HomeMy WebLinkAboutNOA^gt. gg,
14 W,II-DADS COUNTY
PRODUCT CONTROL SECTION
11805 SW 26 Street, Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES Miami, Florida 33175-2474
(RE.R)
BOARD AND CODE ADMINISTRATION DIVISION T (786) 315-2590 F (786) 315-2599
NOTICE OF ACCEPTANCE (NOA) www.miamidade.gov/economy
Clopay Building Products Company
8585 Duke Boulevard
Mason, OH 45040
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction ;.materials. The
documentation submitted has been reviewed and accepted by Miami -Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction (Afli).
This NOA shall not be valid after the expiration date stated below. The Miami -Dade County Product Control Section (In
Miami Dade County) and/or the AHJ (in areas other than Miami Dade County) reserve the right to have this product or
material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, the
manufacturer will incur the expense of such testing and the AHJ may immediately revoke, modify, or suspend the use of
such product or material within their jurisdiction. RER reserves the right to revoke this acceptance, if it is determined by
Miami -Dade County Product Control Section that this product or material fails to meet the requirements of the
applicable building code.
This product is approved as described herein, and has been designed to comply with the Florida Building Code,
including the High Velocity Hurricane Zone.
DESCRIPTION: 2" EPS Insulated W6 DP38 Steel Sectional Garage Door up to 16'-2" Wide
w/ Optional Impact Resistant Lites
APPROVAL DOCUMENT: Drawing No. 104724, titled "2" EPS Insulated Doors", sheets l through 3 of
3, dated 10/12/2012, with revision 6 dated 7/2017, prepared by Clopay Building Products Company, signed
and sealed by Scott Hamilton, P.E., bearing the Miami -Dade County Product Control revision stamp with the
Notice of Acceptance number and expiration date by the Miami -Dade County Product Control Section.
MISSILE IMPACT RATING: Large and Small Missile Impact Resistant
LABELING: A permanent label with the manufacturer's name or logo, manufacturing address, model number, the
positive and negative design pressure rating, indicate impact rated if applicable, installation instruction drawing
reference number, approval number (NOA), the applicable test standards, and the statement reading `Miami -Dade
County Product Control Approved' is to be located on the door's side track, bottom angle, or inner surface of a panel.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change in
the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials, use, and/or manufacture of the product or process. Misuse of this NOA as an endorsement of any product, for
sales, advertising or any other purposes shall automatically terminate this NOA. Failure to comply with any section of
this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami -Dade County, Florida, and followed by the
expiration date may be displayed in advertising literature. If any portion of the NOA is displayed, then it shall be done
in its entirety.
INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and shall
be available for inspection at the job site at the request of the Building Official_
This NOA renews and revises NOA #15-0225.14 and consists of this page 1 and evidence pages E-1 and E-
2, as well as approval document mentioned above.
The submitted documentation was reviewed by Carlos M. Utrera, P.E.
NOA No 17-0920.03
Expiration Date: December 27, 2022
Approval Date: December 7, 2017
/it � � )I Page I
Clopay Building Products Company
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
L EVIDENCE SUBMITTED UNDER PREVIOUS NOAs
A. DRAWINGS "Submitted under NOA # 15-022S.14"
1. Drawing No. 104724, titled "2" EPS Insulated Doors", sheets 1 through 3 of 3, dated
10/12/2012, with revision 05 dated 2/2015, prepared by Clopay Building Products Company,
signed and sealed by Scott Hamilton, P.E.
B. TESTS "Submitted under NOA # 13-0402.03"'
I. Addendum to Test Report No. ATLNC 0801.01-12, dated 02/0612013, signed and sealed by
David W. Johnson, P.E.
"Submitted under NOA # 12-10-72.03"
2. Test reports on 1) Uniform Static Air Pressure Test, Loading per FBC TAS 202-94
2) Large Missile Impact Test per FBC, TAS 201-94
3) Cyclic Wind Pressure Loading per FBC, TAS 203-94
4) Forced Entry Test, per FBC 2411 3.2.1, TAS 202-94
5) Tensile Test per ASTM E8
Along with marked -up drawings and installation diagram of 16'2"x 8% 27ga steel garage door
Model 43 00 with windows, prepared by American Test Lab, Inc., Test Report No. ATLNC
0801.01-12, dated 08/15/2012, signed and sealed by David W. Johnson, P.E.
