HomeMy WebLinkAboutProduct Approval MIAMI-DADS MIAMI-DARE COUNTY
�. PRODUCT CONTROL SECTION
11805 SW 26 Street,Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(RER) Miami,Florida 33175-2474
BOARD AND CODE ADMINISTRATION DIVISION T(786)315-2590 F(786)315-2599
NOTICE OF ACCEPTANCE (NOA) www.miamidade.sov/economy
DAB Door Company,Inc.
12195 NW 98'Avenue
Hialeah Gardens,FL 33018
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction materials.The
documentation submitted has been reviewed and accepted by Miami-Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction(AHJ).
This NOA shall not be valid after the expiration date stated below.The Miami-Dade County Product Control Section(In
Miami Dade County)and/or the AHJ(in areas other than Miami Dade County)reserve the right to have this product or
material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, the
manufacturer will incur the expense of such testing and the AHJ may immediately revoke,modify,or suspend the use of
such product or material within their jurisdiction. RER reserves the right to revoke this acceptance, if it is determined
by Miami-Dade County Product Control Section that this product or material fails to meet the requirements of the
applicable building code.
This product is approved as described herein, and has been designed to comply with the Florida Building Code,
including the High Velocity Hurricane Zone.
DESCRIPTION:Hurricane Master®Model 824/811 Steel Sectional Garage Door 16'-2"Wide with
Window Lite Option(DP+36.0,-44.0 PSF)
APPROVAL DOCUMENT:Drawing No.02-21 Rev L,titled"24 GA.Roll Formed Steel Sectional
Garage Door",dated 09/10/2002 and last revised on OCT 05,2017,sheets 1 through 5 of 5,prepared by Al-
Farooq Corporation,signed and sealed by Javad Ahmad,P.E.,bearing the Miami-Dade County Product
Control Revision stamp with the Notice of Acceptance number and expiration date by the Miami-Dade
County Product Control Section.
MISSILE IMPACT RATING:Large and Small Missile Impact Resistant
LABELING:A permanent label with the manufacturer's name or logo,manufacturing address,model/series
number,the positive and negative design pressure rating,indicate impact rated if applicable,installation
instruction drawing reference number,approval number(NOA),the applicable test standards,and the
statement reading`Miami-Dade County Product Control Approved' is to be located on the door's side track,
bottom angle,or inner surface of a panel.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials,use,and/or manufacture of the product or process.Misuse of this NOA as an endorsement of any product,for
sales,advertising or any other purposes shall automatically terminate this NOA.Failure to comply with any section of
this NOA shall be cause for termination and removal ofNOA.
ADVERTISEMENT: The NOA number preceded by the words Miami-Dade County, Florida, and followed by the
expiration date may be displayed in advertising literature. If any portion of the NOA is displayed,then it shall be done
in its entirety.
INSPECTION:A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official.
This NOA revises NOA#15-0304.01 and consists of this page 1 and evidence pages E-1,E-2 and E-3,as
well as approval document mentioned above.
The submitted documentation was reviewed by Ishaq I.Chanda,P.E.
NOA No.17-1018.12
MIAMNDADE COUNTY Expiration Date: July 21,2020
•.. , Approval Date:December 14,2017
,' Page 1
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
1. Evidence submitted in previous files
A. DRAWINGS
1. Drawing No.02-21,titled`24 GA.Roll Formed Steel Sectional Garage Door",dated
09/10/2002,with last revision K dated 03/09/2015,sheets I through 5 of 5,prepared by Al-
Farooq Corporation,signed and sealed by Javad Ahmad,P.E.
B. TESTS "Submitted under NDA#.11-0414.12"
1. Test Report on Uniform Static Air Pressure Test,Loading and Forced Entry Test per FBC,
TAS 202-94,of"DAB 824 Sectional Residential Garage Door"prepared by Hurricane
Engineering&Testing Inc.,Report No.BETI-07-4200,dated 05/02/2007,signed and sealed
by Candido F.Font,P.E.
