Loading...
HomeMy WebLinkAboutAPPROVED 21-0628.17 ES 6100 SGDNOA No. 21-0 628.17 Expiration Date: June 14, 2023 Approval Date: August 1 9, 20 21 Page 1 MI AMI -DADE COUNTY PRODUCT CONTROL SECTION 11805 SW 26 Street, Room 208 DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES (RER) Miami, Florida 33175-2474 BOARD AND CODE ADMINISTRATION DIVISION T (786) 315-2590 F (786) 315-2599 NOTICE OF ACCEPTANCE (NOA) www.miamidade.gov/economy E.S. Windows, LLC 10653 NE Quaybridge Ct. Miami, Fl.33138 S COPE: This NOA is being issued under the applicable rules and regulations governing the use of construction materials. The documentation submitted has been reviewed and accepted by Miami-Dade County RER -Product Control Section to be used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction (AHJ). This NOA shall not be valid after the expiration date stated below. The Miami-Dade County Product Control Section (In Miami Dade County) and/or the AHJ (in areas other than Miami Dade County) reserve the right to have this product or material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, the manufacturer will incur the expense of such testing and the AHJ may immediately revoke, modify, or suspend the use of such product or material within their jurisdiction. RER reserves the right to revoke this acceptance, if it is determined by Miami-Dade County Product Control Section that this product or material fails to meet the requirements of the applicable building code. This product is approved as described herein and has been designed to comply with the Florida Building Code, including the High Velocity Hurricane Zone. DESCRIPTION: Series “6100 ” Aluminum Sliding Glass Doors 2 -tracks (Wet glazed) w/ reinforcements-SMI APPROVAL DOCUMENT: Drawing No. W07-26 Rev O, titled “Series -6100 Alum Sliding Glass Door (SMI)”, sheets 1 through 12 of 12, prepared by Al-Farooq Corporation, dated 04 -04-07 and last revised on Jun 23, 2021, signed and sealed by Jalal Farooq, P.E., bearing the Miami-Dade County Product Control Revision stamp with the Notice of Acceptance number and expiration date by the Miami-Dade County Product Control Section. MISSILE IMPACT RATING: Small Missile Impact Resistant Limitations: 1.See Design Pressures (DP) Vs reinforcements & glazing options charts in sheets 3. 2.See Head/ sill anchors capacities charts in sheet 5. See Jambs anchor spacing Vs DP per sheet 1 . 3.Lower DP sheet 3 or anchor capacity chart, shall control for the entire system. 4.Glass lites wider than 36” shall have two setting blocks per FBC requirements. Max. 3/8” wide Alum spacer. 5.See approved configurations in sheet 2. Max. Door frame width not to exceed 192” and 120” frame height .LABELING: Each unit shall bear a permanent label with the manufacturer's name or logo, Barranquilla, Columbia and series and f ollowing statement: "Miami-Dade County Product Control Approved", noted herein. RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change in the applicable building code negatively affecting the performance of this product. TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the materials, use, and/or manufacture of the product or process. Misuse of this NOA as an endorsement of any product, for sale s, advertising or any other purposes shall automatically terminate this NOA. Failure to comply with any section of this NOA shall be cause for termination and removal of NOA. ADVERTISEMENT: The NOA number preceded by the words Miami-Dade County, Florida, a nd followed by the expiration date may be displayed in advertising literature. If any portion of the NOA is displayed, then it shall be done in its entirety. INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and shall be available for inspection at the job site at the request of the Building Official. This NOA revises NOA #18 -0129 .0 6 and consists of this page 1 and evidence pages E-1 , E-2, E-3 & E-4, as well as approval document mentioned above. The submitted documentation was reviewed by Ishaq I. Chanda, P.E. Ishaq I. Chanda, P.E. Product Contr ol Unit Superv isor NOA No. 21-0628.17 Expiration Date: June 14, 2023 Approval Date: August 1 9 , 20 21 E - 1 E.S. Windows, LLC NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED 1.Evidence submitted in previous files A. DRAWINGS 1. Manufacturer's