Loading...
The URL can be used to link to this page
Your browser does not support the video tag.
Home
My WebLink
About
Notice of Acceptance
I F MIAMI•DADE MIAMI-DADE COUNTY PRODUCT CONTROL SECTION 11805 SW 26 Street,Room 208 DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(RER) Miami,Florida 33175-2474 BOARD AND CODE ADMINISTRATION DIVISION T(786)315-2590 F(786)315_2599 NOTICE OF ACCEPTANCE (NOA) www.miamidade.Qovleconomy DAB Door Company,Inc. 12195 NW 98"Avenue Hialeah Gardens,FL 33018 SCOPE:This NOA is being issued under the applicable rules and regulations governing the use of construction materials.The documentation submitted has been reviewed and accepted by Miami-Dade County RER-Product Control Section to be used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction(AHJ). This NOA shall not be valid after the expiration date stated below.The Miami-Dade County Product Control Section(In -Miami Dade County)and/or the AHJ(in areas other than Miami Dade County)reserve the right to have this product or material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, the manufacturer will incur the expense of such testing and the AHJ may immediately revoke,modify,or suspend the use of such product or material within their jurisdiction. RER reserves the right to revoke this acceptance,if it is determined by Miami-Dade County Product Control Section that this product or material fails to meet the requirements of the applicable building code. This product is approved as described herein, and has been designed to comply with the Florida Building Code, including the High Velocity Hurricane Zone. DESCRIPTION:Hurricane Mater Model 824/811 Steel Sectional Garage Door up to 16`-2"w/ I Window Lite Option(DP+48.0,-52.0 PSF) j APPROVAL DOCUMENT: Drawing No.98-05,titled"24 GA.Roll Formed Steel Sectional Garage Door",dated 02/23/1998,with last revision L dated 03/05/2015,sheets 1 through 6 of 6,prepared by Al- Farooq Corporation,signed and sealed by Javad Ahmad,P.E.,bearing the.Miami-Dade County Product Control renewal stamp with the Notice of Acceptance number and expiration date by the Miami-Dade County Product Control Section. MISSILE IMPACT RATING:Large and Small Missile Impact Resistant LABELING:A permanent label with the manufacturer's name or logo,manufacturing address,model/series number,the positive and negative design pressure rating,indicate impact rated if applicable,installation instruction drawing reference number,approval number(NOA),the applicable test standards,and the statement reading`Miami-Dade County Product Control Approved' is to be located on the door's side track, bottom angle,or inner surface of a panel. ! i RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change in the applicable building code negatively affecting the performance of this product. , ! TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the i materials,use,and/or manufacture of the product or process.Misuse of this NOA as an endorsement of any product;for sales,advertising or any other purposes shall automatically terminate this NOA.Failure to comply with any section of this NOA shall be cause for termination and removal of NOA. ADVERTISEMENT:The NOA number preceded by the words Miami-Dade County,Florida,and followed by the expiration date may be displayed in advertising literature. If any portion of the NOA is displayed,then it shall be;done in its entirety. INSPECTION:A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and shall be available for inspection at the job site at the request of the Building Official. This NOA renews NOA#14-0814.08 and consists of this page 1 and evidence pages E-I and E-2,as we as approval document mentioned above. The submitted documentation was reviewed by Carlos M.Utrera,P.E. NOA No.15-0302.01 Expiration Date:July 21,2020 MIAMI•DADE COUNTY Approval Date:April 23,7015 Page PAN.RALL E.STUFFY P.A. 03379 AR6001 1105 APPROVED REVISE&RESUBMIT APPROVED AS CORRECTED REJECTED This rc1ji&w.4,,only for nnn,-raj c.nf1foun-ante villh the de:;gn concept of the prC48-1anal (MrPli-RD"ce"filth given in tia contract dcujmant3. ur ryj.ada on tho shop,drawings during this raviev do nc,t relisVu '-is xntra-.-,: r ixin compii13noe with the rcquka- niwm ci llie p!:siqs 2nd peCiti IJPS.pqpp.oval cl a specilric it2rn shall nDt includo qporo,.'F i:'f u assembly of%vhicb thu, iarn is a component.Con- :13 fo, to be mnf.mad- and comalatod M the job&`le;lnfu-nalisli Uhzt panr:<,:ns solely to the f8Vc8t10n processes or to ear, ad tachn ethemK, ls, -1 , s and prowdures of construc- tion:coomination of the wwk of all olhar�.-dss:and for performing all work in a safe and satisfactory manner. DATE: BY: _ P T ' I MIAMI•DADE MIAMI-DADE COUNTY PRODUCT CONTROL SECTION 11805 SW 26 Street,Room 208 DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(RER) Miami,Florida 33175-2474 BOARD AND CODE ADMINISTRATION DIVISION T(786)315-2590 F(786)315-2599 NOTICE OFj ACCEPTANCE (NOA) www.mismidade.eov/economy DAB Door Company,Inc. 12195 NW 98'.h Avenue Hialeah Gardens,FL 33018 SCOPE:This NOA is being issued under the applicable rules and regulations governing the use of construction materials.The documentation submitted has been reviewed and accepted by Miami-Dade County RER-Product Control Section to be used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction(AHJ). This NOA shall not be valid after the expiration date stated below.The Miami-Dade County Product Control Section(In Miami Dade County)and/or the AHJ(in areas other than Miami.Dade County).reserve the right to have this product or material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, thei manufacturer will incur the expense of such testing and the AID may immediately revoke,modify,or suspend the use of such product or material within their jurisdiction. RER reserves the right to revoke this acceptance,if it is determined by Miami-Dade County Product Control Section that this product or material fails to meet the requirements of the', applicable building code. This product is approved as described herein, and has been designed to comply with the Florida Building Code,; including the High Velocity Hurricane Zone. DESCRIPTION:Hurricane Mater Model 8241811 Steel Sectional Garage Door up to 16'-2"w/ Window Lite Option(DP+48.0,-52.0 PSF) APPROVAL DOCUMENT:Drawing No.98-05,titled"24 GA.Roll Formed Steel Sectional Garage Door",dated 02/23/1998,with last revision L dated 03/0 512 0 1 5,sheets 1 through 6 of 6,prepared by Al- Farooq Corporation,signed and sealed by Javad Ahmad,P.E.,bearing the Miami-Dade County Product Control renewal stamp with the Notice of Acceptance number and expiration date by the Miami-Dade County Product Control Section. I MISSILE IMPACT RATING:Large and Small Missile Impact Resistant LABELING:A permanent label with the manufacturer's name or logo,manufacturing address,model/series number,the positive and negative design pressure rating,indicate impact rated if applicable,installation instruction drawing reference number,approval number(NOA),the applicable test standards,and the statement reading`Miami-Dade County Product Control Approved'is to be located on the door's side track, bottom angle,or inner surface of a panel. RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change in the applicable building code negatively affecting the performance of this product. TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the materials,use,and/or manufacture of the product or process.Misuse of this NOA as an endorsement of any product,for sales,advertising or any other purposes shall automatically terminate this NOA.Failure to comply with any section of this NOA shall be cause for termination and removal of NOA. ADVERTISEMENT:The NOA number preceded by the words Miami-Dade County,Florida,and followed by the expiration date may be displayed in advertising literature. If any portion of the NOA is displayed,then it shall be done in its entirety. INSPECTION:A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and shall be available for inspection at the job site at the request of the Building Official, This NOA renews NOA#14-0814.08 and consists of this page 1 and evidence pages E-1 and E-2,as well as approval document mentioned above. The submitted documentation was reviewed by Carlos M.Utrera,P.E. I NOA No.15-0302.01 Expiration Date:Jul 21,202 QMNALMDADE CO UNTY ira P� Y 0...imp �1� Approvals p3 i1 0 j(oP eI ' • DAB Door Company,Inc. li NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED I I � A. DRAWINGS 1. Drawing No.98-05,titled"24 GA.Roll Formed Steel Sectional Garage