HomeMy WebLinkAboutProduct Approvalslwv
MIAMI-DADE COUNTY
PRODUCT CONTROL SECTION
11805 SW 26 Street, Room 208
DEPARTMENT OF REGULATORY AND ECONOriIC RESOURCES (RER) Miami, Florida 33175.2474
BOARD AND CODE ADMLNISTRA'IION DIVISION T (786) 315-2590 F (786) 315-2599
NOTICE OF ACCEPTANCE (NOA) www.miamidade.?ov/economy
DAB Door Company, Inc.
1.2195 NW 98x' Avenue
Hialeah Gardens, FL 33018
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction materials. The
documentation submitted has been reviewed and accepted by Miatr.i-Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction (AHJ).
This NOA shall not be valid after the expiration date stated below. The Miami -Dade County Product Control Section (In
Miami Dade County) and/or the AHJ (in areas other than Miami Dade County) reserve the right to have this product or
material tested for quali y assurance purposes. If this product or material fails to perform in the accepted manner, the
manufacturer will incur the expense of such testing and the AHJ may immediately revoke, modify, or suspend the use of
such product or material within their jurisdiction. RER reserves the right to revoke this acceptance, if it is determined
by Miarri-Dade County Product Control Section that this product or material fails to meet the requirements of the
applicable building code.
This product is approved as described herein, and has beer. designed to comply with the Florida Building Code,
including the High Velocity Hurricane Zone.
DESCRIPTION: Hurricane Master Model 824/811 Steel Sectional Garage Door up to 9'-4" Wide w/
Window Lite Option (DP +50.0,-60.0 PSF)
APPROVAL DOCUMENT: Drawing No. 01-09 REV L, titled "Sectional Garage Door", sheets 1 through
5 of 5, dated 02/01/2001 and last revised on OCT 05, 2017, prepared by Al-Farooq Corporation, signed and
sealed by favad Ahmad. P.E., bearing the Miami -Dade County Product Control Revision stamp with the
Notice of Acceptance number and expiration date by the Miami -Dade County Product Control Section.
MISSILE IMPACT RATING: Large and Small Missile Impact Resistant
LABELING: A permanent label with the manufacturer's name or logo, manufacturing address, model
number, the positive and negative design pressure rating, indicate impact rated if applicable, installation
instruction drawing reference number, approval number (NOA), the applicable test standards, and the
statement reading `Miami -Dade County Product Control Approved' is to be located on the door's side track,
bottom angle, or inner surface of a panel.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance of this product.
TERMENATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials, use. and/or manufacture of the product or process. Misuse of this NOA as an endorsement of any product, for
sales, advertising or any other purposes shall automatically terminate this NOA. Failure to comply with any section of
this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami -Dade County, Florida, and followed by the
expiration date may be displayed in advertising literature. If any portion of the NOA its displayed, then it shall be done
in its entirety.
INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official.
This NOA revises NOA # 16-0330.02 and consists of this page 1 and evidence pages E-1, E-2 and E-3, as
well as approval document mentioned above.
The submitted documentation was reviewed by Ishaq 1. Chanda, P.E.
NOA No. 17-1018.13
Expiration Date: August 9, 2021
Approval Date: December 14, 2017
Page 1
DAB Door Comnanv, Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
1. Evidence submitted in previous files
A. DRAWINGS
1. Drawing No. 01-09, titled "Sectional Garage Door", sheets I through 5 of 5, dated
02/01/200 1, with last revision K dated 03/21/2016, prepared by Al-Farooq Corporation,
signed and sealed by Javad Ahmad, P.E.
B. TESTS "Submitted under NOA # 09-0128.04"
1. Test reports on 1) Uniform Static Air Pressure Test, Loading per FBC TAS 202-94
2) Large Missile Impact Test per FBC, TAS 201-94
3) Cyclic Wind Pressure Loading per FBC, TAS 203-94
4) Forced Entry Test, per FBC 2411 3.2.1, TAS 202-94
along with marked -up drawings and installation diagram of a DAB 824 24 GA
Sectional Garage Door with Fixed Windows, prepared by Hurricane Engineering &
Testing, Inc, Test Reports No. HETI-08-2149A/B, dated 06/27/2008, signed and
sealed by Candido F. Font, P.E.
