HomeMy WebLinkAboutProduct ApprovalMIAMI-DaADE MIA.MI-DADE COUNTY
s PRODUCT CONTROL SECTION
11805 SW 26 Street, Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES (RER) Miami, Florida 33175-2474
BOARD AND CODE ADMINISTRATION DIVISION T (786) 315-2590 F (786) 315-2599
NOTICE OF ACCEPTANCE (NOA) www.miamidade.gov/economy
DAB Door Company, Inc.
12195 NW 98' Avenue
Hialeah Gardens, FL 33018
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction materials. The
documentation submitted has been reviewed and accepted by Miami -Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction (AHJ).
This NOA shall not be valid after the expiration date stated below. The Miami -Dade County Product Control Section (In
Miami Dade County) and/or the AHJ (in areas other than Miami Dade County) reserve the right to have this product or
material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, the
manufacturer will incur the expense of such testing and the AHJ may immediately revoke, modify, or suspend the use of
such product or material within their jurisdiction. RER reserves the right to revoke this acceptance, if it is determined
by Miami -Dade County Product Control Section that this product or material fails to meet the requirements of the
applicable building code.
This product is approved as described herein and has been designed to comply with the Florida Building Code, including
the High Velocity Hurricane Zone.
DESCRIPTION: Hurricane Master® Model 824/811 Steel Sectional Garage Door 16'-2" Wide with
Window Lite Option (DP +36.0, -44.0 PSF)
APPROVAL DOCUMENT: Drawing No. 02-21, titled "24 GA. Roll Formed Steel Sectional Garage
Door", dated 09/10/2002, with revision L dated 10/03/2017, sheets 1 through 5 of 5, prepared by Al-Farooq
Corporation, signed and sealed by Javad Ahmad, P.E., bearing the Miami -Dade County Product Control
renewal stamp with the Notice of Acceptance number and expiration date by the Miami -Dade County
Product Control Section.
MISSILE IMPACT RATING: Large and Small Missile Impact Resistant
LABELING: A permanent label with the manufacturer's name or logo, manufacturing address, model/series
number, the positive and negative design pressure rating, indicate impact rated if applicable, installation
instruction drawing reference number, approval number (NOA), the applicable test standards, and the
statement reading `Miami -Dade County Product Control Approved' is to be located on the door's side track,
bottom angle, or inner surface of a panel.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials, use, and/or manufacture of the product or process. Misuse of this NOA as an endorsement of any product, for
sales, advertising or any other purposes shall automatically terminate this NOA. Failure to comply with any section of
this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami -Dade County, Florida, and followed by. the
expiration date may be displayed in advertising literature. If any portion of the NOA is displayed, then it shall be done
in its entirety.
INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official.
This NOA renews NOA #17-1018.12 and consists of this page 1 and evidence pages E-1, E-2 and E-3, as
well as approval document mentioned above.
The submitted documentation was reviewed by Carlos M. Utrera, P.E.
Dte_MLr5,
OA No. 20-0107.06
ExpiratioDate: ly 21, 2025
Approval 2020
7 Page 1
DAB Door Company, Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
1. Evidence submitted under previous NOA's
A. DRAWINGS "Submitted under NOA # 17-1018.12"
1. Drawing No. 02-21, titled "24 GA. Roll Formed Steel Sectional Garage Door", dated
09/10/2002, with last revision K dated 03/09/2015, sheets 1 through 5 of 5, prepared by Al-
Farooq Corporation, signed and sealed by Javad Ahmad, P.E.
B. TESTS "Submitted under NOA # 11-0414.12"
1. Test Report on Uniform Static Air Pressure Test, Loading and Forced Entry Test per FBC,
TAS 202-94, of "DAB 824 Sectional Residential Garage Door" prepared by Hurricane
Engineering & Testing Inc., Report No. HETI-07-4200, dated 05/02/2007, signed and sealed
by Candido F. Font, P.E.
