No preview available
HomeMy WebLinkAboutEvaluation ReportNEMO I etc. Certificate of Authorization #32455 353 Christian Street, Unit #13 Oxford, CT 06478 (203) 262-9245 ENGINEER EVALUATE TEST CONSULT EVALUATION I REPORT Owens Corning Evaluation Report 037940.02.12-1111' One Owens Corning Parkway FL10674-1116', Toledo, OH 43659 Date of Issuance: 02/06/2012 (740) 404-7829 Revision 11: 12/11/2020' SCOPE: This Evaluation Report is issued under Rule 61G20-3 and the applicable rules and regulations governing the use of construction materials in the State of Florida.lThe documentation submitted has been reviewed by Robert Nieminen, P.E. for use of the product under the Florida! Building Code. The product described herein has been evaluated for compliance with the 7th Edition (2020) Florida Building Code sections noted herein. DESCRIPTION Oweris.;Corning Asphalt Roof Shingles LABELING: Labeling shall be in accordance with the requirements of the Accredited Quality Assurance Agency noted herein and FBC 1507.2.7.1 / R905.2.6.1 CONTINUED COMPLIANCE: This Evaluation Report' is valid until such time as the named product(s) changes, the referenced Quality Assurance or production facility locati'on(s) changes, or Code provisions that relate to the product(s) change. Acceptance of our Evaluation Reports by the named client constitutes agreement to notify NEMO ETC, LLC of any changes to the product(s), the Quality Assurance or the production facility location(s). NEW ETC, LLC requires a complete review of its Evaluation Report relative to updated Code requirements with each Code Cycle. ADVERTISEMENT: The Florida Product Approval Number (FL#) preceded by the words "NEMO I etc. Evaluated" may be displayed in advertising literature. If any potion of the Evaluation Report is displayed, then it shall be done in its entirety. INSPECTION: Upon request, a copy of this entire Evaluation Report shall be provided to the user by the manufacturer or its distributors and shall be available for inspetion at the job site at the request of the Building Official. This Evaluation Report consists of pages 1 through 10. Prepared by: Robert J.M. Nieminen P.E. The facsimile seal appearing was authorized by Robert '+.;°S%"a?• r' Nieminen, P.E. on 12/11/2020. This does not serve as an Florida Registration No. 59166, Florida DCA ANE1983 ":!d••'.+'' electronically signed document. CERTIFICATION OF INDEPENDENCE: 1. NEMO ETC, LLC does not have, nor does it intend to acquire or will it acquire, a financial interest in any company manufacturing or distributing products it evaluates. 2. NEMO ETC, LLC is not owned, operated or controlled by any company manufacturing or distributing products it evaluates. 3. Robert Nieminen, P.E. does not have nor will acquire, a financial interest in any company manufacturing or distributing products for which the evaluation reports are being issued. j 4. 'Robert Nieminen, P.E. does not have, nor will acquire, a financial interest in any other entity involved in the approval process of the product. S. This is a building code evaluation. Neither NEMO ETC, LLC nor Robert Nieminen, P.E. are, in any way, the Designer of Record for any project on which this Evaluation Report, or previous versions thereof, is/was used for permitting or design guidance unless retained specifically for that'purpose. ©2018 N E M 0 ETC, LLC ONEMO I etc. ROOFING SYSTEMS EVALUATION: Product Category: Roofing ' Sub -Category: Asphalt Shingles Compliance Statement: Owens Corning Asphalt Roof Shingles, as produced