"Submitted under NOA # 09-0128.04"
2. "Test report of Tensile Test per ASTM E 8, Report No. HETI 08-T182, prepared by
Hurricane Engineering & Testing, Inc., dated. 12/23/2008, signed and sealed by
Candido F. Font, P.E.
"Submitted under NDA # 01-0516.03"
3. Test report of large missile impact test per PA 201 and cyclic wind pressure test per
PA 203 on "Sectional Residential Garage Door", prepared by Hurricane Engineering
& Testing, Inc., Report No. HETI 01-974A, dated 01/29/2001, signed and sealed by
Hector M. Medina, P.E.
4. Test report of Uniform Static Air Pressure Test per PA 202 and Force Entry
Resistance Test on "Sectional Residential Garage Door", prepared by Hurricane
Engineering & Testing, Inc., Report No. HETI 01-969, dated 01 /18/2001, signed and
sealed by Hector M. Medina, P.E.
5. Test report on Salt Spray (Corrosion) Test per ASTMS B 117 of a painted G-40 steel
panels, prepared by Celotex Corporation, Test Report No. 258592, dated 08/17/1998,
signed by W. A. Jackson, P.E.
Ahaq 1. Chanda, P.E.
Product Control Examiner
NOA No. 17-1018.13
Expiration Date: August 9, 2021
Approval Date: December 14, 2017
E - x
I)AB Door Companv, Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTER
C. CALCULATIONS "Submitted under NOA # 14-0814.04"
1. Anchor verification calculations prepared by Al-Farooq Corporation, dated 09/22/2014 and
07/24/2014, signed and sealed by Javad Ahmad, P.E.
"Submitted under NOA # 09-0128.04"
2. Anchor verification calculations prepared by Al-Farooq Corporation, complying with F.B.0
2007, dated 12/19/2008, signed and sealed by Humayoun Farooq, P.L.
D. QUALITY ASSURANCE
1. Miami -Dade Department of Regulatory and Economic Resources (RER)
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 15-0915.08, issued to SABIC Innovative Plastics, for their Lexan
Polycarbonate Sheet Products, approved on 12/10/2015 and expiring on 07/17/2018.
2. Notice of Acceptance No. 14-031.1.08, issued to Insulfoarm, LLC, for their
Insulfoam Expanded Polystyrene Insulation, approved on 08/14/2014 and expiring on
1U29/2017.
3. Notice of Acceptance No. 11-0926.07, issued to Dyplast Products, LLC, for their Expanded
Polystyrene Blick Type Insulation, approved on 11/10/2011 and expiring on 01/11/2017.
4. Notice of Acceptance No. 11-0926,06, issued to Dyplast Products, LLC, for their
Dyplast ISO -CI Polyisocyanurate Insulation, approved on 11/10/2011 and expiring on
01/11/2017.
5. Notice of Acceptance No. 15-1203.04, issued to Cellofoam North America Inc, for
their—Expanded Polystyrene Block Insulation, approved on 03/17/2016 and
expiring on 02/24/2021.
"Submitted under N0A # 05-0228.02"
6. Test Report on Accelerated Weathering Using Xenon Are Light Apparatus Test per
ASTM G 15 5 of "PVC. Extrusion Material', prepared by Hurricane Engineering &
Testing, Inc., Report No. HETI 04-A002, dated 09/27/2004, signed and sealed by Rafael F.
Droz-Seda, P.B.
7. Test Reports on Tensile Test per ASTM D638 of "PVC Extrusion Material", prepared by
Hurricane Engineering & Testing Inc., Report No. HETI 04-T251, dated 11/29/2004 signed
and sealed by I. Ghia, P.E.
8. Test Report on Self -Ignition Temperature Test, Rate of Burn Test and Smoke Density
'fest of "REHAU non -foam PVC extrusion material', prepared by ETC Laboratories,
Report No. 04-761-15019.0, dated 05/06/2001, signed and sealed by J. L. Doldan, P.E.
