HomeMy WebLinkAboutNotice of Acceptance File Copy
M IAMI-DADS MlAI•II-DADS COUNTY,
p PRODUCT CONTROL SECTION
11805 SW 26 Street,Room 208
DEPARTAIENT OF REGULATORY AND ECONOMIC RESOURCES(RER) Miami,Florida 33175-2474
BOARD AND CODE AD*51INISTRATION DIVISION T(786)315-2590 - F(786)315-2599
NOTICE OF ACCEPTANCE•(NOA) ;vrvw,ndamianae.Hovleconomy
Nichiha USA,Inc.
6465 E.Johns Crossing
Johns Creek,GA 30097
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction
materials. The documentation submitted has been reviewed and accepted by Miami-Dade County RER
Product Control Section to be used.in.Miami Dade County and other areas where allowed by the Authority
Having Jurisdiction(AHJ).
This NOA shall not be vafid after the expiration date stated below.The Miami-Dade County Product Control
Section(In Miami Dade County)and/or the AHJ(in areas other than Miami Dade County)reserve the right
to have this product or material tested for quality assurance purposes. If this product or material fails to
perform'in the accepted manner, the manufacturer will incur the expense of such testing and the AHJ may
'immediately revoke, modify, or suspend the use of such product or material within their jurisdiction. RER
reserves the right to revoke this acceptance, if it is determined by Miami-Dade County Product Control
Section that this product or material fails to meet the requi ements:of the applicable building code.
This product is approved as described herein,and.has been designed to comply with the Florida Building
Code, including the High Velocity Hurricane Zone.
DESCRIPTION:NichiProductsThi Fiber-Cement Siding
APPROVAL DOCUMENT:Drawing No.ITS N1090403,titled"NichiBoard&EcoPlank",sheets 1 and 2
of 2 and Drawing No.ITS N2090403,titled"NichiPanel",sheets 1 and 2 of 2, both dated 03/16/2009,
prepared by.Nichiha USA,lnc,.signed'and sealed by Carl D.Fussner,P.E.on 07/10/2014,bearing the Miami-
Dade County Product Control revision stamp with the Notice of Acceptance number and expiration date by
the Miami-Dade County Product Control Section.
MISSILE IMPACT IR.A.TIN"Q Large and Small Missile Iripact Resistant
LABELING:Each unit shall.bear a permanent label with the manufacturer's name or logo,city,state and
following.statement: °Miami-Dade County Product Control Approved",unless otherwise noted herein.
RENEWAL.of this NOA shall be considered after a renewal application has been filed and there has been
no change in the applicable building code negatively affecting the performance ofthis.product.
TERIVIINATION of this NOA will occur after the expiration date or if there has been a revision or change
in the materials,use,and/or manufacture of the product or process.Misuse of this NOA as an endorsement of
any product,for sales, advertising or any other purposes shall automatically terminate this NOA.Failure to
comply with any section of this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT:The NOA nuinher preceded by!lie words Miami-Dade County,Florida,and followed
by the expiration date may be displayed in advertising literature. If any portion of the NOA is displayed,then
it shall be done in its entirety.
INSPECTION: A copy of this entire NOA shall be provided to the user.by the manufacturer or its
distribwors and shall be available for inspection at the job site at the request of the Building Official.
This NOA renews and revises NOA#09-0511.01 and consists of this page I and evidence pages E-1 and E- i
2,as well as approval document mentioned above. I
The submitted-documentation was reviewed by Carlos M.Utrera,P.E.
NOA No. 14-0715.03
MIAM4DADE COUNTY Expiration Date:July 22,2019 �
.•••, Approval Date:January 29,2015
yl ,r Page I
Pei
Nicliiha USA,Inc.
NOTICE.OF ACCEPTANCE: EVIDENCE SUBMITTED
A. DRAWINGS
1. Drawing No.ITS N1090403,titled"NichiBoard &EcoPlank",sheets 1 and 2 of 2 and
Drawing No.ITS N2090403,titled"NichiPanel", sheets 1 and 2 of 2, both dated
03/16/2009,prepared by Nichiha USA,Inc,signed and sealed by Carl D.Fussner,P.E.
on 07/10/2014.
