARCH&DESIGN,LLC.
Certificate of Authorization#9503
TRINITY ERS _PrnTTing 353 CHRISTIAN STREET,UNIT#13
r �_- OXFORD,CT 06478
(203)-262-9245
EVALUATION REPORT
Owens Corning Evaluation Report 037940.02.12-118
One Owens Corning Parkway FL10674-R13
Toledo,OH 43659 Date of Issuance:02/06/2012
(740)404-7829 Revision 8: 10/09/2017
SCOPE:
This Evaluation Report is issued under Rule 61620-3 and the applicable rules and regulations governing the use of
construction materials in the State of Florida.The documentation submitted has been reviewed by Robert Nleminen,
P.E. for use of the product under the Florida Building Code and Florida Building Code, Residential Volume. The
products described herein have been evaluated for compliance with the 6u' Edition (2017) Florida Building Code
sections noted herein.
DESCRIPTION: Owens Corning Asphalt Roof Shingles
LABELING: Labeling shall be in accordance with the requirements the Accredited Quality Assurance Agency noted
herein and FBC 1507.2.7.1/R905.2.6.1.
CONTINUED COMPLIANCE: This Evaluation Report is valid until such time as the named product(s) changes, the
referenced Quality Assurance documentation changes, or provisions of the Code that relate to the product change.
Acceptance of this Evaluation Report by the named client constitutes agreement to notify Robert Nieminen,P.E.if the
product changes or the referenced Quality Assurance documentation changes. Trinity(ERD requires a complete
review of this Evaluation Report relative to updated Code requirements with each Code Cycle.
ADVERTISEMENT:The Evaluation Report number preceded by the words "Trinity)ERD Evaluated" may be displayed in
advertising literature. If any portion of the Evaluation Report is displayed,then it shall be done in its entirety.
INSPECTION:Upon request,a copy of this entire Evaluation Report shall be provided to the user by the manufacturer or
its distributors and shall be available for inspection at the job site at the request of the Building Official.
This Evaluation Report consists of pages 1 through 8.
0 Prepared by: ,�f�wnUrra,,rr�
The facsimile seal appearing
Robert J.M.Nieminen,P.E. Nieminen, on SO/09J201�7This does not serve as an
Florida Registration No.59166,Florida DCAANE2983 5' Nleminen,P.E.P.signed document
CERTIFICATION OF INDEPENDENCE:
1. TrinitylERD does not have, nor does it Intend to acquire or will it acquire, a financial interest in any company manufacturing or
' distributing products it evaluates.
2. Trinity I ERD is not owned,operated or controlled by any company manufacturing or distributing products it evaluates.
3. Robert Nieminen,P.E.does not have nor will acquire,a financial interest in any company manufacturing or distributing products for
which the evaluation reports are being issued.
4. Robert Nieminen,P.E.does not have,nor will acquire,a financial interest in any other entity involved in the approval process of the
product.
S. This is a building code evaluation. Neither Trinity IERD nor Robert Nieminen, P.E.are,in any way,the Designer of Record for any
project on which this Evaluation Report,or previous versions thereof,is/was used for permitting or design guidance unless retained
specifically for that purpose.
r
'**\J TRINITY I ERS
ROOFING SYSTEMS EVALUATION:
1. SCOPE:
Product Category: Roofing
Sub-Category: Asphalt Shingles
Compliance Statement: Owens Corning Asphalt Roof Shingles,as produced by Owens Corning,have demonstrated
compliance with the following sections of the 6th Edition (2017) Florida Building Code and Florida Building Code,
Residential Volume through testing in accordance with the following Standards. Compliance is subject to the
Installation Requirements and Limitations/Conditions of Use set forth herein.