F. STATEMENTS
1. Statement letter of code conformance to the 5ffi edition (2014) FBC and of no financial interest
issued by Al-Farooq Corporation, dated 03/21/2016, signed and sealed by Javad Ahmad, P.E.
Ishaq 1_ Chancta, P.E.
Product Control Examiner
NOA No. 17-1018.13
Expiration Date: August 9, 2021
Approval Date: December 14, 2017
E -2
DAB Door Company. Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUB
2. New Evidence submitted.
A. DRAWINGS
1. Drawing No. 01-09 REV L, titled "Sectional Garage Door", sheets 1 through 5 of 5, dated
02/01 /2001 and last revised on OCT 05, 2017, sheets 1 through 5 of 5, prepared by Ai-
Farooq Corporation, signed and sealed by Javad Ahmad, P.E.
Note: This revision consist of editorial changes to comply with FBC 2017.
B. CALCULATIONS
1. None
C. QUALITY ASSURANCE
1. Miami Dade Department of Regulatory and Economic Resources (RER).
D. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 'At 7-0221.06., issued to lnsulfoam, LLC, for their
Ix
nsulfoam Expanded Polystyrene Insulation, epiring on 11/29/2022.
2. Notice of Acceptance No. 16-1108.04, issued to Dyplast Products, LLC, for their Dyplast
ISO -C1 Polvisocyanurate Insulation, expiring on 0 1/1 1/2022.
3. Notice of Acceptance No. 15-1203.04, issued to Cellofoarn North America Inc, for their
Expanded Polystyrene Block Insulation, expiring on 02/24/2021.
4. Notice of Acceptance No. 15-0915.08, issues! to SABIC Innovative Plastics, for their Lexan Sheet
Products, exp+ring on 07/17/2018.
E. STATENT NTS
1. Statement letter of conformance to FBC %014 (51b Edition) and FBC 2017 (0 -'Edition),
prepared by Ej Farooq Corporation_, dated 10/05/17, signed and sealed by Javad Ahmad,
P.E.
F. OTHER
1. This NOA revises NOA # 16-0330.02, expiring 08/09/21.
Ishaq I. Chapala, P.E.
Product Control Examiner
NOA No. 17-1018.13
Expiration Date: Auhust 9, 2021
Approval Date: December 14, 2017
E -3
mK
' b
II
�IG
NII
O
I•l a�l•I'1411I
A 4
m A
4
IN11
N• P 4
�11
GI IeIA
11101
G m�
In�l
t:l •Ib
l lm:l•lil'.VII
P 4
• b PIG
•Ib
1
TI
/
+INN
4 h
(P�Au Cye�•yy+,
I$�Si
4
N A
IbIP
+ NI4
P
+
i1
N.P P
G.+ fT
I
NNq
1m, yny,
1.1 Irl
M
�mr� Ijnnayy$1
NN
n;
yY1
�V1
WZ�•III.1
N
N'�j
1/Py, 1/WN�
oZ m
A1m� IP
o
pNyy
-NP�..
P
+
•WW
.. w
Om•O
w +Nm
wl
•O�AIOS�m
......a.....4,N...1
_7
N
�RmIOaAO�
.
w..�
Lr N+
±C�
'
Z
I�
0� •m
t... ...:
Yi P 4
w .-I.N.
m,
... .i ��.4
N� •
�
W •I.
_•' -
...• �
........
«
.N,im+
••'•I•••.•
1 4
Cq
N
1
m V
A A
I�
P Gj I
V P
P:♦
ggI
A mTa
a Kid
M
I
xilI
><(
S0.
sc
1
aa: a
1
Ia
Rig
IS
I1NN
OC D p0'0U Om O 1O x GCl/1
cir>i 0o cL/jv m'� g �yN � m
�� -1 A D'0-
mZ n mON O nmG
A
�no
�Vs)
pzm7' o�0 'z "' �QD
twom3�g r=`I� A rmJ•Q gr2n rmn
m= C-iz SCm1U >OyZO m
Z.
