HomeMy WebLinkAboutAPPROVED, NOAAMI*MMIAMI-DADE COUNTY
PRODUCT CONTROL SECTION
11805 SW 26 Street, Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(RER) Miami, Florida 33175-2474
BOARD AND CODE ADMINISTRATION DIVISION T (786) 315-2590 F (786) 315-2599
NOTICE OF ACCEPTANCE NOA www.miamidnde. ov/econom
DAB Door Company, Inc.
12195 NW 98" Avenue
Hialeah Gardens, FL 33018
SCOPE: This NOA is being issued under the applicable rules and regulations governing the use of construction materia Is,
The documentation submitted has been reviewed and accepted by Miami -Dade County RER-Product Control Section to
be used in Miami -Dade County and other areas where allowed by the Authority Having Jurisdiction (AM).
This NOA shall not be valid after the expiation date stated below. The Miami -Dade County Product Control Section (In
Miami -Dade County)and/or the AHJ (in areas other than Miami -Dade County) reserve the right to have this product or
material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, the
in a nufacturer will incur theexpense of such testing and the AHJ may immediately revoke, modify, orsuspend the use of
such product or material within their jurisdiction. RER reserves theright to revoke this acceptance,ifit is determined by
Miami -Dade County Product Control Section that thisproduct or materialfails to meet the requirementsoftheapplicable
building code.
This productis approved as described herein and has been designed to complywith the Florida Building Code, including
the High Velocity Hurricane Zone.
DESCRIPTION: Hurricane Master Model 824/811 Steel Sectional Garage Door up to 9ft.-4in. Wide w/
Window Lite Option (DP +50.0,-60.0 PSF)
APPROVAL DOCUMENT: Drawing No. 01-09, titled "Sectional Garage Door", sheets I through 5 of 5,
dated 02/01/2001 with last revision M dated 07/30/2020,prepared by Al-Farooq Corporation, signed and sealed
by Jalal Farooq, P.E., bearing the Miami -Dade County Product Control Revision stamp with the Notice of
Acceptance number and expiration date by the Miami -Dade County Product Control Section.
MISSILE IMPACT RATING: Large and Small Missile Impact Resistant
LABELING: A permanent label with the manufacturer's name or logo, manufacturing address, model
number, the positive and negative design pressure rating, indicate impact rated if applicable, installation
instruction drawing reference number, approval number (NOA), the applicable test standards, and the statement
reading `Miami -Dade County Product Control Approved' is to be located on the door's side track, bottom
angle, or inner surface of a panel.
RENEWAL of this NOA sliall be considered afters renewal application ha s been filed and there has been no change in
the applicablebuild ng code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materia Is, use, and/ormanufacture of the product or process. Misuse of this NOA as an endorsement of any product, for
sales, advertising or any otherpurposesslia11 automatically terminate this NOA. Failure to comply with any section of this
NOA shall be cause for termination and removalof NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami -Dade County, Florida, and followed by the
expiration date maybe displayed in advertising literature. If any portion of the NOA is displayed, then it shall be done in
its entirety.
INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturerorits distributors and shall
be available forinspection atthe job site at the request of the Building Official.
This NOA revises NOA # 17-1018.13 and consists of this page 1 and evidence pages E-1, E-2, E-3 and E-4,
as well as approval document mentioned above.
The submitted documentation was reviewed by Carlos M. Utrern, P.E.
Mrar+A•DADE COUNTY NOA-No. 20-0901.19
Expiration Date: August 09, 2021
Approval Date: December 03,2020
Page 1
DAB Door Company, Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
1. Evidence submitted in previous files
A. DRAWINGS
1. Drawing No. 01-09, titled "Sectional Garage Door", sheets 1 through 5 of 5, dated
02/01/2001, with last revision K dated 03/21/2016, prepared by Al-Farooq Corporation,
signed and sealed by Javad Ahmad, P.E.