2. Test Report on Large Missile Impact Test per FBC,TAS 201-94 and Cyclic Wind Pressure
Test per FBC,TAS 203-94,of"DAB 824 Sectional Residential Garage Door",prepared by
Hurricane Engineering&Testing Inc.,Report No.HETI-11-3204,dated 01/20/2011,signed
and sealed by Candido F.Font,P.E.
3. Test Report on Tensile Test per ASTM E8-08 of"Sectional Residential Door(skin)",
prepared by Hurricane Engineering&Testing Inc,Report No.HETI-11-T100,dated
01/21/2011,signed and sealed by Candido F.Font, P.E.
"Submitted under NOA #05-0228.02"
4. Test Report on Large Missile Impact Test and Cyclic Wind Pressure Test, of"Sectional
Residential Door with Windows",prepared by Hurricane Engineering&Testing Inc.,Report
No.HETI 03-1328,dated 07/15/2003,signed and sealed by Rafael E.Droz-Seda,P.E.
5. Test Report on Uniform Static Air Pressure Test,of"Sectional Residential Door"prepared by
Hurricane Engineering&Testing Inc.,Report No.HETI 03-1329,dated 07/15/2003, signed
and sealed by Rafael E.Droz-Seda,P.E.
6. Test Report on Tensile Test per ASTM E-8 of"Sectional Residential Door(skin)",prepared
by Hurricane Engineering&Testing Inc,Report No.HETI 03-T078,dated 10/31/2003,
signed and sealed by Rafael E.Droz-Seda,P.E.
"Submitted under NOA#03-0210.04"
7. Test report on Salt Spray(Corrosion)Test per ASTM B 117 of a painted G-40 steel panels,
prepared by Celotex Corporation,Test Report No.258592,dated 08/17/1998,signed by W.A.
Jackson,P.E.
C. CALCULATIONS "Submitted under NOA#14-0814.10"
1. Anchor verification calculations prepared by Al-Farooq Corporation,dated 09/22/2014 and
07/24/2014,signed and sealed by Javad Ahmad,P.E.
C
Ishaq L Chanda,P.E.
Product Control Examiner
NOA No.17-1018.12
Expiration Date: July 21,2020
Approval Date:December 14,2017
E-1
I
I
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
C. C
ALCULATIONSCont.
t )
"Submined under NOA #11-0414.12"
2. Anchor verification calculations prepared by Al-Farooq Corporation,complying with F.B.0
2007,dated 04/07/2011,signed and sealed by Javad Ahmad,P.E.
3. Anchor verification calculations prepared by Al-Farooq Corporation,complying with F.B.0
2007,dated 12/19/2008, signed and sealed by Humayoun Farooq,P.E.
"Submitted under NOA #09-0128.02"
D. QUALITY ASSURANCE
1. Miami-Dade Department of Regulatory and Economic Resources(RER)
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 13-0717.01, issued to SABIC Innovative Plastics,for their
Lexan Sheet Products,approved on 11/28/2013 and expiring on 07/17/2018.
2. Notice of Acceptance No. 14-0311.08, issued to Insulfoam,LLC,for their
Iasulfoam Expanded Polystyrene Insulation, approved on 08/14/2014 and expiring on
11/29/2017.
3. Notice of Acceptance No. 11-0926.07,issued to Dyplast Products,LLC,for their Expanded
Polystyrene Block Type Insulation,approved on 11/10/2011 and expiring on 01/11/2017.
4. Notice of Acceptance No. 11-0926.06,issued to Dyplast Products,LLC,for their
Dyplast ISO-C1 Polyisocyanurate Insulation,approved on 11/10/2011 and expiring on
01/11/2017.
5. Notice of Acceptance No. 10-1129.04,issued to Cellofoam North America Inc,for their
Expanded Polystyrene Block Insulation,approved on 02/24/2011 and expiring on 02/24/2016.
"Submitted under NOA#OS-0228.02"
6. Test Report on Accelerated Weathering Using Xenon Arc Light Apparatus Test per
ASTM G155 of"PVC Extrusion Material",prepared by Hurricane Engineering&
Testing,Inc.,Report No.HETI 04-A002,dated 09/27/2004,signed and sealed by Rafael E.
Droz-Seda,P.E.
