HomeMy WebLinkAboutAPPROVED 16' NOA 3644MIAMI•DADE MIA.MI-DADE COUNTY
s PRODUCT CONTROL SECTION
11805 SW 26 Street, Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES (RER) Miami, Florida 33175-2474
BOARD AND CODE ADMINISTRATION DIVISION T (786) 315-2590 F (786) 315-2599
NOTICE OF ACCEPTANCE (NOA) www.miamidade.gov/economy
DAB Door Company, Inc.
12195 NW 98' Avenue
Hialeah Gardens, FL 33018
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction materials. The
documentation submitted has been reviewed and accepted by Miami -Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction (AHJ).
This NOA shall not be valid after the expiration date stated below. The Miami -Dade County Product Control Section (In
Miami Dade County) and/or the AHJ (in areas other than Miami Dade County) reserve the right to have this product or
material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, the
manufacturer will incur the expense of such testing and the AHJ may immediately revoke, modify, or suspend the use of
such product or material within their jurisdiction. RER reserves the right to revoke this acceptance, if it is determined
by Miami -Dade County Product Control Section that this product or material fails to meet the requirements of the
applicable building code.
This product is approved as described herein and has been designed to comply with the Florida Building Code, including
the High Velocity Hurricane Zone.
DESCRIPTION: Hurricane Master® Model 824/811 Steel Sectional Garage Door 16'-2" Wide with
Window Lite Option (DP +36.0, -44.0 PSF)
APPROVAL DOCUMENT: Drawing No. 02-21, titled "24 GA. Roll Formed Steel Sectional Garage
Door", dated 09/10/2002, with revision L dated 10/03/2017, sheets 1 through 5 of 5, prepared by Al-Farooq
Corporation, signed and sealed by Javad Ahmad, P.E., bearing the Miami -Dade County Product Control
renewal stamp with the Notice of Acceptance number and expiration date by the Miami -Dade County
Product Control Section.
MISSILE IMPACT RATING: Large and Small Missile Impact Resistant
LABELING: A permanent label with the manufacturer's name or logo, manufacturing address, model/series
number, the positive and negative design pressure rating, indicate impact rated if applicable, installation
instruction drawing reference number, approval number (NOA), the applicable test standards, and the
statement reading `Miami -Dade County Product Control Approved' is to be located on the door's side track,
bottom angle, or inner surface of a panel.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials, use, and/or manufacture of the product or process. Misuse of this NOA as an endorsement of any product, for
sales, advertising or any other purposes shall automatically terminate this NOA. Failure to comply with any section of
this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami -Dade County, Florida, and followed by. the
expiration date may be displayed in advertising literature. If any portion of the NOA is displayed, then it shall be done
in its entirety.
INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official.
This NOA renews NOA #17-1018.12 and consists of this page 1 and evidence pages E-1, E-2 and E-3, as
well as approval document mentioned above.
The submitted documentation was reviewed by Carlos M. Utrera, P.E.
NOA No. 20-0107.06
Expiration Date: July 21, 2025
Approval Date: March 5, 2020
7 Page 1
DAB Door Company, Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
1. Evidence submitted under previous NOA's
A. DRAWINGS "Submitted under NOA # 17-1018.12"
1. Drawing No. 02-21, titled "24 GA. Roll Formed Steel Sectional Garage Door", dated
09/10/2002, with last revision K dated 03/09/2015, sheets 1 through 5 of 5, prepared by Al-
Farooq Corporation, signed and sealed by Javad Ahmad, P.E.
B. TESTS "Submitted under NOA # 11-0414.12"
1. Test Report on Uniform Static Air Pressure Test, Loading and Forced Entry Test per FBC,
TAS 202-94, of "DAB 824 Sectional Residential Garage Door" prepared by Hurricane
Engineering & Testing Inc., Report No. HETI-07-4200, dated 05/02/2007, signed and sealed
by Candido F. Font, P.E.
