HomeMy WebLinkAboutProduct Approval MIAMI•� MIAMI-DADE COUNiTY
PRODUCT CONTROL SECTION
11805 S W 26 Street Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(RER) Miami.Florida 33175-2474
BOARD AND CODE.ADMTNISTRATION DIVISION T(78613l5-2590 F(786)315-2599
NOTICE OF ACCEPTANCE(NOA) www.miamidadesnv/economy
DAB Door Company,Inc.
12195 NW 986 Avenue
Hialeah Gardens,FL 33018
SCOPE:
this NOA is being issued under the applicable rules and regulations governing the use of construction materials.The
documentation submitted has been reviewed and accepted by Miami-Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction(AHD).
This NOA shall not be valid after the expiration date stated below.The Miami-Dade County Product Control Section(tn
Miami Dade County)znd'or the AHD(in areas other than Miami Dade County)reserve the right to have this product or
material tested for quality assurance purposes.If this product or material fails to perform in the accepted manner,the
manufacturer will incur the expense of such testing and the AHD may immediately revoke,modify,or suspend the use of
such product or material within their jurisdiction. RER reserves the right to revoke this acceptance,if it is determined
by Miami-Dade Counry Product Control Section that this product or material fails to meet the requirements of the
applicable building code.
This product is approved as dewrihed herein, and has been designed to comply with the Florida Building Cade,
including the High Velocity Euricaae Zone.
DESCRIPTION:Hurricane Master Model 8241811 Steel Sectional Garage Door up to 18'-2"Wide w/
Window Lite Option(DP+40.0,-4-4.0 PSF)
APPROVAL DOCL�1fENT:Drawing No.Ot03 Rev 1,tilled"Sectional Garage Door".sheets 1, Ll,2
through 5 of 5,dated 05/16/2005 and last revised on AUG 17,2017,prepared by AI-Farooq Corporation,
signed and sealed by Javad Ahmed,Y.E.,bearing the Miami-Dade County Product Control Revision srarnp
with the Notice of Acceptance number and expiration date by the Nliami-Dade County Product Control
Scclion.
MISSILE IMPACT RATING:Large and Small Missile Impact Resistant
LABELING:A permanent label with the manufacturer s name or Into,manufacturing address,model
number.the positive and negative design pressure rating,indicate impact rated if applicable,installation
instruction drawing reference number,approval number(NOA),the applicable test standards,and the
statement reading'hliami-Dade County Product Control Approved'is to be located on the doors side track,
bottom angle,or inner surface of a panel.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or ifthere has been a revision or change in the
materials,use,andtor manufacture of the product or process.Misuse of this NOA as an endorsement of any product,for
sales,advertising or any other purposes shall automatically terminate this NOA.Failure to comply with any section of
this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT:The NOA number preceded by the words Miami-Dade County,Florida.and followed by the
expiration dace may be displayed in advertising literature. If any portion of the NOA is displayed,then it shall be done
in its entirety.
INSPECTION:A copy of this entire NCA shall be provided to the user by the manufacturer or its distributors and
shah be available for inspection at the job site at the request of the Building Official.
This NOA revises NOA#16-0330.01 and consists of this page I and evidence pages E-1.E-2 and E-3,as
well as approval document mentioned above.
The submitted documentation was reviewed by Tshaq 1.Chanda,P.E.
NOA No.17-0919.11
mwnwta4Tv Expiration Date:March 29,2022
y Approval Date:December 14,2017
p Page I
DAB Door Company,In
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
1. Evidence submitted in previous files
A. DRAWINGS
1. Drawing No.05-03,titled'Sectional Garage Door',sheets I through 5 of 5,dated
Oi/16,,2005,with revision H dated 03/21/2016,prepared by Al-Farooq Corporation,signed
and sealed by Javad.Ahmad,P.E.
B. TESTS"Submitted under NOA#09-0128.06"
1. Test reports on 1)Uniform Static Air Pressure Test Loading per FBC TAS 202-94
2)Large Missile Impact Test per FBC,TAS 201-94
3)Cyclic Wind Pressure Loading per FBC,TAS 203-94
4)Forced Entry Test per FBC.TAS 202-94
along with marked-up drawings and installation diagram of a DAB 824 24 GA Sectional
Garage Door with Fixed Windows,prepared by Hurricane Engineering&Testing,Inc,Test
Reports\o.BETI-08-2149A/B,dated 06127/2008,signed and scaled by Candido F.Font,
P.E.
2. Test report of Tensile Test per ASTM E 8,Report No.TIETI 08-T182,prepared by
Hurricane Engineering& Testing, Inc., dated 12i232008, signed and seated by Candido F.
Font.PE.
"Submitted underNOA#06-0817.07"
3. Test report of Uniform Static Air Pressure and Force Entry Resistance Test,per FBC,TAS
202-94 on`Sectional Residential Garage Doors',prepared by Hurricane Engineering&
Testing,Inc.,Report No.BETI 05-1445,dated 03/18/2005,signed and sealed by Rafael E.