by Owens Corning, have demonstrated compliance with the following sections of the 7th Edition (2020) Florida Building Code through testing in accordance with the following Standards. Compliance is subject to the Installation Requirements and Limitations / Conditions of Use set forth' herein. Section 1507.2.4, R905.2.3 1507.2.5, R905.2.4 1507.2.7.1, R905.2.6.1 1507.2.7.1, R905.2.6.1 90titt Owens Corning PRI(TST5878) UL LLC (CER9626) UL LLC (CER9626) UL LLC (TST9628) UL LLC (TST9628) UL LLC (TST9628) UL LLC (TST9628) UL LLC (TST9628) UL LLC (TST9628) PRI (QUA9110) PRI (QUA9110) Pro e Physical Properti Material standar Wind Resistance Wind Resistance Declaration , ASTM D1976 i Physicals & Wind Resistance Physicals & Wind Resistance Physical Properties Wind Resistance Physicals & Wind Resistance Wind Resistance Physical Properties Physical Properties Quality Control Quality Coni.rol Standard ASTM D1970 ASTM D3462 ASTM D3161 ASTM D7158 Reference Equivalency Declaration OCF-382-02-01 File R2453, Vol. 3 20120516-112453 06CA20263 11CA34308 4786093137 4786126532 Classification letter Classification letter Service Confirmation Florida BCIS Year 2015 2010 2016 2019 Date 08/06/2019 10/24/2017 02/15/2007 05/16/2012 04/18/2006 02/18/2012 02/01/2014 02/10/2014 02/13/2014 10/02/2015 04/05/2020 Current TABL O 1. ASPHALT SHINGLE COMPONENTS Type Product Plant(s) Material Standard Description Starter Strip Shingle H-TX, OR Starter Strip Plus MN, OR Accessory ASTM D3462 starter strips for asphalt roof shingles SRS TopShield Starter MN, OR Starter Strips Starter Shingle Roll NH ASTM D1970 mineral -surfaced, fiberglass -reinforced, self -adhering SBS modified bitumen starter Supreme° GA, CA, CO, I -TX, NJ, OH, ASTM D3462 fiberglass reinforced 3-tab asphalt TN, OR, IL roof shingles Berkshire' MN ASTM D3462 fiberglass reinforced, 4-tab asphalt roof shingles Duration' Premium CA, OR Duration' Premium COOL CA Asphalt TruDefinition° Duration' Shingles IN, C�, CO,_1-TX, FL, NJ, OH, TruDefinition° Duration° N OR, GA, IL, TN fiberglass reinforced, laminated Designer Color Collection I ASTM D3462 asphalt roof shingles Oakridge° GA, Ill, CA, CO, H-TX, I -TX, FL, NJ OH, TN TruDefinition° Oakridge H-TX, I -TX WeatherGuard° HP j TN NEMO ETC, LLC Evaluation Report 037940.02.12-1131 Certificate of Authorization #32455 fH EDITION (2020) FBC NON-HVHZ EVALUATION F1.10674-1116 Owensi Corning Asphalt Roof Shingles Revision 21:12/11/2020 Page Z of 10 ONEMOletc. TABL 4',1: ASPHALT SHINGLE COMPONENTS t Type Product Plant(s) MaterialStandard Description Berkshire' Hip and Ridge MN Shingles with Sealant DuraRidge® Hip and Ridge MN Hip and fiberglass reinforced, hip and ridge Ridge Shingles with Sealant ASTM D3462 asphalt roof. shingles ProEdge® ;GA, CA, OH, OR Shingles WeatherGuard® HP Hip and j TN Ridge Shingles I 5.1 This is a building code evaluation. Neither MEMO ETC, LLC nor Robert Nieminen, P.E. are, in any way, the Designer of Record for any project on which this Evaluation Report, or previous versions thereof, is/was used for permitting or design guidance unless retained specifically for that purpose. 5.2 This Evaluation Report is not for use in 1FBC High Velocity Hurricane Zone jurisdictions (i.e., Broward and Miami - Dade Counties). 5.3 This Evaluation Report pertains to above -deck roof components. Roof decks and structural members shall be in accordance with FBC requirements to the satisfaction of the Authority Having Jurisdiction. 