Door",dated 02/23/1998,with last revision L dated 03/05/2015,sheets 1 through 6 of 6,prepared by Al- Farooq Corporation,signed and sealed by Javad Ahmad,P.E. I B. TESTS "Submitted under NOA#I1-0414.13" 1. Test Report on Uniform Static Air Pressure Test,Loading and Forced Entry Test per FBC, TAS 202-94,of"DAB 824 Sectional Residential Garage Door"prepared by Hurricane Engineering&Testing Inc.,Report No.HETI-07-4267,dated 06/29/2007,signed and sealed by Candido F.Font,P.E. 2. Test Report on Large Missile Impact Test per FBC,TAS 201-94 and Cyclic Wind Pressure Test per FBC,TAS 203-94,of"DAB 824 Sectional Residential Garage Door",prepared by Hurricane Engineering&Testing Inc.,Report No.HETI-11-3206,dated 02/10/2011,signed and sealed by Candido F.Font,P.E. 3. Test Report on Tensile Test per ASTM E8-08 of"Sectional Residential Door(skin)", prepared by Hurricane Engineering&Testing Inc,Report No.HETI-114101,dated 01/29/2011,signed and sealed by Candido F.Font,P.E. "Submitted under NOA#05-0217.02" 4. Test Report on Large Missile Impact Test and Cyclic Wind Pressure Test,of"Sectional Residential Door with Windows"prepared by Hurricane Engineering&Testing Inc.,Test Report No.HETI 03-1328,dated 07/15/2003,signed and sealed by Rafael E.Droz-Seda,PE. 5. Test Report on Uniform Static Air Pressure Test,of"Sectional Residential Door"prepared by Hurricane Engineering&Testing Inc.,Test Report No.HETI 03-1329,dated 07/15/2003 signed and sealed by Rafael E.Droz-Seda,P.E. 6. Test Report on Tensile Test per ASTM E-8 of"Sectional Residential Door(skin)"prepared by Hurricane Engineering&Testing Inc,Test Report No.HETI 03-T078,dated 10/31/2003, signed and sealed by Rafael E.Droz-Seda,P.E. "Submitted under NOA#03-0210.04" 7. Test report on Salt Spray(Corrosion)Test per ASTM B 117 of a painted G-40 steel panels, prepared by Celotex Corporation,Test Report No.258592,dated 08/17/1998,signed by W.A. Jackson,P.E. C. CALCULATIONS "Submitted under NOA#14-0814.08" 1. Anchor verification calculations prepared by Al-Farooq Corporation,dated 09/22/2014 and 07124/2014,signed and sealed by Javad Ahmad,P.E. Carlos M.Utrera,P.E. Product Control Examiner NOA No.15-0302.01 Expiration Date:July 21,2020 Approval Date:April 23,2015 E-1 I I � I I • DAB Door Company,Inc. NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED C. CALCULATIONS ) "Submitted Cont.( under NOA#09-0128.0I" 1. Anchor verification calculations prepared by Al-Farooq Corporation,complying with F.B.0 2007,dated 04/05/2011,signed and sealed by Javad Ahmad,P.E. • `Submitted tinder NOA #09-0128.01" 2. Anchor verification calculations prepared by Al-Farooq Corporation,complying with F.B.0 2007,dated 12/18/2008,signed and sealed by Humayoun Farooq,P.E. r D. QUALITY ASSURANCE 1. Miami-Dade Department of Regulatory and Economic Resources(RER) E. MATERIAL CERTIFICATIONS 1. Notice of Acceptance No. 13-0717.01,issued to SABIC Innovative Plastics,for their Lexan Sheet Products,approved on 11/28/2013 and expiring on 07/17/2018. 2. Notice of Acceptance No.14-0311.08,issued to Insulfoam,LLC,for their Insulfoam Expanded Polystyrene Insulation,approved on 08/14/2014 and expiring on 11/29/2017. 3. Notice of Acceptance No.11-0926.07,issued to Dyplast Products,LLC,for their Expanded Polystyrene Block Type Insulation,approved on 11/10/2011 and expiring on 01/11/2017. 4. Notice of Acceptance No.11-0926.06,issued to Dyplast Products,LLC,for their Dyplast ISO-Cl Polyisocyanurate Insulation,approved on 11/10/2011 and expiring on 01/11/2017. 5. Notice of Acceptance No.10-1129.04,issued to Cellofoam North America Inc,for their Expanded Polystyrene Block Insulation,approved on 02/24/2011 and expiring on 02/24/2111* "Submitted under NOA#OS 0228.02" 6. Test Report on Accelerated Weathering Using Xenon Are Light Apparatus Test per ASTM G155 of"PVC Extrusion Material',prepared by Hurricane Engineering& Testing,Inc.,Report No.HETI 04-A002,dated 09/27/2004,signed and sealed by Rafael E. DrOz-Seda,P.E. 7. Test Reports on Tensile Test per ASTM D638 of"PVC Extrusion Material",prepared by Hurricane Engineering&Testing Inc.,Report No.HETI 04-T251,dated 11/29/2004 signed and sealed by I.Ghia,P.E. 8. Test Report on Self-Ignition Temperature Test,Rate of Burn Test and Smoke Density Test of"REHAU non-foam PVC extrusion material',prepared by ETC Laboratories, Report No. 04-761-15019.0,dated 05/06/2004,signed and sealed by J.L.Doldan,P.E. F. STATEMENTS "Submitted under NOA#I4-0814.08" 1. Statement letter of code conformance to the 51 edition(2014)FBC and no financial interest issued by Al-Farooq Corporation,dated 05/13/2014,signed and sealed by Javad Ahmad,P.E. Carlos M.Utrere,P.E. Product Control Examiner NOA No.15-0302.01 Expiration Date:July 21,2020 Approval Date:April 23,2015 E-2 ; I , II I i i I t • I I I I IF I • T-1/z'X z-1/4"%le GA GRLV.arm CORER HNBC � PIAM MJf TOP iOR11RE 5-I/z'X 01- X 0.1' ►` y W/(4)114%5/5'SYS O ATEEL PLATE WITH ONE 9/I6-IB YS W/NUT OPTIONAL.DOOR VIEWER 4_V 3 o at1,E0 TO END S.WLO 10 BE 0ENTERE0 AT WImWT MNiON SUEVE(sm.) FASTENED ENE X]/E sus DIRL%c saiEYrs ABE MAL SAT q 0 7-1/z•X 3•%.071•DAM STEEL I, G B , BK BNEET 4 FOR TOP BRACKET OPTIONS Z END f10lLEN 14NLE I ;0: N/(a)tl4%6/9'516ti OO 1 CENTFA sirs - r A W17401 T DEMR N SLLLVC(STD.) SEE Sm'A' SS. WITH DEMON SLEEVE(OPTIONAL) LL 7-1/]'X 1-Ile X 071" GALV.S,EEL ClNIEN InNSE O W/0)t14 X 5/5'SKR LOCK `� I WITH DELNON s1EEYE(oPTroNAL) z/DOOR a CENTER HINGE i ; 1•W x.15 WOK L TM, I O d a I STANONID LOCK _ I� IT SPRING LOADED SLIDE E BOLT _ _ - FASTENED N/(4)/14%1/2'S.IAS. __...._.__. _ __ ...-I_._..__�-I l� .._._ 5/8'ION.LOOK OIf.V,EYENI �`.B _ _ .__.-.___ _ II1I -__ a Gil 8 1 Ol il�R1 GARAGE DOORS T TO SET;110N low W'GiAPAO GARAGE O AM OIA.CNV.AIRCRAFT TYPE • , �_._.` J---.:- -�,.'G+ _ __ _-__ QIk -Y� r� .. E DOLE h NICO-PRESS SLE 0 _ = W/YW.5 TO 1 SAFETY FACTEVEOR _ ` ,_ _ _ EE SIE}1 PATE I'1''LI 'j'�'' WITH(4) 14%3/4' t • I • 1--_=_.JL�--_J I _ - Fm ®I L1 t� SELF ONG SCREWS ,A STD.BRACKET DOR LOW NFDADROOM ;; N 2_TT-'Od g DOOR eB °T o 1 xOEM Calsmm M F/41 DOOR E=B.x 3-I/B'%.010` OPTIONAL VENTS OPIION4l ft11511 FACE L y A C O 3 7$ J 5•LADE AT 7'O.C.IAAO GRA51 06�N O 2 6'-�1 SECIDNJ le'1 5[GTAWS 1' MH(4)114 x O 4 SDS 0)PNC.AREA Nor TO EXCEID 1z0 so.N. -N Y-•• I EECION te• 1 661d2 41 /" YA%.DOOR IWOTH ¢ O 7r'e e sEc1•xs Iv- J CORER Sr. INSIDE ELEVATION DAB DODRS INC. rye - 10• B-'-�-L• OI719oE OND STYE RAISED PANEL EMBOSSED DOOR Ma She tt6�t2�%6�024HighT J Y SFEIIONs 1C Y EDOIIOxS YI HANDLE e'-)'i]eECJNNS 16 l SECOMs]I W(h<YPd-U1e O.U.. W,+SfG1oN Id'•SECIm+a]I t14 X 3/4•SEtF DRUM SMERS 1UY BE USED s_scglwrs zr- Loci Bw conEs !IN UOU OF 014 X 5/8'WS DESIGN PRESSURE RATING= +48,0 PSF K e• es¢cnoicid'- -520 PSF 4'-3 s sEcrm%s iC t smuN zt• A PbTAD.EO ON DID SIRE THIS PRODUCT IS RATED TOR LARGE M5511E(YPAGT Rik v-v 1 sErnoxs 1v z scOmrs 7I• Q wnll N)114 x 5/e•sNs N A NO c <9 i� 9 4'-•]6EOIIDNS 1e'] s 1 IDT X Xw LOCI'BAR L THE PRODUCT IIAS�EH DESIGNED At10 TESTED 70 COLDLY WITH 7NE R 1. S SEOMxS le'4 SELTpm 1' ENCODES N TRACK f5'AI.WtELilGs 6 TIS FLOROA BUEANO CWE Io•-,s•,uclux te•a scrno%s (FBc)IRTIT EaOox tW-e'9 sCCINN9 11'- ON EACH SIDE OF BOOR .CENTER STILES SCNLODLE'K INCl10GNG IxOI MEIAOR •�ZOIE DNIG} •; IG-0'•eFFTmNe 16 f SECOGN 31' _ ANCHORS SMALL BE AS LISTED•SPACED AS SHOWN ON DEWLS, OUTSIDE KFYED LOCK CDNTDt smES COa1CURARON 11 a SECRR6 18 Y ORIIOITS 4I DOOR ftm /Or cEnim surfs ANCHOR FOR STUCCO. TO BASE MATERIAL SMALL BE BEYOND WALL 11'-J•4 SEDIIDNS 19•J SCCIWS 3I S� ........ __ .._ ........ OI�SSOC OR SNCCO. II.— SEERM M'.Ls[RgNs fir" 15 W-O•TD o'-tp' z _ 7. ALL BOLTS HM AND WUNEAS SHALL BE MC PLATED CARBON STEEL. ..-.r..•............. LOCK 5AR IDL%NO SHOWN •• 11'-f Y J[CDOXS le'J ADTIW$11' 10-D"ID 11-10' 1 '- ` S AL1EAtMTE 70 4.ANCHOFhhI0 OR LOADWO COIDRIONB OTHER THAN 1HOSE SMOFM IN o. -- A f7 I SECIOXP'1C F YCORts 41 1r-0.10 1J'-IO• 5 `D, :OWNS SHOOED A®E BOLT I ' TIOSE DEUS ARE NOT PART Of TKIS APPRMFAL IKn- 14=J•Mail;ran 41- LOCKS SHOWN ABOVE B'--0'TO R'-tD' 14'-0•to t1-IC 4 5. A LEAD WROION NDRASE IS tM N DESICK OF N1==IRTO\OW ONLY. � _g•� R I-4•a IS JTLTIDIS YI• DOOR O'IOiH$ le'-1/'TO te'1' 6 , I I V 5 SFLRIpI,e te'IJ SECTUNIS 41 DOOR iESIEp N AIxWON7M Yell)111E Ta00W[YENIS-RDIe61 y. 1J' 4 e'4 sO.TIRTs]I _. -- _ -- M AB�5LDRG OD-lELS/ASTY EB;ID96-0]B9.t C TI$-M]TOR IA1C AND g T IS_J•]JEG4D1a Ir a JLCTIONS 41 9 - rip:UY ANWD ' i El IS-e'1 SEC11mIa IC/LOCfOIIi 11El I t 5[CImX le" T 5(CtUMJ YI 1{-0 TO 13-t0' Fit PE/ PRODUCTIIDDIWFiID B :1 9 5[mMls 11'- I_ 17-0 lD 11-10• I CAM.7 • 1e']Sdigx9 21' DOOR IN OTHS DOOR WN7H5 �4�•Be/•/k m Is•--4•-scclmNSl=e:=saTwRs:r REFER To saEr z ... tz-o•m II - - ITo ta•_z' 98-05 1r-4.4 s[COMs lr is stswxs a• • RUM u-BAR PLALEYExi ODOR vnml+s DOOR W101xs ----1 6 20 •N• o! fif ., le' J 6FCaNis le''e SECTIONS 21 rOR IS-S 2 SFCO0x5 le'1 6FGfONS 41' d IRg Ad. I-C t sLcmlT e• a st>:noxs xl 16' a S[XIpM]IC I SQXxN]41 I I I r Smnn. � scmou e � SttllaN J--- I I SA1gM' YRW 1 {,,� , a SEL•a0N DDDR ..xooa aJxaE sr•ro r-a• — .. .. __ �o ll)U-aN6 SCtmt] I sa1Mt J � M BYIION J li i 4fJWN. I a�EnRON DDOR a SECRDN DOOR a tmmr/wxa,Y-e•ro,r-r xxart wla,r-/•ro,5-0• �.