B. TESTS "Submitted under NOA#09-0511.01
1. Test reports on 1)Air Infiltration Test,per FBC,TAS 202-94
2)Uniform Static Air Pressure Test,Loading per FBC TAS 202-94
3)Water.Resistance Test,per FBC,.TAS 202-94
4) Large Missile Impact Test per FBC,TAS 201-94
5) Cyclic Wind Pressure Loading per FBC,TAS 203-94
along with marked-up drawings and installation diagram of NichiProducts Fiber-
Cement Panels,prepared by Intertek Testing Services NA LTD,Report No.
3145127COQ-004A, dated 08/07/08,signed and sealed by Rick Curkeet,P.E:
2. Test reports on 1)Uniform Static Air Pressure Test,Loading per FBC TAS 202-94
2)Large Missile Impact Test per FBC,TAS 201-94
3)Cyclic Wind Pressure Loading per FBC,TAS 203-94
along with marked-up drawings and installation diagram ofNiehiBoards and
EcoPlanks,prepared by Intertek Testing Services NA LTD,Report No.
3145127COQ-004B,dated 10/24/.08,signed and sealed by Rick Curkeet,PZ
3. Test report on Standard Specification for Flat Non-Asbestos Fiber-Cement Sheets of
NichiProducts Fiber-Cement Panels,per ASTM C1186-07,prepared by Intertek
Testing Services NA LTD,Report No, 3145123COQ-005,dated 05/20/08,with a
revision dated 02/02/09,signed and sealed by Rick Curkeet,P.E.
4, Test report on Surface Burning Characteristics of NichiPanel Fiber-Cement Panels,
per ASTM E84-08,prepared by Intertek Testing Services NA LTD,Report No.
3145123COQ-006, dated 06/25/08,with a revision dated 04/03/09, signed and sealed
by Rick Curkeet,P.E.
5. Test report on Standard Test Method for Behavior of Materials in a Vertical Tube
Furnace at 750°C of.Nichiba.M series lmprimed cementitious;.per ASTM E136-99,
prepared by Intertek Testing Services NA LTD,Report No. 3105885C.OQ-002,dated
10/26/06,with a revision dated 03/30/09,signed and sealed by Rick Curkeet,P.E.
Carlos M.Utrera,P.E.
Product Control Examiner
NOA No.14-0715.03
Expiration Date:July 22,2019
Approval Date:January29,2015
•E-1
Nichilia USA,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
C. CALCULATIONS
1. Anchor calculations prepared by Progressive Engineering, Inc.,dated
10/22/2014,signed and sealed by Carl D. Fussner,F.E.
"Srtbinitted un(lei-NOA #09-0511.01"
2. Anchor analyses prepared by Category 5 Engineering Services,Inc., dated
04/03/2009,signed and sealed by Enuna T.Mellinger,P.E.
D. QUALITY ASSURANCE
1. Miami-Dade Department of Regulatory and Economic Resources(RER)
E. MATERIAL CERTIFICATIONS
1. None.
F. STATEMENTS
1. Drawing No.ITS N1090403 and ITS N2090403 statements of code conformance to
2010 FBC issued by Nichiha USA,Inc,dated 03/I 6/2009,.signed and sealed by Carl
D.Fussner;P.E. on 07/10/2,014.
2.1 Statement letter of no financial interest issued by Progressive Engineering,Inc.,dated
07/10/2014,signed and sealed by Carl D.Fussner,P.E.
P
°or1 z
Carlos M.Utrera,P.E.
Product Control Examiner
NOA No,14-0715,03
Expiration Date:July 12,2019
Approval Date:January 29,2015
E-2
12"Panels Shown 5 114-Panels Shown DESCRIPTION and SPECIFICATION NichiBoard&
EcoPlank lap siding material is a non-asbestos fiber cement
2"x Studs product tested in accordance with ASTM C-1185&ASTM
@ 16"o/c C-1186 Type A meeting the requirements of the 2010 Florida
(TYP) Building Code(HVHZ). Planks are available in a variety of
widths within the maximum and minimum dimensions
specfied below.
8"Max.
o/c Spacing Plank Dimensions
(TYp-)
Width Len Thickness
5Y"Min. 12'
12"Max.
Design Pressure Rating -125 psf
5&"Max. LIMITATIONS
o1c Spacing 1. All installation shall be done in accordance
(Tpac with this Notice of Acceptance,the
manufacturer's installation recommendations,
and the applicable sections of the 2010
Florida Building Code including High Velocity
L4"o/c Spacing Hunicane Zone where Required.