3. Test report on Salt Spray per ASTM B 117 of painted G40 galvanized coated panels, prepared
by Stork Materials Technology, Test Report No. 30160-04-63365, dated 01/26/2005, signed
by John D. Lee, P.E.
C. CALCULATIONS "Submitted under NOA # 12-1022.03"
1. Jamb anchor calculations prepared by Clopay Building Products Company, dated 12/10/2012,
signed and sealed by Scott Hamilton, P.E.
D. QUALITY ASSURANCE
1. Miami -Dade Department of Regulatory and Economic Resources (RER)
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 15-0915.08 issued to SARIC Innovative Plastics, US LLC for their
Lexan Polycarbonate Sheet Products, approved. on 12/1012015, expiring on 07/17/2018.
2. Test report on Surface Burning Characteristics, per ASTM E84 of Type I EPS, Test Report
No. 3082960-500, prepared by Intertek Testing Services, NA, Inc., dated 10/04/2005, signed
by Javier Trevino.
3. Test report on Ignition Properties of Plastics per ASTM D 1929 of Type I EPS, Test Report
No. 3082959-500, prepared by Intertek Testing Services, NA, Inc., dated 09/16/2005, signed
by C. Anthony Penaloza.
earlos'Al. Utrera, P.E.
Product Control Examiner
NOA No 17-0920.03
Expiration Date: December 27, 2022
Approval Date: December 7, 2017
E-1
Clopav Building Products Company
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
F. STATEMENTS "Submitted under NOA # 15-0-725.14"
1. Statement letter of code conformance with the 2010 and the 5"' edition (2014) FBC issued by
Clopay Building Products Company, dated 02/18/2015, signed and sealed by Scott Hamilton,
P.E.
"Submitted under NOA # 12-1022.03"
2. Statement letters of code conformance to 2010 FBC and of no financial interest, issued by
Clopay Building Products Company, dated 10/30/2012, signed and sealed by Scott Hamilton,
P.E.
2. NEW EVIDENCE SUBMITTED
A. DRAWINGS
1. Drawing No. 104724, titled "2" EPS Insulated Doors", sheets 1 through 3 of 3, dated
10/12/2012, with revision 6 dated 7/2017, prepared by Clopay Building Products
Company, signed and sealed by Scott Hamilton, P.E.
B. TESTS
1. None.
C. CALCULATIONS
1. None.
D. QUALITY ASSURANCE
1. Miami -Dade Department of Regulatory and Economic Resources (RER)
E. MATERIAL CERTIFICATIONS
1. None.
F. STATEMENTS
1. Statement letter of code conformance to 5' Edition (2014) and 6t' Edition (2017) FBC
issued by Clopay Building Products Company, dated 09/06/2017, signed and sealed
by Scott Hamilton, P.E.
2. Statement letter of no financial interest issued by Clopay Building Products Company,
dated 09/06/2017, signed and sealed by Scott Hamilton, P.E.
Carlos M. Utrera, P-E.
Product Control Examiner
NOA No 17-0920.03
Expiration Date: December 27, 2022
Approval Date: December 7, 2017
E-2
o U m Q W mm
z W
w M
Imi O� mw O('o
Z WN YQUQ20 Z� W jN
C W W Z I I I I I I J a
W W O N O
o
3
¢ 0Z ZO II W 2
O ZO 'FZ W
li it I Il � WIQ K
~ ¢�a V a \ 'I it II 'I ¢
Zo Z N a F ===v lt- I it- ` a a In N>
wwU Z _ _ N N
__"�i IM1' I I W � 0 U v
O 0 m\
III. 'I I �1 II ~ZQOZa �0 10 o
p W i�� 30H fw/1 \ 11 II II i� OT IEW1 lJ
owp �9a z \ ii li II ii ii o �"roF61aan
ZAY a I \ 11 I II II 11 1 OrJn Z R0Z
0 100 G W
Zow x
N Q cc: �F-Z G'� Z \ li �I 'I it li w6�0 z wUw I p m
p a nwa i-^= I I, l' '� I ii UF�da yo I=-I�°� dl a m a z
N ZO o'z z 1- ti c� .=='ti' lY-. L �= S Z `n o Z 0 3 cYi
rcN1 d JO NS OQ �„m' W
'� U V Z z m O -i Irl-- �- �- U W U U N N � 2 3
x I-zo-' �Z li it .I II li z~ZoIS ci a w w U o
z �nZZN wf/�w¢ \ it I' I it li np _ oFm O
¢ IQ f,pQ QWW \ II II II II II Z M- •�. .-NN^'
X KO ==31 IIL L J_'= WD ~ OLLZW ° I•l op poN
o �ztc "i a� gw� p o0om '+' In -t \ mz
mowir= " F-Y� U0mz mo U
�zwo ¢-Z 11 II II a P.