2. Test Report on Large Missile Impact Test per FBC, TAS 201-94 and Cyclic Wind Pressure
Test per FBC, TAS 203-94, of "DAB 824 Sectional Residential Garage Door", prepared by
Hurricane Engineering & Testing Inc., Report No. HETI-11-3204, dated 01/20/2011, signed
and sealed by Candido F. Font, P.E.
3. Test Report on Tensile Test per ASTM E8-08 of "Sectional Residential Door (skin)", prepared
by Hurricane Engineering & Testing Inc, Report No. HETI-11-T100, dated 01/21/2011,
signed and sealed by Candido F. Font, P.E.
"Submitted under NOA # 05-0228.02"
4. Test Report on Large Missile Impact Test and Cyclic Wind Pressure Test, of "Sectional
Residential Door with Windows", prepared by Hurricane Engineering & Testing Inc., Report
No. HETI 03-1328, dated 07/15/2003, signed and sealed by Rafael E. Droz-Seda, P.E.
5. Test Report on Uniform Static Air Pressure Test, of "Sectional Residential Door" prepared by
Hurricane Engineering & Testing Inc., Report No. HETI 03-1329, dated 07/15/2003, signed
and sealed by Rafael E. Droz-Seda, P.E.
6. Test Report on Tensile Test per ASTM E-8 of "Sectional Residential Door (skin)", prepared
by Hurricane Engineering & Testing Inc, Report No. HETI 03-T078, dated 10/31 /2003,
signed and sealed by Rafael E. Droz-Seda, P.E.
"Submitted under NOA # 03-0210.04"
7. Test report on Salt Spray (Corrosion) Test per ASTM B 117 of a painted G-40 steel panels,
prepared by Celotex Corporation, Test Report No. 258592, dated 08/17/1998, signed by W. A.
Jackson, P.E.
C. CALCULATIONS "Submitted under NOA # 14-0814.10"
1. Anchor verification calculations prepared by Al-Farooq Corporation, dated 09/22/2014 and
07/24/2014, signed and sealed by Javad Ahmad, P.E.
�ez`,7 202�
Carlos M. Utrera, P.E.
Product Control Examiner
NOA No. 20-0107.06
Expiration Date: July 21, 2025
Approval Date: March 5, 2020
E-1
DAB Door Company, Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
C. CALCULATIONS (Cont)
"Submitted under NOA # 11-0414.12"
2. Anchor verification calculations prepared by Al-Farooq Corporation, complying with F.B.0
2007, dated 04/07/2011, signed and sealed by Javad Ahmad, P.E.
3. Anchor verification calculations prepared by AI-Farooq Corporation, complying with F.B.0
2007, dated 12/19/2008, signed and sealed by Humayoun Farooq, P.E.
"Submitted under NOA # 09-0128.02"
D. QUALITY ASSURANCE
1. Miami -Dade Department of Regulatory and Economic Resources (RER)
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 13-0717.01, issued to SABIC Innovative Plastics, for their
Lexan Sheet Products, approved on 11/28/2013 and expiring on 07/17/2018.
2. Notice of Acceptance No. 14-0311.08, issued to Insulfoam, LLC, for their
Insulfoam Expanded Polystyrene Insulation, approved on 08/14/2014 and expiring on
11/29/2017.
3. Notice of Acceptance No. 11-0926.07, issued to Dyplast Products, LLC, for their Expanded
Polystyrene Block Type Insulation, approved on 11/10/2011 and expiring on 01/11/2017.
4. Notice of Acceptance No.11-0926.06, issued to Dyplast Products, LLC, for their
Dyplast ISO -CI Polyisocyanurate Insulation, approved on 11/10/2011 and expiring on
01/11/2017.
5. Notice of Acceptance No. 10-1129.04, issued to Cellofoam North America Inc, for their
Expanded Polystyrene Block Insulation, approved on 02/24/2011 and expiring on 02/24/2016.