(TYp•) 2- Wood studs and plywood sheathing
supporting NichiBoard and EcoPlank siding
shall conform to the 2010 Florida Building
Code(including the•HVHZ where required),
and the requirements of this Notice of
Acceptance(See.Note Sheet 2).
3. Siding installed as specified herein shall be
54"Panel Height classified as Large Missile Impact RR
(Typ-) PRODUCT REVISM
?T`_ as w tic Fiarida oo •E N
12"Panel Height C�dc G SF•...Q
> i
CrYP•) , Aeoepem—Nwb l Q3� ti G'
? No 719.07
14"Overlapr i - . i. -— —. >� _
(TYP•) 714'Overlap ►TO&MCCoatvl �•b. a�
(Typ.) S•>TATE OF :�
-W M N109D403 v,oaei
I Cf2 NichiBoard & EcoPlank NICHIHA USA, INC. JUL 1.0 2014
NICHIHA ' 0 Fiber Cement Siding 6465 E Johns Crossing.Johns Creck.GA.30097
fir ixmesd a" awn ts.2009
NICHIBOARD&ECOPLANK SIDING INSTALLATION
The planks shall be applied horizontally commencing from the
bottom course of the wall.
• Each successive course shall overlap the prior course by 1 X".
• Any vertical joints shall be over framing members,with
fasteners either side of the joint-
• The planks shall be installed over%"APA rated exterior-grade
plywood(SG=0.50 min.)supported by 2"x 4"minimum wood
NichiBoard or EcoPlank Siding studs spaced a maximum of 16"o.c.
Weather-ResisantBarrier The siding shall be fastened through over-lapping planks with
8d x 2Y."Common Nail @ 8d x 2 V long common nails over wood studs.
5%-Ole vertically,8,0/r . A row of fasteners shall be placed in the overlap of each
Hor¢ontaffy. % Mln.. course,spaced 8"o%in the horizontal direction.
2"Max Edge Distance.
Successive rows of fasteners shall be spaced not more than 5
%^o/c.(Planks greater than 6 5/8"in width shall require an
Y"Plywood Shoathing additional row of fasteners in the center of the plank).
Fastened to Studs per 2010 . A distance of between 4"and 2"from the edges shall always
Florida Building Code
be observed.
PLYWOOD SHEATHING NOTE
NichiSoard and EcoPlank Fiber-Cement Lap Siding is designed
NicHBoard or EcoPiank Siding to be installed to plywood sheathing. Such plywood shall be%"
Weather-Rosisant Barrier (5-ply)minimum,APA rated sheathing,Structural 1 grade,with a
8d x 2Yz"common Nail @ specified specific gravity of 0.50 or greater(e.g.Douglas
5 Ve ok Vertically,8r o!c
Horizontally. W min., Fir-Larch or.Southern Pine). Use of other grade plywood shall
2"Max.Edge Distance. require a site-speck fastener design for the siding attachment,
signed and"sealed by a Florida Registered Professional
Engineer.
%'Plywood Sheathing
Fastened to Studs per 2010 Such plywood sheathing shall be supported by framing
Florida Building Code consistin " 41��1l1Rd�I�O
studs,eagch at 164o/c inPmywo d shall
lltuds,or be attached to the fram ng.�`tP�,
ffioaUCT studs in accordance with the 2010 Florida Building Code(Hig��GQ'%��C E N S�'
oolpkYMS with the k3o"
Velocity Hurricane Zone). = No 71907
.tiocxpoonae;•4. 7f.S 03 �: :t
STATE OF
A,
ITS NlOX403
= 2cf2 NichiBoard& EcoPlank NICHIHA USA, INC. JUL 10 2014
e«at o
NlCNIHA Fiber Cement Siding G485 E.Johns Crossing,Johns Creek,GA 30097
.�,,oa,is.zcos fit..c.c:'h, �?('•4r}`�
- tlt>er cement
} ——48"Panel Width 48"Pane[Width� DESCRIPTION and SPECIFICATION
is a non-asbestos
!f I� NichiPanel siding material is anon-asbestos
i fiber cement product tested in accordance
with ASTM C-1185&ASTM G1186 Type A
2"x Studs meeting the requirements of the 2010
@ 16"o/c Florida Building Code(HVHZ). Panels are
(Typ) - - available in four-foot widths within the
maximum and minimum dimensions
. specified below.
