Loading...
HomeMy WebLinkAboutAPPROVED NOA ES MX1000 SH 20091501 NOA No. 20 -0915.01 Expiration Date: November 06, 2023 Approval Date: December 17, 2020 12/4/20 Page 1 MIAMI -DADE COUNTY PRODUCT CONTROL SECTION 11805 SW 26 Street, Room 208 DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES (RER) Miami, Florida 33175-2474 BOARD AND CODE ADMINISTRATION DIVISION T (786) 315-2590 F (786) 315-2599 NOTICE OF ACCEPTANCE (NOA) www.miamidade.gov/building E.S. Windows , LLC 3550 NW 49th Street Miami, FL 331 42 SCOPE: This NOA is being issued under the applicable rules and regulations governing the use of construction materials. The documentation submitted has been reviewed and accepted by Miami–Dade County RER– Product Control Section to be used in Miami–Dade County and other areas where allowed by the Authority Having Jurisdiction (AHJ). This NOA shall not be valid after the expiration date stated below. The Miami–Dade County Product Control Section (In Miami–Dade County) and/ or the AHJ (in areas other than Miami–Dade County) reserve the right to have this product or material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, the manufacturer will incur the expense of such testing and the AHJ may immediately revoke, modify, or suspend the use of such product or material within their jurisdiction. RER reserves the right to revoke this acceptance if it is determined by Miami–Dade County Product Control Section that this product or material fails to meet the requirements of the applicable building code. This product is approved as described herein and has been designed to comply with the Florida Building Code, including the High Velocity Hurricane Zone. DESCRIPTION: Series “1000/1050” Aluminum Single H ung Window – L.M.I. APPROVAL DOCUMENT: Drawing No. W03-56, titled “Series-1000/1050 Alum. Single Hung Wdw. (L.M.I)”, sheets 1, 1.1, 2, 2.1 and 3 through 8 of 8, dated 07/31/03, with revision M, dated 07/17/20, prepared by Al-Farooq Corporation, signed and sealed by Jalal Farooq, P.E., bearing the Miami-Dade County Product Contro l Revision stamp with the Notice of Acceptance number and expiration date by the Miami-Dade County Product Control Section. MISSILE IMPACT RATING: Large and Small Missile Impact Resistant LABELING: Each unit shall bear a permanent label with the manufacturer's name or logo, Barranquilla , Colombia , model/series, and following statement: "Miami–Dade County Product Control Approved", unless otherwise noted herein. RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change in the applicable building code negatively affecting the performance of this product. TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the materials, use, and/ or manufacture of the product or process. Misuse of this NOA as an endorsement of any product, for sales, advertising or any other purposes shall automatically terminate this NOA. Failure to comply with any section of this NOA shall be cause for termination and removal of NOA. ADVERTISEMENT: The NOA number preceded by the words Miami–Dade County, Florida, and followed by the expiration date may be displayed in advertising literature. If any portion of the NOA is displayed, then it shall be done in its entirety. INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and shall be available for inspection at the job site at the request of the Building Official. This NOA revise s NOA No. 1 8-0905 .07 and consists of this page 1 and evidence pages E-1 , E-2, E-3 and E-4, as well as approval document mentioned above. The submitted documentation was reviewed by Manuel Perez, P.E. Manuel Perez, P.E. Product Control Examiner NOA No. 20 -0915.01 Expiration Date: November 06, 2023 Approval Date: December 17, 2020 E – 1 E.S. Windows, LLC NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED 1. EVIDENCE SUBMITTED UNDER PREVIOUS NOA’s A. DRAWINGS 1. Manufacturer's die drawings and sections. (Submitted under NOA No. 03-0910.03) 2. Drawing No. W03-56, titled “Series-1000/1050 Alum. Single Hung Wdw. (L.M.I)”, sheets 1 through 8 of 8, dated 07/31/03, with revision L, dated 09/27/17, prepared by Al-Farooq Corporation, signed and sealed by Javad Ahmad, P.E. (Submitted under NOA No. 17-1114.09) B. TESTS 1. Test reports on: 1) Air Infiltration Test, per FBC, TAS 202–94 2) Uniform Static Air Pressure Test, Loading per FBC TAS 202–94 3) Water Resistance Test, per FBC, TAS 202–94 4) Large Missile Impact Test per FBC, TAS 201–94 5) Cyclic Wind Pressure Loading per FBC, TAS 203–94 6) Forced Entry Test, per ASTM F 588–04/ 07 and per FBC 2411 3.2.1, TAS 202–94 along with marked -up drawings and installation diagram of an aluminum single hung window, prepared by Fenestration Testing Laboratory, Inc., Test Reports No. FTL-5815 and FTL-5337, dated 02/13/09 and 01/25/08 respectively, both signed and sealed by Michael R. Wenzel, P. E. (Submitted under NOA’s No. 09-1008.05 and 07-0928.14) 2. Test reports on: 1) Air Infiltration Test, per FBC, TAS 202–94 2) Uniform Static Air Pressure Test, Loading per FBC TAS 202–94 3) Water Resistance Test, per FBC, TAS 202–94 4) Large Missile Impact Test per FBC, TAS 201–94 5) Cyclic Wind Pressure Loading per FBC, TAS 203–94 6) Forced Entry Test, per ASTM F 588–04/ 07 and per FBC 2411 3.2.1, TAS 202–94 along with marked -up drawings and installation diagram of an aluminum single hung window, prepared by Hurricane Engineering & Testing, Inc., Test Reports No. HETI- 05-1448 and HETI-05-1953, dated 04/22/05 and 04/25/05 respectively, both signed and sealed by Ivonne Ghia, P.E. (Submitted under NOA No. 05-0720.01) Manuel Perez, P.E. Product Control Examiner NOA No. 20 -0915.01 Expiration Date: November 06, 2023 Approval Date: December 17, 2020 E – 2 E.S. Windows, LLC NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED 1. EVIDENCE SUBMITTED UNDER PREVIOUS NOA’s (CONTINUED) B. TESTS (CONTINUED) 3. Test reports on: 1) Air Infiltration Test, per FBC, TAS 202–94 2) Uniform Static Air Pressure Test, Loading per FBC TAS 202–94 3) Water Resistance Test, per FBC, TAS 202–94 4) Large Missile Impact Test per FBC, TAS 201–94 5) Cyclic Wind Pressure Loading per FBC, TAS 203–94 6) Forced Entry Test, per ASTM F 588–04/ 07 and per FBC 2411 3.2.1, TAS 202–94 along with marked -up drawings and installation diagram of an aluminum single hung window, prepared by Fenestration Testing Laboratory, Inc., Test Reports No. FTL-3820 and FTL-3806, dated 06/09/03, signed and sealed by Joseph C. Chan, P.E. (Submitted under NOA No. 03-0910.03) C. CALCULATIONS 1. Anchor verification calculations and structural analysis, complying with FBC 5th Edition (2014), prepared by Al-Farooq Corporation, dated 10/23/14 and revised on 07/14/15, signed and sealed by Javad Ahmad , P.E. (Submitted under NOA No. 15-0129.03) 2. Glazing complies with ASTM E1300-09 D. QUALITY ASSURANCE 1. Miami-Dade Department of Regulatory and Economic Resources (RER). E. MATERIAL CERTIFICATIONS 1. Notice of Acceptance No. 17-0808.02 issued to Kuraray America, Inc. for their “SentryGlas® (Clear and White) Glass Interlayers” dated 12/28/17, expiring on 07/04/23. 