}]n qg Es -- --- S SECl10H DDDR S SrCfIDN DDDR xa[]R t(3) Y-/•ro a•-o• tvLa M:¢rJ'1D r-r e € MI I uopx e i p� a { acrnox a I E z u 4[IIM a ]mNtt a a a i t m� g i JSEnM 1 i J Q N N 1:El1IXl J I aRaOa] t 't SfL,laa t SflaaM f xECIII RAIN[,P-Y ro 15-E• f0 u-aws a lYCtaxl[IDOR a sECT10N DDDR IIF10R M`N)E��.1P-Y MEF�)4a IP-a• A411m1 Ia o v D p g SUTOHa Vij,y��Y feflNa 1 - - aC.EtlJll 1 ei SC[IIJN a c N- r I• _ � ek+ J¢nnt a _ ; � •AitlN a __.._ Sm011 J �i � S I xzrou. ua J,rJo ufuJn ,� Q i NDDUI.T 4F7EYi1D 8 senor,t1�9 draaing xuo7 SLC„DN DDDR p U�O no. ,ao-c•m • ,o seeroN DDDR Y 98-05 Iax1a nvu n•-a• aneei?mi B cm u-nNEs I I I I i' i r • I I I. • 24 GA STEP,PAST. ...- �'I -� FLAS BENT PJER PAN¢ F O 1/2•PV"EO HOLES 1 r + 0 4'O.C. }`t R fQQ( gi 115E RENFORCFIG'U BAR a TOP SECTION ONLY AT I 8 li H q18GLx2-,4•%]/1'X]' roURSECImNDOORSFS0 110 STEEL PAR RFIE=FA TENED ,6 f,A T 2-1/4'%]/4•x NO BOITDY Of PAY¢MUSS FASTFNm ro , SiER 118Vt RFIXroRCwO 1RV55TRIFaS FASIROA ro VERTC.Q IMEIWFOATE SIRES __-___] LL _1 �1{z s/6'SITS AHD ro FIED 501E W/ThD/14 Y S/6"SAS.AND TO Elm STBE I W/iDUR 014 x 3/4•SELF DRnLNG S. W/FOUL/14 X]/4'SELF DRILLING SCR )�1 Q i/2'X 1-3/1'OP TUBE _ O• W 0,.&mu� ]/NI•POP RNEfs ' _ AT s•O.C. 1 ri_o i Q (5)FOR R 18 v. •SINFS GR, STEEEL fR1NFORC2IG TRUSS ,pl TRU.55 FA:IFNm'TO VFFOx+LL 6VIEPL20WE STAFS END SOLE �F iC3 14 X 5/a'SIA.S AND TO ENO SUE 14 X 3/4•EELS LR'Uw SCR. AQI'STL PANEL Yn'3 gq� 1ST SECDON fROTTOMI INTERMEDIATE SECTIONS TOP SECTIDN — OUTSIDE OF DOW �LL 03�P g RONFORCONG REINFOWNG 9 v OPTIONAL STOP YOULOREC mm BY OE10R wST4UER d 2 'Qp nD,•1 SITE¢TRALI(UEACI4T fASRNm � F TO WOOD JAVG WITH /14 X Sro'SNS ]4'X 2'%2-1/2'X PONE'STEEL 5/16'X 1-5/6'LAG SCREWCORRECT TO PANELS (FULLY 7MSAOm1 a PER NwGE FLAPS AND S()OR(6)3116'Ally AVETS REX WA51ffN HEAD TYPE/1 1/2-x,a/4•X A56•Fo161FO 51E¢ SEE DRAT 1801'E CFf1ID R DOOR NEWER OLU�ID PANEL Wm SmUim ro SOUTHERN O.eS S.C.I END STAE WITH(4)3/16•PoP�P/ M RF'SCH{AGE SECURRY FWtDWARE' .i •4 1CFIGFR S, /-SED 4N RNE�RD ,WpISF -�EDGE INSTATED 1N POSITIONED EYE LEVELCFMFA STILE o.x !v bMMW TO PANEL W/(4)]/16•RAM POP RIVETS II Yw. 1 14 X 5/6'SY.. :' '+i1 w 4/I6NGE A•'V'• Y Z4yQ _, .. :--• T - �_.... —..... 1 L 2. PER IwtTar B 1( -] I` ]ro•PDWTR-eou BY•INS' c i j 2 WN.EL BFD INTO CONC. e ti d 4 9 2•IG1L mGE OGT. R 4 1.7'x 2.18•x 13'X ADO' SEE SHEET]FOR BRACKET SPACING _ y STEEL TRACK BRACKETS SEE SITTER]PUl SPACING , UAL I M PE 70592 r�'T y 1 ]-1/2•X.OSD• 1/4-20 SS BOLT INTERIOR SIDE 7-1/2-x A71• NUr D GALV.STEEL Elm ROLLER TWICE H 0A X 2-1/B'x 1'SE(STkmVm)EL TRADK CENTER HwGE 1.ffi'DII�%SO'SITE¢BOLTERS(5T6 ,z GA x]-5/16•x 1-1/2•(DlmoxAU 7/e•P1axNur 1Az'Dw x so•xn.DH ROLERS(oPnaT4A) 3 0 2015 98-05 W/IA/S4-Em x750roiPA ry[ AVSS� wsrALLm ON ROLLER SNAFT 2.75'ON X 30'SIEFL RUIFAS(OPRWLV.)-'•. �+ SLOTTm YS a LOCK NUT 2.75'OLL Y.50'NttON ROLLERS(OPTIONAL) SECTI R-9 wRH 5•STET4 �?�!„ae�3.OE,6 I I � i I ofp 21'PN `q; fie " mAb�i ',-�hi Rig x: OPENINGGOO El.l. Re :� B3a � BI m 192 _ € o � s a,r� a2-2a-oe nX a Q_n 24 GA ROLL FOIe1D1 ro;0I 7; aw..a wM,_x Alo-----' I,r moi,vvn.a,ar.,,,•y—�Nnyrooarre*„ovN iwNNaom ncRe cN mn n6,':rcm.a l a o+uecn --H12IP1I9E5A HN-.W. --- L-OR AcuLe-oFsmARtsO a.O vrQto oCuOer R oE-PVOEw_RP_dTC A _O_N_ �a DB DOORS INC. sss&W.ev AVEaM, 9 TH.AVE.338GARDENS.-Fli0t - - -- -- -m=twsisa�euo - vAx uos7aazaa>'e 555-6624 G0.WLE\96-05M8, I \ J W GOW //�V2,xYD061FLL• DIST. la K 1• __ 6IFEL �IIK _ SE1F 1% 1 SCREWS OR le%1' `..Y 1-1/r MN. _ 3/16"M"STELE RW SS-\ SELF%=NG SCREWS OR E DIM. !� Na WLROeP N/A001RE• STEELW�L S YVLTIGWP W/004E HEAD, o58 � 1/2'%t-l/f'K A5e'' FORMED STEEL 6 1/4'OK IACr SOtDYS 1/T 00.IRO SCREWS 2WOOD AT a'fNOY ENDS M�pOp� AT a•FROM ENDS _ �' ♦" AND It'Ot RVX 1 AM 11.O.C.ENDS — 8 q�, MSI uA YPfER sum ADAPTER leiziW pOp{mil ORI 51ELL RI109E11 W'SwPnS, RUBDER VISiRWPNC Q to G Y� DFo LLz�Ei� I Ssf Ic -c BOTTOM SEAL OPTIONS OPDON'A' OPTION'B' WOOD BUCK CONNECTION TO WOOD SUBSTRATE(WOOD SPEC[M GRAYRY Sr-0.55 MIN.) D THE INSTALLATION METHS SHOWN ABOVE 91M 2Y6 SVP WDDD BUCK ATTACHMENT TO WOOD STRUCMTES,IT 7NESE METHODS NK FOLLOWED NO ADDITIONAL CALCULATIONS/DESIGN WILL BE REQUIRED FOR DESIGN OF GARAGE DOOR ANOIGR f FOR DOOR REPLACEMENT APPLICATIONS WITH NO ENGMEOR OF RECORIA INSTALLATION MAY BE -- SV4fd✓C ___ Z N VERIFIED AND APPROVED BY THE B1%DM OFFICAL UPON INSPECTION. _ _ StRI1C11%E fllBm SPACIAV SEDGE OIST. J a NlC SIFtVE BI"MGT� CONC. 1-1 f _a 2 I y m o T S/16'%1-6/d J CONREK BY FTDO f11IFD B1001 a J-J f RAG SCEWS STEEL STRUCTURE ITT OTHERS J OYNIBOLi BY 71V!' GOEIL' t-I z R p AT it'O.G MUST SUPPORT lIE LOADS DO'OSEO J e POUER-BO T 9Y P Nflb CGHG 8' 2' O z BY DOOR SYSTEM J a CONCRETE BY 0M150N LONG I1-I 2 6• r j m COFRAE7E 1'e JOOO PA I.R. j ma DLL BOARS C-90 GROUT To BLOCK Vm.20M PSI MIN. - YhM WASHER&NUT AT Tr D.C.MAX EDGE DST. WOOD BUCK CO ,51VIN TO MASONRY GROUTED TREATED 2116 SYP 6000 BLOCK WALL WHICH SHALL OL ANCHORED TO GROUTED REEODRCED YASOF80'[4IX%WALL M CONG COlU1RF WIN � 1/4'ULTRACON BE TiCO'WITH SPACM OF b it O.C.INTO GROUT fDLID BIDIX WALL,WDH 2-i/f•YN.EWER i-1 f'K 2-1 Y Ff GA _ o yy O 9'O.C.INTO JDDO PSI CONCRETE.WITH 1-J/f'NN.EMBED I-1/1' 1-1/2' GVN�si[EL tE 1-1/2' i y 2-In•WIN.EDGE DISTANCE g p F2 T B ACKE STEEL Q l�f'TAPPER BY'P0WTR5'WITH SPAONG OP i Fe'Y 2-1 MT BRACKETS IX LONG ]-1/e'K 1'Y tf CA 8 OG MID GROUT FILLED BLACK WALL WON 1-1/2'Ict EMBED I F411T BR D' AT 12.0.0.N DOOR OPFA. s 9.O,G INTO 3D00 P9 CONCRETE WITH ITT/f'MIN.Q18[0 AT IS'0.C.ABOVE GOON OPtIG FASIWDFm TO T PUlT9 N G �� J•MIL EDGE DISTANCE AT Ir O.C.MAX CONNECTED A CARE.OR O w (2 1/f-2DK5/p TRU55 H0. J/a'CONFIEK BY'ELOD D2 W/(J)SPOT WADS AT EACH SIDE S Y5.A IDCK N I _ . J/a•.0 B/'TRY WITH 5PACNNG Of �1�E_TB6SM CDNRNIAIIS ARCU TRACK o - 21'OO.ROE DODO P9 CONCRETE,WITH 2-1/2'MS.EMBED A WOOD Ruff 1RS4FL TO_C9arR2fE.ANO F%IfD BLOCK R tl _ J'IAK FDOE NSTANCE J/e•NIC SIEEYE BY Hxlr sum.SPA=CP ��{_ �o it C.Dj10G 0 0 PSLLCONBLOCKCRETE.ALL,WITH I IOFI.CAM B�P MN.EDGE DST. AITERWATE TPACK INSTALLATION 2-1/r MN.EDGE DISTANCE S PREPARATION OF JAMBS BY OTHERS fAx RODUCTRH&wm D 1 l7oKi FOR HER DONSTIMMON ENONEER OF RECORD OR ARCHITECT TO VERIFY RCAI�I. T9S� �wMWW ADEQUACY OF SUPFOXBIG SIRTICHIRE TO SUPPORT LOADS IMPOSED p FOR D�OOR�MEPWFIBRT N RETRWiT BUIBNGS WON NO ENGMQR OT RECORD.CON I/SM11Al1pN WY BE W.VEWED AND APPROVED BE C 1m BMILOIND OFTTCW.UPON R6PE . 0 2Ut5 Iti MAI0MIA1 EIOERRN%()LOAD PER.MMB-(I sAr K fa PSF)/2.3e5 LW pw n. 98-05.J MAOMUM NOAIOR(-)LOAD PER.41m (16.11'Y 70 PSF)/2 420.4 LbA p.FL ehael 5➢f,6 I • • r I i i I ! , i s • s PLASTIC COMPLIES WITH 1«++-250DOOR Y�v zU C P(m4)On WL CADENCE CHAPTER 26 OF 1 1 •F/IB'OK WKNER �� 'I� I u�. $� ( /B X J/�•SNJ 21 MAX0�I I O!/E'FROM ENM X pg AND T O.G YAX WDIf.WR11N J14 AOO 'I '�� >R EXTERIOR FRAEIF �1NTERN)R FRA4E �' µ)/e x!/�•srs IB 1/B' FOOD PVC ONE PIECE INJECTION RIGID PVC ONE PIECE WtJECDON � 0 1-0/e'FROM Qlp6 lU%• ._ BL^ ' AND 6-1/2'O.C.YFOL ' GROOVE A X R C�•. 11 t ...fi ' 1 II n ;+II lTe X.062 DEEP 111 .. I Ilil 1/A'Nu/IJ-0111.01 ;— ...._1 S •• t 9___ �� il•I POLIT.ARBONt1E IETAN 7 F •,., Intl 9Y'SABLE O1I10VA1NE PIASIOCS' (Y. }4Y[1 1J I S IJ n Ei n 2 G N iIII •—_- ___._- _---__---.--_ I�U] Q�T III illl ,y n n C• yi. .. �J m ; IA A ` J III • :III xn I GROOVE 62 DEEP . .._ .... �,% III, • � �s� 1`i! (4)le■_Jh'sus INSIDE ELEVATION @ III 0 1-J/e FRou ENDS RAISED PANEL EMBOSSED DOOR WITH OPTIONAL WINDOWS III AND O-t/2•D.c NAx. /e x JH• C WINDOW LITES CAN BE IN ANY LOCATION IN DOOR SECTION O s1Es O J/B'FROM ENDS 1 DEEP Mm a-1/2•as YAfL 73 MOVE 1 �^�< �9 r•-.1 �oa6$L9 /B X 3/1'SYS zl_ AND 2•o.a IOJL — -- -- Y _ NCAM. J92 DDDR F'MIFL ------- EXTERIOR —�.T',._N' :.a 6oxq s1m NN 0 2 015 DOOR PANE2. 1J/I6'wR py CPC. dlaaing n 24 fd;.L.ozq SRFL TOIL GU2OlG BOE _.__._. 