HomeMy WebLinkAboutNotice of Acceptance M[�IPA4�MI RECEIV.7D SEP 2 6 2017
flY MIAMI-DADE COUNTY
fLW PRODUCT CONTROL SECTION
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(RER) 11805 SW 26 Street,Room 208
BOARD AND CODE ADMINISTRATION DIVISION Miami,Florida 33175-2474
�j T 1786)315-2590 F(786)315-2599
�,q�
NOTICE OF ACCEPTANCE NO �v"/'o '�W / www.miamidade.eov/economy
3M Company " • �1
3M Center Building 0220-05-E-06 ItEIt1EVIEWED EV ,C
St.Paul,MN. 55144-1000 DATE, ��ED B�
DATE, s
PLANS AND PUTIMI ST BE XEPT ON JC'9
SCOPE: ORNO LN-SPECTION WILL BE MADE.
This NOA is being issued under the applicable rules and regulations governing the use of construction materials. The
documentation submitted has been reviewed and accepted by Miami-Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction(AHJ).
This NOA shall not be valid after the expiration date stated below.The Miami-Dade County Product Control Section
(In Miami Dade County)and/or the AHJ(in areas other than Miami Dade County)reserve the right to have this product
or material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner,the
manufacturer will incur the expense of such testing and the AHJ may immediately revoke,modify, or suspend the use
of such product or material within their jurisdiction. RER reserves the right to revoke this acceptance,if it
determined by Miami-Dade County Product Control Section that this product or material fails)to meet the requirements
of the applicable building codniESE PLANS AND ALL PROPOSED ORK ,. a ► e GNP OR ATTACHMENTS
This product is approved as dAN-fl WT0hA cbb� pb signed to comply with the$dg4.1 'aaB3ii�cl"in �e de
including the High Velocity INW199 l9L&1W t ding Code. ;ARE THE.RESPONSISILITY OF THE
ECESSARY IN ORDER TO
COMP6 dYJTH A P149 kR?9E9: CORTI QTQR OF RECORD
DESCRIPTION: 3M Foam Roof TTile A�esrve
LABELING: Each unit shall bear a permanent label with the manufacturer's name or logo,city, state and following
statement: "Miami-Dade County Product Control Approved",unless otherwise noted herein.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials,use, and/or manufacture of the product or process.Misuse of this NOA as an endorsement of any product,for
sales, advertising or any other purposes shall automatically terminate this NOA.Failure to comply with any section of
this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami-Dade County, Florida, and followed
by the expiration date may be displayed in advertising literature. If any portion of the NOA is displayed,then
it shall be done in its entirety.
INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official.
This NOA renews NOA# 14-0805.02 and consists of pages 1 through 8.
The submitted documentation was reviewed by Alex Tigera.
N(Fule
MIAMI•DADE COUNTY
Expiration Date: /
Approval Date: 12/31/15
Page 1 of 8
I
ROOFING COMPONENT APPROVAL:
Category: Roofing
Sub Category: Roof tile adhesive
Materials: Polyurethane
SCOPE:
This approves 3M Foam Roof Tile Adhesive RTA-1 as manufactured by 3M Company as described belc..� in this
Notice of Acceptance. For the locations where the pressure requirements,as determined by applicable building code,
do not exceed the design pressure values obtained by calculations in compliance with RAS 12 7. For use with approved
flat,low,and high profile roof tile systems using 3M Foam Roof Tile Adhesive RTA-1.
PRODUCTS MANUFACTURED BY APPLICANT:
Product Dimensions Test Product Description
Specifications
3M Foam Roof Tile N/A TAS 101 Single component polyurethane foam roof tile
Adhesive RTA-1 adhesive.
PRODUCTS MANUFACTURED BY OTHERS:
Any Miami-Dade County Product Control Accepted Roof Tile Assembly having a current NOA which list attachment
resistance values with the use of 3M Foam Roof Tile Adhesive RTA-1 roof tile adhesive.
MANUFACTURING LOCATION:
1. Norton,OH.
PHYSICAL PROPERTIES:
Proper Test Results
Density ASTM D 1622 1.95 lbs./ft.3
Compressive Strength ASTM D 1621 7.8 psi
Tensile Strength ASTM D 1623 15 PSI Parallel to rise
Water Absorption ASTM D 2842 4.6 Lbs./Fe
Moisture Vapor Transmission ASTM E 96 1.94 Perm/Inch
Dimensional Stability ASTM D 2126 +0.89%Volume Change @ 70'C.,2 Weeks
Closed Cell Content ASTM D 2856 54.1%
Note: The physical properties listed above are presented as typical average values as determined by
accepted ASTM test methods and are subject to normal manufacturing variation.