B. TESTS "Submitted underNOA # 09-0128.04"
1. Test reports on 1) Uniform Static Air Pressure Test, Loading per FBC TAS 202-94
2) Large Missile Impact Test per FBC, TAS 201-94
3) Cyclic Wind Pressure Loading per FBC, TAS 203-94
4) Forced Entry Test, per FBC 2411 3.2.1, TAS 202-94
along with marked -up drawings and installation diagram of a DAB 824 24 GA Sectional
Garage Door with Fixed Windows, prepared by Hurricane Engineering & Testing, Inc,
Test Reports No. HETI-08-2149AB, dated 06/27/2008, signed and sealed by Candido
F. Font, P.E.
"Submitted under NOA # 09-0128.04"
2. Test report of Tensile Test per ASTM E 8, Report No. HETI 08-T182, prepared by
Hurricane Engineering & Testing, Inc., dated 12/23/2008, signed and sealed by Candido
F. Font, P.E.
"Submitted under NOA # 01-0516.03"
3. Test report of large missile impact test per PA 201 and cyclic, wind pressure test per PA
203 on "Sectional Residential Garage Door", prepared by Hurricane Engineering &
Testing, Inc., Report No. HETI 01-974A, dated 01/29/2001, signed and sealed by
Hector M. Medina, P.E.
4. Test report of Uniform Static Air Pressure Test per PA 202 and Force Entry Resistance
Test on "Sectional Residential Garage Door", prepared by Hurricane Engineering &
Testing, Inc., Report No. HETI 01-969, dated 01/18/2001, signed and sealed by Hector
M. Medina, P.E.
5. Test report on Salt Spray (Corrosion) Test per ASTM B 117 of a painted G-40 steel
panels, prepared by Celotex Corporation, Test Report No. 258592, dated 08/17/1998,
signed by W. A. Jackson, P.E.
&M�
Carlos M. Utrera, P.E.
Product Control Examiner
NOA No. 20-0901.19
Expiration Date: August 09, 2021
Approval Date: December 03, 2020
E-1
DAB Door Company, Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
C. CALCULATIONS "SubmittedunderNOA#14-0814.04"
1. Anchor verification calculations prepared by A]-Farooq Corporation, dated 09/22/2014 and
07/24/2014, signedandsealed byJavad Ahmad, P.E.
"Submitted under NOA # 09-0128.04"
2. Anchor verification calculations prepared by Al-Farooq Corporation, complying with F.B.0
2007, dated 12/19/2008, signed and sealed by Humayoun Farooq, P.E.
D. QUALITY ASSURANCE
1. Miami -Dade Department of Regulatory and Economic Resources (RER)
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 15-0915.08, issued to SABIC Innovative Plastics, for their Lexan
Polycarbonate Sheet Products, approved on 12/10/2015 and expiring on 07/17/2018.
2. Notice of Acceptance No.14-0311.08, issued to Insulfoam, LLC, for their Insulfoam Expanded
Polystyrene Insulation, approved on 08/14/2014 and expiring on 11 /29/2017.
3. Notice of Acceptance No.11-0926.07, issued to Dyplast Products, LLC, for their Expanded
Polystyrene Block Type Insulation, approved on 11/10/2011 and expiring on 01/11/2017.
4. Notice of Acceptance No. 11-0926.06, issued to Dyplast Products, LLC, for their Dyplast ISO-
C1 Polyisocyanurate Insulation, approved on 11/10/2011 and expiring on 01/11/2017.
5. Notice of Acceptance No. 15-1203.04, issued to Cellofoam North America Inc, for their
Expanded Polystyrene Block Insulation, approved on 03/17/2016 and expiring on 02/24/2021.
"Submitted under NOA # 05-0228.02"
6. Test Report on Accelerated Weathering Using Xenon Arc Light Apparatus Test per ASTM
G 155 of "PVC Extrusion Material', prepared by Hurricane Engineering & Testing, Inc., Report
No. HETI 04-A002, dated 09/27/2004, signed and sealed by Rafael E. Droz-Seda, P.E.
