Loading...
HomeMy WebLinkAboutEvaluation Report; Crawl Space Door Systems Flood VentDIVISION: 08 00 00—OPENINGS SECTION: 08 95 43—VENTS/FOUNDATION FLOOD VENTS REPORT HOLDER: CRAWL SPACE DOOR SYSTEMS, INC. EVALUATION SUBJECT: CRAWL SPACE DOOR SYSTEMS FLOOD VENT ICC ICC ICC QE I • CMG LISTS© NMI w ° "2014 Recipient of Prestigious Western States Seismic Policy Council ��� (WSSPQ Award in Excellence" A Subsidiary of CODE OUNG"i ICC-ES Evaluation Reports are not to be construed as representing aesthetics or any other attributes not specifically addressed, nor are they to be construed as an endorsement of the subject of the report or a recommendation for its use. There is no warranty by ICC Evaluation Service, LLC, express or implied, as to any finding or other matter in this 4z report, or as to any product covered by the report. PdU'S°"Ec noes 01000 Copyright 012018 ICC Evaluation Service, LLC. All rights reserved. .M Evaluation i Issued September 2018 This report is subject to renewal September 2019. www:icc-es.ora 1 (800) 423-6587 1 (562) 699-0543 A Subsidiary of fhe International Code Council® I, DIVISION: 08 0000—OPENINGS 4 Section: 08 953 construction from the exterior side. Installation of the vent —Vents/Foundation Flood Vents must be in accordance with the manufacturer's REPORT HOLDER: instructions, the applicable code and this report. In order to comply with the engineered opening design principle noted CRAWL SPACE DOOR SYSTEMS, INC. in Sections 2.7.2.2 and 2.7.3 of ASCE/SEI 24-14, the vent must be installed as follows: EVALUATION SUBJECT: ■ With a minimum of two openings; one on different sides of each enclosed area. CRAWL SPACE DOOR SYSTEMS FLOOD VENT 1.0 EVALUATION SCOPE Compliance with the following codes: ■ 2018 and 2015 Intemational Building Code® ■ 2018 and 2015 Intemational Residential Code® Properties evaluated: ■ Physical operation ■ . Water flow ■ Weathering. 2.0 USES Crawl Space Door Systems flood vent is used .to provide for the equalization .of hydrostatic flood forces on exterior walls. 3.0 DESCRIPTION 3.1 General: Crawl Space Door Systems flood vent is an engineered mechanically operated flood vent. Upon contact with. flood water, the flood vent automatically opens and allows flood water to enter and exit enclosed areas. The vents are constructed of general purpose ABS SP-9010 plastic. The vent has a faux louver with either a solid plastic plate or wire mesh attached to the back of the louver. The louver is dislodged from the vent upon contact with flood waters. See Figure 1 for illustrations of the flood vent. 3.2 Engineered Opening: The Crawl Space Door Systems static flood vent complies with the design principle noted in Section 2.7.2.2 of ASCE/SEI 24 for a rate of rise and fall of 5 feet per hour (0.423 mm/s). In order to comply with the engineered opening requirement of ASCE/SEI 24-14, the flood vent must be installed in accordance with Section 4.0 of this report. 4.0 DESIGN AND INSTALLATION The Crawl Space Door Systems flood vent is designed to • be installed into walls or doors of existing or new ■ With a minimum. of one vent for the square footage of enclosed area noted in Table 1. ■ Below the base flood elevation. ■ With the bottom of the vent located a maximum of 12 inches (305 mm) above grade. 