2. Test Report on Large Missile Impact Test per FBC, TAS 201-94 and Cyclic Wind Pressure
Test per FBC, TAS 203-94, of "DAB 824 Sectional Residential Garage Door", prepared by
Hurricane Engineering & Testing Inc., Report No. HETI-11-3204, dated 01/20/2011, signed
and sealed by Candido F. Font, P.E.
3. Test Report on Tensile Test per ASTM E8-08 of "Sectional Residential Door (skin)", prepared
by Hurricane Engineering & Testing Inc, Report No. HETI-11-T100, dated 01/21/2011,
signed and sealed by Candido F. Font, P.E.
"Submitted under NOA # 05-0228.02"
4. Test Report on Large Missile Impact Test and Cyclic Wind Pressure Test, of "Sectional
Residential Door with Windows", prepared by Hurricane Engineering & Testing Inc., Report
No. HETI 03-1328, dated 07/15/2003, signed and sealed by Rafael E. Droz-Seda, P.E.
5. Test Report on Uniform Static Air Pressure Test, of "Sectional Residential Door" prepared by
Hurricane Engineering & Testing Inc., Report No. HETI 03-1329, dated 07/15/2003, signed
and sealed by Rafael E. Droz-Seda, P.E.
6. Test Report on Tensile Test per ASTM E-8 of "Sectional Residential Door (skin)", prepared
by Hurricane Engineering & Testing Inc, Report No. HETI 03-T078, dated 10/31 /2003,
signed and sealed by Rafael E. Droz-Seda, P.E.
"Submitted under NOA # 03-0210.04"
7. Test report on Salt Spray (Corrosion) Test per ASTM B 117 of a painted G-40 steel panels,
prepared by Celotex Corporation, Test Report No. 258592, dated 08/17/1998, signed by W. A.
Jackson, P.E.
C. CALCULATIONS "Submitted under NOA # 14-0814.10"
1. Anchor verification calculations prepared by Al-Farooq Corporation, dated 09/22/2014 and
07/24/2014, signed and sealed by Javad Ahmad, P.E.
�ez`,7 202�
Carlos M. Utrera, P.E.
Product Control Examiner
NOA No. 20-0107.06
Expiration Date: July 21, 2025
Approval Date: March 5, 2020
E-1
DAB Door Company, Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
C. CALCULATIONS (Cont)
"Submitted under NOA # 11-0414.12"
2. Anchor verification calculations prepared by Al-Farooq Corporation, complying with F.B.0
2007, dated 04/07/2011, signed and sealed by Javad Ahmad, P.E.
3. Anchor verification calculations prepared by AI-Farooq Corporation, complying with F.B.0
2007, dated 12/19/2008, signed and sealed by Humayoun Farooq, P.E.
"Submitted under NOA # 09-0128.02"
D. QUALITY ASSURANCE
1. Miami -Dade Department of Regulatory and Economic Resources (RER)
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 13-0717.01, issued to SABIC Innovative Plastics, for their
Lexan Sheet Products, approved on 11/28/2013 and expiring on 07/17/2018.
2. Notice of Acceptance No. 14-0311.08, issued to Insulfoam, LLC, for their
Insulfoam Expanded Polystyrene Insulation, approved on 08/14/2014 and expiring on
11/29/2017.
3. Notice of Acceptance No. 11-0926.07, issued to Dyplast Products, LLC, for their Expanded
Polystyrene Block Type Insulation, approved on 11/10/2011 and expiring on 01/11/2017.
4. Notice of Acceptance No.11-0926.06, issued to Dyplast Products, LLC, for their
Dyplast ISO-C1 Polyisocyanurate Insulation, approved on 11/10/2011 and expiring on
01/11/2017.
5. Notice of Acceptance No. 10-1129.04, issued to Cellofoam North America Inc, for their
Expanded Polystyrene Block Insulation, approved on 02/24/2011 and expiring on 02/24/2016
"Submitted under NOA # 05-0228. 02"
6. Test Report on Accelerated Weathering Using Xenon Are Light Apparatus Test per
ASTM G 15 5 of "PVC Extrusion Material", prepared by Hurricane Engineering &
Testing, Inc., Report No. BETI 04-A002, dated 09/27/2004, signed and sealed by Rafael E.