"Submitted under NOA # 05-0228. 02"
6. Test Report on Accelerated Weathering Using Xenon Are Light Apparatus Test per
ASTM G 15 5 of "PVC Extrusion Material", prepared by Hurricane Engineering &
Testing, Inc., Report No. BETI 04-A002, dated 09/27/2004, signed and sealed by Rafael E.
Droz-Seda, P.E.
7. Test Reports on Tensile Test per ASTM D638 of "PVC Extrusion Material", prepared by
Hurricane Engineering & Testing Inc., Report No. HETI 04-T251, dated 11/29/2004 signed
and sealed by I. Ghia, P.E.
8. Test Report on Self -Ignition Temperature Test, Rate of Burn Test and Smoke Density
Test of "REHAU non -foam PVC extrusion material", prepared by ETC Laboratories,
Report No. 04-761-15019.0, dated 05/06/2004, signed and sealed by J. L. Doldan, P.E.
F. STATEMENTS "Submitted under NOA # 14-0814.10"
1. Statement letter of code conformance to the 51 edition (2014) FBC and no financial interest
issued by Al-Farooq Corporation, dated 05/13/2014, signed and sealed by Javad Ahmad, P.E.
�d2/27/2D'Ld
Carlos M. Utrera, P.E.
Product Control Examiner
NOA No. 20-0107.06
Expiration Date: July 21, 2025
Approval Date: March 5, 2020
E-2
DAB Door Company, Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUB
2. New evidence submitted.
A. DRAWINGS "Submitted under NOA #17-1018.12"
1. Drawing No. 02-21, titled "24 GA. Roll Formed Steel Sectional Garage Door", dated
09/10/2002, with revision L dated 10/03/2017, sheets 1 through 5 of 5, prepared by Al-
Farooq Corporation, signed and sealed by Javad Ahmad, P.E.
B. CALCULATIONS
1. None.
C. QUALITY ASSURANCE
1. Miami Dade Department of Regulatory and Economic Resources (RER).
D. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 17-0221.06, issued to Insulfoam, LLC, for their Insulfoam
Expanded Polystyrene Insulation, expiring on 11/29/2022.
2. Notice of Acceptance No. 16-1108.04, issued to Dyplast Products, LLC, for their
Dyplast ISO -CI Polyisocyanurate Insulation, expiring on 01/11/2022.
3. Notice of Acceptance No. 15-1203.04, issued to Cellofoam North America Inc, for
their Expanded Polystyrene Block Insulation, expiring on 02/24/2021.
4. Notice of Acceptance No. 15-0915.08, issued to SABIC Innovative Plastics, for their Lexan
Sheet Products, expiring on 07/17/2018.
E. STATEMENTS
1. Statement letter of code conformance to the 6"' edition (2017) FBC, prepared by Al
Farooq Corporation, dated 12/23/2019, signed and sealed by Javad Ahmad, P.E.
F. OTHER
1. This NOA renews NOA 917-1018.12.
j0111�
?�Za26
Carlos M. Utrera, P.E.
Product Control Examiner
NOA No. 20-0107.06
Expiration Date: July 21, 2025
Approval Date: March 5, 2020
E-3
eL89Z9t (900 • vzl OOSei9Z (90FJ -m
(869S 'N'ro) eL'ree Valaold'(wviw
OZZ a.Uns'3AIHa 13sNns o9m
JmwdOl3A3a lDnaomd 19 5H33N19N3
�Jell NOI1V 0dH00 a00UVA-1V
ASON a000 .0-,91
NOW SNOUD3S 3M3
JM13H H000 „O-,9
„LZ
.9L
r- —m
<
I
I II
I
II I. �II
U
• �
o
a
Z
Jq�
V? !q
N
N
7 e,mo
CE��
Ou
6 amY
S
e
m
c
toy
g
I I I
Z
II II
x
X N.o
\ml zY
I
I�
I I
a
in
cr
o ¢
-�.10 NM �N
�ae�N
to
d
".�tn
I
I
I
m
O v0
I
II
z
1
mY
o'Zn
z
3
0 X K \
I
um -sec Nos) :%D4 9LOZ-Les (oos) :1-
8L0££ 'Id 'suap.loo y001DIH
•any 14186 WN 96LZL
•oul 'luodwoo rood gyp
as 3DYM WN003S -931S CBR1 ll0a vs 4Z
02
(n �.�t`ff• �.