5.0 CONDITIONS OF USE The Crawl Space Door Systems flood vent described in this report complies with, or is a suitable alternative to what is specified in, those codes listed in Section 1.0 of this report, subject to the following conditions: 5.1 The Crawl Space Door Systems flood vent must be installed in accordance with this report, the applicable code and the manufacturer's published installation instructions. In the event of a conflict, the instructions in this report govern: 5.2 Use of Crawl Space Door Systems flood vent as under -floor space ventilation is outside the scope of this report. 6.0 EVIDENCE SUBMITTED Data in accordance with the [CC -ES Acceptance Criteria for Mechanically Operated Flood Vents (AC364), dated August 2015 (Editorially revised October 2017). 7.0 IDENTIFICATION 7.1 The Crawl Space Door Systems flood vent recognized in this report must be identified by a label bearing the manufacturer's name (Crawl Space Door Systems), the model number, and the evaluation report number (E8R-3851). 7.2 The report holder's contact information is the following: CRAWL SPACE DOOR SYSTEMS, INC. 3669 SEA GULLBLUFF DRIVE VIRGINIA BEACH, VIRGINIA 23455 (757) 363-0005 www.crawisdaceaoors.com ICC-ES Evaluation Reports are got to be construed as representing aesthetics or any other attributes not specifically addressed, nor are they to be construed as an endorsement oftlhe subject ofthe report or a recommendation for its use. There is no vvtaranty by ICC Evaluation Service. LLC, express or implied, as to any finding or other matter in this report or as to awry product covered by the report Copyright © 2018 ICC Evaluation Service, LLC. All rights reserved. ®ern° M Page 1 of 3 ESR-3851 I Most Widely Accepted and Trusted Page 2 of 2 TABLE 1—CRAWL SPACE DOOR SYSTEMS FLOOD VENT OVERALL VENT SIZE ROUGH OPENING SIZE ENCLOSED MODEL (Width x Height x Depth) (Width x Height) AREA COVERAGE (in) (in) (ft2) CSBA816 18'/4 x 10'12 x 13/4 16 x 8'/4 305 FIGURE 1—CRAWL SPACE DOOR SYSTEMS FLOOD VENT 17 ICC-ES Evaluation Report ESR-3851 FBC Supplement Issued September 2018 This report is subject to renewal September 2019. .. www.icc-es.org 1 (800) 423-6587 1 (562) 699-0543 A Subsidiary of the International Code Council® DIVISION: 08 00 00—OPENINGS Section: 08 95 43—Vents/Foundation Flood Vents REPORT HOLDER: CRAWL SPACE DOOR SYSTEMS, INC. EVALUATION SUBJECT: CRAWL SPACE DOOR SYSTEMS FLOOD VENT 1.0 REPORT PURPOSE AND SCOPE Purpose: The purpose of this evaluation report supplement is to indicate that Crawl Space'Door Systems flood vent, recognized in ICC-ES master evaluation report ESR-3851, has also been evaluated for compliance with the codes noted below. Applicable code editions: ■ 2017 Florida Building Code —Building ■ 2017 Florida Building Code —Residential 2.0 CONCLUSIONS The Crawl Space Door Systems flood vent, described in Sections 2.0 through 7.0 of the master evaluation report ESR-3851, complies with the Florida Building Code —Building and Florida Building Code —Residential, provided the design and installation are in accordance'with the 2015 International Building Code® provisions noted in the master report. Use of the Crawl Space Door Systems flood vent has also been found to be.in compliance with the High -Velocity Hurricane Zone provisions of the 2017 Florida Building Code —Building and Florida Building Code —Residential. For products falling under Florida Rule 9N-3, verification that the report holders quality assurance program is audited by a quality assurance entity approved by the Florida Building Commission for the type of inspections being conducted is the responsibility of an approved validation entity (or the code official when the report holder does not possess