HomeMy WebLinkAboutProduct Approval M IAM PDADE NIIAMI DADE COUNTY
PRODUCT CONTROL SECTION
11805 SW 26 Street,Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(RER) Miami,Florida 33175-2474
BOARD AND CODE ADMINISTRATION DIVISION T(786)315-2590 . F(786)315-2599
NOTICE OF ACCEPTANCE (NOA) www.miamidade.zov/economy
DAB Door Company,lint.
12195 NW 98a'Avenue
Hialeah Gardens,FL 33018
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction materials.The
documentation submitted has been reviewed and accepted by Miami-Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction(AHJ).
This NOA shall not be valid after the expiration date stated below.The Miami-Dade County Product Control Section(In
Miami Dade County)and/or the AHJ(in areas other than Miami Dade County)reserve the right to have this product or
material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner,the
manufacturer will incur the expense of such testing and the AHJ may immediately revoke,modify,or suspend the use of
such product or material within their jurisdiction. RER reserves the right to revoke this acceptance, if it is determined
by Miami-Dade County Product Control Section that this product or material fails to meet the requirements of the
applicable building code.
This product is approved as described herein, and has been designed to comply with the Florida Building Code,
including the High Velocity Hurricane Zone.
DESCRIPTION:Hurricane Master Model 824/811 Steel Sectional Garage Door up to 9'4"Wide w/
Window Lite Option(DP+50.0,-60.0 PSF)
APPROVAL DOCUMENT:Drawing No.01-09 REV]L,titled"Sectional Garage Door",sheets 1 through
5 of 5,dated 02/01/2001 and last revised on OCT 05,2017,prepared by Al-Farooq Corporation,signed and
sealed by Javad Ahmad,P.E.,bearing the Miami-Dade County Product Control Revision stamp with the
Notice of Acceptance number and expiration date by the Miami-Dade County Product Control Section.
MISSILE IMPACT RATING:Large and Small Missile Impact Resistant
LABELING:A permanent label with the manufacturer's name or logo,manufacturing address,model
number,the positive and negative design pressure rating,indicate impact rated if applicable,installation
instruction drawing reference number,approval number(NOA),the applicable test standards,and the
statement reading`Miami-Dade County Product Control Approved'is to be located on the door's side track;
bottom angle,or inner surface of a panel.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials,use,and/or manufacture of the product or process.Misuse of this NOA as an endorsement of any product,for
sales,advertising or any other purposes shall automatically terminate this NOA.Failure to comply with any section of
this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami-Dade County,Florida, and followed by the
expiration date may be displayed in advertising literature. If any portion of the NOA is displayed,then it shall be done
in its entirety.
INSPECTION:A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official.
This NOA revises NOA#16-0330.02 and consists of this page 1 and evidence pages E-1,E-2 and E-31,as
well as approval_document mentioned above.
The submitted documentation was reviewed by Ishaq I.Chanda,P.E.
NOA No.17-1018.13
AMMMMADECOUNTYM Expiration Date:August 9,2021
Approval Date:December 14,2017
Page 1
%
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
1. Evidence submitted in previous files
A. DRAWINGS
1. Drawing No. 01-09,titled"Sectional Garage Door", sheets 1 through 5 of 5, dated
02/01/2001,with last revision K dated 03/21/2016,prepared by Al-Farooq Corporation,
signed and sealed by Javad Ahmad, P.E.
B. TESTS "Submitted under NOA #09-0128.04"
1. Test reports on 1)Uniform Static Air Pressure Test,Loading per FBC TAS 202-94
2) Large Missile Impact Test per FBC,TAS 201-94
3) Cyclic Wind Pressure Loading per FBC,TAS 203-94
4)Forced Entry Test,per FBC 2411 3.2.1,TAS 202-94
along with marked-up drawings and installation diagram of a DAB 824 24 GA
Sectional Garage Door with Fixed Windows,prepared by Hurricane Engineering&
Testing,Inc,Test Reports No.SETT 08-2149A/B,dated 06/27/2008, signed and
sealed by Candido F. Font,P.E.
"Submitted under NOA#09-0128.04"
2. Test report of Tensile Test per ASTM E 8,Report No.HETI 08-T182,prepared by
Hurricane Engineering & Testing, Inc., dated 12/23/2008, signed and sealed by
Candido F. Font,P.E.
",submitted under NOA #01-0515.03"
3. Test report of large missile impact test per PA 201 and cyclic wind pressure test per
PA 203 on"Sectional Residential Garage Door",prepared by Hurricane Engineering
&Testing,Inc.,Report No.HETI 01-974A, dated 01/29/2001,signed and sealed by
Hector M.Medina.P.E.