i
NOA No.: 15-1201.04
M uoanecouNrir Expiration Date: 01/03/21
Approval Date: 12/31/15
Page 2 of 8
EVIDENCE SUBMITTED:
Test Agency Test Identifier Test Name/Report Date
Southwest Research Institute 01-1208-025 ASTM E 108 06/16/98
PRI Construction Materials FOP-009-02-10 Physical Properties 12/14/10
Technologies,Inc. FOP-009-02-01 TA9-101 11/8/10
FOP-009-02-02 TAS-101 11/4/10
FOP-009-02-03 TAS-101 11/8/10
FOP-009-02-04 TAS-101 11/8/10
FOP-009-02-05 TAS-101 11/8/10
LIMITATIONS:
1. Fire classification is not part of this acceptance.
2. 3M Foam Roof Tile Adhesive RTA-1 can be used with flat,low,medium and high tile profiles.
3. Minimum underlayment shall be in compliance with the Roofing Application Standard RAS 120.
4. Roof Tile manufactures acquiring acceptance for the use of 3M Foam Roof Tile Adhesive RTA-1 ro- -tile
adhesive with their tile assemblies shall test in accordance with TAS 101 with section 10.4 as modified herein.
F W
2
F'=
MS
5. All products listed herein shall have a quality assurance audit in accordance with the Florida Building Code and
Rule 61 G20-3 of the Florida Administrative Code.
J
NOA No.: 15-1201.04
t�u►tYt�•n/me COUNTY Expiration Date: 01/03/21
Approval Date: 12/31/15
Page 3 of 8
INSTALLATION:
1. 3M Foam Roof Tile Adhesive RTA-1 may be used with any roof tile assembly having a current,NOA that
lists attachment resistance values with the use of 3M Foam Roof Tile Adhesive RTA-1.
2. 3M Foam Roof Tile Adhesive RTA-1 shall be applied in compliance with the Component Application
section and the corresponding Placement Details noted herein. The roof tile assembly's adhesive
attachment with the use of 3M Foam Roof Tile Adhesive RTA-1 shall provide sufficient attach- ,ant
resistance to meet or exceed the resistance values determined in compliance with Roofing Application
Standards RAS 127. The adhesive attachment data is noted in the roof tile assembly NOA.
3. 3M Foam Roof Tile Adhesive RTA-1 roof tile adhesive and its components shall be installed in accordance
with Roofing Application Standard RAS 120,and Fomo Products,Inc. 3M Foam Roof Tile Adhesive RTA-
1 Operating Instruction and Maintenance Booklet
4. Installation must be by a Factory Trained'Qualified Applicator'approved and licensed by Polyfoam
Products,Inc.
5. Tiles must be adhered in freshly applied adhesive.Tile must be set within 4 minutes after 3M Foam Roof
Tile Adhesive RTA-1 has been dispensed.
6. 3M Foam Roof Tile Adhesive RTA-1 placement shall be in accordance with the'Placement Details'herein.
Each generic tile profile requires the specific placement noted herein.
I
Table 1: Adhesive Placement For Each Generic Tile Profile
Tile Typical Placement Weight per paddy(grams)
Profile Detail
Flat,Low&High Profile # 1 12
High Profile 2-Piece Barrel #2 12
LABELING:
All approved products listed herein shall be labeled and shall bear the imprint or identifiable marking of the
manufacturer's name or logo and following statement: "Miami-Dade County Product Control Approved" or the Miami-
Dade County Product Control Seal as shown below.
MIAMI-DADE COUNTY
BUILDING PERMIT REQUIREMENTS:
As required by the Building Official or applicable building code in order to properly evaluate the installation of this
system.
NOA No.: 15-1201.04
MIAMI•DADE COUNTY
Expiration Date: 01/03/21
Approval r. te: 12/31/15
Page 4 of 8
ADHESIVE PLACEMENT DETAILS
PLACEMENT DETAIL#1
#er gthening ri
Pad on tap d Itile
connected to paddy
underneath file
d file
Uhderlodc
lid ool. w
Overlock
0
Start overlock side
paddy at tile omise line.
Start.underiodk side paddy
F:ave appro)ari-stely 1" above file
Closure carae lire
FLAT PROFILE
NOA No.: 15-1201.04
QM1AM-DADRC=0UNW Expiration Date:01/03/21
Approval Date: 12/31/15
Page 5 of 8
PLACEMENT DETAIL#1 (CONT...)
Pad on flop of file
1 oonneded to paddy
undemeath tile.
Pm of file
lhide 0*
Ewe Overiodc
course line
Start ovvedodc side paddy
at file course line.