7. Test Reports on Tensile Test per ASTM D638 of "PVC Extrusion Material", prepared by
Hurricane Engineering& Testing Inc., Report No. HETI 04-T251, dated 11/29/2004 signed
and sealed by 1. Ghia, P.E.
8. Test Report on Self -Ignition Temperature Test, Rate of Burn Test and Smoke Density Test of
"REHAU non -foam PVC extrusion material", prepared by ETC Laboratories, Report No. 04-
761-15019.0, dated 05/06/2004, signed and sealed byJ. L. Doldan,P.E.
F. STATEMENTS
1. Statement letter of code conformance to the 5" edition (2014) FBC and of no financial interest
issued by Al-Farooq Corporation, dated 03/21 /2016, signed and sealed by Javad Ahmad, P.E.
Carlos M. Utrera, P.E.
Product Control Examiner
NOA-No. 20-0901.19
Expiration Date: August 09, 2021
Approval Date: December 03, 2020
E-2
DAB Door Company, Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUB
2. EVIDENCE SUBMITTED IN PREVIOUS NOA # 17-1018.13
A. DRAWINGS
1. Drawing No. 01-09, titled "Sectional Garage Door", sheets 1 through 5 of 5, dated
02/01/2001, with last revision K dated 03/21/2016, sheets 1 through 5 of 5, prepared by
Al-Farooq Corporation, signed and sealed by Javad Ahmad, P.E.
Note: This revision consists of editorial changes to comply with FBC 2017.
B. CALCULATIONS
1. None.
C. QUALITY ASSURANCE
1. Miami Dade Department of Regulatory and Economic Resources (RER).
D. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 17-0221.06, issued to Insulfoam, LLC, for their Insulfoam
Expanded Polystyrene Insulation, expiring on 11/29/2022.
2. Notice of Acceptance No. 16-1108.04, issued to Dyplast Products, LLC, for their
Dyplast ISO-C1 Polyisocyanurate Insulation, expiring on 01/11/2022.
3. Notice of Acceptance No. 15-1203.04, issued to Cellofoam North America Inc, for their
Expanded Polystyrene Block Insulation, expiring on 02/24/2021.
4. Notice of Acceptance No. 15-0915.08, issued to SABIC Innovative Plastics, for their
Lexan Sheet Products, expiring on 07/17/2018.
E. STATEMENTS
1. Statement letter of conformance to FBC 2014 (51h Edition) and FBC 2017 (6th Edition),
prepared by Al Farooq Corporation, dated 10/05/17, signed and sealed by Javad Ahmad,
P.E.
F. OTHER
1. This NOA revises NOA # 16-0330.02, expiring 08/09/21.
Carlos M. Utrera, P.E.
Product Control Examiner
NOA-No. 20-0901.19
Expiration Date: August 09, 2021
Approval Date: December 03, 2020
E-3
DAB Door Company, Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
3. NEW EVIDENCE SUBMITTED
A. DRAWINGS
1. Drawing No. 01-09, titled "Sectional Garage Door", sheets I through 5 of 5, dated
02/01/2001 with last revision M dated 07/30/2020, sheets 1 through 5 of 5, prepared by
Al-Farooq Corporation, dated 08/13/2020, signed and sealed by Jalal Farooq, P.E.
B. TESTS
1. None.
C. CALCULATIONS
1. None.
D. QUALITY ASSURANCE
1. Miami Dade Department of Regulatory and Economic Resources (RER).
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 19-0129.06, issued to lnsulfoam, LLC, for their lnsulfoam
Expanded Polystyrene Preformed Block Type I Insulation, expiring on 11/29/2022.
2. Notice of Acceptance No. 17-1207.04, issued to Dyplast Products, LLC, for their
Dyplast ISO-C 1 Polyisocyanurate Rigid Foam Insulation, expiring on 01/11/2022.
3. Notice of Acceptance No. 18-0918.06, issued to Plaskolite, LLC, for their TUFFAK
Polycarbonate Sheets, approved on 01/15/2018 and expiring on 8/27/2022.