Droz-Seda, P.E.
7. Test Reports on Tensile Test per ASTM D638 of "PVC Extrusion Material", prepared by
Hurricane Engineering & Testing Inc., Report No. HETI 04-T251, dated 11/29/2004 signed
and sealed by I. Ghia, P.E.
8. Test Report on Self -Ignition Temperature Test, Rate of Burn Test and Smoke Density
Test of "REHAU non -foam PVC extrusion material", prepared by ETC Laboratories,
Report No. 04-761-15019.0, dated 05/06/2004, signed and sealed by J. L. Doldan, P.E.
F. STATEMENTS "Submitted under NOA # 14-0814.10"
1. Statement letter of code conformance to the 51 edition (2014) FBC and no financial interest
issued by Al-Farooq Corporation, dated 05/13/2014, signed and sealed by Javad Ahmad, P.E.
�d2/27/2D'Ld
Carlos M. Utrera, P.E.
Product Control Examiner
NOA No. 20-0107.06
Expiration Date: July 21, 2025
Approval Date: March 5, 2020
E-2
DAB Door Company, Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUB
2. New evidence submitted.
A. DRAWINGS "Submitted under NOA #17-1018.12"
1. Drawing No. 02-21, titled "24 GA. Roll Formed Steel Sectional Garage Door", dated
09/10/2002, with revision L dated 10/03/2017, sheets l through 5 of 5, prepared by Al-
Farooq Corporation, signed and sealed by Javad Ahmad, P.E.
B. CALCULATIONS
1. None.
C. QUALITY ASSURANCE
1. Miami Dade Department of Regulatory and Economic Resources (RER).
D. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 17-0221.06, issued to Insulfoam, LLC, for their Insulfoam
Expanded Polystyrene Insulation, expiring on 11/29/2022.
2. Notice of Acceptance No. 16-1108.04, issued to Dyplast Products, LLC, for their
Dyplast ISO -CI Polyisocyanurate Insulation, expiring on 01/11/2022.
3. Notice of Acceptance No. 15-1203.04, issued to Cellofoam North America Inc, for
their Expanded Polystyrene Block Insulation, expiring on 02/24/2021.
4. Notice of Acceptance No. 15-0915.08, issued to SABIC Innovative Plastics, for their Lexan
Sheet Products, expiring on 07/17/2018.
E. STATEMENTS
1. Statement letter of code conformance to the 6t' edition (2017) FBC, prepared by Al
Farooq Corporation, dated 12/23/2019, signed and sealed by Javad Ahmad, P.E.
F. OTHER
1. This NOA renews NOA 917-1018.12.
f 0101�
? �Za26
Carlos M. Utrera, P.E.
Product Control Examiner
NOA No. 20-0107.06
Expiration Date: July 21, 2025
Approval Date: March 5, 2020
E-3
1HO13H HOOO „0-,91
HOOD SNOIL33S 3MJ
LHOGH 8000 „0-,8
„LZ
.8L ..8.1
r —m
.131
.LZ
<
I
11
I
II I. �II
13
U
m O
o
$Wo O•? h
a
0
I
Io
z
m LL O
g
N 9
a$.
IIII
o �; ®N
s 9
G
7a�o
O .2;
6amaY
3
E E
m
m�
II II
K
g
I I I I
5
Z
II fII
VI
� 2ygYUQ
NN�Qmq
I
I I
�
�a8.r= �N
Ll
I
III
�Wz
O v0
Z
�
,
o O N
Q1111'J8JJJn
�Z
3
3
t M
Xg�
a:v
\Ed al zC
F 3oydva ZLZ6-Z9£ (SO£) :XD_4 9LOZ-LSZ (008) :1-
BL6ezez(900)xvd 00T"gz(ow •'lal. 9Lo££ 'Ii 'SuapJDD 40a101H
(Be96 •N'YO) CITESvalN7d o'Iwvlw •9AV 4186 WN 96LZL
ozz a.uns'anlaa JasNns o9M •oul 'Auodwoo loon gyp
Jmwdoiwaa J.onamid * Si333NIOZ
No�tbaoaaoo aooad�-�v as 3�vavo iarroua�s ��s o3wao� TON W vu
wg o0 8 jt� 9 �!