98-0.5 WpDOW W sheet B o/16 i ?Florida Building Code Online Page 1 of 3 I Florida Deparnerltf BCIS Home I Log In ( User Registration Hot Topic Submit Surcharge Slats&Facts Publications FBC Staff BCIS Site Map Links Search Busines Professi � 47US'ER:roduct Approval Public User Regulation Product Approval Menu>Product or Application Search>Application List>Application Detail FL# FL17022-112 • "a3s` Application Type Revision Code Version 2014 Application Status Approved Comments Archived Product Manufacturer Extreme Metal Fabricators,LLC. Address/Phone/Email 2160 SW Poma Drive Palm City,FL 34990 (772)872-8034 tara@extrememetalfabricators.com I Authorized Signature James Buckner jimmy@cbuckinc.net Technical Representative Tara Faulkner Address/Phone/Email 2160 SW Poma Drive Palm City,FL 34990 (772)872-8034 tara@extrememetalfabricators.com i Quality Assurance Representative Address/Phone/Email Category Roofing Subcategory Metal Roofing Compliance Method Evaluation Report from a Florida Registered Architect or a Licensed Florida Professional Engineer Evaluation Report-Hardcopy Received I Florida Engineer or Architect Name who James L. Buckner, P.E.@ CBUCK,Inc. developed the Evaluation Report Florida License PE-31242 Quality Assurance Entity Keystone Certifications,Inc. Quality Assurance Contract Expiration Date 04/22/2024 Validated By Steven M.Urich,PE Validation Checklist-Hardcopy Received Certificate of Independence FL17022 R2 COI CertOfIndep.Ddf Referenced Standard and Year(of Standard) Standard Year TAS 125 2003 UL1897 2004 UL 580 2006 Equivalence of Product Standards i �I http://www.floridabuilding.org/pr/pr_app_dti.aspx?param=wGEVXQwtDgv2aB QpHpQQ... 11/5/2015 PAMDIk LL E. 8 7 OFF T A 1:1--,31MI T 2C 75n P 3 A42D03379 AF&0011105 [ f APPROVED REVISE&RESUBMIT ®APPROVED AS CORRECTED REJECTED This rvivi i;only for cen rah con;,ept of the j prcj-�ch and g3oorsl Ci ii 'cPG ' iffil the ip"armEtion given in the conir2ct CCGUiiiO:;:' {vrrEC!^!t". •r(:CFI vi l8 m2d,,on tins Shop draaYings during tl:i;r:1lc:'il�F�R1Ji rBilc;�2 fS19`.`nlFri<Civ�frCslil complianco wilih ire regLRre- , r.•i3 C('u i3i; ari �[.Gill iiDl a.�1!:p Y2i Cf a spocfflc itsm shall net IlC vue a 1;er Vfi3 6f m E'.v r.`.iy of which the fiem is a component.Con- t a!-r is ru,pona`i,i Din:ensie r io ha conf,�md and ccrreiated at the job sre;In o:nhat,'on Ghat psriains solely to tie fabrication processes or to the means,nrihads,techniques, sequances and procedures of construc- / ton:coon iination of the work of ail other trades:and for porforming all work in a safe and satsfaciory planner. DAIS: / i f �Oorida Building Code Online Page 1 of 3 I I I Bus iness + ' a i, i I onala 'f !' .... Ronda Departmentof BCIS Home Log In I User Registration I Hot Topics (Submit Surcharge Stats&Facts (Publications FBC Staff I BCIS Site Map (Unks Search Busines P USER: blu ser Approval Regulation EMCEE= Product Approval Menu>Product or Application Search>Apolication List>Application Detail 'I FL# FL17022-112 Application Type Revision Code Version 2014 Application Status Approved Comments Archived I Product Manufacturer Extreme Metal Fabricators,LLC. Address/Phone/Email 2160 SW Poma Drive Palm City,FL 34990 (772)872-8034 tara@extrememetalfabricators.com �I Authorized Signature James Buckner jimmy@cbuckinc.net Technical Representative Tara Faulkner Address/Phone/Email 2160 SW Poma Drive Palm City,FL 34990 (772)872-8034 tara@extrememetalfabricators.com I Quality Assurance Representative Address/Phone/Email I Category Roofing Subcategory Metal Roofing Compliance Method Evaluation Report from a Florida Registered Architect or a Licensed Florida Professional Engineer Evaluation Report-Hardcopy Received I Florida Engineer or Architect Name who James L.Buckner,P.E.@ CBUCK,Inc. developed the Evaluation Report Florida License PE-31242 Quality Assurance Entity Keystone Certifications,Inc. Quality Assurance Contract Expiration Date 04/22/2024 Validated By Steven M.Urich,PE Validation Checklist-Hardcopy Received Certificate of Independence FL17022 R2 COI CertOfIndep.pdf Referenced Standard and Year(of Standard) Standard Year TAS 125 2003 UL 1897 2004 UL 580 2006 Equivalence of Product Standards http://www.floridabuilding.org/pr/pr app_dtl.aspx?param=WGEVXQwtDgv2aBQpHP ... 11/5/2015 � I I � IL r,Florida Building Code Online Page 2 of 3', I Certified)By Sections from the Code i i Product Approval Method Method 1 Option D Date Submitted 07/02/2015 Date Validated 07/02/2015 Date Pending FBC Approval 07/09/2015 Date Approved 08/18/2015 Summary of Products FL# Model,Number or Name IlDescription 17022.1 (1)5-V Crimp 26 Gauge Steel,Lapped Roof Panel,Mechanically Attached to Wood Deck. Limits of Use Installation Instructions Approved for use In HVHZ:No FL17022 R2 II 1 5VCrimo 26oa WoodDeck EVALREPORT.Pdf Approved for use outside HVHZ:Yes Verified By:James L.Buckner,P.E.@ CBUCK,Inc.P.E.#31242 Impact Resistant:No Created by Independent Third Party:Yes Design Pressure:+N/A/-SOS Evaluation Reports Other:Refer to evaluation report for FL17022 R2 AE 1 5VCrimo 26oa WoodDeck EVALREPORT.odf conditions and limitations of use.Refer to Created by Independent Third Party:Yes manufacturer's installation instructions as a supplemental guide for attachment. 17022.2 (2)5-V Crimp 0.032"Aluminum,Lapped Roof Panel,Mechanically Attached to Wood Deck. Limits of Use Installation Instructions Approved for use in HVHZ:No FL17022 R2 I1 2 5VCrimo 032Alum WoodDeck EVALREPORT.odf Approved for use outside HVHZ:Yes Verified By:James L.Buckner,P.E. @ CBUCK,Inc.P.E.#31242 Impact Resistant:No Created by Independent Third Party:Yes Design Pressure:+N/A/-168.5 Evaluation Reports Other:Refer to evaluation report for FL17022 R2 AE 2 5VCrimo 032Alum WoodDeck EVALREPORT.odf conditions and limitations of use.Refer to Created by Independent Third Party:Yes manufacturer's installation instructions as a supplemental guide for attachment. 17022.3 (3)1.5"Mechanical Seam 2"Rib Height, 16"Wide,24 Gauge Steel Roof Panel Mechanically Attached to Wood Deck. Limits of Use Installation Instructions Approved for use in HVHZ:No FL17022 R2 II 3 1.5 Approved for use outside HVHZ:Yes MechSeam 24aa WoodDeck EVALREPORT.odf Impact Resistant:No Verified By:James L.Buckner,P.E.@ CBUCK,Inc.P.E.#31242 Design Pressure:+N/A/-191 Created by Independent Third Party:Yes Other:Refer to evaluation report for Evaluation Reports conditions and limitations of use.Refer to FL17022 R2 AE 3 1.5 manufacturer's installation instructions as a MechSeam 24aa WoodDeck EVALREPORT.odf supplemental guide for attachment. Created by Independent Third Party:Yes 17022.4 (4)1.5"Mechanical Seam 2"Rib Height, 16"Wide,0.032"Aluminum Roof Panel Mechanically Attached to Wood Deck. Limits of Use Installation Instructions Approved for use In HVHZ:No FL17022 R2 II 4 1.5 Approved for use outside HVHZ:Yes MechSeam 032Alum WoodDeck EVALREPORT.odf Impact Resistant:No Verified By:James L.Buckner,P.E.@ CBUCK,Inc.P.E.#31242 Design Pressure:+N/A/-191 Created by Independent Third Party:Yes Other:Refer to evaluation report for Evaluation Reports conditions and limitations of use.Refer to FL17022 R2 AE 4 1.5 manufacturer's installation instructions as a MechSeam 032Alum WoodDeck EVALREPORT.odf su plemental guide for attachment. Created by Independent Third Party:Yes 17022.5 (5)1"Nail Strip 1"Rib Height, 16"Wide,26 Gauge Steel Roof Panel Mechanically Attached to Wood Deck. Limits of Use Installation Instructions Approved for use In HVHZ:No FL17022 R2 II 5 1NailStrio 26aa WoodDeck EVALREPORT.odf Approved for use outside HVHZ:Yes Verified By:James L.Buckner,P.E.@ CBUCK,Inc.P.E.#31242 Impact Resistant:No Created by Independent Third Party:Yes Design Pressure:+N/A/-97.25 Evaluation Reports Other:Refer to evaluation report for FL17022 R2 AE 5 1NailStrio 26aa WoodDeck EVALREPORT.odf conditions and limitations of use.Refer to Created by Independent Third Party:Yes i http://www.floridabuild'mg.org/pr/pr app_dtl.aspx?param=wGEVXQwtDgv2aBQpHpQQ... 11/5/2015 - I I. I I } .�, lorida Building Code Online Page 3 of 3 I manufacturer's installation instructions as a supplemental guide for attachment. 17022.6 (6)1"Nail Strip 1"Rib Height,16"Wide,0.032"Aluminum Roof Panel Mecha11 nically Attached to Wood Deck. Limits of Use Installation Instructions Approved for use in HVHZ:No FL17022 R2 II 6 INailStrio 032Alum WoodDeck EVALREPORT Ddf App roved oved for use outside HVHZ:Yes Verified By:James L.Buckner,P.E.@ CBUCK,Inc.P.E.#31242 Impact Resistant:No Created by Independent Third Party:Yes Design I Pressure:+N/A/-78.5 Evaluation Reports Other:Refer to evaluation report for FL17022 R2 AE 6 1NailStriD 032Alum WoodDeck EVALREPORT od conditions and limitations of use.Refer to Created by Independent Third Party:Yes manufacturer's installation instructions as a supplemental guide for attachment. 17022.7 (7)1.5"Nail Strip 1.5"Rib Height, 19"Wide,26 Gauge Steel Roof Panel Mechanically Attached to Wood Deck. Limits of Use Installation Instructions Approved for use in HVHZ:No FL17022 R2 II 7 1.5NailStrio 26aa WoodDeck EVALREPORT Ddf Approved for use outside HVHZ:Yes Verified By:James L.Buckner,P.E.