Droz-Soda.P.E.
4. Test report of Large Missile Impact Test,per FBC TAS 201-94 and Cyclic Wind Pressure
Test per,per FBC,'fAS 203-94 on"Sectional Residential Garage Doers prepared by
Hurricane Engineering&Testing,Inc.,Report No.TWTI 05-1446.dated 05/112005,signed
and scaled by Rafael E.Droz-Seda,P.E.
"Submitted under NOA#03-0210.04"
5. Test report on Salt Spray(Corrosion)Test per ASTM B 117 of a painted G-40 steel panels,
prepared by Celotex Corporation,lest Report No.258592.dated 08/17/1998,signed by W.A.
Jackson,Y.E.
C. CALCULATIONS "Submitted under NOA#14-0814.03"
1. Anchor verification calculations prepared by AI-Farooq Corporation,dated 09.j22/2014 and
0724,12014,signed and sealed by Javad Ahmad,P.E.
"Submitted under NOA#69-0128.06"
2. Anchor verification calculations prepared by At-Farooq Corporation,complying with F.B.0
2007.dated 1112 L2008,signed and sealed by Humayoun Farooq,P.E.
Ish.4 I.c6anaa,P.E.
Product Control Examiner
NOA No.17-0919.11
Expiration Date:March 29,2022
.Approval Date:December 14.Ml1
E-1
DAB Door Cotn ant' Inc.
NOTICE OF ACCEPTANCE.: EVIDENCE SLIBM11"I`ED
D. Ql-ALITY ASSURANCE
1. Uian?i-Dade Department of Regulatory and Economic Rc-sources(RER)
F. MATERIAL.CLRTOICATIQINS
1. Notice of Acceptance'_No. 1i-0915.08,issued to SABIC Innovative 1'last:cs,fcr their
Lexan Polvcarhonatz Sheet Products,approved on 12/10/2015 and expiring on
07 17`2018.
2. '.Notice of Acceptance No. 14-0311.08,issued to Insulfaam,LLC,For their
Insulfuam Expanded Polystyrene Insulation,approved on 08/14/2014 and expi.-ing on
11/29/2017,
3. Notice of Acceptance No. 1]-0926.07,issued to Dyplast Products,LLC,for their
Expanded Polystyrene Block:Type Insulation,approved on 11/l012011 and expiring
on 01/1102017.
4. Notice of Acceptance-No.11-0926.06,issued to Dyplast Products,LLC,for their
Dyplast!SO-Cl Polyisocyanurate Insulation,approved on 11/I0120I I and expiring on
OFl1r2017.
5. Notice of Acceptance No. 15-1203.04,issued to Cellofoam North America Inc, for
their Fxpdnded Polystyrene Block Insulation,approved on 03/17,/2016 and
expiring on 02/24%2021.
"Submitted under rNOA 4 05-02-78.02"
6- Test Report on Accelerated Weathering I-sing Xenon VC Light Apparatus Test per
ASTNI Ci155 of"PVC Extrusion_Material",prepared by Hurricane Engineering&
Testing.Luc-Report No.HFTI 04:A002,dated 09/27r'2004,signed and sealed by
Rafael F.Droz-Soda,P.E.
7. Test Reports on Tensile Test per ASTM D638 of'-PVC Extrusion Material prepared
by Hurr:cane Engineeriag&Testing Inc.,Report No.HFTI 04-T251,dated
I P29'200=4 signed and sealed by I.Crhia,P.E.
S. Test Report on Self-Ignition Temperature Test,Rate of Burn Test and Smoke Density
Test of"REHAU non-foam PVC extrusion material",prepared by ETC Laboratories,
Report No.04-761-M19.0,dated 05i0612004,signed and sealed by J.1..Doldan.P.E.
F. STATEMENTS
]. Statement letter of code conformance to the 5"'edition(2014)FBC and ofno financial
interest issued by AI-Farooq Ccrpomtiou,dated 03,21/2016,signed and sealed by
7avad_lhrnad.P.E.
r
Ls aq t.Chanda.P.E.
Product Control Examiner
SOA N u. 17-0919.11
F.xpiratiott Date:March 29,2022
Approral hate:December 14,A]7
L
D413 Door Comnanv,Inc.
NOTICE OF ACCEPTANCE:EVIDENCE SUB
2. New Evidence submitted.
A. DRAWINGS
1. ]hawing No.05-03 Rev L titled"Sectional Garage Door",sheets 1,LI,2 through.5 of 5,
dated 0516/200S and last revised on AUG 17,2017,prepared by Al-Farooq Corporation,
signed and sealed by.iavad Abroad,P.F.
Note:This recision consist of editorial changes to comply with FBC 2017.