Save Start unclerlodc side paddy 4
appro)amately 1" above the
Closure course line.'
LOW PROFILE
NOA No.: 15-1201.04
CMAMIMADEOUNTY Expiration 1 .te:01/03/21
' Approval Date: 12/31/15
Page 6 of 8
PLACEMENT DETAIL#2
{
Paddy on top d tie
connected to tie
two paddies
�tile.
Pan dtil
Eave course %
line
SRart l on e apprad� rr�at�
lotabove file c line. y
Eave dosme
HIGH PROFILE
NOA No.: 15-1201.04
QMIAW-DAE COUNTY Expiration Date:O1/03/21
Approval Date: 12/31/15
Page 7 of 8
1
PLACEMENT DETAIL#2(CONT...)
I
Two.(2) -T'tblong
course lne Eave \�'\ side urxier per�i tiles.
\ \\\ One(1)-;7'paddy
„` \�\1 on fail side U1der
\} \ cover flea
tee,
1
l
\1\) Two(2) -ICT oblong
paddies side by side
under pan tiles
leave oourseor�y)
'Mortar eare dosure
2-PIECE BARREL PROFILE
END OF THIS ACCEPTANCE
NOA N�:: 15-1201.04
CM1AM1WDADECOUNTY ' Expiration Date:01/03/21
Approval Date: 12/31/15
Page 8 of 8
Florida Building Code 5th Edition (2014)
High-Velocity Hurricane Zone Uniform Permit Application Form
Section A (General Information)
Master Permit No. Process No.
Contractor's Name 1 ante aL�_
I 2gL
Job Address Yb3teq �5()Ia4ethM L /�J J�l
ROOF CATEGORY
El Low Slope id Mechanically Fastened Tile 0 Mortar/Adhesive Set Tile
O Asphaltic 13 Metal Panel/Shingles 0 Wood ihingles/Shakes
Shingles Are there
13' Prescriptive BUR-RAS 150 Gas Vent Stacks?
Yes❑ No❑
—/ ROOFTYPE Type: Na ural❑ LPGXQ
• New Roof 13 Re-Rooflng E3 Recovering 0 Repair ❑ Maintenance
ROOF SYSTEM INFORMATION
Low Slope Roof Area(SF) Steep.Sloped Roof Area(SF) Total (SF)
ao 6 oo Ll. q toC) C1
Section B (Roof Plan)
Sketch Roof Plan: Illustrate all levels and sections, roof drains, scuppers, overflow
scuppers and overflow drains. Include, dimensions of sections and levels, clearly
Identify dimensions of elevated pressure zones and location of parapets.
2
^2 F2 F�a m
'IF
Ob td , Z
I
�o e2 cn
12
2 0 --
+g
- —- A I -
- - - `� R3
19
�o -
- - -
--- — — sr
He G
�s
�I'
Florida Building Code 5th Edition (2014)
High-Velocity Hurricane Zone Uniform Permit Application Form
Section D (Steep Sloped Roof System)
Roof System Manufacturer:
r
Notice of Acceptance Number: I o� a 00
1
Minimum Design Wind Pressures, If Applicable(From RAS 121 or Calculations):
...—�Desi9 n Pressure
From the NOA Specific System):
Method of the attachment:T� C�
Steen Sloped Roof System Description
Deck Type: 1 .
c IA
ype Underlayment: ,r:Roof Slope: o 41
nsulation:
: 12
Fire Ba er: I NIA
Ridge Ve ilat/�nion? astener Type&Spacing: n�S', u �1
dhesive Type
Ype Cap Sheet: .
oof Covering:
Mean Roof Helght: Ov Q
Type&Slze DIIr p
dge.
�J
Florida Building Code 5th Edition(2014)
High-Velocity Hurricane Zone Uniform Permit Application Form
Section E (file Calculations)
For Moment based the systems,choose either Method 1 or 2.Compared the values
for Mrw�ith the values from M&' If the M,values are greater than or equal to the Mr
values,for each area of the root,then the the attachment method Is acceptable.
/p Method 1_"Moment Based T2ile Calculations Per RAS 127"
-Mr. �D 17 s 111rt GZ.J NOA 11%
NOAr4 r�
(P3; S'01 O z 0.3 =-f 8. 1—Mg: 'f —N1 -25.03 NOA A*
Method 2"3impNed Tile Calc"on Per Table Below"
Required Moment of Resistance(Mr)From Table Below 2 5 •NOA-K
Mr equirod Moment Resistance*.
Mean R�NOW
Roof Slop. 15, 20' 2V 30' 4W
• 2 35.1 .3
i
6:12 ZOO 40.1' 3 . ' �:fi 3iA
20A
:12 .8
*Must be used in conjunction with a list of moment based the systems endorsed by the
Broward County Board of Rules and Appeals.