an approval by the Commission). This supplement expires concurrently with the master report, issued September 201.8. ICGES Evahtation Reports are not to be construed as representing aesthetics or any other attributes not specifically addressed, nor are they to be consented R as an endorsehnent of the subject of the report or a recommendation for its use. There is no warranty by ICC Evaluation Service, LLC, express or implied, as ME' to any finding or other matter in this report, or as to any product covered by the report. Copyright© 2018 ICC Evaluation Service, LLC. All rights reserved. Page 3 of 3 F--MOUNT LEVEL (D) (c) 0(A)00P 4r (B) STEP i. STEP 3. -- baw.11, Doors ems-- 1- INCORPORATED o Founded on great products, principles and customer service i What �ou'll.need Power drill 1/4" Masonry Bit Phillips Head Screwdriver Hammer Level included in; the kit: A. Screws B. Anchors C. Frame D. Louver Step i. Frame installation BALANCE frame (C) centered over crawl space opening. With frame (C) in place, drill top center hole. INSERT anchor (B) into hole in wall. SECURE top center screw (A). LEVEL frame (C). With frame (C) held in place, drill remaining Boles. INSERT remaining anchors (B) into wall. SECURE all screws (A). Or use construction adhesive to mount frame to foundation. Step z INSERT (D) louver into frame. (C) Snap louver into place. Unit 105 Virginia Beach, VA123455 757.363.0005 CrawlSpaceDoors.com MODEL HxW (in) Net Area 00 ❑ 1220CS 12 x 20 235 ❑ I232CS 12 x32 305 ❑ i6i6CS 16 x i6 18o ❑ 1624CS 16 x24 310 ❑ 632CS 16 x32 405 ❑ 2032CS 20 x 32 630 24243 2024 24 570 ❑ 2436CS 24 x 36 850 Plastic Crawlspace Doors & Vents Plastic Crawlspace Louvers/Screens ventilation Standard Door/Air Vent Great for new construction and remodeling. One-piece doorplate with easy to insert vermin screen, fixed louver and door lid. Made of durable PVC/ABS plastic (no rust or rot) with a UV retardant, treatment. Quick and easy to install. - ; craw l ' s- ace. 0-o Dborpw- stems; : I N C O R: P, O R• A. T E. D i 5741 Bayside Road, Unit 105 Virginia Beach, VA 23455 757.363.0005 1 1.800.230.9598 www.crawispacedoors.com MODEL DOOR OPENING - H x W TOTAL DIMENSION wth APPROXIMATE 3" FRAME 1220CS 12" H x 20" W 17 3/4" H x 26" W 1232CS 12" H x 32" W 17 N4" H x 37 1/2" W 16i6CS 16" H x 16" W 21 '3/4" H x 21 3/4" W 1624CS 16" H x 24" W 21 3/4" H x 30" W 1632CS 16" H x 32" W 2.1 ;3/4" H x 37 1/2" W 2032CS 20" H x 32" W 25 1./2 ' H x 37 3/4" W 2424CS 24" H x 24" W 29 3/4" H x 30" W 2436CS 24" H x 36" W 29 3/4" H x 41 3/4" W • All doors are surface mount — meaning they mount over the foundation opening • Because the frame / flange adds an approximate extra 3 inches around it is okay if your opening is a little smaller or bigger. So, you do not have to make a custom door • All doors are paintable with a plastic adherent paint. We suggest Krylon Spray Paint and wait an hour then use Krylon Clear Coat for a lasting finish • The frame / flange can be trimmed if needed since our doors are made of durable ABS Plastic • All louvered doors come with mounting hardware, frame, screen, louver (vent) and a cover • To remove the cover or louver just pull the pins out of the left and right side frawlspa.ce, .00Po or.. Sy stems I NC0RP0RA.TED Plastic Crawlspace Doors & Vents Plastic Crawlspace Louvers/Screens Engineered FENMA Flood Vents 5741 Bayside Road, Unit 105, Virginia Beach, VA 23455 1 757.363.0005 11.800.230.9598 1 www.crawlspacedoors.com I Standard Door I Great for new construction and remodeling. One-piece doorplate with easy to insert door lid. Made of durable PVC/ABS plastic (no rust or rot) with a UV retardant treatment. Quick and easy to install. MODEL HxW (in) El 1232CSNL 12 x 32 ❑ 1624CSNL 16 x24 ❑ 1632CSNL 16 x 32 ❑ 2032CSNL 20 x 32 ❑ 2436CSNL 24 x 36 Plastic Crawlspace Doors ENCAPSULATION _- � ��-- - (raw[S ace P. Doo.tstems oy _1-� 1 NCOR.PORATED 041 Bayside Road, Unit105 Virginia Beach, VA 23455 757. 