N :E
GS'I�VI
_S (1 Viym Nm -1-O SUCH
p OrCt 'wo O Crm/1 m0 Z
goo Ai� Z �p� �00
iJ X1 O O
O�Z N N �Im•1 Z mC A{L7 JC,
gz 1p�O nmm>1.�tnt y,y mS0
CR Pz >ul"a p D D poN plt�l •0i
O� A•p W2 z�r�1f
z< 1 god z8
z M z *
ag
0 ov p
�� O Ont X83 Z r;•1 2"
mo g�g zg; D 0ov $_A
a m ��� Dzm~ D� $
z r O9z Z. O mN mm
Sr x r
�7 FIw 1 - -
X � z 11 •.
C
cx
P
f
y'
x
OA�
z
mo
v UkA
pU lrl�
w qZ
rt Ax
x Vlx
Z
�02
°;•ox vl
ryI�R :�
y
m N !
ON
/
'1
/
1
I$�Si
rrnn
Sr x r
�7 FIw 1 - -
X � z 11 •.
C
cx
P
f
y'
x
OA�
z
�Vrn
pU lrl�
/ 2 Z N
rt Ax
5A, w
Z
p�p
2 0^q X
+ D i
ryI�R :�
y
m N !
p JJ N
S r7i vy
/
�2 1L mY
vv!
/
Pr
I$�Si
rrnn
pal
r m
FI
t
33 w�
N
N'�j
No O
bo
0
visions:it
�..
a e tv esery
•au
3.....................
_7
mPs• 1/Y t 0'
n all
– •-
a axoa.ls vo iw.Kc
,
_...- .. ......J
O
O
K 05.41.16 10 CIPNC
U.
l !0.03.i'1 UPOhTF.01
T
y
nF—SECTIONAL GARAGE DOOR
"'ll sn t DAB Door Company, Inc.
nls Ilrr 12195 N.W. 98th Ave.
+al -- I Hialeah Gardens, FI. 33018
Tw BNEE J
201i-er. Tel: (800) 257-2016 FaK: (305) 362-9272
------------
A•
\v
r++l. m
••
x
OA�
z
pU lrl�
/ 2 Z N
rt Ax
5A, w
NM.
p�p
2 0^q X
+ D i
/ mr^xr4i
p JJ N
S r7i vy
/
�2 1L mY
vv!
/
1
AL-FAROOQ CORPORATION a
ENGINEERS & PRODUCT DEVELOPMENT rr
9360 SUNSET DRIVE, SUITE 220 1
MIAMI, FLORIDA 33173(C..1.N. 3538)
TEL (305) 268100 FAX.
(305) 2626978
4�,
N t?
6.
Pp-
� • OYi
I'\�IJO� \ \ 41�N °1 1 • O
\`
71
a;x 'x z
/ T _.
v Oa T^ih ��YtJi
fir`"' rbc .1, pQ
`.
z.rW z0 xm
ju O
x r moP_
c �
$ o m
_ A�mx N
'L CymS� - mon! 009
T g p P O D N b
P X > m!a
� c
m r
m
N O� Z A O
a w m m
_ m n ti
m
�W \
X
N �
V.
�.XP me .•`"'.._` n'a r�rn ox
HImw F.i
mm i,
N��i� `�'
y
� Via^
Al -
0 �m T no
w i 0 v t
N � Un
O�' s
A 2
`�`
<y'-
r 16
z �J
;iso°r� Yt k:z'__I n� o
o sofa: o2 of of 1r v s o a SECTIONAL GARAGE DOOR : AL-FAROOQ CORPORATION a
ENGINEERS d PRODUCT DEVELOPMENT
I xar M oo to t• o aavo� TMs s�eiT i DAB Door Company, Inc.
-^—• -II , P° y - 9380 SUNSET DRIVE, SUITE 220
! It W h I wv uuvat rXn 2195 N.W. 98th Ave. MIAMI. FLORIDA 33173
;a p I�dP Oy. W00 . 03.09.? !. X0 M W l TWS SNtfr is eoh Gardens 33018 TEL.(30S)="200 FAX (305)262.6978. C
'. VO pN`15E 1'X15 VITT• '___. .. ..
v ��"- _ j C ,°.a3.n uroniFO 70 20+7 FK�. Tel: (800) 257-2016 Fax: (305) 362-9272 �gRAGE�o1-o9DAB j
18' OR 21" -_---_ .-•_—_.^�_ 18' OR 21' 18" OR 2t'
PANEL HfIGM T ..._--_ –� PANEL HEIGHT _._.__._ _ _..____.–.- � PANEL HEIGHT
i
I
1pg �
-
_ II
0.