B. CALCULATION'S
1. None
C. QUALITY ASSURANCE
1. Miami Dade Department of Regulatory and Economic Resources(RER).
D. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 17-0221.06,issued to Insulfoam,LI.C,for their
lnsulfoam Expanded Polystyrene Insulation,expiring on 1129./2022.
2. Notice of Acceptance No.16-1108.04.issued to Dyplast Products.LLC,for their Dyplast
ISO-CI Polvisocyanurate Insulation,expiring on 011112022.
3. Notice of Acceptance No. 15-1203.04,issued to Cellofoam North America Inc,for their
Expanded Polystyrene Block Insulation,expiring on 02242021.
4. Notice of Acceptance No.15-0915.08,issued to S.ABIC Innovative Plastics,for their Lexan Sheet
Products,expiring on 0 7/1 72 0 1 S.
E. STATEMENTS
L Statement letter of conformance to FBC 2014(s'^Edition)and FBC 2017(6tb Edition).
plepar:d by Al Farooq Corporation,dated 08/17/17,signed and sealed by Javad Ahmad,
P.E.
F. 0 MER
1. this NOA revises NOA g16-0330.01,expiring 03/29/22.
tshaq 1.Chanda,P.E.
Product Control Examiner
NOA No. 17-09MI1
Expiration Date:March 29,2022
Approval Date:December 14,2017
E3
ZLEB-Z3G(SUE)-3 P,Dz-isz(om).1-L
"i
CLT..�IUOI I—
.1v 4196 'N'
Xund,w—o,D,,I
r4oavuodEpoz)t)OOHV:A--IV
ISIQU�5-�2s
Al 11
zi,
15,,
-Ee
'80"Mi,
OLZ 15'MUO OW In z
S�u -oul 2.11.1 J-0 m
Poll
ull
A
PET
!47;1
, ® L.
ml t
J!
hL
S!RI; q
NMI
A I:-
jA
� � ]ytr I Lii L-L4£�Af)'/ai 91UL-G5Z I004)Y�l I -
ao-ruz/ - � aosur4e iFa 3. 9l0£'f i3 suaP�o� 4o N c s� 4 O
.� t c zee vo¢ao>-,iwaiw o v 4igc 'M N 6 Zl
nac Suns 3AIMa].�sT:ns avee -oul Atiodwoo good 9b'9 r r I �,
iw3wann3nio innooaaasaa3M�se� 1. ___
NOI.LVHOdNOO bOObd-4-9V 324,V- 1N::�-35 -
I ,
a
#G mpg m
ey
� w
-335
-
�w�
s� v 62
W2 ,
00
__ rrt uc(oc7:•�� 3•oz c,(oaa� i..-�-I� — ._. � ,n
_ ego 7n I' u104f Id 'llH
1 i. E_TEE t101 U"If'IMktll64 q 47Bc M N S�l Z l -..-�
U,3 zz ins•3nmol3srvrts o9es •�ul Auodwo� aooB 9Vd ' - I u7 N
•7 vdoi rsianooad vsa33rv�a _ _s.c.A4
NOI1VHodDlPz)booHVd--iv j 4—4 ?a d✓� 'd�.'•^.i 3 - _ ._I r�.j "
leg
N a -
tt
�E
I = 2
Wi 5
J _
i I i
zu.. ._
. 4g
aow_
- llt9t3H;talN3a]
Sg-
- -ys
_�.i. d--mil"'' n �` °d og Sxo a = Y sot FFm noR�s .n
w "1va Yuva:vr,E RLUCi 13 '—p-0 y in rx
d.sn 1' .rl w"w tl a"gfi IJ'h" 6L.1
E2TE[wOWn7J•L — e x
uaz�lns'a:uLxa suns ogcr. .Ou� ,(uod 4 6Y0 wa� �00 1 "�' sO
e Norv3Laeo�in�a.a�naoae ssas3r u CD ,y
uyaoaaoo booavd-7V e100J 3ria^iJtl9-IvNOi.3 _.
i7 _ zaW
or
• Ids .. '�� % � ��� � 3 1y`
x
C$
it
t;a
vet LM
si
ttII Yi' €S 'wE S '•
,r•�s a J lrC :fig � �� ���� 4�€`s I
- � 9
c� v Lfi tYi 59s1 xoJ 916E Lot(Ow1�'H
Bares- 8 l3CC of sudp�rog 4a� f
CD
6ZL 3Lf15'3NNO 135Nf15 Q4eb i 1.
Sul RuodWoD xroa ava n Ln
U:aweoaa as�anaoNa rosaaaN,hN3
L' Noityjjodao3 aoomvd--iv I a00a arvaas IVNOI03G
IL
g a-
� r I
g
•ti 1 I�i wz
III o
J C 3 3
II
� l o
�c �z
G
�s
- --- - — ----- - — --
- - -- --z>
tl]Ie13L�? -