The URL can be used to link to this page

Home My WebLink AboutTROP FMW1 PLAN REVIEWPlan Review Mike Galasso PepsiCo Inc "Tropicana (MFG)" 6500 Glades Cut Off Road Fort Pierce, FL 34981-4303 USA Index-Rec No: Account No: Date of Review: Review No: Plans Submitted By: Jason Mills, Sutter Roofing Company of Florida Subject: Feed Mill Warehouse No. 2 Reroof 084469.04-04 01-32540 October 14, 2020 323108 Executive Summary: This submittal is for the installation of a new metal panel through fastened roof system on the above building. The submittal is in accordance with FM Global standards and considered acceptable. Scope of Review: This confirms the receipt and review of: • Sutter Roofing submittal for "PAC -CLAD 22 ga. corrugated panels" This submittal is for the reroof over the (east) Feedmill Warehouse 2 at the above site. This building is approximately 204 x 104 ft. with an eave height of 30 ft. and a ridge height of 56 ft. A new Petersen Roofing PAC CLAD 22 ga. metal panel roof is to be installed. The PAC CLAD is a corrugated metal panel with a 7/8 in. depth and a rib to rib spacing of 2.67 in. The existing supports are 4 ft. o.c. throughout. The panels are to be secured to the 16 ga. steel supports with 1/ - 14 1 1/4 in. long hex head self drilling fasteners with 5/8 in. dia. seal washers. This is to be done at every other panel rib (or 5.33 in. o.c.). Side laps are to be fastened at 12 in. o.c. with No. 12 -24 x 1 in. long hex head self drilling fasteners with 5/8 in. dia. seal washers. A slope of 6 in./12 in. is provided for this building. The above results in the following roof zones/areas: Design Pressure Wind Rating Zone 1/2e 100 psf 1-210 Zone 2n, 2r, 3e 148 psf 1-300 Zone 3r 160 psf 1-330 This report has been developed for insurance underwriting purposes. It is provided to you for informational purposes only to reduce the possibility of loss to insured property by bringing to your attention certain potential hazards or conditions. Life, safety, or health issues are not addressed. You must make the decision whether to take any action. The company undertakes no duty to you or any other party by providing this report or the activities on which it is based. The liability of the company is limited to that contained in its insurance policies. 7281A (0712019) Page 2 of 3 The following design parameters were used for this review: • 135 mph Wind Speed (for 3 -second gusts) • 1.15 Wind Importance Factor (for cladding) • Ground Roughness "C" • Partially Enclosed Building Classification Recommendations to Reduce Hazards during Installation: 1. Thorough supervision by the building owner's qualified representative should be provided during construction/installation to ensure adherence to specifications and quality of workmanship. 2. Combustible rubbish should be disposed of promptly and safely. Strict rules and an adequate number of clean up personnel are essential to facilitate the removal of accumulations of paper wrappings, scrap lumber, and other construction rubbish. Prompt disposal is particularly needed for material subject to spontaneous ignition, such as oily waste and paint rags. 3. Hot work of any kind should be avoided. If there is a practical and safer way to do the job without hot work, the alternative method should be used. If hot work is unavoidable, precautions such as those outlined on the FM Global Hot Work Permit System should be taken during any such work. This review is for property insurance purposes only in accordance with FM Global standards and guidelines. Nothing should be inferred from this review regarding compliance with any rules, regulations or requirements of government agencies, state or local codes or any other jurisdictional authority. We are retaining the copy of your submitted plans for Pur files. Sincerely, Keith M Camara FM Global Senior Engineering Specialist keith.camara@fmjzlobal.com Loss Prevention Resources: FM Global Property Loss Prevention Data Sheets (https://www.fmglobal.com/research-and-resources/fm- global-data-sheets) FM Global Loss Prevention Training(https://fniglobaltrainin-.skillport.com) Approval Guide (http://www.approvalguide.com) RoofNav (http://roofnay.fmglobaI.com) This report has been developed for insurance underwriting purposes. It is provided to you for informational purposes only to reduce the possibility of loss to insured property by bringing to your attention certain potential hazards or conditions. Ufe, safety, or health issues are not addressed. You must make the decision whether to take any action. The company undertakes no duty to you or any other party by providing this report or the activities on which it is based. The liability of the company is limited to that contained in its insurance policies. 7281A (07/2019) Page 3 of 3 Distribution: Scott Davis, PepsiCo Inc, scott.davis@pepsico.com Jason Mills, Sutter Roofing Company of Florida, jmills@sutterroofing.com Brenton Liba, PepsiCo Inc, brenton.liba@pepsico.com Kevin Duffer, PepsiCo Inc, kevin.duffer@pepsico.com Derek Janquart, PepsiCo Inc, derek.janquart@pepsico.com Ed Barbour, PepsiCo Inc, ed.barbour@pepsico.com Scott Davis, PepsiCo Inc, scott.davis@pepsico.com Steve Lawrence, North America Beverages, steve.lawrence@pepsico.com Torn Smith, PepsiCo Inc, tom.smith2@pepsico.com Juliana Parente, North America Beverages, juliana.parente@pepsico.com Kimberly Lawler, PepsiCo Inc, kimberly.lawler@pepsico.com Gary Roberts, FM Global Senior Account Engineer, g_ary.roberts@fmglobal.com Amy Wisecarver, FM Global Account Engineer, amy.wisecarver@fmglobal.com Shaun Keith, FM Global Senior Account Manager, chris.keith@fmglobal.com Mike Galasso — Tropicana Contractor Mike.Galasso.Contractor@pepsico.com Rob Cain, Sutter Roofing rcain@sutterroofmg.com This report has been developed for insurance underwriting purposes. It is provided to you for informational purposes only to reduce the possibility of loss to insured property by bringing to your attention certain potential hazards or conditions_ Life, safety, or health issues are not addressed. You must make the decision whether to take any action. The company undertakes no duty to you or any other party by providing this report or the activities on which it is based. The liability of the company is limited to that contained in its insurance policies. 7281A (0712019)