Iy-{ O O � g � � O p• �r
€.� ; -gip
FIR�:
Ur\1 SS3w U.
€ z voi
y oa
'zr '^�€ '
U W U• dN RM U
�w yy 5<o w �jE 5
$9 3 u F JUo gNmFga K U .. ev
m ' a r� ; _1 o� X=3o
&a=7-P arm
a9 iro�
o N M < m
o
0
on
(n
�o mm ao
m \ = O cl
I LLI J w aN0 o M dam' �j •'�
W Ld m�.o t I zo ® in o
2
Q O NNMdN
(n IL �XOn U rK O
m
El
Z Q t_j ®
O U a N O
I- O of i
a q oin3 � 2 a�� ..n -
0.
w
Lu
O J.
o
F zm ® m ® ® o
a Z �ZO� .0 ® N
o
J f`S
O m ji
N �c
o-
4 ~
H
c
U
OM iICZ 01 MIVCJn
-LVC0'01
-I
J33HS SIHl 301"3 ON
91'sOU
N
133HS SIHL 30NNI0 ON
*vLo'll
f
J33HS S;M 3- ON
*LVI'.
I
uo uosa
a 0
ou
:R9 714o p.
` N
bINtl1 e(q 'gyp
C14
Q
ZO-Ol-fi0 :e}op v
c<o
g
S8000 TIV m ,n. L
yiI/�n
�
2
N n
N
NN
N
N N
�Ng
NNN
N
1/F�
N
NN
Z4G1
N
n
�+N
N2,f/�
u-Ni
FZOFN
W i
GZ F22cc
W W
W
CFw�.yU1
CGCZCN
yR
O2�
�l
O
u muWiU
GN
g
1$2�1�
Fry
VIN
N M
I I
NNNN
I I
a I
1 N
�VI
N
N
Vi'V'iw/1
I -
VI
w N
•o I
N
n
I M
�i
Jm
m �
m I t
r�
o
mmN
_--'
-toN
0
_---
m.Nm
aPN-
O
O Z
2
y 2.....
0 0
0 000 N'
N
N o
0
2 2
O O
Z NZ
O
Z NZ N
0 0
2 2
0 0
2 2
0 0
2 ZO
2 2
2 M
0 0
2 Y
0 0
Z NZ ZZN
0 0
1� ZNZ
9 6
M I/Z
1
65
Z 2 2
0 0
MU
D
R
w
�NNN�NN
��
�����9
W'•'
Y I
N4MN.-
...
NtMN.-
.......
bN
aMN
_.
N�f
MN.-0�
NNN
InaM
.1
•I •I
i�I.
�1 �I
io •I
,I •I
60
•I
•I
J
iN
A •�
•I
"p'I
}II
in •i
•� 'i io
-R =
a _I
_I
-I
_I
_I
_I
N N
_I
N(sos) wj00ta-b9z (ROW -ML
(8859 N'YD) EC6EEVURla'Id`MN
ozaans=9MHa13smsoos
imwdo,M-aa lofiCoud 39 SIMMIDN9ecsozliavlclmoo
booad:j--Id
ZL36-Z9£ (SO£) :--A 9LOZ-44Z (008) :1-1
9 LO€£ '19 •suap�00 4001DIH
'any 4186 WN 962L
,oUj 44uodWOo JOOQ eyQ
A -44'
& �
` N
I
'� NO
01 xq ,P
O
zo oL-6o >,.,
80 38VM IVNOLL33S :6 03PWJ Boa v9 4a
:S OISIA9�
F o ```````L�L•`•L L�`j��/i
�9d LLOl Ol 031tlOdf1
Ll'f0'UL
l
13?HS SIHL 3`JNtlHO ON
SL'60'SO
N
133HS SIHL 39NvHa ON
L'LO'LL
f
J33H5 SIHl 3�HVH'J ON
4'4'8L'90
I
uol uosa
a o
oU
C11
W Z W 1 `� OI
�g'Z
A' a V of pU w
_ g Oo pO �®•
.� i 8$g• i O o_i L4 E r /s . • • �tfi
uww rnNoo f� trW z�W no /fff1jILLL`���
W d U o m
IL
0 E' oEl �
,a =�� IQ moo In
N pp a
o () O W W w W
•� O a O rn
e f i W {al p
ZZ td•Z KO ¢ "'y
Z N iV I NJ' U V 'Y
Q m ✓
m
K
•2.