die drawings and sections (Submitted under files referenced below ) 2. Drawing No. W07-26 Rev L, titled “Series -6100 Alum Sliding Glass Door (SMI)”, sheets 1 through 12 of 12, prepared by Al-Farooq Corporation, dated 04-04-07 and last revised on 12/14/15, signed and sealed by Javad Ahmad, P.E. B. TESTS 1. None. C. CALCULATIONS 1.Anchor verification calculations and structural analysis, complying with FBC-2014, 5th edition, prepared by Al Farooq Corporation, dated 12/21/15, 12/10/15, 08/13/15, signed and sealed by Javad Ahmad, P.E. 2.Glazing complies w/ ASTME-1300-02 , -04 & -09. D.QUALITY ASSURANCE 1. Miami Dade Department of Regulatory and Economic Resources (RER) E.MATERIAL CERTIFICATIONS 1.Notice of Acceptance No. 14-0916.11 issued to Kuraray America, Inc. for their “Sentry Glass ® (Clear and White) Glass Interlayers”, expiring on 07/04/18. 2.Notice of Acceptance No. 14-0916.10 issued to Kuraray America, Inc. for their “Butacite ® PVB Glass Interlayer”, expiring on 12/11/16. F.STATEMENTS 1.Statement letter of conformance to FBC 2014, 5th edition and letter of no financial interest, prepared by Al Farooq Corporation, dated 08/1 3/2015, signed and sealed by Javad Ahmad, P.E. 2.Lab compliance as part of the above referenced test report . G.OTHER 1.This NOA revises NOA #13-1008.04, expiring on 06/14/18 2.Evidence submitted in previous files A. DRAWINGS 1.Drawing No. W07-26 Rev I, titled “Series -6100 Alum Sliding Glass Door (SMI)”, sheets 1 through 12 of 12, prepared by Al-Farooq Corporation, dated 04-04-07 and last revised on MAR 10, 2014, signed and sealed by Javad Ahmad, P.E. B.TESTS (Submitted under files #13-1008.04/ #12-0223.45/ #09-1217.02) 1. Test reports on: 1) Air Infiltration Test, per FBC, TAS 202-94 2) Uniform Static Air Pressure Test, Loading per FBC TAS 202-94 3) Water Resistance Test, per FBC, TAS 202-94 4) Small Missile Impact Test per FBC, TAS 201 -94 5) Cyclic Wind Pressure Loading per FBC, TAS 203-94 6) Forced Entry Test, per FBC 2411 3.2.1, TAS 202-94 along with marked -up drawings and installation d iagram of OX aluminum sliding glass door, prepared by, prepared by Fenestration Testing Laboratories, Test Report No. FTL7572 (FTL 10384) dated 11/03/1 3, signed and sealed by Marlin D. Brinson, P.E. Ishaq I. Chanda, P.E. Product Contr ol Unit Superv isor NOA No. 21-0628.17 Expiration Date: June 14, 2023 Approval Date: August 1 9 , 20 21 E -2 E.S. Windows, LLC NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED B.TESTS (continue): 2. Test reports on: 1) Air Infiltration Test, per FBC, TAS 202-94 2) Uniform Static Air Pressure Test, Loading per FBC TAS 202-94 3) Water Resistance Test, per FBC, TAS 202-94 4) Small Missile Impact Test per FBC, TAS 201-94 5) Cyclic Wind Pressure Loading per FBC, TAS 203-94 6) Forced Entry Test, per FBC 2411 3.2.1, TAS 202-94 along with marked -up drawings and installation diagram of OXXX aluminum sliding glass door, prepared by, prepared by Fenestration Testing Laboratories, Test Report No. FTL- 6293 (FTL 10063), dated 10/15/10 and FTL- 5669 (FTL 08057), signed and sealed by Jorge A. Causo, P.E. and Michael Wenzel, P.E. respectively. (Submitted under files # 09-1217.02/#12-0223.45) 2.Ad d itional Test reports (transferred from file # 07-0828.08) 1) Air Infiltration Test, per FBC, TAS 202-94 2) Uniform Static Air Pressure Test, Loading per FBC TAS 202-94 3) Water Resistance Test, per FBC, TAS 202-94 4) Small Missile Impact Test per FBC, TAS 201-94 5) Cyclic Wind Pressure Loading per FBC, TAS 203-94 6) Forced Entry Test, per FBC 2411 3.2.1, TAS 202-94 Along with marked -up drawings and installation diagram of aluminum SGD, prepared by Fenestration Testing Laboratories, Test Report No. FTL- 5076(FTL06165), dated 02/22/07, FTL- 5157(FTL061116), dated 02/14/07 and FTL- 5158(FTL06115) dated 02/13/07, all signed and sealed by Michael Wenzel, P.E. (The test report No. FTL- 5076 has been revised an addendum let ter dated July 10, 2007, issued by Fenestration testing lab, signed & sealed by Carlos S. Roinda, P. E.) C. CALCULATIONS 1.Anchor verification calculations and structural analysis, complying with FBC-2010, prepared by Al Farooq Corporation, dated 03/06/14, signed and sealed by Javad Ahmad, P.E. 2.Glazing complies w/ ASTME-1300-02 , -04 & -09. D.QUALITY ASSURANCE 1. Miami Dade Department of Regulatory and Economic Resources (RER) E.MATERIAL CERTIFICATIONS 1.Notice of Acceptance No. 11-0624.02 issued t o E.I. DuPont De Nemours & Co., Inc. for their “DuPont Sentry Glass ® Interlayer”, expiring on 01/14/17. 