4. Test report of Uniform Static Air Pressure Test per PA 202 and Force Entry
Resistance Test on"Sectional Residential Garage Door",prepared by Hurricane
Engineering&Testing, Inc.,Report No.BETI 01-969,dated 01/18/2001, signed and
sealed by Hector M. Medina,P.E.
5. Test report on Salt Spray(Corrosion)Test per ASTM B 117 of a painted G-40 steel
panels,prepared by Celotex Corporation,Test Report No.258592,dated 08/17/1998,
signed by W.A.Jackson,P.E.
Ahaq L Chanda,P.E.
Product Control Examiner
NOA No.17-1018.13
Expiration'Date:August 9,2021
Approval Date:December 14,2017
E-1
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
C. CALCULATIONS "Submitted under NOA#14-0814.04"
I. Anchor verification calculations prepared by Al-Farooq Corporation,dated 09/22/2014 and
07/24/2014,signed and sealed by Javad Ahmad,P.E.
"Submitted under NOA#09-0128.04"
2. Anchor verification calculations prepared by Al-Farooq Corporation,complying with F.B.0
2007,dated 12/19/2008, signed and sealed by Humayoun Farooq,P.E.
D. QUALITY ASSURANCE
1. Miami-Dade Department of Regulatory and Economic Resources(RER)
E. MATERIAL CERTIFICATIIONS
1. Notice of Acceptance No. 15-0915.08,issued to SABIC Innovative Plastics,for their Lexan
Polycarbonate Sheet Products,approved on 12/10/2015 and expiring on 07/17/2018.
2. Notice of Acceptance No. 14-0311.08,issued to Insulfoam,LLC,for their
Insulfoam Expanded Polystyrene Insulation,approved on 08/14/2014 and expiring on
11/29/2017.
3. Notice of Acceptance No. 11-0926.07,issued to Dyplast Products,LLC,for their Expanded
Polystyrene Block Type Insulation, approved on 11/10/2011 and expiring on 01/11/2017.
4. Notice of Acceptance No. 11-0926.06,issued to Dyplast Products,LLC,for their
Dyplast ISO-C1 Polyisocyanurate Insulation, approved on 11/10/2011 and expiring on
01/11/2017.
5. Notice of Acceptance No. 15-1203.04,issued to Cellofoam North America Inc,for
their Expanded Polystyrene Block Insulation,approved on 03/17/2016 and
expiring on 02/24/2021.
"Submitted under 1V0,4#05-0228.02"
6. Test Report on Accelerated Weathering Using Xenon Arc Light Apparatus Test per
ASTM G155 of"PVC Extrusion Material",prepared by Hurricane Engineering&
Testing,Inc.,Report No.HETI 04-A002,dated 09/27/2004,signed and sealed by Rafael E.
Droz-Seda,P.E.
7. Test Reports on Tensile Test per ASTM D638 of"PVC Extrusion Material',prepared by
Hurricane Engineering&Testing Inc.,Report No.HETI 04-T251,dated 11/29/2004 signed
and sealed by 1.Ghia,P.E.
8. Test Report on Self-Ignition Temperature Test,Rate of Burn Test and Smoke Density
Test of"REHAU non-foam PVC extrusion material",prepared by ETC Laboratories,
Report No.04-761-15019.0,dated 05/06/2004, signed and sealed by J.L.Doldan,P.E.
F. STATEMENTS
1. Statement letter of code conformance to the 51 edition(2014)FBC and of no financial interest
issued by Al-Farooq Corporation,dated 03/21/2016,signed and sealed by Javad Ahmad,P.E.
Ishaq iL Chanda,P.E.
Product Control Examiner
NOA No.17-1018.13
Expiration Date:August 9,2021
Approval Date:December 14,2017
E-2
DAB Door ComipML Inc.
NOTICE OF ACCEPTANCE:EVIDENCE SUB
2. New Evidence submitted.
A. DRAWINGS
1. Drawing No. 01-09 REV L,titled"Sectional Garage Door'',sheets 1 through 5 of 5, dated
02/01/2001 and last revised on OCT 05,2017,sheets 1 through 5 of 5,prepared by Al-
Farooq Corporation, signed and sealed by Javad Ahmad,P.E.
Note:This revision consist of editorial changes to comply with FBC 2017.