\ �7
xO ��N V<>=03 p I v^N L•� w�l; sf�oy'4> "'
mo .'OmN �� YV, pv_, p o; o..� '_$>vyra� _ rgg71_•yyn�i \
�V4r
AF X< °mm� ���j�jii� pczi< vp up mn gF c�5t-n rL\�1 iir':q
N p2ZymCyyX� Zm (t x
\~ S VZKr NN 04 10f1' C X' x n s.
U��r �0 i
o =o U�NL�L^� PP 2-o �� e�t x H" oma"
Nr� '�'� pOO NrOn 'I Y" )N ACp p'
jj°IIx m mN =oS� °o O°m �jr1 o
;Q
�5 ti
il
P
OmX + O~N X
_ I
FF�yy� Np 0!
ZAp; r�
T v
OPENING
HEIGHT
. A• U
._. ... ._. _... —
DOOR HEIGHT
NNW
� o _
87
��A� AOmO
84
82 N
' {
I ' i
_r} r:-
i
m 4 O
x r�77m
17i x 0 W Q% `v m m o
c m; d 0; 0: Nv O = 11 T
)
y N N N N N r r
UCU,
l_ZZw
O
ZO
E m 8 l
�
00
A A w w m q
A
�Sx
_ X o% 55x
.- O �
q e,`
L'z' - ®/ r Z,w m m i m D SiS���DD ;cF
-
s'
;-,Wp 'i'. 1I ,opF .—Nd.a..+e.._.to_l. Me ' -7-AR'-0 =-}anrH1a ovlids31 laaUot3p—n.e.11s4 by[d2-s-eCo-rsa•r6cow_rRp+54tr.no. Inr o
O °SECTIONAL
� GARAGE DOOR —11I
AL -F, AROOQ CORPORATION N
ENGINEERS &PRODUCT DEVELOPMENTs 7611 1 red nan RC -4. DAB Door Company, Inc. SUTE220UHUI1219$ N.W. 98th Ave. 9M3IA8M0I5FLNOSREITDDAR3IV31E,73
,
� (C
h 3598)
Hialeah Gordons, R. 33018 TEI(305)2eo-sioo rnx(aos)262-8978Q(p 03.211 N_ I Te: t800) 257-2016 Fox: t305) 362-9272 GARAGE\O
i 09[i ,Obt w0A—
Z1�
mw .
A S �
.EaA
l"
N
T�
i
�- OJ A +
Mph
�eeO���T��• 1 4:4 _
bgia$awa
Nt � � Ki~ ~'~ ff7J•i
1
'� m � Ig'b •I j I
\♦� ��\ ��_. _S '.N !''r. TISi
lll.� •il T+` xt, a: In _ poz muc
Q�x
� N :0 1 3f "4b Iwia .�v: v: �z2 L• r - z �k � A i v
�' n` Idtll<: oz Oi Oi revlsans:SECTIONAL GARAGE DOOR I AL-FAROOQ CORPORATION
» -� awls I os +t ANcvuNs ((.vlsc_ ENGINEERS &PRODUCT DEVELOPMENT
I� I DAB Door Company. Inc.