owxa �I o0000 �o
n QOUz�wo� \ ==LI 1�= ll %i-= II gC)¢ za ajaw z Vo o
I;.i aOaN\woo H¢O mOw v0-i �I- o vb
o 0 zp J Yw �wx_ w
�v�c9mz�v \ __? M1= I IY- li OmyJUo am o §s
w�U°�� m th N N
w o
O O N o
J Z W Z O
ZI vlw>OI.¢l0 o Cu
N Lo m w L=
�j u4cn'�z = NY�UawyLo�0 wn worn y->�_UmQ0
N
oz a
o U9
0
z° ?'a
acto zo t-Ib 0 wt7w � 7as
Oo•=?nm¢ p NNU cawCD U-cl- mmx IG.oa6t
OZ nU n.o JO'n
I`IVUa m? �m 00 am
w 3�ma
w N_ d a
�ZU�ZVZ_Ovxi `N-'L .'O la-9 'ti. �d 3
N¢UO
p D o wz
OtZtyy �IUNIV p {a1J Z lup ¢ OyUN
2
I I I I IN� o O
a ?
� o H ?zW yo
¢ ^ W i' i ��_1 it II 'I I' ii it 11 W
w ti_ It 1= v=' I um Y z n a
N a Q o \ w n
II \ li 11 li II II 'I 1- 0a
o Z' U
>zo
J o N o 11 0
7Cn� N O
m Vl II 11 \ II li I� II I 'I - ^ O
ro .o II 'I II Ij II II II it z�n m .\ I�
-I� Irll-_ II �_= II } Q Q z IZWZll �-1�� V Z ()
~ O II II \ II II II II II II 100 0- !Q-1ew�N
R 1� 1= 'I IL 'I ' _AlII J w Z d w OZ o In�J�g
i y O
= x o It-=-�i'- ii '�%__-' it' oLLm W
H L, N Sams
t¢j o .0 N W~ p 0 14'- I- -fl 'F- x z
r� z-1 II \ 7 �I I II II zzz aw9d
n ° ZcwiNoo II II I' i� I C, o°' Hof v�i
N N W I� w
__
O
z 0 O �__� i~ i~=_ ' Lil
wz
�} _ �oT_o li II n\ II 11 �I jl II iIIfl lti r4
lZ
� w F 2 Vl - F d In N n N 0+ do F- �� Ol .. • � •, .,A•V�.y I� q
d V U 0¢ = Irl--= `'I 11= M= I r_ _ 4 ` llJJ2 N
N I Zkm 11 li \ it II 'i 'I N IL'6-:" i• [O
�awJ it \ I i ii ii li it li = CO
O wwZ
vW ;Q Wa
z¢ II \ II II II0 = om �,"oo• o_ S;ul m �F �•Z �Zw
N 1 to N N= U 0^ ZD :i° �' � r :(.o l} ¢ �: 0� L o z
w L f w �p i ammo MOP W YO�i z' m!� tW _
o o Q �m o I a ^ x O •••.
f c� x w ,.0-.9 L 1HO13H woo XVW iu v £ ,1i� i4 • •. • •
„LZ 'J-I NOLL035 'X'dW ,'I,���7! pR��o� A 00
0 U m Q
L�
C�
m
Q
W
co ^ .
lil=pJ
Y j Z� J
Q
„l J 3N
_¢ m
vlk
to n x N
=U
k m vF"i
¢IssW"
/'1
sKp
OZ .N
KJaNK0�p
a.y'
W
Wz
rU¢K+1i
Y
UG1-
za
K
oZ,
0
�CI¢mwJQO
I.:WWx
OL
WNMO-
aD] vi
Z ZN\C-`I
FIUn
mW J
Z W Q O.