5.4 This Evaluation Report does not include; evaluation of fire classification. Refer to FBC 1505 for requirements and limitations regarding roof assembly fire classification. Refer to FBC 2603 for requirements and limitations concerning the use of foam plastic insulation. 5_5 Wind Classification: Refer to Section 6 for installation requirements to meet wind classifications TABLE 24:, WIND CLASSIFICATIONS, ASPHALT SHINGLES, Product FBC Table 1507.2.7.1 orR905.2.6.1 Supreme' ASTM D3161(F) & ASTM D7158(H) Berkshire" I Duration® Premium Duration' Premium COOL i TruDefinition° Duration® TruDefinition® Duration' Designer Color Collection Oakridge° TruDefinition' Oakridge° WeatherGuard® HP 5.5.1 Classification by ASTM D7158: ASTM D7158, Class H applies only to exposure category B or C and a building height of 60 feet or less. Calculations by a qualified design professional arel required for conditions outside these limitations. Contact the shingle manufacturer for data specific to each shingle. NEMO ETC, LLC Evaluation Report 037940.02.12-1111 Certificate of Authorization #32455 7N EDITION J2020) FBC NON-HVHZ EVALUATION FL10674-1116 Owens! corning Asphalt Roof Shingles Revision 11: 12/11/2020 Page 3 of 10 ONEMOletc. TABLE;P-,,WIND-CLASSIFICATIONS, STARTER STRIPS AND HIP &'RIDGE Type Product FBC Table 1507.2.7.1 or R905.2.6.1 Starter Strips Starter Strip Shingle ASTM D3161, Class F Starter Strip Plus SRS TopShield Starter Hip,& Ridge Shingles Berkshire' Hip and Ridge Shingles with Sealant ASTM D3161, Class F DuraRidge® Hip and Ridge Shingles with Sealant ProEdge® WeatherGuard' HP Hip and Ridge Shingles 5.5.2 Refer to Owens Corning published inforYnation on wind resistance and installation limitations. 5.6 All components in the roof assembly shall have quality assurance audit in accordance with F.A.C. Rule 61G20-3. Refer to the Product Approval of the component manufacturer for components that are produced by a Product Manufacturer other than the report holder on Page 1 of this Evaluation Report. 6. INSTALLATION: 6.1 GENERAL: 6.1.1 Roof deck, slope, underlayment and, fasteners shall comply with FBC 1507.2 / R905.2 and the shingle manufacturer's minimum requirementsl. 6.1.2 Underlayment shall be acceptable to the shingle manufacturer and shall hold current Florida Statewide Product Approval, or be Locally Approved per R l le 61G20-3, per FBC Sections 1507.2.3, 1507.2.4 or R905.2.3. 6.1.3 Fasteners shall be in accordance with the shingle manufacturer's published requirements, but not less than FBC 1507.2.6 or R905.2.5. Staples are not permitted. 6.1.4 Owens Corning asphalt shingles are acceptable for use in reroof (tear -off) or recover applications, subject to the limitations set forth in FBC Section 1511 or R908 and published installation instructions. 6.2 ACCESSORY STARTERS: 6.2.1 Installation of Starter Strip Shingle, Starter Strip Plus and SRS TopShield Starter shall comply with the Owens Corning current published instructions, (using minimum five (5) nails per strip. Felt rmdedayment 2"Ll" from eave Install fast Self-sealing adhesive Starter Strip positioned along eave shingle with 5'remaved Starter Strip shingle overhangs eaves end Les W'-VP Figure 1: Minimum Nailing, Starter Strip Figure 2: Minimum Nailing, Starter Strip Plus NEMO ETC, LLC I Evaluation Report 037940.02.12-Rll Certificate of Authorization #32455 7T" EDITION (2020) FBC NON-HVHZ EVALUATION FL10674-R16 Owens Corning Asphalt Roof Shingles Revision 11: 12/11/2020 j Page 4 of 10 ONEMO etc. 6.2.2 Installation of Starter Shingle Roll shiall comply with the Owens Corning current