@ CBUCK,Inc.P.E.#31242 Impact Resistant:No Created by Independent Third Party:Yes Design Pressure:+N/A/-63.5 Evaluation Reports Other:Refer to evaluation report for FL17022 R2 AE 7 1.5NailStriD 26aa WoodDeck EVALREPORT.Ddf conditions and limitations of use.Refer to Created by Independent Third Party:Yes manufacturer's installation instructions as a supplemental guide for attachment. Back Next I it Contact us::1940 North Monroe Street.Tallahassee Fl-32399 Phone:850-487-1824 The State of Florida is an AA/EEO employer.Copyright 2007-2013 State of Florida.::Privacy Statement::Accessibility Statement::Refund Statement i Under Florida law,email addresses are public records.If you do not want your e-mail address released in response to a public-records request,do not send electronic mail to this entity.Instead,contact the office by phone or by traditional mall.If you have any questions,please contact 850.487.1395. 'Pursuant to Section 455.275(1),Florida Statutes,effective October 1,2012,licensees licensed under Chapter 455,F.S.must provide the Department with an email address if they have one.The emalls provided may be used for official communication with the licensee.However email addresses are public record.If you do not wish to supply a personal address,please provide the Department with an email address which can be made available to the public. To determine if you are a licensee under Chapter 455,F.S.,please click here. Product Approval Accepts: F %fCUYlt ASF.-rRtCS` , i i I I http://www.floridabuilding.org/pr/pr_app_dtl.aspx?param=wGEVXQwtDgv2aBQpHpQQ... 11/5/2015 I �, i I � Florida Building Code Online Pale 1 of G - I . I � - ♦ � i i . � f i �"d l� s Florida Qepanmentff BCIS Home I Log In User Registration (Hot Topics I Submit Surcharge I Stats&Facts I Publications I FBC Staff I BCIS Site Map I Links Search j Busines� �,',,])i 2,11dproduct Approval rofessiU USER:Public User Regulation Product Approval Menu>Product or Application Search>Application List>Application Detail y — , a FL# FL12334-R5 Application Type YP Revision Code Version 2014 Application Status Approved *Approved by DBPR.Approvals by DBPR shall be reviewed and ratified by the POC and/or the Commission if necessary. Comments Archived Product Manufacturer Therma-Tru Corporation Address/Phone/Email 118 Industrial Drive Edgerton,OH 43517 (419)298-1740 rickw@rwbldgconsultants.com I Authorized Signature Vivian Wright rickw@rwbldgconsultants.com Technical Representative Address/Phone/Email Quality Assurance Representative Address/Phone/Email Category Exterior Doors Subcategory 9 rY Swinging Exterior Door Assemblies Compliance Method Certification Mark or Listing Certification Agency National Accreditation&Management Institute Validated By Ryan 1.King,P.E. . i Validation Checklist-Hardcopy Received I i Referenced Standard and Year(of Standard) Standard Year ASTM D1929 1996 ASTM D2843 1999 i ASTM D635 2003 ASTM D638 1996 ASTM E1300 2004 ASTM E84 2000 ASTM G26 1995 TAS 201,202,203 1994 Equivalence of Product Standards Certified By Florida Licensed Professional Engineer or Architect FL12334 R5 Equiv of Standards Ddf https://floridabuilding.org/pr/pr_app_dtl.aspx?param=wGEVXQwtDgtF2AezuarjgKARgl... 9/30/201"5 a P&HPALL ED S FEET AMNITECTS9 P AA#003379 ARi0011105 APPROVED ®REVISE&RESUBMIT ®APPROVED AS CORRECTED ®REJECTED This revi©w I only for general conformance with the design concept of the pro; rt and general compliance wllh the information given in,the contract do;,urnsnts.Cortactiors or ccmrm?ents made on the shop drawings during Geis rep i v do nol mi;ave the conliactor from,compliance with the require- m&0 of ft plans and specihcaGans.Approval of a specific item small not incli,03 approv.i of an.assc�nbly of which the item is a component Con- trackc is responsible for:Dimensions to be conriffed and correlated at the job Elie;Information thst pertains solely to the fabrication processes or to the means,methods,techniques, sequences and procedures of construc- tion:cm diriatioi of the�vorlc of all other trades:and for parforming all woek in a safe and saWEctety manner. ' DATE: (Ja• BY: J ; r- I i I • i Y t I '�41. I7 " uildzng COnSi4 tarits IriG Consuldn�and Bn"enng Service far Ilia 8w7dtng Industry A.O Bax2;4tlYatanv F43SSSS Ptwree813k54.$!F7 kiuftda t3oar�fnf ttrorsriaiet Eafltaflpite oAufhor�ati P7a F8r3 Praduot Sub Category Manufacturer ProstueEtdam® +� 'o `` Phsmta Tru Corporation 31zwoth Star,Fttar Cta*ark Ctele haft i rnassta Crpft Ruelk F.xtertar' '$winging itatndustrtatgr,; F atteir�rIIaor itrargtass Ghlo Doorwmldotttee Y ••tX�tamtsitss grrtgriROtta3SfT Otctawfny - �k _ .-.. .. ono�'ti8 Seop® '- Tots to a Product EYffEuaon report rssued by f71N Build�ng'Cansuttants,inc and 4yndon F'SchMdS R E.(System ID# 18t18j for Themia Tm Corporation based;an Ruh Chapter No SM-3,•N{sttrod 1A of the Mate of Florida Product A�rprovat, Depar6mt of Buatrtezis 4 Pr»fessionat aeguta earl RtN Butidtng Conauitaitts and Lyndon t`.Schmidt,,P E do not have nor will acqu finandal Interbstin the:comoany- rn8i lufactutlrig ar distnputsnng,ttie pradPO nr in.any other entity tnvvatued in the apprmt process ofthe pratictct named tiorain 1 This product has been evacuated and is in csomptiance wrfh the 2aia Ftartda Buffing Cede(FBC}structural rqusretnenis rnctudng the F "tf tr vei flu ot}r rricane Zone"(HVH Seethe Ce[ttftcatiari Agency CertiRcate for s[ass;;spea$ tions and rtHngs' 2 Product artrhars shalt be as R�tedand spaced ag scion vn on i!e#ails Anchor etnt+edment to base.inatsnat shah ba bayand Wad dresshtg �- orifdc'a'o r $ When'used in tft9"tiVkt tots pr cud�tpprt"wfthlsid6pri 1626 of the Florida Buildsng Code and`daes not t {utra an impact reststant cavenng e Whenirsed ia'ateas outside of the"iilti#T"'raquirtng wand tsiirrie debris protection this prydttct campties with:section'180912 of the Ft3C and does not require an trriask restnrtt covering,This product treats missile level`p"anrt iricfudes tMmd Zane 4 as defirtarfi in • ASTM E1996'and Section 1fii}8,12 4 of d#9 FBC `; " . Far?it stud trarhmg constru..... anchonng of these units shall be the same r a U1,6t shown for 2x buck lln, iiryr constn,ciwn B Site cotuifdons-that deviate from`the details of ftwmg FL-12334 3 tequue further erx inaenrtg`aoatysss.try a licensed engineer or i registered arglrltect 7 Outs�virig 001), urmtion$using ttsrasttc�id Rein d/31 rneetrvater irtfrltcatlan;requiretnents ior"FtvHZ';:.: B Qutswing cantirjuratians'uStng ihreshatd items#1�a, 18 and'#37 da riot Inset"the waterinfiltratron requtrsrtleMs or the"tiVHZ'arrd shattEbe irtstailed only in non-t#ahitable areait oralabitte Locations protected by sn overhang or campy surds that;the angre tsetween:; fhs edge of canopy araverttag to silt is ass than 6'degrees 9 6es draw Fl�12334,3 for size and d 'r "pressure irmrtatier►s, �appoiiing tlocumetrts 1 � �+.,#�.gs Test Standard � Tt#adina!aRailt,+torn TEL tY19&a1a51 TASy2a1-84r02 94&,T�,B 2a3=94 Testing Evacuation Lati,fnc,�Lyndon F.Schmt,P.E ;t Orawtrsrt bra Preitased by '; Stetted fit Seated W No FL-12334 3:. RW BugCimg Gansuitants Inc (CA"al 3) Lyndon F Schrnldt'P:E Anchon RW Bumg t',ansuttsnts,Inc (CA98i3} Lyndon F 8oafed by atcutat7ona� . Schmidt P fw ASt to E i300-tf4 Glass toad t yndan F;Sctmsrd�f'E Ij a _ Lyndon F.Schmidt,P,.t,c Fi.PE Nn•z43i1'(t9� rY .... ....... C"fi ' 3tt2rXOt2 PF 1455 Sheet i of HLE ,I I .. � M t41 � .. 1 7$tNOt7b17gt�t.DR EOC6AfON y0}1+'F3517 113.75'tdAX.OAtiAKff £jt }�y� SMddTH STAR, hBER CUdkd, 7771 77511 lASVC GRAFT& ClASSiC�Ri4fT Rt9ST1C' � � � a�,�� FA18N�61 r--P��---t �ISF�GcasS� p uooR WtrN sl��cn :_ -r E OIfFSWING ,.� t ,�PtuCuclaKtpM40vn1rtChOf(takl4.tlni7kFaihypTpYpr�'A#thb9�:V10E4ftgGod� j -� _ .. IFdC�FIC1�a',glee.?R�IYdodi�'llietkbldEaid'1lMW 3oaddCet9S�a8at.+�{cYCedelol _- a .�L#b''PXatora andtafipi r - �� �: 2 imtLclmdfardrlOemisbQLM�xoAa�md�p0l2kwfmra�t�h�f9tJWt+a1M1'p`4rlc! ..@ . .Qkil>ahsr«dvxflt9esstr{C«lntaaa ..., & wM1s90jIT3FM1'F4'niROaC,�f�SM�3EC�I,,dld aiDiCt9G ONl d�wlgIR438a� Y , hipncttasUmrocava,r� - I b O t TH ,�� � tv�anu�hv+�vsc�7dsot♦nor;fht�rdzNtrgwbabQma est�Atfo+«86nm6�QV�eptnnksv�+ ' � � x � _ i ,. 5`efiaM1lBt/Ig,LFtra F$CtsN3do9tm7re¢Aia W,MFOCIrldiio+ISUh'thD.Tt�Msd�rttkteeht(Fsie. R - ,.�` i9tiNV«%Ik{dv,7hWMI«»kcteyifnitMEl4ibaWS?cM{t 1.b�Y12A0t.1M[SC. :- - .: � � .: . s ta2:s�,asars9er� �aapn.�nsnosea+rnauo�+rasaa.+r«2caxn y - � d �c«�n�iae�ombw�{r";,��oacststa�,a�,.aanescsx«�gm�y,a �, SemfeA«�p5b¢tbrrd�etpd«arypet .