ZY
Q
JuJv¢v4-
W
�i=-SON N NW
_ Z ly �. y
(n fY3Z
O�
Q 3 W Q W w
O w
fl - In >
Z
O tJ
z0
UY
mWU
4w- xy71=_U
Oa��
Z �¢¢Iw-�w m O
i WFf~/I xw
W U O R
a � QH
mS yy
JJN Z
.N-.
N
N
« O
U
U
ji Q dd
W
o0
Q-
!n
n
0
�dto
o
0
z
0UZ
d QQYama.
UN�1- Nm
Z2p
m
zrn �(�q�'�a
y.-=n
��
�W
N Lw. Y JRz
0 5wJ,-- -t i (q 1 FQ-
w U;4
¢v Z
� 4 � O
AM pZ
v m m H Q
cl
N�mdm
aa
0?u�i_y
M y JQ
t1 m�r N
a
SN
W
8 = O
N K
n
Q p m
vi
q
W
¢
WCi N3w
>
I
O
o
O
Z
}C}C
U100 Zm OQ
W m Y O
WtJ
Z �V~I
O
J= OW
W N Z W Z
(Wn
i- (n 0000� u�
� W .H -H -H -H
I
w
W owu
OWO,.?Z
0
fF/1�
W �Q
HY�F0Y
NIn RIyN
lz
U
O1ZQ if II II II It o
OJ Mw. C
wW6W
Y �it>:W
QZ=
U 0~��
0.= 0.Nlal
W F mm
O 1 vi,
c
IW
dl xz
N
o
2�
1 >�C6,
�Wo
�
w
zV)?-
ZU�
N
lil
Z I
aj�" w
O a
m?-Jp Old
(9
N
Z fl
a
2
D?ZY¢
z
0
NN UO
O z
Lw
O
Fo
Nw
J
N H o AN
awa
�0o
!n
BE
O
a
aQ�Fs oj.orK10
x�oo
0 o
2'
cKi
tJQo
m
K O Z.
00
NIN1p WiO Zm(jz
�Cw3K•-•-
F
F-
N[Nyj
�j
O UIK OI-.J
le I
z
lJ
72
c=io
F=awp- rc0 0
6Z�VQ
30omWl�ro n
xz
=
xZ
U
a0s
O a0
O
m
\�
II--
YQ �<
mFzwm>o
CxxF0Fo�-
W'gqqqyO 9mO
R.
mo�WmGG
h U
I!\]
N
z
<r~Ur
0
O8-O
oW
mZWmON�i�moc-w-Fm
allorKWKzmCz-ww
zKomZb
o
_
�`/O`-
O
o
Jro
pO
o
z
.�I
m�
✓VpOO
¢ W
r.N
3
Ems a.
OOUO
¢NOlKoO�-iLL<=�Wzm)ooKWm
aN0IY<w2¢Nnomx+
yy.'
wlu-
00wZO
zKod
z
Z
O n
3,�z
�UwK
0ZZwK
W3g31w«oWK¢b.E
Vzo2mWq'
§¢WZ
U�O.mn���;_zo�O
FU.
ZW
F
~
R
l7
N
o-
a-
�gNZQzm
¢
O �a NZO =KOWmNZ
OmMKOK
KL)EwoO
OOwJOwQ
2KO0
UO
RxU
O N
o
Ut- 01z1+ z u
Gan,
oo? m Oal'ircjoz
ZZ
k �0 I l n
p
0C
W m ONE h l07
O
F-
�C��a wwv-fm
>¢�->W�
Hq Pl
Apzoo
O ¢�5 < Z-,O
_tom ¢4u zo orn'd
W Z o I
rz a pOo
via
u
jr 1� � R
f0 U N
_ `D oxrm�0
m-N
a2Mm
0o
O ww¢K
3wao a�' �• r_eKm30
fio O
I- U Fm
U gg 4F7
B
O
za
G
R
R y
LL•-a
Opo
�'13m�
RKOKrya
F
zmz
o �K
Fe'R
U^a.v
m
ri .r 3ur
1-za�3 co.
naza'
tiFzo
Zzwz¢
OE��
a k w
zK¢w
O
T
�vvm•�
NKO
fU
Zoo
m0 OZ Y
w
SPOU
\\�G/
u' b•�'- �" �, cM0
ESmw
xF w
o K zz_
wt
Q:Z
wliz
=Z
-
T.w
H
G?ZW ZJ-o
YQcn
Q
?J= Jwc
Jaf
LLFa-Oa�.�
•i�0.U•z
OZ
- WpW
acJi
m03ywoin-o
o
••
�O'�•.
m
l . ......