F. STATEMENTS
1. Letter of conformance to FBC 2020 (711, Edition) and FBC 2017 (01' Edition), prepared
by Al Farooq Corporation, dated 07/15/2020, signed and sealed by Jalal Farooq, P.E.
Carlos M. Utrers, P.E.
Product Control Examiner
NOA No. 20-0901.19
Expiration Date: August 09, 2021
Approval Date: December 03, 2020
E-4
\ i'• ( " 'Z'6'60LL NOUO3S H11M kidnoo OL 9NrUW
�\ w�'�i -30M ONlalln8 Vajboli 30 f•8-6OLI NOU.33S N18M 33t Mb003V m
60— �O ` ` ..- Sypjy., NOUYW'l 31EIMA kIKW3S V No a31V301 38 TWHS T38Y1 s.a3Wu3Vdnwn '9
•ou 6u!.Ojp /� •C ''. "M3LU0 ONla-U S A8 03M31008 38 01 ONY
` '• •:T� •kl3lvwd3S a3Zk7MV 38 01 3bV !DMMVW S*U NJ NMOHS lON SMOIVON00
3 '013 30NYMSMI NO11VL'11Lifll b31VM
£ nary HO3 9NMd0 ONnOW 9NnN3S CUV 10nO0bd SIHl 9NW333b 3bn10n815 d0
a 9 a-w w A7VnO3aY 10na08d SIW !O A133VS 33n ""I 1331.08d 013103dS 31U V 80.1
w 13 ' Y t9 NOUVWNOINI 3GMUd 1014 S300 ONV 31W?43o sl IYAOdddV MO0bd SMI •S
r I o '% 3g yS1,+r�Q ` LZOZ/eOfeo �rO IwWra'sabwNYls 031dOOY V 3aW '9018 VCwO-U ozoz/LIoZ 3HL !o S1fi3YgmnO38
6L'LOSO••OZ 31VH1 'SM383S �'Tt/1331S Ol O3NNfl lON 8 ONIGITIION1 STMXVW '9
.,....: .
r 11111t1111 evNgi'S'3 oaW' ta-0 —d 'A1NO a00M O1M M04OW !0 N9!S30 M a35n Sl 35Y3aaNI NOLLY2ln0 OYOI V 'f O3SUl9N JafMOild
'000n1S HO 5MSS3b0 T1VM oNOA38 38 TrMS 1VN1UM
f y 9 0 0 13VdW1 3lfSSIW 39HV'1 b0! 031Vb SI 13nOOUd SIHL 35V0 01 LN3W0-iaW3 O3UI03dS 'SNOIQra Lsld! S,3nNYW bad 03TWISN1 ONV
^Y- S11Y130 NO NMOHS SV O3OVdS 'LNYLS153b NOISOSHOO 38 TiYHS SHOHONV 'Z
'60-966L3 NlSY SO-9BB 13 1'11SY '(ZFIAH) 3NOZ 3NvomnH ALI3ow HOIH ONIan10M 3000 9NIOlInS
Wrr ZLWIb01 InCt3ME-i111 lOL^SV1'ZOZ-sYl 3007'JMO11a8I Yo"*U (NOW03 Hl.L) OZOZ/(NOI1103 H19) LIOZ 3H1 30 SLN3W3bin03b
WwOL !0 su13N3b n03a 3H1 H1 Al 30NYC x100Y N1 031531 b000 3H1 HIM AldM3 01 awsm aw 03Nowa N333 SVH 13na0Nd SWl 'I
3Sd 0'09 - S3MW
!Sd 0'05 + = 9NI1Va 321f15S3ad NViS30
S"S .0/9 x elf 10 n3n N1
Ond0 "In MaPu?M Vlh4
oMn 38 A" SM3b0S OMT1!b0 313S .t/f x *if
!)