0
Ram li. .I.z
n
n
T— e.
7 .
oqyf
M
�mo
vv
nbOdW N
O
m
c
C
WIT-
'O O�d.f° vm\iw 1 • I .w Xen x_z
a.a
XE L
3wp -Uh
a
� ZNZ-M
0 Xa�
z �otj
® ®Ld9 y x�G
uj gjKI ... .... KI
z �b
o� xx
�o aka
2
N
j8}�L9
--
U�F�o
�n b
LLo��r
�KQ
Z���d'a
\j I•.CVIY
�
py�QJ
}�my
N Oat v\im
xa(c3XLL
O
07
to .
®'05va3
I d O
O
cY�O\�JSd
w,31n Xo rr
Y�.- 3 Zvi
8VEI A 0Naa0.iNl38 H11M
(~i1
N -
N01L33S WO-LLO9
m
��I KOOON
O WKW K K 3
W
ERR
X� �XxX
\p °DODO
nW �.HC4
w N
o
ul
O I
w
tE O
� p � F
X�S N
r U rK
BYO CZ-ZO\3DV'8VO ZLZO-ZSS (goo) =j gtoz-L5z (009) :lol
sceerss Woe)xvd oacetez (loe)-M 8lLi 0££ ''suapJog y09101H
(asss •er•rs) emeaalao-Wimm any y}96 'MIN 96LZL
or
3mns'3/ ma 13sNns o9e6 •�u�-Xuoduw60 good ava
1N3wdolwaa J.OnaoNd V sN33NION9
N NOIJLVUOdUOD t)OOUVd--M 8a 30VW0 NNOIL035 13315 03W2J03 IION tiff tib
�d 8 �q Nwil o p .a
2_o=mmox'��mmm N m m m o i>9� j o_
T UOT1O6ZOf!".m\\ YT Tm:, G �sva
x OZX�?��oOmaN x � m N 0��n•�
�go�g�ano�.X 3 m d- fla"d z
O
Or`03av m M M M 17 M Y
'M gU�j�aZ
m x 0 1 ` ~
303m 60Al
1
x �O
N
H
6
U
E�
ad
os
w
m °p
w
zo o. 3
w� m x �"
T Y UZ
o8 xmx��
$�NtUi21Fo
�
4l a0
x�my
xm
'o
j
LL
�8
�
8N
wm�
li
Ro
8ptleia�
d
�¢
��
�rc�
m ra�n8
q
O Z 0
o
G
o
l3NVd .lZ
R9 M4° c
OIaYl d9 _� N
rn
2 00 0
zo-ot-so :o)oo $
_ J
etiaiz-zo svav� ZLZ6-ZK (eos) :xoe gm-Lo (ooe) aal
ecss�sz(soeYx i oos8•b9z(90e)-131 8L0££ 'Id 'suapJoo yoaIoiH
(ssys 's,ro) ELyEeva°ao-Wi mw 'any H426 -M'N SWL
7■ ozzauns'antaa.msNnsoses ouL '.Cuodwop jooa gyQ
. N3 Wdo-°aA3a ionaoud v s.(3aN1'JNa
moummodmon bOomv-q-gtl 'i1Q 35"a wRoams -Gas o3 w -noN 'tlo 4z
N g= rj
'U 3n I,
w 3ao pso a a
� z
2O PRO
RO
mXm� �qq
M IY
y - F, N
M �
N
a�zm"zz °
s da$o o
rny��65 °
t� O
m
0
r
o�
K
2 N
8.