7. Test Reports on Tensile Test per ASTM D638 of"PVC Extrusion Material",prepared by
Hurricane Engineering&Testing Inc.,Report No.HETI 04-1251,dated 11/29/2004 signed
and sealed by I.Ghia,P.E.
8. Test Report on Self-Ignition Temperature Test,Rate of Bum Test and Smoke Density
Test of"REHAU non-foam PVC extrusion material",prepared by ETC Laboratories,
Report No.04-761-15019.0, dated 05/06/2004,signed and sealed by J.L.Doldan,P.E.
F. STATEMENTS "Submitted under NOA#14-081410"
1. Statement letter of code conformance to the 561 edition(2014)FBC and no financial interest
issued by AI-Farooq Corporation,dated 05/13/2014,signed and sealed by Javad Ahmad,P.E.
Ishaq I.Chanda,P.E.
Product Control Examiner
NOA No. 17-1018.12
Expiration Date:July 21,2020
Approval Date:December 14,2017
E-2
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE:EVIDENCE SUB
2. New Evidence submitted.
A. DRAWINGS
1. Drawing No.02-21 Rev L,titled"24 GA. Roll Formed Steel Sectional Garage Door'',
dated 09/10/2002 and last revised on OCT 05,2017,sheets 1 through 5 of 5,prepared by
Al-Farooq Corporation, signed and sealed by Javad Ahmad, P.E.
Note:This revision consist of editorial changes to comply with FBC 2017.
B. CALCULATIONS
1. None
C. QUALITY ASSURANCE
1. Miami Dade Department of Regulatory and Economic Resources (RER).
D. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 17-0221.06,issued to Insulfoam,LLC, for their
Insulfoam Expanded Polystyrene Insulation,expiring on 11/29/2022.
2. Notice of Acceptance No. 16-1108.04,issued to Dyplast Products,LLC,for their Dyplast
ISO-C1 Polyisocyanurate Insulation,expiring on 01/11/2022.
3. Notice of Acceptance No. 15-1203.04, issued to Cellofoam North America Inc, for their
Expanded Polystyrene Block Insulation,expiring on 02/24/2021.
4. Notice of Acceptance No. 15-0915.08,issued to SABIC Innovative Plastics,for their Lexan Sheet
Products,expiring on 07/17/2018.
E. STATEMENTS
1. Statement letter of conformance to FBC 2014(5th Edition)and FBC 2017 (6th Edition),
prepared by Al Farooq Corporation,dated 10/05/17,signed and sealed by Javad Ahmad,
P.E.
F. OTHER
1. This NOA revises NOA 915-0304.01,expiring 07/21/20.
\4�,fn V L`,.a ..
Lshaq L Chanda,P.E.
Product Controt Examiner
NOA No. 17-1018.12
Expiration Date:July 21,2020
Approval Date:December 14,2017
E-3
;-.IV/2W-2-t 4'%78 GA R1St1 NVf TOP iTXNRE S-1/2'X 2-3/4'X O.1'
W/(STEEL LOSE O STEEL PULE 5-11 ONE 5/16-18 Its W/NUT OPTIONAL DOOR NEWER -
W/(4)/74%3/8'SYS FASfLNED TO 00 STILE WITH TO BE INSTALLED AT
e WRHOVT Of1KW.SLEEVE(SID.) I A 0 B 1 (6)/14 X 3/4'SELF DRILLING SCREWS ANY