- - 9360 SUNSET DRIVE, SUITE 220
2.'R covu¢n"5 1 2195 N W 98th AYE MIAMI FLORIDA 33173 (CAA 538)
r: 0 tlr. Oy: TMSIJ J C708. iv B01TOY SEh 'LION Ik �I �/
Hialeah Gardens, FI. 33018 TEL.(305)2B�-asoo3l 3 FAX. (306) 2e2E978
(D 'o • . K cazl : Ac cv,No( nl:s s+[cr ; _ _
—.. --
d, i +vo�iT orwT� ro cn rx 17.1: (eoo) zs�-zots Fox: (305) 362 eve C GA RAG 0 -09DAa
m A+1 yp
N+mU
W
OO
Nh44 4++•�
e0\D•
ZZOO~
+ fT.1b
N0O COC
�S
��5
i>�bf1
+16A00
N�r•�
Or
an1
r^�� ,a0A
g opc
OO zA
z
5�p
AA
SzCC�;C2A
z5'
L•
oon�q+ w
mVC
o'n mmx HOW
N5� K 0
RmQ�+mz p�
XSg � pF'j
1\.
y1,0
g
zgz
NA(]mZm
8a?
m
Wp 30(q
Al P 2:6
�',.
=m
29Y
jam'
Z�
OR
sm
umm(:
�A
1'O
II -,g+i
1>
1� FS
�+4
ON
'DO
Zy
z K
L 2N
x 3
i+
Z
Z
1r0
"'
--7
a ME
r
�6
s
z
s
ti
(rq
f
7 vr
r_tl
x
-
--
y �
N+�(w
Z1�
mw .
A S �
.EaA
l"
N
T�
i
�- OJ A +
Mph
�eeO���T��• 1 4:4 _
bgia$awa
Nt � � Ki~ ~'~ ff7J•i
1
'� m � Ig'b •I j I
\♦� ��\ ��_. _S '.N !''r. TISi
lll.� •il T+` xt, a: In _ poz muc
Q�x
� N :0 1 3f "4b Iwia .�v: v: �z2 L• r - z �k � A i v
�' n` Idtll<: oz Oi Oi revlsans:SECTIONAL GARAGE DOOR I AL-FAROOQ CORPORATION
» -� awls I os +t ANcvuNs ((.vlsc_ ENGINEERS &PRODUCT DEVELOPMENT
I� I DAB Door Company. Inc.
- - 9360 SUNSET DRIVE, SUITE 220
2.'R covu¢n"5 1 2195 N W 98th AYE MIAMI FLORIDA 33173 (CAA 538)
r: 0 tlr. Oy: TMSIJ J C708. iv B01TOY SEh 'LION Ik �I �/
Hialeah Gardens, FI. 33018 TEL.(305)2B�-asoo3l 3 FAX. (306) 2e2E978
(D 'o • . K cazl : Ac cv,No( nl:s s+[cr ; _ _
—.. --
d, i +vo�iT orwT� ro cn rx 17.1: (eoo) zs�-zots Fox: (305) 362 eve C GA RAG 0 -09DAa
m
N
z
oma+
0�
m�F
O
n
o �
1\.
i
T --
-ter
�',.
29Y
jam'
Z1�
mw .
A S �
.EaA
l"
N
T�
i
�- OJ A +
Mph
�eeO���T��• 1 4:4 _
bgia$awa
Nt � � Ki~ ~'~ ff7J•i
1
'� m � Ig'b •I j I
\♦� ��\ ��_. _S '.N !''r. TISi
lll.� •il T+` xt, a: In _ poz muc
Q�x
� N :0 1 3f "4b Iwia .�v: v: �z2 L• r - z �k � A i v
�' n` Idtll<: oz Oi Oi revlsans:SECTIONAL GARAGE DOOR I AL-FAROOQ CORPORATION
» -� awls I os +t ANcvuNs ((.vlsc_ ENGINEERS &PRODUCT DEVELOPMENT
I� I DAB Door Company. Inc.
- - 9360 SUNSET DRIVE, SUITE 220
2.'R covu¢n"5 1 2195 N W 98th AYE MIAMI FLORIDA 33173 (CAA 538)
r: 0 tlr. Oy: TMSIJ J C708. iv B01TOY SEh 'LION Ik �I �/
Hialeah Gardens, FI. 33018 TEL.(305)2B�-asoo3l 3 FAX. (306) 2e2E978
(D 'o • . K cazl : Ac cv,No( nl:s s+[cr ; _ _
—.. --
d, i +vo�iT orwT� ro cn rx 17.1: (eoo) zs�-zots Fox: (305) 362 eve C GA RAG 0 -09DAa