a(q rya
L a Q31Mdn LL'EO'OI IC N
TM H0 -LOS 0, 0'E0 N biatll :Fq •gyp
aea "" n3a >vcu'u p I
vaa saoxoav rs reo 1 N
o
ZOOL
col uose a o ou O
:6 u01s1naJ --6b lZia���i
A, �K5 .
_VJ
z s
u{ U
in�t�a5 y O °p
0O < O N Q
WM O M p
ZM g h ii
X U.UU o_ W- N O g
OON �3 w
W m a`
mNmZv F' C
VAf.I C
G G
G EcZ y
O $'5 ` a E
oe
o
dnm2 p°1 mg
�yya
\� 5
N
CJ
X�O
m rim
\ f.
6
3 03.1 031 N o31 �� zw vm
M.
�x cU� yi
om �i U y U Gj
��QiQi. iq �z rc9BE aQs
� :Uw UN"w Y�y� � Zz �OF¢Z p6
Nw sow aooa-11`�0¢ �r�'o� t+- .o � a �•-•
&8�80 orn z Uz ao
C.
Z' 000oowoy�y!! Za.
rc g zg az6m�
�9 FF>000b 5,3 090? moot o z oS&?
�o tt.. \ •o-. . io �o.M� m.. ipop-9 �S8
iiU �N^N ��MiM MMM1M MO^V1N lOi.6 �j
9V0LZ—ao 30yeva uu-Z9£ (S0£) :xuj 9LOL=L4Z (00") 1a1
rrr��� azas-zsz csoaa W-4 0o'ca-eez fsoe7n3i. 8t0€c 'Ij 'SUapJDO 4oaIo!H
✓_ (B89S 'N'Ya) ELSEEVa1Ho'Id omm •BAV 4196 'M'N S6.lZl
.T/ ozaauns'26mucl 13sr+nsoae6 oul bSundwoo poop gyd
JN3Ws10-m3o 3anOOHdV SH33NION3
e NOIlVlOdUOD bOOHV=I-IV 1331S 03MM fitUH ND 4Z
z
0
0 [EDI
'z
N o
Lw
1� 0
0
�El,�� a
cp�
z.
0
w
U
-i o IT
E I
0
�+Mw
m
w t`' a a\\Ca\\�
J
O
fo U
UN W.
F��
CL U In
ow LLOZ o1 mivadn
j4vco*mj
l
133HS 91 39WHO ON
1w6o'col
N
SIUMNOD U38 U3d '/Gll
L'LO'll
f
133H551H1 3aNVHa ON
ft's l'60
I
UOI IJOS2
B D
OU
c N
DIUV1 :(Q •JF
ZD-OL-80 :aeop v
m
0z
3 o
a O N
O
Q
3N
Wa O
s
O
o r
,ry N
g
Z o
O
Wz� N o
Z
p
Q
o
z z
Fig c
C
O O
D-N-U
amd °
c
i...i¢
¢3U
GEEj E
y
n
j 0 OJ
L Z m
00
N M W
f
w
W
�C,z
!n
?mm
or
O
r
W C
U
I I
Ijl
Q W
nir
II!!
W 3
I111
C Z
�
i
U
t
i I
1 1 1
IIII
Iljl
j
ll
,
\
w
nod
x � N
Vk\
M Y
®p
6�
n.
J
oY
N
t�ii Ci
NOx
Z
N
W es-
W� tOOvj
¢
�
fs •aq
X�\
�zo
Z_7
^�
o
3
.xMQ
in
x0
ko ®tea
�o�a
�� � o
�z
.;�, R.
I
bOINRX3 _ O
'Od0 'TO m
H013H MOONIM