-. � " ,.. F Ou1rJMcontgvoConcv�gcnoii�fpgayFg9�n/9TP�l�Ot«MRfRaConrcq{#mtrnht«'InMP I""`— - -+1�--13'¢8si')�.�tt -}., 8- T7lwlWfpuakns+dnC'tem7At=9«�It9CCmkm§rtYie «h6�affiiiieq{Cee�guAt« _ g •MY+'tM6'adshdtastctNalaMfin�orvt�di�7nm+mrorat haMtm{�bcaoami±ol�Wod 5, _ .� aakamasesa�prot�,vbenme¢�«cnio{�r«a�Fonol�mbl�atnsu,ss: Verka �4 s 2 :g0aiu+$btl i S f. f verxpyc= , T` 3> haarPMel��i¢6 -.- n FO 6 % OY&tA1L ry�fCgGjvl7j ooa y �1 N stK6 ro.t:S 1:. . Oa+at dDlob .i 11 Fw1M I7(W+ak SIYtt70 F71{A(si -.. ._ - E- um aw& RL% t2 frttino % Y� � NECA7IV= w0.sr ,::Itt i 6• .- t9 an -LFS $! t oau>rabm �, tau otntvtao nsz€K»l> +5bC 53Q w R � s �1. 13d3L s ww «f y r { AT $ .ry 11 df zgy�n� f Y' lei 4 It i MOK : f �. •a ': �9._::. �' EXI92IOR GlV �:' 4i � � Jf ��� aicRa 2 u R g _ e -r r C9IUTAR CxAiS �" ..,,i@3FACf 3/aAwFatio f rnwlyx; onsvnae+lea�E¢ l 3 stu�txerwruro�: 19 305 A2kCa. .. Patel nl Z .V ( �S T _C,AECRSS —R ^',ate F.It7 � 1 i �. .a:aauc NO&53 SfOYJ74'9 _ ��wa5u�p� . v�rWr 3a Z © get ZMTNI K -r A V, ., 1 Xt7R9W bd1 ,:. 'sv/vowV YOU I to Mill Yvon, gm Iva f KO Itl1M top SAW, a z. ! � 77 AV TOO 7 C 5 f ^mot gap sit TWA too 5 rfcrt! v.; 4 sy7 .iannu :�. £. '. _'."PvW�MW9➢i't5d�—�_.i - j wt t S PIANO won 074 PMW j x..' .�lOTT lton _ .. .. .. _ .. i 5 1 i I . . .. 1, . : .. .. -. . m � . . . _.� p �:vfbeno_ wl L YYttl4id'�E _5�1 -u Y i�11109 _. atr: ' t+�absd� a¢. . so ar z m- , r .O ~"'x aootaoaoo r , _.. .E �+�� wwus i , Y f �- .. " 1 -`.- - .. p (1 : T a y xr ,* M '. a ' V V�Vt3fl . 1 Fs x ari-� r 1NE nan3ua tQ - - HalsmoyaI t .. � xa"i a t. � I - � .. -: 4Q t8'� l9 .:A s �. I! v g "1 ! ° >rF .. 1 }' ' no+ f„ s - �. -_ ,-. .. '. - ,. F .,, , „ .. t III `> - -7 a p° SY'' 1! a auane 011 SSOy�7Y llltbt i ik(4 rash,CA 5 f SS7': w,ro 3 _ h l g 86 9L 2 Imo o c� t I I "t3 ':� xvtv'vgSw I# tL ae , Y : , .;�,:��.; . :f...��LL I-I�.��,��..�..&.I L_;.�.. .:��.,:..��iLL I'--I"..I...",�I�,:I;:."-,'",I."L,CCr to t' ' . -1�.��7�1_--L-��,L I e*m,,�;;,�--L.--�',7 I.II�.I;�'ip,II.',-,,,��,.2"If.;�I�-I�q�;,-,.,�"'�'1-,..;'j,-,..I;;,I, 3 F o �l '" 2(OId61Nt E088iX� " r i ,1 4 tt !—srt "- , v. i .. - - > ;1Y t 4. s y 4t tJ t tl , ' Q=ie� ��:flL.%..,j���...II,I':.��,.-),�:'..,�-�L n,:....�.....�'':,"�;L,';L*�..,._I..��':L%I.1...LI I L...";r..;.,.V:C%i LL�L::.�;L�-K-,I-....�..��,�..-.,"L:..L,:� ",,4�.L,,.�I-:.,.,- Y- '� "', = a 6t �. YOI�BIN1. •..�LL.�,—j...........',:u:.,7.:,:'o�-'I..::....::��,�--lI�:".,.t-�'-.L,,�%,..:��:.:�L��;.�,.',�.IL.:��L-,,.��L'',,.::.,,.-�....��,I,LZ-:LI.,:,LI,_..:��..:--,.,,�CCL4�A:�,-�.�:':'.L,,'.L�'�,,!LL-,�.�;..II-;,.,:..,-.:i*:,"�I.)L...L.I'..LL.".,1..,,�'�.,I 0,.��-L.'.�,.-L;,,....,,�:�;-��",".�L'�a,."L��,"1�.....,,�.,.:,.I'".;:,I-�Z1-,'::�,i;I��.-�.;L.*,1�.--K:.L-."�:*I L-.,,:-�,L jp.L,,..:tL�',�,I...::,:." x 1� � u t t 2 d£t .. t `r ,. XVtfi9CtL 1 I I it ` 5 : 1 a sta pram .•. ,gam . . r s -.'t N "NOita34 fSOiS'IIC�f�Y3 ► > .�, ;; � -- _ '� .......... 8i vivo rrauaas'sso 3 (fi s 9� of or tu .r F ei taor err sspaa� t x: z r v �' �aM31Da � ttNJ31Xd 09 4S � 0�"A131.t3' 01 c \ r , it 7 r/ . itORAlX3 �a q 09 OS 09 OS a �- *411 ^' k0.14 a 8 F s ° . ♦ 0 bVMSTwo r "A,. AT A IA 08 31 UJ3SSSt7897 O L 'N s zoom -go' ns or as a°ten° curt t �. �woarihnuvas t i i 4 a i y t I ssonal urot.�as r � .5 ' Y lost On �° gt�1y1 ! 9 I . � I ;: 'rx . - E .,. r ;v E�. r a v d V. psi+ - g $j#n.f ; F1' 4 a2 .: • . # .--�,� �� ..- . . � .� s - I.:.:::,.,e ! .,,.�:::� :: ::� . .q .I.: � q..�F-q . � �.I%, . �� . . .� ... , ..- . -.....�:� . I I, .:.. I . .. . . .. .. . :5:� ;V,r-.. , ,�� �� . , , .. . . .,J.- 4..,. � ,- .: .. . I : -,;, - : - :::,: .,..e� .".. ...I : ��,,-,- ., . h gp :i :%�,, ::%. �: .-1*1 :. - :: ....f."� *: ..-��; ...:--,1. ... yy .. - ,;, : ,: I . ...I - .: .-. 4 .� �- p`3,-�.�I i ���I,,` ,::::. I q:: " -I..:f %I, ,,..�-.. . �-.- - - - . ,`�,,: . ",�. ;: � . 6 I -� �- � . I . :. :... -,, �.*.'.�,��:.,; t �4.�t, . .4 -� :; I A G .�.1 rE�.!,;,i�, �s {-.. ..-.:.A , - ., :., ��. ,,: �: �: I. I I .. .1. . .. � , ...... . % �—�� '.. � �*, -��, .:.. . i: ,�..- �..%...��, I. ... -.1- ;I ::, . ;�::,:.,%:;:, ,, - I , -I- �:::� � 1: ,- I .. .� . "I:,,,.� I:.. I . �� � :4 � .1 � �� ::� ,-".--;. z �..%. . `�{ . .�, , I . I� . -. � I... -1:�',".. .. . - ,. �,-- - -, . .: ,. � -..�:.- '. . I - ,�, - I � . - , c ,�.:.�.':19' � -. , :.. . .� -. .f�. I wre� : -...1 �I ,. � --"...-.......�-. ?� I I it x tl....... -, ' - 1%.: - . . , '�f��"' ��I, -, .. -,--.,��..4'.. II I�, . < I-P 1,,I'. --tl�*, �-0 �.- I -. .� . . �- — "F,I� �' ,�; -,--�,-�,, �r .�" .7 ..�.: .. , - ,�-- I � . :� . .. .�I'- .., . I ,,..,. Z..-� : .. . .. . ..11 .. ..�... , - . *** ..-I.-. I-:� �L.e�;-,T4� . . .1 .1, , - I ,-...,q��;; -, --,�, I..1 �. �,,��., -. u -�,-.,.�1,1.; ,-,-� �, . ,- , -- ,- I . I- d"I -,�., --�: �,,,,�,t,*, I. I:::- � . ..: - . -...�i I-I�' :� . . a C-,�,��I-..:v, ay ;,�- ,-- , , ,-;� lMFit OR . , :-', 1.�,�:,; - q� vw� .-�- � --.. �, Q� . . � "I . -. ., r "��,;";�,���4, `. ca a ' - ,;, , ��. 91!, , z� -, , @ �" --. . EXiFRPOR11" ltR � t[fRILSR � . :: E . ,�- . ,. iz r; 1 CRQSf SFG7lON \ ? vexncu c s �° :, Yore.p SECitoH 9 ro la - ,; f Y K1. f l L «' ' I tk,+,.,.a J11, 1. � Pi , .-Ma �fjTBtIQR c - �/�'�) c a \ k D tN1E&IOR e E7ti8t�R r rt e - '' 31 fir- % y -.._. J —:-. - .r Q w..¢ i'dmBs! � P s X : .� r 3-- ,-::�::�'; � Ki5 R/rCAICRUi . f ��ve rrK,reeaoss serrror� Y _ m f .a 9 O�7sWpca,` i , '�r t[uvrgn y . .. a %N y?, k e _,. '; __ S ., .. � K k . .' , ... .......... :.: .. . .- x,::r. „... :n. .,. r.:x,:... - - ... ,,.. _. -. ... fw x,:,::;F .. . ..;`. ... .r _ f r ::. .� .`�'�"— ' �:: -ii� I{ pp �- l�l Il. �ra.s R � III 3II �` '" :. rn III IIIIa: III i!( .. 1{ t. Y 3 v[PWffV 1Mi ... .. - 4C??� A[ ,I" li , _., . , - �,,.._.. ,. III x E �u« Ill :._ 111, - J, : - I : . I . ,: III !1I , ill :. 1{a .. - Z '. . 11 a, i�l pl _, - �-"',, - - .: (I .. (II yl'!""'I',", N�, °n 11. .... . 11 Ill ! Fm ;. . . . Ill I ;n b arxc�wu. ,..._ b_ , r. 1 eafereManehoss 6ama $ f 9 Waqua+.. dtfaegfxq�Fwmay"bo,v dyj$wf,.Ve WYoncem a�dcaftw,[staresftctl m«;n' ... 2�a1+�T4�R4febgrMcatkm arthrcaP,, mai'be tM toM'*-n ,Ir*4hf.ecge CW=j toe WCWt pk'ti ea.crvlpOao. - . . - mcau.I I..n? oireaerermwr;w .�reafoarorpaxI"pfteegaclam,caeoaonaw+++s:oda+ro�,arewfereta:: rt .assmoram oa« .me�avcor+ «error ceeeea, s 3<CatcreiemcAortrote: .. '..... ,...1:; uecxoa �ricxoii Aarx.. -' AUN.CtkvIRAHCE i0'•MiM ClEAtA--E ro':... 5 tree SIZE:; eraseutsexr M�sgxRr=nce ':�nt,�ear►aNerwr! +n a rs: F r.. I,r : _. N.r5: lriit 1lr i_1la.:: II=1!! !r an e», < rE{CO J!i' I.-Vir-.. . Y :*, ,. - <. . pwYr.o w tFs, c .. ._ I :.:a ..:.. - -..- .. - a1+ l I p E.. { I_ - 1j . .. .. .. .. ....;:z ..C"3 M.:.. - — ' II .. . „� 1. . .,,I,f'�-;-I..V"�6L,!-z I..�:.-.,�.!,�,.,..-�,",:::.,,,,—�I�,`,4,-,.::;.��:1�J--fi.--�-L1 I:-�.,,,�.,I,.�5:�-i!I'iI-,*,"I4.-g..�ti,-�:�* P ,.,m .. . :.,,.,��.:�"'��I,,7-.I�'l-�f�:i,.:,,,'",I,,:.1�"..�"��I..-',�.I,-i9�1,,i��—'I;:.�,�,-%,:I,1 A'':.I�:I-,:,��1',—....�,:11��,:;-,;.:.i:I,,l� '4-,�-"Q.,:.l"��.1.-1"� ,1:j�.��Il,:::9-�-,I1':.:.!.1.,,,"-i,.,��iI,�;:...--F',,--k,I�,.-�t:�9O7:c.-"1�..-. I.,:.-�,�..--.L"....,_1--.._-�,:�,����I,,..-�.-�--�--.-.:.�i1.:I�.-_,,,.�.-.�:�,:i-,-"I�-":.7--..�,.�...?1--....I.--,�-.-:...f-I.�-".::.",�1.I.,�:-L::.,�)L.,7-:.-A,.,z1.2,---�'...-''.�-.�:.��...�;'.��,,.:'.:I I:..:,:.....-�..-1.-�.':.q�1��.-?.-ff...I�L��...:'..�.-I-:,.�).----:.L��.L.,.'.:��;-�.-..,1,.,--,-.�.,-.::-1,.�."'I.'..-!.�,.-.��-,-:I�`-v,...L.,:��-.":�*',.....'���.-...z �,.-.,;,.�.L,,,-��..:'�L��..:.`�.':,�1.-.;":..,L If,--..l,�-L,L.�-I-,L����.:-7":.,l..,..-�,L1.L..,-�-,I,;,1-..'.,'..,,-.,ll..�;,�.�..i"I,,,..,:;��,�-,.1,l','-.*...-.,.�,.�:.1I 1--:�":....:f:.:�,1,.�.!.":..�'�l�..I-�,-.,I..:,.l.:�::..l'I�,��:-%�"'I�-�-'�,...':..j��,.-�-.f��,.:�..%I...�^.,,.�,.1.-:,�:�'.,�-..':..-:'"�:��,l..,.:.,gRj-�,,--'--�.,�--.-M,.4.::...-.;.- :v+;m 8 r•i + vy..e ,` ■ " wsa YY-mawl7 t!t,„IDt 4 illL X". * { :JUC OAit 4 -:,-.,,...i��.M'-1�..'-.:.Z-�:-I4-,.�-!..':-,�I-�-:..-1�w-.I��,1O.�I:I,�.1!`.1�..��...],..--�-1...'-1.-_.-;-1 L,.;I1,�-i,.��,....�1� ,-LL-]--�:..I":.��I,..��:I't''..1L-;�.,�.-L-��L..,:.,.,LL,-,.��I...lI��-..�1�I.-.�.:,:.-11:,-- .-�.,.1'.�I,".,,I..L,:�.-,,�.,,�,:-.;;.�-,�---^�!.L.�,�.�,.,II:�P.I1,�,l I,-�.-;-I� 3n",j,q—j•l�uodam.P"uWAi -4 six - a[: ,1M .1.411 oa>3 ,�. 7 S ift•L st/t 4 .,fll tw{g ,` '.. i Qt f_" .. itflH]NY1N3flYiOYJ 3'�{A4)o6 YW .tl131QC3AW3 3M a1jAL ti ' D137ku7dv 73 N,iV '. oot*, 37J'N,W ..yow YOH?MY 1{GN,7NY . 1 .- •4Ww+oyrm"""", LS - - •PaPa-mRtcQ,Wo -ONn No.Xft,p,,�go=o,t Te,i1nw s,gtry,» u _..:::,.. _: : "..: ,::. „.... -.. _ .-M.