0:
o..: m •i
rc rcn S'z ' Q�
g N i w a Nye ZU y apOt n mooK- in! - •lsr9.
gW �@ f9 w �o o¢no Sqz
u9 �j;
3,i w N �Hem
corm (.� mwo u3� � m�w <izwz�Tm � Q n
am �i mm z��''LLiy}� FE2 ly x
gQ. �wU Yevn
o U==m m xw>
22&tQJJ9 22�� � ��1QJJ _S&Zp 2�
Q. Us. 4 H. 1-�03(S< N
O N < m m
O
0
Z a
09
�(n
(n
o m m IT
101,
0
oo
.0 P3
W�w —+
V3 vI
oila NNM+m ® o�no3 �® .N.Neo
0¢ xoo gn
a.
3 g
F � bmu P1-Qn_ rtpp13
Ltj
CL
rn
w
K
LL
a 2 O N
F w2532 O ® m ® ® O
[] VI �
xyo
zm eo
mw= o
o �
o m �
m �
g� H
O_s
U
m ZLW OL mlvadn
-
L•4a•OL
l
mm sm 3sum ON
t*--
M
1331b SIR 35NWHD ON
LYAYL
r
J33f6 5911 3aNIX:I ON
fLW
1
uo Rasa
a
ou
Lfa '14- p
blWl :(4 'gyp '
O
ZO-Ol-aO :vlop v
G < O
8
saooa Iry tivs ,n. 1
yiI/�n
ZP m
Z
N wN
a 2
2
.
N
ww.
i 2
.
W u'
.
Z
.'1N
Z 2
N'iiw
Z-i
wa
m W
.y Qlwp
Z i
i N
NrnN�+N
Z S
N W
N
2 WW
t?Pll
BsXN11
E;
Uo11N
NMI'
I
I-
m
l •-
wNo
I
N
n:
MJmm
n
m I t
o
mWN
Wm•mm
NCO
WNm
m"v1-
'!`
m--
U
•-
O
m Z.
O O
W'......
O O
O O
O O
O O
O 0
Z ..
OF O
OF
OFF
O O
O O
O O
O O
W
O O
Z m Z W
O O
m Z N
0 OF
m
O OFF
O Oc OF
NOR
N
N
F
N
F
N N
fn
F
W
W
c F
W.W
"1 •I
i� •I.
•I •1
i0 •k
,1 •I
•1
•1 I
O
•1 •1
� •1
•1
�F'1
}I •I
in •1
•� '1 io
-ii =
A
-I
_i J
� -L
-N iV
' -M
-'
evOLZ-Z0 wince ZLZ6-Z9£ (SO£) :--A sloz-Lsz (00e) a.i u= a �
8L89-Z9Z i8oe)•":I OOL8-b9Z(ROE)-M 'SUa JD oa 01 � L10L Ol odltlodll 9t,wLVEol N c
9 60££ 'V. P 9 4 I H N
V 4186 'M'N 961Z L sw 3srmu a+ st•sozo >I aaat xa •�a o
(8596 xro) etTee valao-11'Ywvlw an .
orc amns'3mma J3sms U os 1 s gm 3OMM.O ON 'VIM N
oUj 4CuodWoo good 8V0 t33xs sU014al ose �«tim I 's N
iti3Wd0'13A3a 10f10oNd39 SU33NION3 um uosa ao 0 2 O
NOIJLvuoduoo t)0021v:j--I / •aO 38VM IVNOLL03S MIS Q3N8OJ 11DH Y0 4Z :suolsln9j
�.