For Uplift based the systems use Method 3.Compared the values for F with the
values for F,if the F' values are greater then or equal.to the F,values,for each
area-of the root,then the tale attachment method is acceptable.
.Method 3"UpHft Based Tile Calculations Per RAS 127"
w:-_)—W:_zcos9:_= Fr{'_ :,AF',��,,,'_
(P2:_:1:_m_z w:- )—W:_zcos9:_= F,2: OAF`
(P3:_zl:_—_s w:—_)—W:_zcds9:_= Fti:_ NOA F'
Where to Obtain Informadon �
Description Symbol Where to find)
DesipPreum PI orP2 orP3 RAS 127 Table 1 or by an cn&ocft sambrats M ued by FE based an ASCB
Mean Roof HeW H Job Site
Roof Mope g Job Site
NOA
RaWthm MMCW dm to ftVq M NOA
ACac m cW Reaumoce Mr NOA
OWN Mamcsrt lrii CalWidad
PAImmmm Atotcbmmt F NOA
R%qt m F, ^nlc
6y=TdeWcJ&ht NOA
Tile DW=daw I-keg& NOA
w-Wkkh
All admdatloat samt be tobmitted to die u ffie d=of licadm
JOSEPH E. SMITH, CLERK OF THE CIRCUIT COURT — SAINT LUCIE COUNTY
FILE' # 4343685 OR BOOK 4034, PAGE 1225, Recorded 08/23/2017 03:11:24 PM
I ,
NOTICE OF COMMENCEMENT
Permit No. Property Tax ID No.3-3 'dU 'CO3 '
State of Florida,County of St.Lucie
The Undersigned hereby gives notice that improvement will be made to certain real,property,and in accordance with
Chapter 713,Florida Statutes,the following information is provided in
,this
Notice of Commencement.
egal Description of property and address if available 8e
1 QSerVI P1 QY1i-ah �� --LIST Ina 33�{rN aQ 3 }'-13?-� '35�1(-nab)
General dese ' 'on of improvements' filL + �� �•[6L
Ownerltessee ��Q "t MW i!Yvl 1 C 1 0-0
AddressR03LO (ojihah}Y) L'N"s bw-kL 5& • J- a(-, h
Interest In property: D :,
Fee Simple Title holder(if other tban owner) A
Address
Contractoembloyt Phone# )-' ' gicc(A
Address5-"�.�, NW merca/W6 'Pla Cf- 4//3 Fax ,ak- 00
Surety /� Phone#
Address Fax#
Amount of Bond
\ eI� Phone#
aK ;A Fax#
6
D a0seis within the State of Florida designated by Owner upon whom notices or other'documents may be served as provided
100t`- 713.13(a)7.,Florida Statues:
_ Phone#
m — a'
v, FA;iV Fax# ;
Pditlon to himself,owner designates of
-{ Phone# Fax#
m� erxeive a copy ofthe Lienor's Notice as provided in Section 713.13(1)(b),Florida Statutes. Expiration date of notice of
cn�'{n cncement is one year-from the date of recording unless a different date is specified. WARNING TO OWNER:
AY PAYMENTS MADE BY THE OWNER AFTER THE EXPIRATION OF THE NOTICE OF COMMENCEMENT ARE CONSIDERED IMPROPER
ct E YMENTS UNDER CH.713.13,F.S.,AND CAN RESULT IN YOUR PAYING TWICE FOR IMPROVEMENTS TO YOUR PROPERTY.A NOTICE OF
NIENCEMENT MUST BE RECORDED AND POSTED ON THE JOB SITE BEFORE THE FIRST INSPECTION.IF YOU INTEND TO OBTAIN
c CING,-CONSULT WITH YOUR LENDER OR ORNEY BEFORE COMMENCING WORK OR RECORDING YYOUR NOTICE OF
C0 CMENT. P1l'GLWlo-� p s
o �
o � Q3
e seq or Owner's or Lessee's Authorized O/riter/Director/Partner/Manager!Signature
Signatory's THI [lice
StattolFlo unty of 1,n I_
Ackre me this day of 20 JZ,by I I i I I('. IP I ' 1C1��_Q YP,nS
whoown to me or who has produce - as Identification,
ture of Nota T e or Print Name of Nota •''�'"•��Se
ry yp ry �:� , •.,�i} EDAM L RYCKMAN a
MY COMMISSION#FF1 45513
Title:Notary Public Commission Number
o'orFdj' EXPIRES July 27,2018
I4ailtaaa.oioa PiorldnNotary5nrvlce,com