B. CALCULATIONS
1. None
C. QUALITY ASSURANCE
1. Miami Dade Department of Regulatory and Economic Resources(RER).
D. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 17-0221.06,issued to Insulfoam,LLC,for their
insulfoam Expanded Polystyrene Insulation, expiring on 11/29/2022-
2. Notice of Acceptance No. 16-1108.04,issued to Dyplast Products,LLC,for their Dyplast
ISO-C1 Polyisocyanurate Insulation, expiring on 01/11/2022.
3. Notice of Acceptance No. 15-1203.04,issued to Cellofoam North America Inc, for their
Expanded Polystyrene Block Insulation,expiring on 02/24/2021.
4. Notice of Acceptance No. 15-0915.08,issued to SABIC Innovative Plastics,for their Lexan Sheet
Products,expiring on 07/17./2018.
E. STATEMENTS
1. Statement letter of conformance to FBC 2014(5th Edition)and FBC 2017 (6th Edition),
prepared by Ai Farooq Corporation, dated 10/0 -17, signed and sealed by Javad Ahmad,
P.E.
F. OTHM
1. This NOA revises NOA$t16-0330.02,expiring 08/09,21.
Isnaq I.Chanda,P.E.
Product Control Examiner
NOA No.17-1018.13
Expiration Date:August 9,2021
Approval Date:December 14,2017
E-3
M AM';Iq MWN
i�0RA-MAIM199mW !1194
log
R
r
V P I-
M.IP235i A U g
2 6801 0�v
H 0 aim
b
MAI
sx, . 9 2P 1�
1EpQI M Z
rn
a -
1,91 �9�P,
mg P
m g.1 Ili
x
00
if
11111J� t� Ila ill
I 1.1.-1 18" .1 21"
+ bm8'-W DOOR HLIGHT
ME SECTION3 DOOR
TEN SEGO
HMW
"1 111*1110 Al SE--UOUR
Mr —,— SECTIONAL GARAGE DOOR A FAROOQ CORPORATIENOION
a
n. .3.=T
t P9 Taxa n®sPfn
NEERS&PRODUCT DEVELOPMENT tr
DAB Door Company, Inc. 9980 IDR I UTM220
12195 N.W. 98th Ave. ..=!V.2n, Mix.asis)
Hialeah Gardens, Fl. 33018 C
jk L INR."I I T.1;(BOO)2507-2DIG r..(3305)362-2272 TEL13-2—
24 EA STEEL
O
3/i6•AWN RNEfS a3q
nAPS BEM OVER PANEL
O pt1 c" .
X24'STL PANEL ,/2•PUNOfID xOlFS,
�o I A
0 4.O.C. 5 6L'
Tru¢
Qb�EC
1
STEEL,RRT]C BRACKET FASTENED SOLID BRASS DOOR VIEWER
TO WOOD dW9 WITH B,'SCHUGE SECURITY HAROVIAMI
5/16•X 1-5/B•LAC SCREW I ALM M 9/TS'DIA HOLES IN CENTER STILE
(v PER HtAOf[)TPOSITIONAT EYE LEVEL Flat STILE o
OPTIONAL STOP MOULDIM ANCHORSAT TRACK DRAC_.�• p O m
N-r nu nom
INTo C Br vnwE,Rs' W c n"
TO ASONRY SEE OF 8000 BMOC
BY DOOR INSTALLERz'M.EEOIED wlD contRETE
ro uASOMn SEE xotE aN SHEET 4 j14 x s/e'ses / //22'' ,-7/a•wN.mca:oaw:cE
s GA.STEEL
6 PER MNGE ]/ STEE.XCOh, 1.
TOPANELSYOM J!6.OK IRRL 9FTTi BI'Rr,IY E.t. "m
FNO i-f 4 10LL ELBED ORfO CONCRETE OR i7LED 13041 O m m
SOlfRGFiI PINE 1/2•X/-]/4's EB9"FORYFD STEEL FLAPS AND!/16'NLN RNF]S /" V R
GWm ro PANEL AFA szoRm ro SEE nErNL A(xNE T-s/B'ION.EDGE 06TAKCE 0110 CONCILiTE Z 3
OSS SG END SIDE MH 3/I6•POP Rl F O t2.O.C. 4•ION.MGG OISTANCE INTO FELLED UM p ti
_ o Z
° 1-7/6'x 2-5/a•X.015•SMEL F>K.E CONCRETE hPSI TE
_3000 N.
O ROy 8 a g
CENTETR STXF.O,IID ANVETM O EDGE .II C-90 G ROM FULL BLOCK I'm�2000 P9 IAL m�o•.•
. I TO PANEL W/(4)3/16•WETS I o =F
POP WETS
1/2'YRL I X14%6/B'S.MS. '::..ti1_3/18 Fn Zftd..