2. STANDARDS:
Section Prope Standard Year
1507.2.5,R905.2.4 Physical Properties ASTM D3462 2010
1507.2.7.1,R905.2.6.1 Wind Resistance ASTM D3161 2016
1507.2.7.1,R905.2.6.1 Wind Resistance ASTM D7158 2011
3. REFERENCES:
Ent) Examination Reference Date
UL LLC(CER9626) Physicals&Wind Resistance File R2453,Vol.3 02/15/2007
UL LLC(CER9626) Physicals&Wind Resistance 20120516-112453 05/16/2012
UL LLC(TST9628) Physical Properties 06CA20263 04/18/2006
UL LLC(TST9628) Wind Resistance 11CA34308 02/18/2012
UL LLC(TST9628) Physicals&Wind Resistance 4786093137 02/01/2014
UL LLC(TST9628) Wind Resistance 4786126532 02/10/2014
UL LLC(TST9628) Physical Properties Classification letter 02/13/2014
UL LLC(TST9628) Physical Properties Classification letter 10/02/2015
Miami-Dade(CER1592) FBC HVHZ Compliance Various NOAs Various
UL LLC (QUA9625) Quality Control Service Confirmation Exp.05/16/2020
4. PRODUCT DESCRIPTION:
4.1 Asphalt Shingles:
4.1.1 Classic and Supreme are fiberglass reinforced,3-tab asphalt roof shingles.
4.1.2 Berkshire are fiberglass reinforced,4-tab asphalt roof shingles.
4.1.3 Devonshire'"'are fiberglass reinforced,5-tab asphalt roof shingles.
4.1.4 Duration, TruDefinition Duration, Duration Premium Cool, TruDefinition Duration Designer Color
Collection, TruDefinition ekridge, Oakridge and WeatherGuard' HP are fiberglass reinforced, laminated
asphalt roof shingles.
4.2 Hip&Ridge Shingles:
4.2.1 Berkshire Hip& Ridge Shingles, High Ridge,WeatherGuard*HP Hip& Ridge Shingles, ProEdge Hip& Ridge
Shingles and DuraRidge"'Hip&Ridge Shingles are fiberglass reinforced,hip and ridge asphalt roof shingles.
4.3 Accessory Starter Strips:
4.3.1 Starter Strip Shingle,Starter Strip Plus and Starter Shingle Roll are starter strips for asphalt roof shingles.
S. LIMITATIONS:
5.1 This is a building code evaluation. Neither TrinitylERD nor Robert Nieminen, P.E. are, in any way, the
Designer of Record for any project on which this Evaluation Report,or previous versions thereof,is/was used
for permitting or design guidance unless retained specifically for that purpose.
5.2 This Evaluation Report is not for use in FBC HVHZ jurisdictions.
5.3 Fire Classification is not-part of this Evaluation Report;refer to current Approved Roofing Materials Directory
for fire ratings of this product.
Exterior Research and Design,U.C. Evaluation Report 037940.02.12-R8
Certfj&ate ofAuthorization#9503 EDITION(2017)FBC NON-HVHZ EVALUATION FL10674-1113
Owens Coming Asphalt Roof Shingles Revision 8:10/09/2017
Page 2 of 8
TRINITY J ERD
5_4 Wind Classification:
5.4.1 All Owens Corning asphalt shingles noted herein are Classified in accordance with FBC Tables 1507.2.7.1
and R905.2.6.1 to ASTM D3161,Class F and/or ASTM D7158,Class H,indicating the shingles are acceptable
for use in all wind zones up to Vasd = 150 mph (Vuft = 194 mph). Refer to Section 6 for installation
requirements to meet this wind rating.
5.4.2 All Owens Corning hip & ridge shingles, Starter Strip Shingle and Starter Strip Plus noted herein.are
Classified in accordance with FBC Tables 1507.2.7.1 and R905.2.6.1 to ASTM D3161,Class F, indicating the
shingles are acceptable for use in all wind zones up to Vasd=150 mph(V„n=194 mph). Refer to Section 6 for
installation requirements to meet this wind rating.
5.4.3 Classification by ASTM D71SB applies to exposure category B or C,as defined in FBC 1609.4.3,and a mean
roof height of 60 feet or less. Calculations by a qualified design professional are required for conditions
outside these limitations. Contact the shingle manufacturer for data specific to each shingle.
5.4.4 Refer to Owens Corning published information on wind resistance and installation limitations.
5.5 All products in the roof assembly shall have quality assurance audit in accordance with F.A.C.Rule 61G20-3.
6. INSTALLATION:
6_1 Underlavment:
6.1.1 Underlayment shall be acceptable to Owens Corning and shall hold current Florida Statewide Product
Approval,or be Locally Approved per Rule 61G20-3,per FBC 1S07.2.3,1507.2.4 or R905.2.3.
6_2 Asphalt Shinales:
6.2.1 Installation of asphalt shingles shall comply with the Owens Coming current published instructions, using
minimum four (4) nails per shingle in accordance with FBC 1507.2.7 or R905.2.6, with the following
exceptions:
➢ Berkshire shingles require minimum five(5)nails per shingle.
➢ WeatherGuard*HP shingles require minimum six(6)nails per shingle.
Devonshire'shingles require minimum six(6)nails per shingle.
➢ Starter Strip Shingle and Starter Strip Plus require minimum five(5)nails per strip.
Refer to Owens Corning published information on wind resistance and installation limitations.
6.2.2 Fasteners shall be in accordance with the manufacturer's published requirements, but not less than FBC
1507.2.6 or R905.2.5. Staples are not permitted.
6.2.4 Where the roof slope exceeds 21 units vertical in 12 units horizontal, special methods of fastening are
required. See figures below for details.