COFIEft SIVE
p 7-1/2'X 3'X A71'CAM STEEL SEE SHEEP 3 FOR TOP BRACKET OPTIONS = ?dw C
Ewn ROl1FR HINGE 1 0 0 ' CENTER STIES A O y n
W/(6)I/4 X s/8's36 SEE SCH.•A• f
WITHOUT DELRON SLEEVE(STD.)) 6 l
B WITH DELRON SLEEVE(OPfgNAl) p O
X 2-1/C X Wl' ---- I
O
W/(4)
XCEN�SUSE 2/DOOR
0.0
OEIRON SLEEVE(OPI)ONALj -- -------
WITH
``�� w �m
r 1 {Y7 ao ppp22pp��1TT F
O •Al +'W X.15 DILL UTCN��`` I�II1�IIj�'((��I a C C g
CENTER HINGE T STANMRD `1 ® ® KUM
IAV I® O Z �_
SPWtiG IMOED SLIDE BOR(BORT ME-) o n
FASTENED W/(4)Ito X 1/Y S.YS. I o oS x g
'f
'—_s/a'MIN.LDIX ETIfAGEAHNT �\
c�ARAcoo s�tE1w1 laae REGARDING 1M
13,
in
In LL Z o D
-- �$o
.158 DN CALV.NRCRAFf TTPE
B
x/W.s 1D�SAF.EI FACTOR A d e ` B
2-3/4-W X 5-5/8'M%.090'1FOCI
STEEL PIAIE,t-3/e'11EID I
SELFDRILLING(3�I G SCIMWS' ♦L 9 p 0
i U
m
BRACKET BRACKET T d
SED.LIFT DOOR LAW HFADR00Y
DOOR OPT10N
rout/ro
tXxR
HDQ,T 00S. OF EAM OM 7-7 'x 3-+/8'x.oto' OPTIONAL VENTS LOFDOXAL FLUSH FACE
I 8 Co3 E•j
6'-6' 2 SFt1015 le'2 SS'11016 21 SfEll fRA1E c( 5'WADE AT 7'O.C.w%. MAIL�R�� Wppp GRAN DESIGN L.�A p Z Ldj.mv
I smROF1 1lr SECTKW 21 WITH(4)I14 X 3/4'�S ' O�NG.AREA NOT TO EXCEED 120 SO.IN.
7 4 SE00011S 21'- 0
1.7'-s- 16'-2- L]N
r v s sam1S IB'- CENTER STEP tE17H
PRODUCT is RATED FOR LARGE MISSILE IMPACT
INSIDE ELEVATION e�imDnalc ETESTED NTAs�o2os vs-m1 TASTHE�O- rsH¢AROvo cdi m d..
7'-9'4 SECTIONS IT 1� 210 a�� ASLY Emw-OSA EI.6-0. N =r
IF 3 Sl B IT 2 SECTIONS 21 RAISED PANEL EMBOSSED DOOR
W'T z SEDOOHS W 3 9nTrolS 21' 1lat1olE GENERAL NOTES 0
W-6' 1 SCBON te' 4 SE 2l END STILE DAB DOORS INC. - 1.THIS PRODict HAS BFEi1 OESIQ:m AI0 TESTED ro CouPtr MRI 111E
B'-9'5 STTaiNs 21'- H—i...W..ters Y.odei 824/811 FMOLOU30M O'T�W.(5T.ED=.)/M17(BRI EIXIION)FLORIDA
9• a 6mROHS 1s•- / BtAt1O1C CODE DX2IKMAC INN VELOCITY IRAdDiNE 20NE(Ma). YY
9•-3•5 SECrg16 IT t SECTSII 21• R CLMES MOX.Sea 16'-2'X 16'-0'High 2 AVOWflS SHALL BE CORROSION R13SA NT.SPACED S SNOAN ON DETA6B C
e'-e•4 SFCOorS 1B'z 52IIILP6 21• D ON END STILE With W.,6-Lite Op(ion /.M!Eb7)yLED 14E YANUiS Pb1RUCIgtS.SPELIr1ED F]NBmWIf m BASE '�a
I14%5/8'St6 DWI.SALL BE BFYOIND WALL DRESSING OR STUCCO.J Sm00N5 te•J 5.000NS 21• xALOADg TIBNIILCRF.ISESUSEDNDES"OFAr✓OWRSNIOWOODONLLYr z s7cnaNS I9 4 sTc rns n• D OCK BAR DESIGN PRESSURE RATING= +36.0 PSF R
1=710H IT S SFLTm6 21 2 KIR -44.0 PSF 4.w1Ef04S NN1mIG BUf NOf IBNm TO TEEL/YRAL sawws.TENT u �e
IW-e•6 sEl'OaNs 21' tS COTE orm CONTACT WITH OIHQN DSmIAAa IFR S AJ.MEET TIz a
1D'-9'6 SECRM6 IT I—ON 21' CENTER STILES soomm'A• REDUfgND05 OF THE 2014/2017 FLORIDA BLDG.CODE h ADOPTED SOueUt65.