' 4/PXGE °•'y".•: .:. r Xor swoue►1°deA
/(I) ITf�, ,., I RE%219'X K BRACK0Y PER BAAC12f Hill
S 3 11
STEEL
,HE E TRACK SPAC(E75 g SEE SHEET]FOR fauaO.T SPACV.0 0 O O F
SEE SHEET 3 FOR SPA[4C
7RC=��EIIS
1/4-20 SS BOLT&WA7-1/2•x X71•GALV.CENTER HINGE 7-1/r%7 TG PUSHWA SECTION B-B ENO fa%lEINSTALLED ON/ROLLER SHAFT . t�!.....INTERIOR SIDE ,EROLLERS(SID.),4mGlr)(3 1/B'x,'(STAIAVOI) ,.ordLERS((OPIIOPUL) -275•DLLERS(OPTIONAL) 70.592
`CA mx ros/16'TRACKx F ,/Sr(GPnnuL) 27s•oK x SG•Nnon ROLLERS(oPrwFuu.) >!t :* g & a
W/,/4-20 X 5/6•TMM NO.
WIM 5"STEM -
SLCTM LLS,h LOCK HUT
Q'•. OF droning no.
AYI Ilp 4`` sheet 201 5
Y POP RNE75 5/16•%1-5/6-LAG SLRENS IMO Yi000 OR x0�TMG(SUPPORT. sPo2T V6UtD/7�0 N0�TRACK v a
2-3/4'X S-1/r X 3•X.104• 5/16-S.EEVE A1IGIORS CENTER SUPPORT REO.ON DOORS WITH TWO WELDS AT 1-1/r APART
t d YIgIN i-t/4'ENDED 91TO 1EA501w'! Ex�ING 8 FT.w xfl FIRST AT 3.O.C. i
TOP•RM BRACKET ON F/iOH SDE 3 PER BRPFJ0=1
FASTENED V/(6)114 X 5/8'SMUL t A -I REST AT 9.;LE 0 'p
OOFBECTFD TO FUG EY6ICKET AMAE Z
.090 DOC GALV.STEEL ADJUSTABLE
V/3/&-18 Y 3/4'BOLT h MFf
1 0
SIDE FASTEED TO WUCKET 2-1/r X 4-1/4•X 13 GA SIFEL PUTES AND TO SPR91G filo?=E MDF �• q
V/8 18-15%3/4'!EX HEAD _
WELDED TO 1-1/2•%1-1/2•%14 GA ANGLE -- A+-J (2)1/4-20%3/B'BOLT O MJf F E z
u k NUfi iA51ENED TO 1RACK -- a R
TOP BRACKET VYITH(4)i/4-20 SS BOLT&NUTS HORQ.TRACT(LENGTH a OPENNG HEMIT PLUS 12' 0 ry�-3e
(STANOAPD) d tl
Top HMCKET G p�
LOW O� a CA Guv.STEEL TRACK 2-1/rTRACK
x�� O�Y1 NO
ri
HroRaoNTAI RELVIORITTENT
SECTION A-A p n 8
aPo
GIIr0.9k7.PAt4tFl kAi A D�6D tD " r x 5-1 � TEEEL g d Q
WERTCAL Wn" FASHNIEDW 4 14 X s SYS z S d
`I d (2)3/1e"FOP RNQB }OP)ii3tlER 8R/CJ�T EDR Q R
LOW HEADROOM DOOR OPTNN DOOR •SECwN HEX:HTS BRACM PLACEMENTS LL=�
H OR90NIAL FENFORLSIIERT HOGHT IST 2ND 3RD 4TH sTxl Bt 82 B3 84 85 B6 97 88 Q a'.E.1
WTI 1-3/4'X Or FORYED STEEL. V-0' 1B`18't8'18 /A 1'TO 2"11-3/4' 2r 3C' 45' 58• 6Y - F
GIIkD 10 PANLL AND FASTENED 70
vERiKAI 518E5 VIM 6'-6' 21.1B'iB'21• /A Y 70 Y 11-3/a' 23" 34' 45' 56' BT -
(2)3/15•POP METS 7'-0' 211'21'
5/1C MFEIING I✓!8 T-6• 18.18.15.18'18't'TO 2-11-3/4 23' 34` 45' 56' 87' 7B-1/4'
8•-0' 21'18'19'118"121'11'TO r 11-3/4' 2Y 34' 45• 56' 67' 78-1/4'
LTr -SECTO ARE NUMBERS)STARnNG AT THE BOTTOM
1PA k 30"ROLLERS y� n