96!H 0-,91 x .9-,6 92!s •XDA
Lt8/6Z8 tOPo)v ®jfl1saW auoo11JnH N000 03SS09ri3 13NVd (13S"
-,—_3NI sgooa ava NOLL M
.f-,6
P3 0 m >
mor
I
ZMw�
N QOW
Enpo
p°a90
o 0.0
V m Oc 0
�G90
o^o�p
om
1 0
m� Z
A�
1 RUM b000 'xm --- '
NO 630 NMBO GOO:A
W3 HSnII lYN0UdO-
NO!S30 1YliNJl00 -t "NI 'OS OZL
a330x3 al Lon V3dY ONIN3dO
XVN 'TO .L 1V 3aIM s (f) - 1
LN3A IVN0Ud0
T.
ZA, I
CL
NI
00
............
n
�y
e..,...
Y-J f
b31N33 /
31U$ b31N33J
ltl b000 OM eOCC Ol SNOWS ONn101a 313S -►/f x fl/ (9)
HUMHUMIYNGUdO HLM 3111S aN3 OL 03N31SY3._;'
1nN /M SW 'IL-9t/S 3NO HiIM 31Vld 13315
.t'0 x ,VC-L x .L/L-S 3bnMi dol
3h08Y NMOHS SN001
1108 3anS a30Vol 0MUdS Ol 31VNd3iW
N1tOHs OND=l His N301
b000 !0 MIS H3V3 NO
NOVbl N1 S30VON3
bY9 N301 AT x 191' p
SWS ,B/e x its (t milm O
3111S ON3 NO 03TWISN1
SWM We 11001 I1
3,1115 ON3
I MGM
SOS .►/f x fl/ (f) WVA 1 31tlS m7l) 0
31Y1d 1331S —
.OLo' x .9/t-f x .B/C-L /
NOLWO 8000 `
WOOa0V3H M01 / u000 13!'1 'OlS
13X3Vb8 ` / 13N3tR!8
~ o r • -o - sIYS 9/9 x rIll (z) HUM
3110 x�x.9
r
I
N=VA WAS t OL S 'MW M
----+-3A331S SS3bd-001N >P
3dAl LiWUDURF A1YU 'VA BSI'
SHOW �OVbYO'ONKR=3b UWI NOLL03S 01 SMHO1NOJ `,
1N3W35VON3 N301'NIW ,9/9
'S'W'S .Z/L X iL1} (Y) Al 03N3LSVd
' (SMIS HIM) 1100 WnS a3aV01 ONIbdS
\ H001 abYONVIS L
l I
'r HO1Y'1 lIH1 .St' x M .l ' 1
� r
\ r
h00a
x001
8 - (7Y7401ld0) 3A331S NOU130 Him
t sms .B/S x ,If (f) /M
30NW b31N30 T331S 'AW0 e
--- .too, x .s/1-L x ,L/t-- i
6
r
O
` " o
1 110
00
(—aidO) W31S NOb'130 HLM
O ('OLS) 3A331S NON-IM InOHUM
SKS .9/5 x ttj (9) /M
--'"~ -ONIH b3llOd CN3
T331S 'AIVO .ILO' x ,f X ,Z/1-4
!z SNal113351,
.91 Se"n 9
.9L
-
.tz SHoumm s
.6-,sI
.R SMOU33S 6
AL NOtl= t
9-,SL
.tL SNOUMS L
.99 SNOU3 iS L
-.51
.lr SNO13M 9
.91 SNOIL936 C.