'_' u p y� s O • O Q. = U) v Cif p W 0 �•. \`
C % mN m y .rf; g.9.9g p o .ri Ix W z rz-.: - i E ��/+'---• .. •' ft'\y���.
F Cq
�Tme a as wuw W a y� ,.
o pW CC ayJ \ to Noo v zow
C ea �f ` e F 6i
u2G % cW7 ioo C• pad' wma om
G�Am2 W mS °a i�V) I ppo .mt5 Mul
N WW W O 0.�
�p a NO8w i f Tb
2g5
Zm
Z NiV I N�f U V 'Y
e � ZZ N pYLL J
a----------- . �� o.�N
TdAN �z
d 0 xFq s '� �,t
c �d Jo p - �'ro
10
QW
rr—
OK. 2•C _Gip .� N -
IM00
O ? otc XUv6 '11 I1.'RN
O O O
�ZJZ
N
�-� XOpppp
ro Z NNN
X p X X X
O - \ m000
LL - O
dp nW mHn
3
= a to w
O Ozdm Nw w
N
O
a cl �.)•'3 V.W W O
o Z r`
a � x�Y y
�wm rc
m.N
OLLJ
41
x
SO
9 m x�� n55
G-
�w
�a tea.
OOp
N
2 3p�
kR�, 91. W o ul
�air�{o
a,mn.c� mNu'y �a :o g.- �nN my
WW4 UU
¢
i-zi.�W M xQV1 X^ 3
K X
zg\�za nmrc 'kxd s
Y�>m < 3i u1�Z hV4 ZNC
\ W.
O
O m x ��
XW
=8.VElWN138 NllM ai-x^x
W011D9 V1 F .� N -c
0
BVatz-SO\3 y6n zLZB-ZBS (goo) =A gwz-Lgz (006) :1-1
aceezas (sor�xdd OasatrezCGOC) 7aL 860££ •Li 's0ap3og gD8101H
n
(es95 'jv, .) ettsevalaou'iwvlw 'anV g196 'MIN 96LZL
ozz allns'3Alaa 33sNns ogee Sul 'Kubduw6o agog gya
1N3wdol3A3a lOnaOild'8 8U33N1ON3
�3 LLW m OUwdn
.LLwot
l
0300V NOOdO T/35 nm
t•60•f0
N
imlis sINL 30K*o ON
C'LO'tt
r
'Atl 1lON 1'IV03
Yt'9l'60
1
U011guosupa
D
Ou
e NOI1VHOdUO3 t)OOUVd-"[V 80 30M IM01133S 1331S QN803 lloN PJ 4b1U :suolslna3
m `
x m�o=
• UO �.60a Y. Ka\\ Y• m ifl N G MZU
F 6 pM M omm,n�? M � N�
z
Fo.¢w
$ N Sa y
U
os
W
O
p�
w�
m �
W
zo o. 3
w� m x �"
T Y UZ
08 x�xaa
O pZS[ s0¢Z
zd f
I P-
49
3 ap•y
r
B9
oC dWm
rzd �,t
BB
LB
w G4i x
1HOGH NOOG
�' • \
LHO13H ONIN3dO
Ne
9Q
M O
yp C
� 5
N Kp9
Va=
\ag
SpOp
Na ¢8
xVy rr
O '\ En
x cps �jarx
xao
�
•\."