6.2.5 Minimum Nailing—Starter Strip Shingle and Starter Strip Plus:
Feltunderieyment Deck FeRanderkyment Deck
Self, edAc
Weathundedayrnem
therLoclte
undedurment '
dg Drip edge Dom'—' Drip
' Nails locatedNaas looted
2'1--3"from eave 2"�"rrom eave
install first p Sell-sealing adhesive
Shin le tarter with positioned along eave �e..�� ` along g
V removed
Starter Strip shingle overhangs eaves and rakes Yr-9i Starter
Strip Plus overhangs eaves and rakes 1/4•-74-
. �
Exterior Research and Design,I.I.C. Evaluation Report 037940.02.12-R8
Certificate ofAuthorization A9503 6'"EDITION(2017)FBC NON-HVHZ EVALUATION FL10674-R33
Owens Coming Asphalt Roof Shingles Revision 8:10/09/2017
Page 3 of 8
TRINITY I ERD
6.2.6 Minimum Nailing—Classic®&Supreme:
Normal Mansard or Aiva para Normal Mansard or Ana Pan
'Wind'Aeoas High Wind dpvanss y Mlliid Anaa High Wind dosvanas y
Area-psra vlantoo norrnales Am" vlantcs Yuartas Arid pairs'idoiitos normal" A<eaa vlarrtoa fuoKaa
... . .
S"Friposuie 6 Wr Exposure
EsposlclGn Eilpoilil6a
6.2.7 Minimum Nailing—Berkshire®:
Aej6ni strip. Sealant strip
;fa ttra de scBeda, La&a&sella&r
SEEN
A 00
B lh 8 Yf 9 Vf 0V ? Lt.8W` awl B W'
s
r
s
Standard Fastening Pattern 6-Nail Fastening Pattern
Seatant3Uip.
La tka de salladu
0 of
r _
ou
2' Asphall:robiing_eement,
Cciirant6 da 1de8ode aslalto
Mansard or Steep Slope Fastening Pattern
Exterior Research and Design,I.I.C. Evaluation Report 037940.02.12-R8
Certilrote ofAuthorlradon#9503 6EDITION(2017)FBC NON-HVHZ EVALUATION FL10674-1113
Owens Coming Asphalt Roof Shingles Revision 8:10/09/2017
Page 4 of 8
TRINITY ERD
6.2.8 Minimum Nailing—Devonshire'"':
$" 8" I 7" 1"
,• arva Nails
•••••• r r r r
HIS'exposure Setdantloestlon ""
fapasici6n de 5618 pulp Ubicad6n del sellodor Gw• �;
Ten 1'Spats of Asphaft Roof Cement
Standard 6-Nail Fastening Pattern Mansard or Steep Slope Fastening Pattern
6.2.9 Minimum Nailing — Duration®, TruDefinition® Duration, Duration° Premium Cool & TruDefinition•
Duration•Designer Color Collection:
4-Nall Fastening Pattern "all Fastening Paltem
.sveNai®faite�iae:ama rWC� &�e,Nal9dtatering meaadINh
NA.LYp" NUG 7wal
Y 1r I 7r 1" 1r it
•.� >.w a.w r.r:o • ��..atw.•r.+a -•• �....o •w.sm+ot.wa. •
G;Wr-yya• 8.118.68R' - -
F---1-.. - M.-, -I-
L. -E
Standard Fastening Pattern 6-Nail Fastening Pattern
Fastening for Stapp Gieat6f Than 2112
aunNaiGy fn6nuq rw vtmn
NW,ltrpktl
t• tr I tr r
au•sar -
e� -
r
r•v t•spots a�sph.n ieoon�q e.m.m
Mansard or Steep Slope Fastening Pattern
Exterior Research and Design,U.C. Evaluation Report 037940.02.12-R8
CertlJlcateofAuthorl:ation#95a3 61H EDITION(2017)FBC NON-HVHZ EVALUATION FL10674-R13
Owens Coming Asphalt Roof shingles Revision 8:10/09/2017
Page 5 of 8
(-)o
TR NrrY j ERD
6.2.1 Minimum Nailing—TruDefinition Oakridge°',OakridgeO:
A Nali l+attim :6`Na1i'Pattern
Esqueiira coif 4 clavos Esgriema'con 6 clavos
Ss
6516"6nwsuro b 618.Eirposup; Nail.
Na0.s 56f6"Erpasme. y SbtB ExQosuie;
BtposieidttQt'b3/S/�utg' GtaYos EzposkldirdrSS/8putg
FxpgsiG6n Qe 6WPa19 Earposieten'dp 6518-U4
Standard Fastening Pattern 6-Nail Fastening Pattern
Fas6cNnp for Slopes Grnater Than 21:12
smeer.o�r.sun��ena.mm
�NN61VDdC4Y
E+.otv+4W<a 'r!.' iw Mus�s0' i.�fe+r ��iaawMRu
44tt• -
ww.