,St
I L SNOU035 s
.91 2= 9
.8-A l
,lL SNOU035 Y
.01 ylilDllOOS C
A-,1l
•LL S11011335 f
•Bl 8
•C-,tl "
-
IZ SM=35 9
,9l
,IL SNa1173S [
.9t NWL'13S t
.fi-,fl
.IZ SeIp1035 8
.8l SNOUI7S L
A-,tL
lL SNOU035 9
_91 SNOUO3S
li S11OU32S f
.09 SNOUMS
.fl
LL SNOLMS f
.01 SNOII7CiS S
.6-,LL
.tL SI1011MIS Z
.91 SN0003S 9,
.9-,Zl
-
,49 SNOUXIS L
.f-ZI
.IZ SNOUD3S 9
_9L SNOUO3S l
,Ll
IL SNp1]35 S
.81 StAU0.T4 L
.6-,II
lz SNW,35 ti
,BL SNOUXIS L
�.9-.11
.Iz smoums f
.91 SWUM •
.f-.II
.Jr. SNOUMIS z
At SNDUM s
,Ll
.lZ Wum i
Al SNO11:135 fl
.6-,01
-.-It
SNOLLO3S 9
S-At
tZ SNoulls 9
A N 1 I
.f-AL
SNOUMS ►
.91 SN Is Z
.aL
lL SNO! f
At Swum f
--6-.6
lL SIi011035 Z
,9t SNOU035 Y
.9-.6
.li NOUO35
SN011:735 S
Wit- 6
Al SNOUMS 9
,6
•lZ SNOIL93S 91
.fl-,0—
.L9 SNOUO3S I,
Al, WOWS t
,9-.8
.It SNaq,t'35 t
_01 3S
IL SNOU33S L
.91 smaum5 ti
,8
,LL Naa n L
At So=s .'
.6-.4
ALL
-
.LC SNOUfl35
.4 --
,Iz SWI03S f
At NOUMS_t
___.6-.9
.1L SNOI133S L .9t SNOU?35 L�
10 SISISNOo i
,9 _9
.5m b000
x x x = i
Wx x
�Pg..
Yi O Wg 9
S zNao r
8 'tt ' tiO
g
p 'K c� I
v M o
► e C o M
+ W a
i
I
i
`* T1
�ulrnllt'
7re
.o'o"br
Ya 0SJ7.�Jo0.,n.21S
O na a
O L 1003.10)
Ce
0 0
zp z
q
1 �
yy
4fx
88p
O�
ff
z
ml
H
Aoxp0
C
�J
2
F,O-
P'
V X
i
O
0
� 11/---
O A G1 Y�
z rn
a
2
N
U
�
r
N
�
„
+
8�
in ) O
Nnx
QON
=1
py
m'8 x
0
e
-
glom
P
J
Val
m
77
m E
N
ESE
i
a
s
o
m
_SECTIONAL GARAGE DOOR
DAB Door Company, Inc. c-ss
12195 N.W. 98th Ave.
Hialeah Gardens, Ff. 33018
Tsl: (800) 257-2016 F— (305) 362-9272
AL-FAROOQ CORPORATIONrC
ENGINEERS d PRODUCT DEVELOPMENT
9360 SUNSET DRIVE, SUITE 220
MIAMI, FLORIDA 33173 MCN. JS30)
Tel(3051300.0100 FAY-r305)20Z,6Wa
18" OR 21' 18- OR 21" IS* OR 21'
PANEL HEIGHT PnNELVE&f PANEL HEIGHT
0VT
"q 2xg-
To b 5!
PI9 15AN P
40 b - x lib- i C,
CO ODC4 IAB `A
R 0 zz C; T
0
P
m mG T
OPENING DGff op
DOOR HEIGHT
1
as
87
86
85
U4 z
-Z 2i
u C 12 T 6;
T
R m ro It! 6; 6; %u z
G 2 1'21
In
0
QD ;518 8 T
4=
>
R
tn
F;
Y4 . ........ ou"
>
a dow. 02-01-01 fev $ions: R-O no o e SECTIONAL GARAGE DOOR ALFA OQ CORPORATION a
to, 6
2 J D3M.1 BMW S 15�� Ompany, Inc.
SILO .00mm ENGINEMS & PRODUCT DEVFLopmew
K 03.21.1 -M"� �-Wrl> 9360 SUNSET DRIVE, SURE
12195 N.W. 98th Ave. ffE 220 MIAMI. FLORIDA 331.73 .,V.
So u 07-14 -1-W �Tlo 15— rgc Hialeah Gardens, Fl. 33018 i 'ru. (305) 20441GO FAX (305) ..2-8070
237-!!10 (30 2-9272
cARAGE -09DAB
11
WOOD g11f7r
AT D R LAG SCREWS I .� - 1/4. OIA lAG SCREWS
AT 6" FROM ENDS y� D 11 AT 6" FROM ENDS
AND 19' O.C. MAX. 1 I AND 19. O.C. MAX.