11• SFLTONS ID'a 5[CTIOR 21 OUTSIDE KEYED LOCKIceYFD LOCK CENTERsnEs CONNIXIRAtuN S THIS fRORRT APPROVAL 6 MOM AND DOES NOT PROVIDE INFORMATIONd E g g
11'-Y 4 SECRd15 IT]SFLTIDCi]t' O�yVOj�V OooR MORS I OF CDOOi SMS FOR A SITE SPECIFIC PROJW..La LIE SAFETY OF THIS PROOLM AOmUACY
ll'-6' GECIIDNS/B'4 SEL'NIO15]I .� I=BAR LOq@iG SHOWN B' TO 9'-10' 2 WAIFR MIRATON RESISTANCE OF SIPIXTURE RECEAINC INS AND 4ALliC ARWNO CPE181G FDR
11'-9' SEl9XXS 1B'5 sFDDONs 21 ALTERNATE 70 lo•-0•TO 11'-10' 2 OWMMOS NOT SIONN IN THIS DPAIPNG ARE ro BE AKAVtt SEPARATELY, e_
1r 1 SElO10HS IT 6 SEC1Ab 2t• SPRm LOADED SLIDE BOLT tr-0•TO 13-ro• 3 AND TO BE FEV'Er1m BY BUIDNG OFFEW- 0 i$
12'-3'7 SRTiONS 21'- LOCKS SHDRN ABOVE �� W-T TO 15'-10' 4 6.HA VFACRWERS IANL S ALL BE LOCATED ON A AFAOLY VfSBIE LOCATION!
B'-0'ro 9'-10' C
1r-6.6 51TIIro6 IT 2=TKNS 21' OF FLORIDA 6
17
2115--it' 'DOOR�� 15-11TO tr-2S N ACCORDANCE"TIN SCLINAI ®93 NWNC COOL
-
1z•-e's gCfpNS IT 3 4IIW6 21• DOOR TO COWLY VON SECTION 170391
IT 1 SEGTONS 1lY 4 SECIIOps 21' HLmUCf a6Vl60 ® I14 x 3/4'STF DRR3NC SCREM ``�
Irk']SECTIONS 18'5 SCB—I 21
Is-6'2 SMIMNS IT a SILTIRK 21' K1►W Rnl1a NAT!+E LLGD Y:VGFILOF i
is-e'1 SECTION 1r! SEtlpxs h IaAAI;� N LIEU OF 114 X 5/6•SNS
14' a SECtIONa 21'- A N41T-(pl Z �10'-O'TO n'-10 j �14'-0'r0 76'-10'
W-3'8 SECOmS 1S 3 SECTIONS 21' BFtr1M Orh a 2 ' r p0 - ••.*-_ $
SCDWS 18'14 siTT10N15 21 -
1
Iw 4 SELIKNS 1CI5 SFOIIOL6 21 _ ��
IS' J STCII@6 1lY B sFC1WNS 1l' P1dNtE��IEI — _ @@- _.._ f 1
OF �` dr9Mng r1o. I,
tr-T I SFLTpN lY a sEC11C15 21 L
Ir-9'9 5ELI0HS 21-1- �. IY-0"ro 13'-10��i s'-tY ro ts'-2� /
W B Sm11D16 16-14�1IO16 zr
DOOR WIDTHS DDDR R10M5 A/rrgllfAlP sheat 1 of 5 I
I
24 CA STEEL PANEL
1
FLAPS BENT OVER PANEL cz
O 1/27 ENENCNED HOLESj�� �+ `�
O v O.C. N cog
- � 1
UV kyPr
I a
Dss'x 2-1/4•x 3/4•x x' j p.G a
ALV.SIM CLEAN1ROS4
O BOTTOM OF PANEL BUSS FASTENED TO Q _
VERITM DUME0WE SIXES W/TWO 1 b i3
(14 X 5/a'SM-&Am TO vm STILE - 1 AloWrcrTtEVQ� _$ TT
W/Fane/14 x 3/4'SELF mnlarD s tYJ �n�ryry, Q $ jr
I LIPI+++r aF o
r
s - - 3/16•POP RNE15 J i X.-orT-t► )„W,TT''c`�`> yg' ti