. Plank Dimensions
. Width Length Thickness
. 48"
6"Max. 48" 10' %s" •
o/c Spacing I 1 1 48" 12' sis"
(fyp-) .
Design Pressure Rating -104 psf
c LIMITATIONS
. 1. All installation shall be done in accordance
• with this Notice of Acceptance,the
n manufacturer's installation
x recommendations,and the applicable
6"Max sections of the 2010 Florida Building Code
o/c Spacing including High Velocity Hurricane Zone
(Typ) r where Required.
, _ 2. Wood studs and plywood sheathing
supporting NichiPanel siding shall conform
. to the 2010 Florida Building Code
(including the HVHZ where required),and
• the requirements of this Notice of
Acceptance(See Note Sheet 2).
3. Siding installed as specified herein shall be tIlsoi!!!p�
classified as Large Missile Impact �`���
Re N
pIt i r SEWSED �.�QQ':''C,E N
' evewil7ipsM!h The TuriAamading
CodeNo 74907
. Rodin Coesiot Z p STATE OF ,'�
S �%
o.s rrs NZM0403 aoa„ct •iawroeua.:
,«z NichiPanel NICHIHA USA, INC. JUL 0 Z014
" -.o Fiber Cement Siding 6465E Johns Crossing,Johns Creek GA.30097
ercemA o"a. rbuns,am9 L.c..i'tt
. 9tler cement
NICHIBOARD&ECOPLANK SIDING INSTALLATION
•. The planks shall be applied vertically,avoiding horizontal
joints.
• The planks shall be installed over%"APA rated
exterior-grade plywood(SG=0.50 min.)supported by
2"x4'minimum wood studs spaced a maximum of 16"o.c.
• Fasteners shall be placed at 6"o/c in the vertical direction
and 6"o/c in the horizontal direction.
A distance of between 3/"and 3"from the edges shall
always be observed.
NichiPanel Siding
Weather-Resisant Barrier
.PLYWOOD SHEATHING NOTE
6d x 2-Common Nail @ NichiPanel Fiber-Cement Siding is designed to be installed to
6*o/c ver icaily,o"olc
Horizontally. Yy'miff- plywood sheathing. Such plywood shall be%"(5-ply)minimum,
3-Max.edge Distance. APA rated sheathing,Structural 1 grade,with a specified
specific gravity of 0.50 or greater(e.g.Douglas Fr-Larch or
Fa Plywood Sheathingstenetl to studs per 2010 Southem Pine). Use of other grade plywood shall require a
Fa
Florida Building code site-specific fastener design for the siding attachment,signed
and sealed by a Florida Registered Professional Engineer.
Such plywood sheathing shall be supported by framing
consisting of 2"x 4"minimurn wood studs,or'2"x 6"I Sga metal
studs,each at 16"o/c. Plywood shall be'attached to the framing
studs in accordance with the 2010 Florida Building Code.(High
Velocity Hurricane ZPReODU fREviSD FPS '
with the Fkrtii4s `s�/ �.�
No 71 907 :�r
Dhft rmdau+contcot 9 STATE OF =44f�
0 -;c P � ••
{ ORX
10 AL �•��,,
o- rrs.M2o9°4w �aK um,.rteeern: 8�1�>t
2o12 NichiPanel NICHIHA USA, INC. 1.0 2014
NItHIHA ° Fiber Cement Siding 6465 E.Johns Crossing.Johns Croek,GA.30097
fiber cemebt nn cnsc;z°oe 4 <;�:rl f ti`Y
0;.,..;Ex- , ia.