OPTION 'A' �/ OPTION '8\�-y
WOOD BUCK CONNECTION TO WOOD SUBSTRATE (WOOD SPECIFIC GRAVITY SGe0.55 MIN.)
THE INSTALLATION METHODS SHOWN ABOVE SHOWS 2X0 SYP WOOD BUCK ATTACHMENT
TO WOOD STRUCTURES. IF THESE METHODS ARE FOLLOWED NO ADDITIONAL CALCUiATYJNS/DESIGN
WILL BE REQUIRED FOR DES" OF GARAGE DOOR ANCHORAGE.
FOR DOOR REPLACEMENT APPLICAM04S WITH NO ENGINEER OF RECORD. INSTALLATION MAY BE
VERIFIED AND APPROVED BY THE BUILDING OFFICIAL UPON INSPECTION.
5/16' x 1-5/8'
LAG SCREWS
AT 12" O.C.
WOOD BUCK CONNECTION TO MASONRY
e
_
f
PRESSURE TREATED 2X6 SYP WOW JAMBS WHICH SHALL BE ANCHORED TO
b
GROUTED REINFORCED MASONRY BLOCK WALL DR OONC. COLUMN WITH
1
1/4' ULTRACON♦ BY 'DEWALr WITH SPACING OF
t/
16' O.C. INTO GROUT FILLED BLOCK WALL. WITH 2-7/4' MIN. EMBED
16" O.C. INTO 3000 PSI CONCRETE. WITH 1-3/4- MIN. EMBED
I
2-1/2- MIN. EDGE OISTANCE
1/4' TAPPER BY 'DEWAL7' WITH SPACING OF
14" O.C. L470 GROUT FILLED BLOCK WALL. WITH 1-1/2- WON. EMBED
I6' INTO 3000 PSI CONCRETE. WITH 1-3/4' MIN. EMBED
D.C.MAC
x 2-
3' EDGE DISTANCE
FILLET W
3/8' CONFLEX BY 'ELCO' OR
AT 12' O.C.
3/8' LOT BY 'ITW WITH SPACING OF
24' O.C. INTO 3000 PSI CONCRETE. WITH 2-1/2' MIN. EMBED
2' INN. EDGE DISTANCE ONTFN
IS ANGLE TRACK
3/8' HLC SLEEVE BY 'H"' WITH SPACING OF TO WOOD
6UCK
8' D.C. INTO GROUT FELLED BLOCK WALL, WITH 1-1/4" MIN. EMBED, 4' MIN. EDGE (1ST.
18' O.C. IN70 3000 P9 CONCRETE. WITH 1-1/4" MIN. EMBED AND
2-1/2' MIN. EDGE DISTANCE
PREPARATION OF JAMBS BY OTHERS
FOR NEW CONSTRUCTION ENGINEER OF RECORD OR ARCHITECT TO VERIFY
ADEQUACY OF SUPPORTING STRUCTURE TO SUPPORT LOADS WPOSEO
BY DOOR SYSTEM.
FOR DOOR REPLACEMENT IN RETROFIT BUILDINGS WITH NO ENGINEER OF
RECORD. ODOR INSTALLATION MAY SE REVIEWED AND APPROVED BY
BUILD NG OFFICIAL UPON INSPECTION.
MAXwJM EXTFRIDR(-) LOAD PER JAMB : (9.3N X 50 PSF)/2 - 233.3 Lb. w FL
MAXMUM INTERIOR(-) LOAD PER JAMB - (9.33' X 60 PSF)/2 279.9 Lbs per F1.