C _ AT 4'O.C. 1% 3 �+
O. (6)FOR 21•SIRES
(5)FOR 18•STILES ti m
a �' O ILLE .024•STL PANEL C M
- OIRSIDE OF � 't M�°•
1ST SECTION(BOTTOMI INTERMEDIATE SECTION TOP SECTION
$zm"
rc OND
BY DOOR
STOP MWIDINO O'
er DooR LN5TALIER SOLID BRASS DOOR VIEWER
STEEL TRACK BRACKET FASTENED N
TO WOOD.WM WITH t 14 x 5/6 SMS 3/4•x Y X 2-t/Y x A49'STEEL �•N 9/16- tk HO Y HARDWARE'
CEF '
5/16'X 1-5/a'IAO SO2Ettl 6 PER IWNS EM STILE.CONNECF TO PANELS WITH INSTALLED IN 9/16' D MOLES E CENTER STILE 0
(FiTLLT 7NRFADED) FLAPS AND(5)OR(6)3/16'AllTM WETS POSITIONED AT EYE LEVEL
HEX WAS"' NEAR TYPE A 1/Y%1-3/4'X.OSS'WRM6D STEEL SEE DETAR ABOVE
ONE PER BRACKET 9 TO PPNFl AMI SECIWID 1D ANCAOILS AT TRACK BRACIZE[`: �.I E J"
Elm SIDE WIN(4)3/16'POP WETS { A"
SOUDIERN PINE ..-' _ a 1-7/a'X 2i/9•X.049'STEELgE.^D,I,E .1 3/A•DIA.POWER-BOLT B/'VOWFRS' 1 y 6i
0S5 S _ �J CEHEER 5T1G ntRn AND-ElmN 2'1011 EMBED DffO CONCRETE(3000 P9 YIN.)TO PANEL W/(4)3/16•RNE15I 2'ML•1 m(E D6MNCEE3E1- ML
^ /t4 x s/b'sdlS ,1-3116 /e• r nssvr BY' n' p 3I�aMr- 4/fONOE B)1-1/4'MOV.EMBED DRO CANCRETE aR TIIlID Bl1xK ¢Q z2-1/4•MPL EDGE DISTANCE INTO CONCRETE
4'MCL EDGE DISTANCE IMO FILLED S DCK
r ii CONOR fc-3000 PSI LOWC-BO CRM9 FILLED BLOCK Pm=20M P9 MOV.19"X 210'x S3'x mw MCKDR TYFE A OR BSTEEL TRAM(BRACKETS 1)PER BRcxrr5EESEOEI]i77R SPACDIO SIRET 3 FIXE BRACKET SPACWC ♦ te♦�'• Dam1/4-20 SS BDLT7-t/2V"MERI.11SIDE EIV�_ @ NW -_*• *_ <
STEEL TRACK GCFATER _ -
14 ILA x 2-1/6 x 1'(slANWm)) 1.92'DIA X 30-STEEL ROLLERS(SID. l�w o i
12 CA%}5/16•x 1-i/2'(OPTIONAL) 7 8'PU5141Ui 1.92'DI0.%.50'N11DN FmLLEiiS OPTIONAL)) t gip'•. OF drDWingo no.
FASTENED TO TRACK PLATES / �•• •• ` rL
DATAUED ON ROVER SHAFT 275'DIA X.56 SfE13 ROl1ET6 O(TONAL -Z1
��LS
O?
W/1/4-20%3/6'7TUS5 ND. (( ���♦ ,
SLOTTED N.S.A LOCK MR SECTION R-R 275 DV4 X.50'NOON ROLLERS(OPTIONAL) Ip��
Wall 5 STEM he 2of
1
POP RIVETS /-1/Y x 1/2'%1/6'Holm ANGLE f
5/18'X 1-5/B'LAG SCMS INTO WOOD OR HORM TRUCK SUPPORT. FON DOOR HO(18"WTO 8 Fi.
5/18'SLEEVE ANCHORS CUM SUPPORT REGO.ON DOORS WITHOUT INSULATION OR BDQJO'K5.