2. Notice of Acceptance No. 17-1114.14 issued to Kuraray America, Inc. for their “Trosifol® Ultraclear, Clear and Color PVB Glass Interlayers” dated 01/18/18, expiring on 07/08/19. Manuel Perez, P.E. Product Control Examiner NOA No. 20 -0915.01 Expiration Date: November 06, 2023 Approval Date: December 17, 2020 E – 3 E.S. Windows, LLC NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED 1. EVIDENCE SUBMITTED UNDER PREVIOUS NOA’s (CONTINUED) F. STATEMENTS 1. Statement letter of conformance to FBC 5th Edition (2014) and FBC 6th Edition (2017) and of no financial interest dated 09/18/17, prepared by Al–Farooq Corporation, signed and sealed by Javad Ahmad, P.E. (Submitted under NOA No. 17-1114.09) 2. Laboratory compliance letter for Test Reports No. FTL-5815 and FTL-5337, issued by Fenestration Testing Laboratory, Inc., dated 02/13/09 and 01/25/08 respectively, both signed and sealed by Michael R. Wenzel, P.E. (Submitted under NOA’s No. 09-1008.05 and 07-0928.14) 3. Distributor Agreement, dated 04/04/16, signed by Carlos Garcia and by Andres Chamorro. (Submitted under NOA No. 17-1114.09) 4. Laboratory compliance letter for Test Reports No. HETI-05-1448 & HETI-05-1953, issued by Hurricane Engineering & Testing, Inc., dated 04/22/05 and 04/25/05 respectively, both signed and sealed by Ivonne Ghia, P.E. (Submitted under NOA No. 05-0720.01) 5. Laboratory compliance letter for Test Reports No. FTL-3820 and FTL-3806, issued by Fenestration Testing Laboratory, Inc., dated 06/09/03, both signed and sealed by Joseph C. Chan, P.E. (Submitted under NOA No. 03-0910.03) G. OTHERS 1. Notice of Acceptance No. 17-1114.09, issued to ES Windows, LLC for their Series “1000/1050” Aluminum Single Hung Window – L.M.I., approved on 01/18/18 and expiring on 11/06/18. Manuel Perez, P.E. Product Control Examiner NOA No. 20 -0915.01 Expiration Date: November 06, 2023 Approval Date: December 17, 2020 E - 4 E.S. Windows, LLC NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED 2. NEW EVIDENCE SUBMITTED A. DRAWINGS 1. Drawing No. W03-56, titled “Series-1000/1050 Alum. Single Hung Wdw. (L.M.I)”, sheets 1, 1.1, 2, 2.1 and 3 through 8 of 8, dated 07/31/03, with revision M, dated 07/17/20, prepared by Al-Farooq Corporation, signed and sealed by Jalal Farooq, P.E. B. TESTS 1. Test reports on: 1) Uniform Static Air Pressure Test, Loading per FBC TAS 202–94 2) Large Missile Impact Test per FBC, TAS 201–94 3) Cyclic Wind Pressure Loading per FBC, TAS 203–94 along with marked -up drawings and installation diagram of an aluminum single hung window, prepared by Fenestration Testing Laboratory, Inc., Test Report No. FTL-12222, dated 07/10/20, signed and sealed by Idalmis Ortega, P.E. C. CALCULATIONS 1. Anchor verification calculations and structural analysis, complying with FBC 7th Edition (2020), prepared by Al-Farooq Corporation, dated 07/2 4/20, signed and sealed by Jalal Farooq, P.E. 2. Glazing complies with ASTM E1300-09 D. QUALITY ASSURANCE 1. Miami-Dade Department of Regulatory and Economic Resources (RER) E. MATERIAL CERTIFICATIONS 1. Notice of Acceptance No. 18-0725.11 issued to Kuraray America, Inc. for their “Kuraray SentryGlas® XtraTM (SGX TM) Clear Glass Interlayer” dated 05/23/19, expiring on 05/23/24. 2. Notice of Acceptance No. 19-0305.02 issued to Kuraray America, Inc. for their “Trosifol® Ultraclear, Clear and Color PVB Glass Interlayers” dated 05/09/1 9, expiring on 07/08/24. F. STATEMENTS 1. Statement letter of conformance, complying with FBC 6th Edition (2017), with FBC 7th Edition (2020), and of no financial interest, dated July 24, 2020 , issued by Al-Farooq Corporation, signed and sealed by Jalal Farooq , P.E. G. OTHERS 1. Notice of Acceptance No. 18-0905.07, issued to E.S. Windows, LLC, for their Series “1000/1050” Aluminum Single Hung Window – L.M.I., approved on 10/04/18 and expiring on 11/06/23.