0• V/.44 DLk X 4-1/4`STEER ' FOR S DORS MORE 7HN1 B FT.MON.115E ADOTTONAL TRACK BRACKETS AT 10'O.C. 0 v m
O tIRDDBCIBEYEf� (W9 c �R
byRA21 6. LLC' m 19•%219•%33'%.090' YDtm�ii'Mdvnl lft 4TVIG G< LL
STEEL TRICK BRACKETS R,t7-t0 t •l3 L�' or
' tSO-225DENSnY X20 E 2-3/16"MGI Oittr+rW�Ss IE m a n
COMOLIED TO TRACK WDMNLOto LY
z 2 OR
A(i6-110804 )1/4'BOLTS&HMS. u1C4mw1 U 0 Z
Bi'CFI lOFOAD NORTH ADFIAG'
t-4 a DENSIIT-IAT P6 I N XI O
ROA 115-1203.04 q m
OR d
B7'RF n FOAu 11 O Z r
DEJISIT 0.92 PCF
u0A/17-0421.06 0
14 G OILY.SIEfL
ROLLER MGM FASTENED
V/(4)#14 X 5/6'91S I e
¢N
® agy
M.024'ROLL FOTOSTM PANEL. _ p
O AV9G OUAUTF G-40
iNl TtEEO STRENCTH-34 M TRACK CONRCURATION
M
M PRUER AND BNQD-ON
POLTSTER PANED TOP KMT
• APPUED TO BOM SOES OF Sim
VER(1CAL U HIGH LIFT STANDARD Ll LOW HEADROOM
m DOUBLE TRACK `-') S' -
_ _ AVAILABLE TRUCK OPTIONS C -'Y
`AHA W u u IITq
12 CA GALA.ETF BOTTOM BRACKAVENED
A}(
O EOTTOH SEAL OPUDNS
SEE SHEET 4 z
u
OF r�� dl9ring no.
SECTION A-A A A E11vFiI1A1tA sheaf 3 of 5
L
Eg5g ypq {�4� na QQm j N5a"�I.'gj 4'm'w i °1°i pJ �+ WOOD
2 S N N5Pggr"�i QQf2$��`S eefinz� 6h � 7 USSTRATE
WN.
Igo
eq
-13 1, a "
1101 P
aie
s
I I 5
a j Ly:
iA `0
� �y � �w m�5r
W n m %
0;
1011P rC9J_
r II111, f,�^
ls' -Iw a2_D1-o1 rcveons:by esc o - SEOTIONAI GARAGE DOOR AL-FAROOQ CORPORATION d'
Kaq- nn Ox tedgjem P�ANxty XMSxY DAB Door COR7 OR IDC. TNOINEER0 J4 PRODVCLP
MENT P Y 99005ONSETDRTVE.S12795 N.W. 98th AVD. MIAMI.FLORIDA 33173n.N.8638)J .I Hialeah Gardens, FI. 33018 TEL,La6e)7D4aioD ,aentloxn
n� Po?xL1 No ONxCE nns s'+FFt T (608 257-7016 Fuu(SOS)362-927.� 1o.aalr urorrco ro xon rec ) 0ARA0 01-09DR8
MNDO'N HOCM
O oro. O
EXTERIOR
_ -J
----- -
ai
`�1
mm
tem
to t/s•VAX.
m i til! i 1`
r I II I vlDW.MEIGM
III I 10 5/8•MAX.
D.L.O. R
Ln 0m
II�i p
IIjI
I F r
A I{II tD �rWj '
�g II
Z
$� II '
�Z
0
II
—.9-7
Xfa
� �
� � Ilttt
O : o2-ot-m reov soa a° s n °- SECTIONAL GARAGE DOOR AL-FAROOQ CORPORATION
C1'1NLC iNR Sx(R VDABDoor Company, {n0. ENGINEERS&FRODUO7DEV2L0FMENT f
DI .� I tI.03.,1 RV.PFR 9]i MvrD115 99008UNSEf DRIVE,8UI7fi I10
I 5 N.W. 98th Ave. Murat,FLORIDA 33173 (CAN.3638) Ir
o-.tr 7Nao + axor.t rw°w+cz tws sum V
h Cardene, Fl. 33018 TEL(°Oe)zso_au0 _ r�x.ca0etasxewe
N ° cnt bA: t°azn wtui[s ro son me 00)257-2018 Fm;(305)362-9272 GARAG Dt-09DAD