23/4'%5-1/2'%J'x.NOF'
GLV.52R WITH 1-1/4•EMBED WTO MNSONRI' E%FEWING 6 R.W HEI Y X Y X 1/9'NOR D-ANGLE ' 1
3 PFR WrACNET 11 A 1 DFOR OORSDOOR O6UTAT AB FB.Fl.— w
OP ROLLER
BRACKET w FILM SLE
FASTENED W/(5)r 14%5/e'SYS SPOT YIELDED TO IIOR2 TRACK Z
14 W GLY.Win AnAFSTAiE 2-1 %hl/4'%13 CA STEEL FRITTS
WITH TRO RODS AT 1-1/Y APART 0 n
SURE FASTENED TO BRACKET _ A—J fOSi AT T O.G,REST AT
B'O.C. f 2
W/s 18-18 X 7/4'REX HEAD WELDED TO i-1/I•x 1-1/YAS@aE0 To A .E CONNECTED TO FUG BRICI(Ef ANGLE g
iy 8 NUM W/3/8-16 K 3/1"BUT h NUT ,4,
rrtRHt(4)1/4-20 SS BOLT 6 MAS FTORQ.TESD(lFli(LH-OPENDIG HE1GLR PWS 12' AND TO SPRING S1AFf QUID:WITH clef
�f
TOP EaAC2T (2)1/4-20 X s/B'BUT h KIM a q ,T
(SUYSYAD) TOP(�MAIMT C it
• LOW HEAOROOY OOM
14 GA.GALV.STEEL TRACK 6$-1 Pl
HDRIZOMAL HFNiORCELIEM 10 CoC
1/2"x I-3/4'x.OSB'FORMED STEEL VERTICAL TRACK p`0 K I9p
OWED TO PAN!Alm FASTENED TO 2-1/B'x l•%.OBD' 0 24 ril$4
��STME5 VnTH 2"X 5-1/Yv SECTION A-A d.�D YN{
3/16-POP RNEIS 19 Z$U a
FASTENED W/!4) ,a z 11.11
�/8 T5� 1�
TOCP .SECTION HEIGHTS BRACKET PUCEU3,GS }b C
LOW 1ffADftOGLE Dow olmow DOOR �{
1WRREEE
XM L.3/4'%x.058'PoRRYED STEEL IST
2ND 3RD TH 8TH 01 B2 63 84 85 86 07 88 Q
GLUED TO PAAEL Nm GST08D TO 6'-0' 18'iB'IB'll'N/A 1'TO 2'11-J/4' y' K' 45 S6' I 67' O
VERIGIL SRFS lilill B'-6' 1,
18'18'21'L/A "TO it-3/4• 23' 34' 45' 56' 1 67" - o
(2)3/IB'POP RBMVS n
5/1fi'IGEGNG RIB
21-121 121-121 N/A i'10 2'11-3/4' 23• 34' 45' 56' 67' -
7'-6' 18,118 18. 2-11-3/4- 23' 34• 4S 56' fir
RAS IC/STEEL RULERS tj V-0• 21 1D'te'te'z1.1'TOY 113/4 z]• 34• as• 58• I 87' 78-1/4•
152'DIA x 50' kk
/ / Q -SECTIONS ARE NUMBERED STARTING AT THE BOTTOM m n
O W .M U0.%h1 4'SIFL •FOR DOORS MORE THAN B FT.MON.USE ADDITIONAL TRACK BRACKETS AT 10'O.C. C o v
rj Tom 8
PR0IMKLMEVISPy C
OPfXINIL PbW.filolS 19'%219'X 3.3"X.080' 4ip(/ty.tbd.Fk.W da C
RI'DIPIAST PRoauNm LEC' O STEEL TRACK BRACKETS �1lq Ctle p
DENT -2.0 0LTANURAIE z-J 78'HI%dl e4srylwtN.�Z B V `o
OE24IY-2D PCF CTED 70 TRACK RDx a i
N.OA r1h,IWA4 ),/4'BUTS A:NWS. ,r1F.w.uh Y,`
OR
BTS H81Ar C4YIYY Z U n
DE19IT I.m PGT - Out to
NCA 115-1261.04 mQmQ m o m
OR
RF-N[In FDAw A1C CNS r
DETSRT 0.92 PCF
ROA rlT-072/A6 �qp
OSTEEL.