Far 1"Cpels W AaphY1 MaBnG Cao.iR !�—T
Mansard or Steep Slope Fastening Pattern
6.2.1 Minimum Nailing—WeatherGuardO HP:
'(' Z �ii�`Ii�dR_1f1l1sf
.......... ,�
Exterior Research and Design,U.C. Evaluation Report 437940.02.12-118
Certificate oJAuthorizatlon#9S03 67 EDITION(2017)F8C NON-HVHZ EVALUATION FL10674-R13
Owens Coming Asphalt Roof Shingles Revision 8:10/0912017
Page 6 of 8
(_)0
TRINITY I ERD
6_3 Hip&Ridge Shingles:
6.3.1 Installation of Berkshire Hip and Ridge Shingles, High Ridge, WeatherGuarde HP Hip and Ridge Shingles
and ProEdge Hip & Ridge Shingles shall comply with the Owens Coming current published instructions,
using four (4) nails per shingle. Installation of DuraRidgem Hip & Ridge Shingles shall comply with the
Owens Corning current published instructions, using two (2) nails per shingle. Refer to Owens Corning
published information on wind resistance and installation limitations, including the use of hand-sealing for
wind warranties.
6.3.2 Fasteners shall be in accordance with the manufacturer's published requirements, but not less than FBC
1507.2.6 or R905.2.5. Staples are not permitted.
6.3.3 Minimum Nailing—Berkshire®Hip&Ridge and High Ridge:
Fig.4 4 Fig.2
DU
�-- DievN(nDWnG
Direction p� •. TaPNev SIASVIety
Nails' --_�4 p� Neils Naos
A
I I 4. T T TOO Pla:e�1d T '
1-
4 1 i
1 I
A I I
1
1.
1
I
6.3.4 Minimum Nailing—WeatherGuard®HP Hip and Ridge:
Fig.A 4 4
Fig.•C Hip'&Rid&..jWngle Easterling
PrevalMn%1W TopYlaw
'�—Dlraellop.
A
• t1011a
P i I Nails Nails.
jO 1 1 7'•
1 1 2"
I 1;2
P 1 I I I
A.
s
Ecpwureure
Cegwaure
17'
Exterior Research and Design,LLC. Evaluation Report 037940.02.12-R8
Certljkate ojAutharl:ation#9503 6T"EDITION(2017)FBC NON-HVHZ EVALUATION FL30674-1113
Owens Coming Asphalt Roof Shingles Revision 8:10/09/2017
Page 7 of 8
TRINITY,ERD
6.3.5 Minimum Nailing-ProEdge Hip&Ridge Shingles:
Prevailing Standard
Wind Direction seaWMStrip Pastore Fastening I �'
8'Espostae • �'I �'� ih I•-r ,
12' } Sealant
{Fasten 7'h'° 7'le' B'Exposure
cave�Erposid
Faetenete wilt
Roof cement
1-12
6.3.6 Minimum Nailing—DuraRidgeTM Hip&Ridge Shingles:
Note:The drawings below pertain to minimum,as-tested attachment requirements. Refer to Owens Corning
published installation instructions for their minimum requirements.
Top
Oinod4ndddnmFr•danimntn I Vida 101 1-I
N.A
ca
�
t/aiY�_�...�� t � .:��Oitirm tade9 SmeNNaO' - t.•. SAO
1 ma�• e I I �
I I I I il8€
d L �
Kal:g atie ���
I
P
11
7. LABELING:
7.1 Labeling shall be in accordance with the requirements the Accredited Quality Assurance Agency noted
herein.
7.2 Asphalt shingle wrappers shall indicate compliance with one of the required classifications detailed in FBC
Table 1507.2.7.1/R905.2.6.1.
S. BUILDING PERMIT REQUIREMENTS:
As required by the Building Official or Authority Having Jurisdiction in order to properly evaluate the installation of
this product.
9. MANUFACTURING PLANTS:
Contact the named QA entity for information on which plants.produce products covered by Florida Rule 9N-3 QA
requirements.
10. QUALITY ASSURANCE ENTITY:
UL LLC—QUA9625;(631)546-2458;Kanchi.Agrawala-Dokania@ul.com
- END OF EVALUATION REPORT-
Exterior Research and Design,U.C. Evaluation Report 037940.02.12-1118
Certfncate oJAuthodlsatlan 119503 6'"EDITION(2017)FBC NON-HVHZ EVALUATION FL10674-R13
Owens Coming Asphalt Roof Shingles Revision 8:10/09/2017
Page 8 of 8