- . +bN!m`0.4of wwaa�un,sgs00N, prioa "wp Rs - ° 8 - °�'°�'�#•+o�sH4.'WNa,++oiD uwroo&.cWDRtwpale,' 2 .: .gg O <.: -^�...:... o M!a!gRP o^W/cv+, £C,no+ey�anv�mu. ow... t 5 � ,Auosoy,. Y a -. R"VIL_ -; , ruu a�Hur n aYnr siraa °lL"�s �J 1 _. ems --}s{-' I a n; 4 ,j w "I-P;.-.7"1.��,I�-kA:.�,:��.�-.,:".-.,F�,�,I�1,53,�;K,,�,1 fI...-I:,-,-,1;t..1.�,..�,,��.-�,�,�"%;-,'�-".-11"--,,.�Lm§�'-�.I-.-k,�,�.RfJ%X-,:I.-�. ,1 rIJ. Br40 Z: s � - .. ' $W. I e• a L[ 9-- dtl iW '... s gy . a srx - s ,�. E �•:I3RiN37i £ -i --.. - €�£rL, 71 V r j y ,-PPaiC I s�oeynw x - L, x sn + 3v .►rt a fls L .N�t dtft rwu aa�re tlY Ot ,s s t .3 s1 ► ilt Ot3 .rK h t 3 N r s z/t L .►��t Ht +u s, pl i YptnxY,w3'svro�'; .BAttNOSYtY 1N1F1a9era ,i' T,,.0 q Q13JNY,lY37�N1W Q173AYYY3J�.71if'� "MW %613NY 7S�H9NY ,� � -» .:. y, - qy.. : OoaWr4nsougptp.y348J1i0"7ctrNi.{ 8 arivxib,aD � 1bc4s [m g c.j T'N$7 : eQ +.E9J�9�✓ b�g000tro�xLO Ci9uuo.� 4P 'k . . $. :>, _ aw!boat'4cnnou,ar+ a�?o«tJtc[,Tt�tcn�'atu,cwpaaa ".. _.,. ; _ :y e9P�i' wuw.,mulnw+a�rn+w.Ysarpim'armnc� m +tata+£s+ z fl!,i 4RIY'119M6f1 j e d8813H71D1Y3N17ff - t11YYr[i)11YfS t t3LON3i5� 2• f 4 a Q `: . s I 11, ' ' i taua � a oi;� . ewer s a1t; YL i , , zt ' , r s & - - _ APB 2 X i �C - Lt �9 th3H d1t' `+%t18d0 , p ' a x Q ' Y { QL . 'jgf :o+ - -- -:� .. ,1 t II � �. t,. a71g - - a W L31tk�t�S* >.• ' � . -.:.+8 �.. I . I F i � ;; ._ .. -, .. - --... 7! fgy.1 I-.,".A:LI-m''.e'�,,I lIIi..,-.....A, ,,, 1. , .. :.. .. a "I I - : ' I cs2s �. ' ' Ir . C�--J t7' r u M�HitlOClt3iARIPLfrt �� 1 I V f ... s _ ""''g�iP• f X D 3 k Fv . �• ! �.S - 6 ' S5 rvr h p I:�'".�:.,.6.,�..1_-.-:.-"-��,-..��.�'I��.,I,-��..�..,,,�.-..,�.:,�...-���.-,...I.7�-.�.6 IL..,:�.-...—�1-�.L��_6.1,.;:.�;,I..---:I�:-:..�.'L'-... ® ;-��'-....1,,,-:L�-�7.,I�,-.:-:�-."-L;.�..-II,I Li�.._w.-'I,�1 f�,.:�'..,.-�:�,.,;—,.-O,..�:-:L'e":; �..'7 r,_.,,,,.W.-�.,�'.,.-,;.-- ��.,�.�-�'.�.-..�.%,','.L.-,,,.,-:.1�.,.�'.�I 1::.-..�I,L,..:I.%.�:..-�',C1�:,;.:L;,,'-I.-Z',L 4�:"",�;--...1.I.�...:1-,,,I."':.�.�-:,..:�:I�M-,:".1...-'�-.:.-U�::I 1 f�XLO'w.;.I-,I:.-.,I..L-:.L-,-�.a.-,�-'1�-.s..�,,I..�I-.,�::._,,-.R..".,-,...:�.�-.,.-:1�..",�-,, :I�,.�,--,_�,,�I��,..,,W-...IK,,,-.,.��;:%,.-E 4���.I,--`:".,I,��.'I,-l:�1.w..".:,_..1;,-I.:wM-:-1-.II,���-:.-W�l,..I�l,:...�',.�I::�-�,�.�,L1..�-.�:-,..��'.!:��:I...._,�.,-,A':..-..1�.,�,��:�L",j_I.._,,;_...:I:-.;�,", -g1vX f b ' - _ �I�4::��--. :...�I.,.%._.-"9,.,'-.''.�L,4.�--��,..'.%,L-,�'�6....-I�,,�.:,..-.:,I�,'.:.-:-�,:L 1:.���-I-0'I,_"�'.!..*-.-,.�I,1�,-M�-,.�,-,,"',";.,.�--"i-I,�,:-.I1���-LL'.,I I*I:",:;�f,.._.-�;1L�;",��.,���,..L:,-".',I�-�2.-.-.�,��L�-,j':,-,"1,,"i,,'"1,-,.,�I,"I:,,��..—�jL-1,-9 L.��III".I,;;IjL�%.�,��1-"-'I"--�-,.-I,.t�-,�---.,,,,6�.,�,,,,.".�.'''"..%-�:,'I,-.,.."6.-,,�"..:.L.;..6i1,-�,-.:;,:.��',�I,.,.,�.�,n7:1,1I I.�--�,�6_,-.-.-.�,II..'..-I,v��'I.,..,e�.�",:...-6,L.�L.I,�,:L....-��I-�.-':.",,,1 I,��,6��..,.[,,�.�";11 L��.��,.,.,":.:,-.�LI:".X-.I.--�-�.L...�1,.�-,,.-�,",.�:�..,,�'!�..��-I..,'::-:1,,-..��,I'..,:1.,.�I.-,Y,.�1....�-..��",I�''..-1--r1 t3::-.11-I-..�,....,wT-,1.I.'."..�L1�1,L",..::'-�e,,1%:-:,.�I-.-...:.":.1,.,..-�.;L�I."�.-.-..-LI L.-�;'�,,I�.,,-..:,.,-.L.I�'�'��!_...-;.�:.,�;-,1�m..—...,,�,..:.--I 44.."�.,I..,�..L%-�,,�I_.,;-�L-:,L�:�.�LL��:'—-,-.,..:.:_�',I.�--,'�0:::;,�,.,;.�.,;.�'-,-L..."..1'-:L..,II.,1:,—,:�:,I,%�,.�,�.,,1E..�6,",I.,;,I:�,,�',.��,M1%.d,11-rI..�.;',."�...r-',.�L"-. .--,�.,,...O.��Ir,..:1..�';:,A.-.�.:-.,.-I�.�-�1:.,�-."'�,.1,�.:.,�,,-.,.�,.,4.:-i,-.,....]-..-L�C 1�e,J..�,I:�.,%t�.I-,..-,.'1-I.$-:.,'�,-I,—.��,�,-I.�.,L:-:,�!,;�.I,,K-'--i.,L 1-.,:,�.�,..-�-�,"'1.--.��...,.�.7.:,,-�I�._.§.,,:."..-".:L-MsI.,p%.-7,.;_L",...:I,,,1,,.,6-:,.LI.:'-... .m�:..I;1L�,--�-�--,:L���L1,",,...:L���.�."�'-'': v N p Ln ia0)d D/',Ii.T a s ?2 ag I A tt,3PdMTwpiq" fbPt .N:iS f o.. ac ':JX x z' �',, - - - n•t er LFS a t 1 �i3.-t23.TfJ .V .i' ' _.,: :. :: .... � _ < t -- :. -: ..., ..:.,.: r. ..:: .:. -, .:.-:: .. ...,,:y ..,, ,- r _. . ti K "". ' NItOPAtt tS s DtiG6f f.{•' . A i%SUCKSGaaaSS ATERtAL HEiI AESCAlfiON r ';: !. -WOOD ':EA HSER'G1,RttDOOR PANFtW Rf@l 51 C 1f4".SHMSRACE=, - - F68t C1ASSIC DOORIIM ila'MUAMUMTHK,RSERRm h z r . D.'1 4'X2 PPFH 9.COORIIWCONCREiESCRRY ,:., ,,,:S'1a3. : IS<::MHGE SiSE . ,. .a...; `� •;:- �' .. E'; h1tiSOtIIti:=3;192 PSIMai.:CONCREIECONFORA�TOACt ::- :: '.'SS SODOA( .. � ` LVtfWOOD 4 .:�IORHOWWSI=COWORM21GIOASDAC9A CaHCR . F..mrx ia/4PHiAWLVNCREfESCRflYt. :- = -':lq.HSERGiA55 D00 PASBW ^' ,. _ �� COMP tWY/OOD�'I G:31CX31 CPFH CONGREtESfSt@At- ?STFEi. '61 C1ASS7C CRAFfO00R SqN 125'Mp�6MSIM iHK fiSESG1,ASS � gS' H•-1 4'x3.1 RPpiRWCON�tEPESCREW - '.SiFFi -62 tOPRAtI:,- _ CQMP ga J:.1 4'% IPFN BCO ORRWCONCREtF_a SiEZL , bq.M9KaE�Slx>; _ Wes - #- I I�':"IRSXX•112'PH1 W2S 'STEEik5 SOROMFA0. .. M'RIA%3'PFHWOODSCREN+ _ '.8T IOCKSRIE : -_SM '70 fl38tG1AtSDOORPA18wIS1EaREMK7RCEid&R CUS9CLx"[Rt7SRC p.� tYLtWOOD^ `� .I<1',E%T6RIDRuEFW1ME = , ".•:: ALUAi <,71-.Ct:+SS�CRAFt--AS DQCWMNJ14-mfl M IM HBERGtAM_2:MERIOR tAE - FtikA. '72 tOP RAIGs^ 3:;LAEFRAMETRLN .:: PYC ,: BOIFOM'RAL x rlax 1 1/2 Pt;i sCREw':. n esHCE'vaaDloCxsi¢e MEIxWtRSACHCOMP wFA&ER-mw . W000 I 5o Arr11 wisim Rsr�oRc 7trI a'..IONG RfACliCotMR65f6N1YPAtlfFR-STRW� -FOAM :et'S0.1flRg .57U'MS�IWWJJMM itIX.HSERGti455 _x 9 4X4H6iGF a2TifaC •:' SI SIItEAND16PRA0. ^f0 Ylax3/3'PFHWOWSCREw TOFRAA .=51fft. = -55 BRFfOM L' ._.. - W� .: �;: ':$ 1z elaxzPFHwaoD :siEEt " ou€sensDarEADAP y ,: W. �' SIL WIISUBS[RA ALU ,ST OUFSMANGSRiEi(IESPACat P'JC :a 5 IS; G51F4 itR3U%AI SRFAx01 A Al MP,.'SS' DfMtRIION RER7fORC6V8iiSG>=AFt.. gg :. ;, 14. FIF+WER=1M7550>=M2 '.,: ., _ fflXM;.,I.:,54 'k9X2.1M PFHWOODSCREw - WOOD: I:f S ]A,UDEJFMBSGS,.O.t1 -, ,.,:'. . .- 'wooD .. 1,1 `'}gt 71:3F:c7WT-70NGUEMW.hPOFITiOC.iSEi:A NOPP :u ;a, ,y, % < 25:tAUIhPDfNF5i17XEP1AR.,_;::• ssm SiEa -- A! COMP.: :. `s31-COASTACOUTSWRlGT16kSNOtO -� :•; - .,, , < ^" ,. ` ' 32 eorroMawm* as.71sx/ c a [ %37`:TfStES1t0[b Ott15WU1G AL,:: h—'296 -+ P a n d 3 y. .: `.AS'SDAOM RAIL F ..COMP .. ,: >., .. .jr s , < TOAMCORE - y: A:" tOCx SRt&: Y AVOOD F' f "�S'iOP :r- 11 , . DOOR- ASSS AMNUAum iHKASERGtASS 215 -.. S8T S COMP 1 HSERGVS3 .-.. g6 :g I .'' :. rrcz N.i:09 4 S^ 7'7 j i ;1 �`� ..'• i 77 .. U C+UfSiywO7MtE4iIXb Jt�: "0 rtnyataTltdtFfOtO FI�J1331.3 $ .&4 .eammna7e�aha.::� - ..� .. .I L- " d . .... - :.. . .: ti 1 . .. :. .. - - _I I e l� Y 505 Deer Ridge Lane Ararat,VA 24053 LD RC Deer Ridge Consulting, Inc. office:276-755-9162 Fax 866-441-1054 www.deer-ridge-consulting.com Code Compliance Research Report I Subject: SES Foam 0.5 lb Spray Spray-Applied Polyurethane Foam Insulation System r Supplement to ESR-3375 • Alternative Assemblies using TPRz F10E Coating Recognized Maximum Thickness behind Prescriptive Thermal Barrier Date: April 17, 2013 I, Materials: SES Foam 0.5 lb Spray Test Standards: 1. ASTM E 84 Test for Surface Burning Characteristics of Building Materials 2. NFPA 286 Standard Methods of Fire Tests for Evaluating Contribution of Wall and Ceiling Interior Finish to Room Fire Growth Purpose and Scope: Since the issuance ofESR-3375 by ICC Evaluation Service,two situations have occurred with affect the interpretation of that report. Namely: 1. SES Foam has conducted additional testing of the SES Foam 0.5 lb Spray(also identified under the trademark"Sucraseal") with the intumescent coating TPRz F 1 OE for use as an alternate assembly to the use of a thermal barrier; and 2. Revisions to AC 377 (Acceptance Criteria for Spray-Applied Foam Plastic Insulation) promulgated in November 2012 have changed the requirements for the recognition of maximum thickness limitations when spray-applied foam plastic insulation is covered with a prescriptive thermal barrier. The intent ofthis Supplement to ESR-3375 is to provide guidance onthe interpretation of that report in view of the above changes. Summary: 1. Based on the test data submitted and the reference documents, the thermal barrier required by IBC Section 2603 and/or IRC Section R316 may be omitted when: • The thickness of SES Foam 0.5 lb Spray does not exceed 11.5 inches in walls and/or ceilings, and • The SES Foam 0.5 lb Spray is coated with a minimum of 14 dry mils(application rate of 80 ftz/gal) of TPRz F10E intumescent coating. I 0� 9 � - 0 r Deer Ridge Consulting,Inc. Page 2 of 4 2. Based on AC 377(November 2012)Section 3.2.2.3,and the ASTM E84 testing summarized in ESR-3375,the installed thickness of SES Foam 0.5 lb Spray is not limited when separated from the interior by a prescriptive thermal barrier (i.e., 1/2-inch [minimum] gypsum wallboard). Discussion: ir 1. Alternative Assembly:In IBC Section 2603.10(Special approval)and IRC Section R316.6 (Specific approval),the building code permits alternate assemblies to the use of the required thermal barrier when tested in accordance with specific tests. One such test is NFPA 286 (Standard Methods of Fire Tests for Evaluating Contribution of Wall and Ceiling Interior Finish to Room Fire Growth)when used in combination with the acceptance criteria of IBC Section 803.1.2.1 or IRC Section R302.9.4.