2.Notice of Acceptance No. 11-0624.01 issued to E.I. DuPont De Nemours & Co., Inc. for their “DuPont Butacite PVB ® Interlayer”, expiring on 12/11/16. F.STATEMENTS 1.Statement letter of conformance to FBC 2010 and letter of no financial interest, prepared by Al Farooq Corporation, dated 10/02/13, signed and sealed by Javad Ahmad, P.E. 2.Lab compliance as part of the above referenced test report. Ishaq I. Chanda, P.E. Product Contr ol Unit Superv isor NOA No. 21-0628.17 Expiration Date: June 14, 2023 Approval Date: August 1 9 , 20 21 E - 3 E.S. Windows, LLC NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED F.STATEMENTS (continue) 3. E-mail dated Nov 14, 2013, issued by Fenestration Testing Lab for Test report # FTL 6293 for part# ES-6023 height confirmation being 3.5”, signed by Ms. Lliana Sanchez. 4.Distribution agreement dated 03/05/14 between ES Windows, LLC and Energia Solar SA, Colombia, signed by Andres Chamorro (Gen MGR) and Clara Garcia (Sales MGR), respectively on behalf of their companies G.OTHER 1.This NOA revises & renews NOA # 09-121 7.02 & 12 -0223.45, expiring on 06/14/14 . 2.Test proposals, # 11-0843 dated July 20, 2011, # 10-0466, dated 07-04-10, # 08-0847, dated 06- 24-08 and # 06-0305, dated 07/18/06 approved by BCCO. 3.Additional reference NOA file # 13-1007.03 (Series 6100 Alum SGD w/ reinf (Dry glazed)). 4.Previous associated NOA(s) files are #12-0223.45, #09-1217.02, #07-0828.08 and #07-0411.12. 3.Evidence submitted under previous approval. A. DRAWINGS 1. Drawing No. W07-26 Rev N, titled “Series -6100 Alum Sliding Glass Door (SMI)”, sheets 1 through 12 of 12, prepared by Al-Farooq Corporation, dated 04-04-07 and last revised on SEP 04, 2018, signed and sealed by Javad Ahmad, P.E. B.Test 1. None. C. CALCULATIONS 1.Anchor verification calculations and structural analysis, complying with FBC-2010, prepared by Al Farooq Corporation, dated 03/06/14, signed and sealed by Javad Ahmad, P.E. D.QUALITY ASSURANCE 1.Miami Dade Department of Regulatory and Economic Resources (RER) E.MATERIAL CERTIFICATIONS 1. Notice of Acceptance No. 17-0808.02 issued to Kuraray America, Inc. (Former E.I. DuPont DE Nemours) for the “Sentry Glass ® clear & white interlayer”, expiring on 07/04/23. 2.Notice of Acceptance No. 16-1117.01 issued to Kuraray America., Inc. for their “Trosifol ® Ultraclear, Clear and Color PVB Glass Interlayers”, expiring on 07/08/19. F.STATEMENTS 1.Statement letter of conformance to FBC 2017 (6th Edition) and “No financial interest” dated 01/12/18, prepared by the manufacturer, signed and sealed by Javad Ahmad , P.E. G.OT HER 1.This NOA revises & renews NOA(s) #15-0430.02 (#13-1008.04), expiring 06/14/2023. Ishaq I. Chanda, P.E. Product Contr ol Unit Superv isor NOA No. 21-0628.17 Expiration Date: June 14, 2023 Approval Date: August 1 9 , 20 21 E - 4 E.S. Windows, LLC NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED 4.New Evidence submitted. A. DRAWINGS 1. Drawing No. W07-26 Rev O, titled “Series -6100 Alum Sliding Glass Door (SMI)”, sheets 1 through 12 of 12, prepared by Al-Farooq Corporation, dated 04-04-07 and last revised on Jun 23, 2021, signed and sealed by Jalal Farooq, P.E. B.Test 1. None. C. CALCULATIONS 1.Anchor verification calculations and structural analysis, complying with FBC-2020, prepared by Al Farooq Corporation, dated May 17, 2021, signed and sealed by Jalal Farooq, P.E. D.QUALITY ASSURANCE 1.Miami Dade Department of Regulatory and Economic Resources (RER). E.MATERIAL CERTIFICATIONS 1. Notice of Acceptance No. 17-0808.02 issued to Kuraray America, Inc. (Former E.I. DuPont DE Nemours) for the “Sentry Glass ® clear & white interlayer”, expiring on 07/04/23. 2.Notice of Acceptance No. 20-0915.22 issued to Kuraray America, Inc. for their “Trosifol® Ultraclear, Clear and Color PVB Glass Interlayers”, expiring on 07/08/24. F.STATEMENTS 1.Statement letter of conformance to FBC 2020 (7th Edition) and “No financial interest” dated 05/17/21, prepared by the manufacturer, signed and sealed by Jalal Farooq, P.E. G.OTHER 1.This NOA revises #18-0 129 .0 6, expiring 06/14/2023.