.
Z.
ZC
�ko % ¢m
C)
m
Q
U m Q
- CC)
0(y) p UN
o ❑�
IJ 41 ON , Z z_vN22
?
3 -F ZOZ rc x3G� O z1\D�1 z 31J
(A= W
N>
z x i� 3m ^�V�d�
Uy¢ Ins o v m J Z- N N
R O p \
W❑ VI C JOI N W F- WM B\ U❑
zo 3 �O oz 3 3b o Cox ��'.t zNbr,.i g w
T N d°1\ a J I Nd m� C14��� oON� N❑
8
o Q�n"Y m-��'631m
I• c�� QQ /��Sp
N KI m N Ij m .M d[�
W' Z m X Z Q O K x ,� %$ Q. O O
_N N' o p\ o ¢ d5p dVN a iE z Y z
�i N m rc WJWJWJW in ` fii �n Z. 17i15 Vi s fa Q W U'
>.. �2w NyUj Z OHO ^��\ N 2 d,�� ❑ �O' U O
0�'�J
J �eo +'Mono
OZ o c� �ti n N e avl zd a I NoU +I-H ii ii +4 �z
Z I F ❑ v= n OoQZ II II II II II
L—L N O O NLL Z V0
J Z S2 vo �$
o
N N
�s k o�mo aCi a 3 FFm a�xm� a .ate;
ui y� q
a� �am� New
5 Gm�!wrn' m W'o �o o� �aY.� v
z
Cf
Ial Q ppz �In�Fz� ,m ofqg� s-0U
om �F N�yV.Fp�p�^� > 3w
a oo� xp53z Km>�x ppa Ig �z n¢.wz
n19 vlEU
N OaiNw^ 4 \W. �mWO�
i M Ua m4 boo N.-F` ,O MZ �0
N mN Nam 3g +~ p ¢ O saw
p N KZ 7 U0-
5-- U\fWOZ
m1-
0 ry�000
YWC 0.
��1y�y vFQ¢mx
pO Vt Oip- - mOiOi- e0 (dV 10^ and 0i - mY ME bw0p1
p Jl�h 0;�� Q'Q 1pm I�I�m �Ojuf NFZ-wLL�
oo ofSNzUU ozp=
wx ate'
Sg
Z � N ¢- i U I/10 Y PI)
Q � N o� � •� I �•' �I"�
l7 O � N SU � O �� �Q•� ��� x
oo Ig
.0 aZlZ^N ��w a
xW � Ym M .O(NCN mV0 II 62 x O
HF F U\- (S rilSU Qj� YYUy Z
.p N Zgln U � WZ Nro I U mttnn zdz ~m� z" w mo
WWOFix ZV U KU NS.,
IS-----
Z U Oe 00 SN -m----
a v InWo �pnY z �Y (yQam--'a"'��G$y ON
u�o NoIS J�J�� LLF==
QOaZ O �� d U¢ FNQNK UOW Fa-yjW \2�D 6Q Z O�'00 OOj 1 I
OOK V QQ3U N F FO� JJ�ZU J'Z O� OCI' NOON^ip
t7 Nab o n�,d'm O v OZ UU llZZ pa s
a m oa m a z oo- z ¢m
� o v zU> ;ova »df
N = L6 N N I N
o o a 8?
a M n M
� � W
N ,D
m I-1N013H 21000 = 1HOI3H ONIN3d0
.tHO13H 8000 1HO13H ONIN3dO
z
O Ip- Y O W N QNl n V .. O\..- ... .'�l%,�� [V
N `r U c� � N � o N � : ` •[G co a• tL 6- :2 '�, �
iqi ^ h ti o Z.//V\1,1 la- O' O Z o z
O 1 G
cQ.i of a a O E°4 7� �'i7 ' �,�� Z = u
°z41
U m d