O
444111
z\ o
x •n aMZ
Y3^
a
OK
¢4i
�1
pq
h'a rc
m �F1 Mini
�Gm
a
\�p~L. a
MLL O' ox
xp�3 d11LLt, SIR
K8 N
�y�F�rM
O)CW�� =\��v
W N
�W\
d
O
-.: oo
ZO
—i
GZO
QO
W2
1�.a`r Z
'a� �
a
L\
1
N
It\ l\\3
d9 �I4° [04
awl Vq R
<`` n /si
_ 'J
J
BVOLZ-'Z0 8MVD
UU-M! (90£) 1X°J gm-Lo (000) :1.-L
'SUa JD Da OI
8l0££ 'V P 9 4 I H
aA
• V N}g6 'Mo 96LZ1
'OUP 4CI10iJW0'J JOOQ 8bd
ow Uoi 6t
LtwmMVL
'1
:(9 -14°
bitltll :6y •gyp
O
c
N
'o N
O
a`
�J;
9[99'd9S.(90P w2l 0068'M9S(90e)-131
(SS9S YT'PJ) ELGEE t101tlO'ti'IWtlIW
ozz nuns 3ntaa imsmns oees
llJ3Wd0"LiA3U L'lnOOild'9 SN33N1'JN3
NOLLvaodmoo b0ouvzl- ltl
tim
oaJ°av NOado NJS wO11oB
L'60'£e
x
swarvwoo aaa as n3a
LYA LL
r
o3svaa saoleury
n�reu
1
UOI nose
- a
UU
•i1Q 35"a iwou03s -Gas a3 w T10i1 V6 4b
zo oL w a1°v
:suoislnal
O
O ZZ
\Q i
900M
A9Z
O
•Z/L-L �;
5h9
Nw
�pOo
\Q
3 0
�w
I
9W3 m
'NIW /L-L
0
cmi 3
aLvaJsen
QODM
Q �
t O
N
Q
C r
W
O
c
r
r
N
11
F c$
c
G Ecy 0
G
O $ = R o
Em
aenm'i
mg
!°rim
J <
o _ A9
�_ •W iW B _iW �g b� ��
O
U
30 031 031 N o31 �� zw
3 UI-mom Sh�1 zGLj' 3m�G1 41 z -0 aw
0 3 z zw O�W Qa
� � 48 UN�W Y�q A SZ FZ � ¢
crw .. 50� aooa 1-1'�oa r!5ao O 6. o
&8�80 or z� Uz go
�9 000N $ooz 89 soo z?o8&?
9VO LZ—Zo ZLZB-Z9£ (20£) cxuj 9LOZ=L4Z (008) :1-1
azaa- (Qo(soe)xdd oo' "OZ(sos)-in 8to€C 'IJ 'SuapJDO 4oajD!H
.7_ (B895. 'N'Y'O) ELGMvawo-u,lwmw •antl 4196 WN 461ZL
L o�auns'3nlaa l3sNnsoasa •oul IKundwoo loop gya
J 1N3 W.WrMA30 J.OnCOUd V Sa33NION3
L. NOIJLV-dOdUOO bOOUVd-IV -80 30YSVD 1VN003S 1331S G]V%O3 fit0il 'V0 4'(
0
0
ci
W
Z '
N o
El
\O\\
n.
w
0
n �
rc `
z
0
w
ti
O z
El' 11
m
J �
O
,*ioo
VN.W.
CL U U)
in L•com i c N
NJ LYIO•[o 7 Dlatll .(y •JP
3d- -rto•u r rn � In
3 B D 011 Q D
:SILOISIABJ ZD-OL-W :.7.P v
�• `��irrriilii�hJJ
o
�z
3
a tD an
04
Z
Q e r N
e
K
r
zo
W (V
=!$ g s
O
rz
�0
6
0
��g p
0¢
GEC m
p
Q3o
O$9Q 'a
n
6"m
000
LL o
m'Z mf
0
w
�Wz
rn
m
m
p
1111
U
W
xA
Ijl
'i i i l
� c
IiJ
Z w
W
Iljl
Q Z
cr
I711
O
z
I I11� 1 n
N d
px
9,6
�\^
m
Oa mSm��n
xt'T v-®mod
�®mod �
�o
�q
6
p /1
Vmj.l
/J
XW
�cP Foz
I 1
/Jn
oc4,
I
bIOM G