RENFORCEMENT
rORMED (STEEL• x .059'
' V
le x 1-
F
SELF DRILLING SCREWS
3/16- 'RA'EX' STEEL RIVETS _\ '
MULTIGRIP W/ DOME HEADOR
1 Je x 1.
/ I DRILLING SCREWS
7/16' 'R STEEL RIVETS
Z S
0 n
AT 48- O.C.
W/
D MULTICRIP W/ DOME HEAD
�, AT 48' O.C_
< >: o
Q L 'i g
REINFORCEMENT
1/2- x 1-3/4' X Ow—,\
FORMED STEEL
E N
L.l
o C 4
•
O �1 V77r
W'STRfP ADAPTER
ALUMINUM
W STRIP ADAPTER
y D O C m
O C -
-
STEEL
``RUBBER
0 IL 0 A
RUBBER WSTRIPPING-
W'STRIPPING
Q O
I
Z
Q Iu� 7 Ii n
. l—d.�,y� \�i�-2f .sat .70D
.,E z6z m d_�
ai
.-i
fff T
1,750
.34B
1 _7
p-1,790
'1 W f
ROTTOM SEAL OPTIONS
N
�O� ni
O
10 C
w
I c7 '` °> r' I°•
ANCHOR SPACING _T, O Q
_ ANCHORS EMBED SPACIG IEOGE DST, L2 n r m
B HLCSLEEVE BY HILTI_ CONC, 1-1 4 I-5 8 IN c
3 8 HLC SLEEVE BY �NiLR' F0.Jg.D- QgK 1-1 4- - 4• yEj ,a
—NI
3 B OYNABOLT BY 'R1V I CONE. 1-I 2
STEEL STRUCTURE 6Y OTHERS __ 3 D OYINABOL7 BY ' 'FILLED BLOCK 1-I• _ B" 2-i 4 i F 0 Z U
MUST SUPPORT THE LOADS IMPOSED J8 .POWER-60LT KEY _.EWALT I CONC. _0 _� 1 U ij4}{ O -.
(9T DOOR SYSTEM 3'�StEEVE-ALL.-ALL. 0Y SIMPSQNS .. _.._LONG..__... 1-1 2 8' 1-7 B' I/W1, U1 n
m m
CONCRETE I'e - 3000 PSI MIN... -
�\ 5/16- DIA. BOLTS C-� GROUT FILLED BLOCK fm 2000 PSI MIN,/ r0
--WITH WASHER G NUT /� T�---•--�
AT 12' D.0 MAX. EDGE DIST. 1
I, �I11771ipg
X 2-1/2- X 14 GA I j L` h•
STEEL ANGLE I -1/2' II "??i� L G
7- 12 GA GALV. STEEL v�� `^P' a�
/ MT BRACKETS t3' LONG uil85Ti£i GAL g S
AT 12' O.C. IN DOOR OPNG. —FASTENED TO TRACK PLATES
I
AT 18' O.C. ABOVE ODOR OPNC. W/ (2) 1/4-20x3/B' TRUSS H0.
CONNECTED TO CONT. ANGLE SLOTTED M.S & LOCK NUT
W/ (3) SPOT WELDS AT EACH SIDE d+
C m � � M
REVERSE TRACK CONTINUOUS ANGLE TRACK 0 , 14 $ •4t
jQ�T y TO CONCRETE AND FILLED BLOCK 15 ^.0 8 - 6
ALTERNATE TRACK INSTALLATION
PRODUCT REVISED �, ��Lv Y� '•;4T I E
as comp ng wlth the Fbdda H % c I
Bullding O '
Noa No. 20 0901.99 �t�v 1 7Q
$ a
Eaplf Dats 08/09/2021-
� •'• SfA{E#OF ,'�4(-F7,,�//// BY drew;ng no.
Nflamf-Dade Product C •'•.�?ORL�:•��i ;v 01 --09
dn_