s•Y t. dl;. i q .,� '.rev„d '�a. N' .} , A, ::biz F a ��,;'r , ,ar t`4a r ;S •"t;'.�,.:_R
�.�.,',^'„�� � A• r N. YJ `�'� �4' '�k.(r sk:,. �s� esT d,. "^�:sY r .!°o n,,.i1 t .p .:�,. r �'�!. �$. iyd.c:
, dd
' 7�\f`�2' ��y ,�`"1``• { ���xY �Tl). !}}: ..� �.G •},M���:1 {., Y el v { I, yy.,, N � %' S .L1�;
k,�..,^� ,•� - hi_4 ''7 ++� ''.; bra �u,�;'y�'�•�'�i?� s �.4��<'•=•�l �.A,: `AN
, Y�., i� - 1.:
i, .7`., ,. ih,M+•4 S.:Y.. y.,) 5,„ - ��,,ti.t :. � �•. �' ,f•'}- {ttr S ;f
vz�:.r ;:A1•. '�. � J `',4,. t'au .rkar .;a 1 S..xdyr}' •Vy. }. i s.. ,(r.tS �, i;, > L tiS tr
th- ! yr�� ^. ��<„'Y`�yr�',�ll..ire ��y.\� ,nYj. a CR r��a3..f��`� a�Y� + ''' :try. ^a ^
I !. t0i,, � � Z t ;�1•s �1: r,':,t�,Lt','
'�I"u, 3',(.yig�><,� !ov ,:`��..q� �5
!' "wrtS, .,�..i t. ,.. PJ"4+Sf�..�i .��**fi'..�.I.Sr' , q•... `�{ 5♦.ti1 L%n..� V' 9j TS;:Y.n
�• Y. �tr.r t�4C' 'j "'
l� ,¢s C � A'•rt N ;:r"
'LL'•,i '�.,J... �Yg_j'G t\�.Y„i.•J , c '.J4` 1t I:
"1•4..�'j;>t l^ ! I f; 5}� `,S i, t I.e,t k. -51�: 4,i4 •�� :Ja`Si :.,y! tt
"?§ i r � K. }. y ,, r � 1 t f�;�sji .r • , ,a { d �, <. k\ , } ���.. a }.� 4
f �
'IC
A }!
v
j t FIRE i t MOISTURE
rm RESISTANT ,.'� _. r RES!ST.�NT "
j Gc6 THERMAL t rr BUG rG _
rc' RESISTANT
Fiber Cement Products by Plycem R--tSTANT {
I ,
PPG ColorMax°
Ceddl
Na
• Industry-leading warranty -'
1. • Add instant curb appeal to your home with ColorMax
,+� • Factory-applied finish form awmum consistency and performance }
1 'y r �i '� r�; ° .}E$'52
f +,. �, {.,It "
W. " Y�''.x�• "4` e,�,.„zzyr. .F 5
t
?' 4
' F � '. y S a ) •i
tw Y 5
G .�..,. :y 11 `, - ,,..,; �, ^. t e.. � ,.,i 1 *>;� t. r ::.k h.t � ffl,�l � i X T.� � �'.:t.1 _l•' .i fl '%,° �,�,. '�(:;;'Y 7 5 t .t`i-.,
x ' .. ;�. .. e),..c ;x dlsa 3.'.b,' �.. ....,,1' .t.. r.cJ .0 in o -,:. :. `.'r, ��,1( ,.y •� :(-'��. , ,Jr.G w�;t •f n;.aid a.�..e1 .,1 rr.
:: ..x r :., .� ,1.�-,! -, .y r�.rn 1 �. -3:- �.',1....if^ ��i+.�,._Cay ..�r. .f�_. D. .0.4, y .Y:. +� 'S• a:C;:^m. ,Y�I,.r y.,.. � ! t., �4.�PL'.'a. .c,� C � r•.� ;u rK.....
. c,�:a.t �,,,:.. nt 1.. '?�.�..� �'rf':.,. . -£.2.._.'�/:�.� .r..Z:.r^,., �i"'r"t'rfii Yi:�}e z .:�,,, d„,I.,,,� �t<.:,,u,.is✓1 Y,y,Sys !''I r. y, C + ,vi°� t �-i,;,'a'� �t,q"�,,s,.�,;s'' .�?t1�^�°
s� y�a£1"'Y.�2:3 � y,i£:g �„r.+t.. k 'i•. e. "n�`�r, wa pc,1<i. Y +:1.,i h{. - y..i', �, �'�F!} r.4.,.'� '! %! ,>, va ,a. ..7;t 7 :��a
S 3.• 4.•,Gy;f, (i„.'7��'� �i.}.• xc� �. .-.��x � X�-.;{r+r ::M•,:�:ir w+^f f !I �:iax,r,, .t�:'i' 03:�•, ,f sr ''�„�" ..;r,;-' �7+�-;f,. .k�-�;. �Y':11.'rj.�:i
r