m Y
-- ROLLER CAN.STEFAS ^
W/(6)11WOE5 FASTENED
W/(8)/14%5/8'915
�o
LWL 024 ROLL FORADD STEEL PANTS m &
QUALITY G-IO
ION.YIELD STRENGTH 39/9
WITH PRIMER AND RAKED-ON TRACK CONFlGURATON m i
A TO�52DTDES OF EL
EM
El
d
VERTICAr r
LLIFT IH GH LIQ STANDARD LIFT LOW HEADROOM o'
DOUBLE TRACK
12 CA GLV STEEL AVARABLE TRACK OPTIONS L11U1U4 FI r
BOTTOM BRACT FASTENED
Yt .(Y
'o YxmDM SGL OPTmNS _ 7
SEE SHEET 5
OTOWing m
SECTION
SEE SHEET 2 FOR LOCATION A s/j�Al ` sheet 3 of 5
OF REINFORCING TRUSSES I11 1,I1Y
�56Pgg'a� �iR+� `Q"i�S�Pg�L 4511
(R1F 1t0BSMTE
F�3 a� r�aoA 4517-1/'MIN.
oily 1CR n 4p
1W P 1,15
a6IF1 10 gig
� W � $ mS
XX@
gw
0
4
P: g
lip
01
g g
ppyy
� ;
1. 1191 P gn
Elm
pryJ�11�i771�`�` •9
O amt.: as-to-as r°°'°"' 24 G4 ROLL rORMD)STEEL SE00YA GIRME OR. A =GOQ CORPORATION a
no_ ° Bycn ron 93.0WNS rPRMSUFM=0PMEM
N�. 0 w.te•t _ Jw tmsm DAB Door Company, Inc. 03805UNSET DRNE.SUR8720 f
11.07.11 IM ow imt cowwl3 12195 N.W. 98th Ave. MU1M4 FLORIDA 33173 (C4N.$638) C
b.a7:tNaO N WW.1 e°ilOY 6PN M1iN1 aaa!° C
N Hialeah Gardens,Fl. 33018 Tru.taoel2asasoo FJ1>t.r3oq 261bs78
o ML t0.w.n uavallu*o zof7 19c tab(800)267-2016 Fm:(305)362-0271
111
cnRnc o1-21On9
WINDOW HEIGHT
OPO. O
EXTERIOR
---
__________
- %
ov r ,Y
µk.
Nils
s
s
14 1/4•MAY.
WOW.HEIGHT
P 4�m 10 5/8•MAX
aa$ D.LO.
Cnr>4s 1�Q III s p .. � ro
1 O 1 Ilj 1 j
f I III 11 �} I
III
Z0x
ilii rlK m O ;r ..I
rQ ji�l o �7 r 1 flm
(S o li!i m 2� mOC
a i i l i � m o •ow. .•aam +a\\� .oS.o
El
�+'
m� m'
2
s� I
zo 'D
9
El�11�1�
El
2"a' =a<e ,cam:
s
m=
1R �
J xJ II 1111 �
mil oe-lG-az fe"I�°^s` 24 Gk ROLL FJI3AED STM SECTIONAL GNWCE DR. AL-FAROOQ CORPORATION a
p n° °e escn on ENGINEERS&PRODBCT OLYELOPMENT
N .mie_ .au xo rnw<e ll,ssmT DAB Door Company, Inc. 9360 SUNSET DRIVE,SUITE 220 f
N ,� J 11.0x.1= RN.Pfli APA mYYPNR
12795 N.W.
;dens.
I. raulIseFIaRIDn33>.T3 (ca 26 ease)( G.
a woa.l No e,.vcc ds swa
N° � ,aaan wwttD to xolx sac Hialeah GDrdens, FI. 33078 ra.r.1os72a1810D PA1C ryOeX 262Jf9Ts
N --`p eAk Dx: TaL•I..)757-x019 F..:(305)3E2-2272 CPAAGOZ-21 DAB