(NFPA 286 does not provide its own acceptance criteria,hence this is specifically defined within the building codes.) SES Foam 0.5 lb Spray was tested in accordance with NFPA 286 with results reported in QAI Laboratories Test Report No. TJ0934, March 12, 2013 wherein the spray foam was coated with the intumescent coating TPR2 F10E. The test result successfully passed the acceptance criteria as defined in the IBC and IRC. thermal barrier as required in IBC Section 2603 and/or IRC Section 316 may Therefore,the q Y � be omitted provided the following limitations are observed: • The maximum thickness SES Foam 0.5 lb Spray in wall and ceiling assemblies is limited to 11.5 inches. • The SES Foam 0.5 lb Spray is coated with 14 mils minimum dry film thickness (application rate of 80 ft2 per gallon) of TPRZ F10E intumescent coating. 2. Maximum thickness:The maximum thickness that can be tested in accordance with ASTM E 84 is four (4) inches. For thicknesses greater than four inches, the IBC (Section 2603.3, Exception 4) and the IRC (R316.3, Exception) provide for testing greater thicknesses in accordance with the Special Approval and Specific Approval sections, respectively. Traditionally,small room corner tests(such as NFPA 286)were employed to test thicknesses greater than 4 inches, with the spray foam covered with a prescriptive thermal barrier (i.e., 1/2-inch gypsum wallboard). However, after reviewing voluminous small room corner test results, ICC-ES staff recommended and the ICC-ES board approved a modification to AC 377 wherein this test protocol may be omitted.Under this provision,the maximum thickness of the spray foam is not limited. The limitations placed on this provision reflect the data that ICC-ES reviewed,namely: • The spray foam product must have passed ASTM E84 testing at a thickness of four (4) inches with maximum flame spread and smoke developed results of 25 and 450 respectively. • The spray foam product must be separated from the building interior by a prescriptive thermal barrier (1/2-inch [min.] gypsum wallboard is the only prescriptive thermal I barrier listed in the building code). The provisions described above are within AC 377, Section 3.2.2.3 (November 2012). 505 Dee'r Ridge Lane Ararat,VA 24053 276-755-9162 www.deer-ridge-consulting.com i I II I Deer Ridge Consulting,Inc. Page 3 of 4 • SES Foam 0.5 lb Spray has been tested in accordance with ASTM E84 with flame spread of less than 25 and smoke developed of less than 450. Therefore, SES Foam 0.5 lb Spray falls within the provisions of AC 377, Section 3.2.2.3 and may be installed at any thickness provided it is covered with a prescriptive thermal barrier. Conclusions: 1 I� ? SES Foam'/z lb Spray foam plastic insulation meets the requirements and intent of the IBC and IRC as specified and as limited in the Summary section above. Respectfully submitted, Deer Ridge Consulting, Inc. i Roger V. Morrison, PE, RRC President I i i I 505 Deal r Ridge Lane Ararat,VA 24053 276-755-9162 www.deer-ridge-consulting.com I . I i r 44 Deer Ridge Consulting,Inc. Page 4 of 4 Reference Documents: 1. 2009 and 2012 International Building Code: Sections 803.1.2.1; 2603. 2. 2009 and 20'!12 International Residential Code: Sections R302.9.4; R316. 3. QAI Laboratories Test Report No. TJ0934, March 12, 2013 (NFPA 286). 4. Acceptance Criteria1377,November 2012. I I i 505 Deer Ridge Lane Ararat,VA 24053 276-755-9162 www.deer-ridge-consulting.com 505 Deer Ridge Lane Ararat,VA 24053 LDR C Deer Ridge Consulting, Inc. office:276-755-9162 Fax:866-441-1054 www.deer-ridge-consulting.com Code Compliance Research Report Subject: SES Foam 1/2 lb Spray Spray-Applied Polyurethane Foam Insulation System Date: July 29, 2011 Materials: SES Foam 1/2 lb Spray Test Standards: 1. ASTM E 84 Test for Surface Burning Characteristics of Building Materials 2. NFPA 286 Standard Methods of Fire Tests for Evaluating Contribution of Wall and Ceiling Interior Finish to Room Fire Growth 3. NFPA 286 as modified in AC 377, Appendix X Summary: 1. Based on the test data submitted and the reference documents, SES Foam %lb Spray spray polyurethane foam at a maximum thickness of 11.5 inches in walls and/or ceilings,covered with an approved or equivalent thermal barrier meets the requirements for use under 2006 IBC, 2006 IRC,2009 IBC and 2009 IRC. 2. Based on the test data submitted and the reference documents, SES Foam %2 lb Spray spray polyurethane foam at a maximum thickness of 11.5 inches may be applied to all geometric construction planes in attics and crawl spaces without the prescribed protection from ignition as required in 2009 IBC Section 2603.4.1.6 or 2009 IRC Sections R316.5.3 and R316.5.4 provided the following limitations are followed: 1) Entry to the attic or crawl spaces is only to service utilities and no storage is permitted. 2) There are no interconnected attic or crawl space areas. 3) Air in the attic or crawl space is not circulated to other parts of the building. 4) Attic ventilation is provided when required by IBC Section 1203.2 or IRC Section R806, except when air-impermeable insulation is permitted in unvented attics in accordance with Section R806.4 of IRC, Under-floor (crawl space) ventilation is provided when required by IBC Section 1203.3 or IRC Section R408.1, as applicable. 5) Combustion air is provided in accordance with Sections 701 and 703 2006 IMC)and Section 701 (2009 IMC). 3. Based on the test data submitted and the reference documents, SES Foam%2 lb Spray spray polyurethane at a maximum thickness of 3.25 inches would not need to be covered with a thermal barrier when applied to sill plates and headers in accordance with 2009 IRC Section R316.5.11. nn � J J���� t,7 colL--� ; r Deer Ridge Consulting,Inc. Page 2 of 4 Labeling Requirements: A- and B-components for SES Foam 1/2 lb Spray insulation must be identified with the manufacturer's name(SES Foam,LLC),address and telephone number;the name of the insulation product SES Foam%2 lb Spray);the flame spread and smoke developed indices;and the name of the third-party inspection agency. Discussion: l. Surface burning characteristics:The 2009 IBC and IRC(and earlier editions)require that r unless otherwise allowed, foam plastic must be tested in accordance with ASTM E 84 as i having a flame spread index of not more than 75 and a smoke-developed index of not more than 450. Intertek Test Reports 100432887SAT-003A(June 28,2011)and 100432887SAT-003B(June 28,2011) report the following at a thickness of four(4) inches in accordance with ASTM E 84: Flame Spread Index 5 Smoke Developed Index 450 Therefore, SES Foam %2 lb Spray insulation meets the surface burning characteristics as stipulated in the IBC and IRC. 2. Maximum thickness:The maximum thickness that can be tested in accordance with ASTM E 84 is four(4) inches. For thicknesses greater than four inches,the IBC (Section 2603.3, Exception 4) and the IRC (R316.3, Exception) provide for testing greater thicknesses in accordance with the Special Approval and Specific Approval sections, respectively. To this end, SES Foam %2 lb Spray has been tested in accordance with NFPA 286 and reported in Intertek Test Report No. 100432887SAT-001,June 28, 2011.The foam plastic was tested covered with 1/2-inch gypsum wall board (an approved thermal barrier) at a thickness of 11.5 inches in the walls and ceiling.The test assembly met the pass/fail criteria of IBC Section 803 (IRC has a similar pass/fail criteria but the IBC criteria is more stringent). Therefore, SES Foam %2 lb Spray insulation meets the IBC Special Approval and the IRC Specific Approval sections for application thicknesses up to 11.5 inches when covered with an approved thermal barrier or an approved equivalent thermal barrier. 3. Use in attics and crawl spaces: Both the IBC and IRC provide exceptions to the thermal barrier requirement for the use of foam plastic insulation in certain attics and crawl spaces. Specifically,both model building codes provide for protecting the foam plastic from ignition through the use of coverings described as prescriptive ignition barriers (2009 IBC Section 2603.4.1.6 or 2009 IRC Sections R316.5.3 and R316.5.4). 505 Deer Ridge Lane • Ararat,VA 24053 • 276-755-9162 • www.deer-ridge-consulting.com i I i