363.0005 1 1.800. 230.9598 1ww. crawlspacedoors. com MODEL DOOR OPENING - H x W TOTAL DIMENSION wth APPROXIMATE 3" FRAME 1232CSNL 12" H x 32" W 17 3/4" H x 37 1/2" W 1624CSNL 16" H x 24" W 21 3/4" H x 30" W 1632CSNL 16" H x 32" W 21 3/4" H x 37 1/2" W 2032CSNL 20" H x 32" W 25 1/2" H x 37 3/4" W 2436CSNL �4„ H X 36„ W 29 3/4" H x 41 3/4" W • All doors are surface mount — meaning they mount over the foundation opening • Because the frame / flange adds an approximate extra 3 inches around it is okay if your opening is a little smaller or bigger. So, you do not have to make a custom door • All doors are paintable with a plastic adherent paint. We suggest Krylon' Spray Paint and wait an hour then use Krylon Clear Coat for a lasting finish • The frame / flange can be trimmed if needed since our doors are made of durable ABS Plastic • All louvered doors come with mounting hardware, frame and a cover • To remove the cover just pull the pins out of the left and right side • You can insulate your crawlspace by adding a piece of Y4 foam board inside the frame • Great for access or encapsulation fraw[Space NoOysas R I NC0RP0RA,TED Plastic Crawlspace Doors & Vents Plastic Crawlspace Louvers/Screens Engineered FEMA Flood Vents 5741 Bayside Road, Unit 105, Virginia Beach, VA 23455 1 757.363.0005 1 1.800.230.9598 1 www.crawlspacedoors.com I.. rITIT omkToTim. far, RFCFIVE� OMNI Our ICC Breakawa ` c eygpt t designed to meet FEMA, land. J ICC requirements for Engineered 199s - 2 Flood Vents in all 50 States. • • • • Our 16"x 8" breakaway, flood vent covers 305 sq. ft. making it the highest rated flood vent that size available in the market. . Getting your home FEMA compliant does not have to be expensive. Made of durable PVC/ABS Plastic. It's paintable. Easily installs into most homes foundation. We're developing larger stackable sizes. (Example: Approx. 32"x 16" — covering 1,220 Sq.Ft.) 0 • Opening: 16"x 8.25" fYaW_: • Outside Flange:18.25" x 10.5" • • Each vent covers 305 sq. Ft. __. _... C• Model # CSBA816 " `' ° R P Founded on great Florida Approval FL-29622 principles and custom ace 5741 Bayside Road p c Unit 105 "" Virginia Beach, VA 23455 A T E, D ducts, 757.363.0005 ervice CrawlSpaceDoors.com } • The bottom of the flood vent opening cannot be higher than 12 inches above grade. • A minimum of two vents for each enclosed area (crawl space, garage, or rooms within a garage), and each flood vent must be on at least two different sides exterior walls. • A minimum of one engineered square inch of opening for each square foot of enclosed area for an engineered flood vent. Or a minimum of one square inch of net open area for each square foot of enclosed area for non -engineered openings. • An engineered certificate of flood openings is required for all engineered flood vents without ICC-ES certification. rawSpace.. Doors stems.. �y I NCO,RP0RATED Plastic Crawlspace Doors & Vents Plastic Crawlspace Louvers/Screens Engineered FEMA Flood Vents NI 5741 Bayside Road, Unit 105, Virginia Beach, VA 23455 1 757.363.0005 1 CrawlSpaceDoors.com