published instructions. Deck Underlayment Drip edge Drip edge Starter Shingle Roll adhered directly to underayment and primed drip edge Self-sealing adhesive positioned along eaves Figure 3: Starter Shingle Roll 6.3 ASPHALTSHINGLES: 6.3.1 Installation of asphalt shingles shall comply with the Owens Corning current published instructions, using minimum four (4) nails per shingle in I accordance with FBC 1507.2.7 or R905.2.6, with the following exceptions: ➢ Berkshire® shingles require minimum five (5) nails per shingle. ➢ WeatherGuard® HP shingles require minimum six (6) nails per shingle. Where the roof slope exceeds 21 units vertical in 12 units horizontal, special methods of fastening are required Refer to Owens Corning published information on wind resistance and installation limitations. 6.3.1.1 Supreme: Normal Mansard or Area pare Wind Areas High Wind dosvanes y Area pare vientos normales Areas vientos fuertes I 5" Exposure Exposicinn Figure 4: Minimum Nailing, Supreme (Standard Size) I Normal Mansard or Area pare Wind Areas High Wind desvenes y Area pare vientos norma►es Areas vientos fuerres V (A) 121 t• r1. 2" (BI f-2. 1" 5 51a' Exposure Exposielon Figure 5: Minimum Nailing, Supreme (Metric Size) NEMO ETC, LLC Evaluation Report 037940.02.12-Rll Certificate of Authorization #32455 1T" EDITION (2020) FBC NON-HVHZ EVALUATION FL10674-R16 Owens! Corning Asphalt Roof Shingles Revision 11: 12/11/2020 Page 5 of 10 i i ONEMOjetc. 6.3.1.2 BerkshireO: i Sealant strip Latin de sefiadnr 8 v2" I 9 vs" I 9 vi' I 1" i Figure 6: S-Nail Pattern, Berkshire t t t Z.. xspnaR reonny .Emenr Gemento de Webb de astalto Figure 8: Mansard or Steep Slope Pattern, Berkshire vz" i-egure /: b-Nall varxern, rserKsnire MEMO ETC, LLC Evaluation Report 037940.02.12-1111 Certificate of Authorization #32455 71" EDITION (2020) FBC NON-HVHZ EVALUATION FL10674-1116 Owens Corning Asphalt Roof Shingles Revision 11: 12/11/2020 Page 6 of 10 6.3.1.3 Collection: NEW ETC, LLC Certificate of Authorization #32455 SMEMO jetc. 4-Nail Fastening Pattern u.reNaiWD fastening area width Hail"Typical 1211 12" CMW I Figure 9: Standard 4-Nail Pattern, Duration 6-NMI Fastening Pattern SureN - ailotasteningweawidth NMI, Typical 127 rt F; Figure 10: 6-Nail Pattern, Duration Fastening for Slopes Greater Than 21:12 SureNail@ fastening area width Nail Typical 11211 12" J 5.518" Four 111 Spots of Asphalt Roofing Cement Figure il-. Mansard or Steep Slope Pattern, Duration i Evaluation Report 037940.0112-1112 1TH EDITIONJ(2020) FBC NON-HVHZ EVALUATION FI.10674-1116 I Owens Corning Asphalt Roof Shingles Revision 11: 12/11/2020 Page 7 of 30 6.3.1.4 TruDefinii 4 Nail Pattern Esquefna con 4 clavos 5SW Exposure N-4I I Fxposiddinde55/8putg. clavos Figure 12: Standard 4-Nail Pattern, 6.3.1.5 WeatherGuard® HP: pn de 6618 ping. i 6 Nail Pattern Esquema con S clavos I'r Q° — 55/9" Exposure Exposfi:r6n de 55LSpulg fONEMOjetc. {4F— 12" 1"_I i 5 618" Exposure Exxposwh de 5SIB pu1p Figure 13: 6-Nail Pattern, Oakridge Fastening for Slopes Greater Than 21:12 SureNail© fastening area width Nail,lyplcal 1" 12" I_ qZ" I � —� -.�aOcmnino5l�.,r ";'•";'�. ans'm+!u,PJ smao:. .�.' 7 •"O.ni°ComS�Y.: 5518" � I I Four 1" Spots of Asphalt Roofing Cement 12" 1 Figure 14: Mansard or Steep -Slope Pattern, Oakridge 6 Na11 Pattern Esquema con 6 clavos Anil 6118" from bottom of shingle Dave a 6 1!8 pping. de la 5 518" Exposure 6 Fasteners parte inferior de E t4a Expirsiciun de 5 518 ping. 6 sujet�lares I " 1 plg w� Itf�ilg i 1 • • • 1tW� • — In Mai K"5 5t$° Er�lm 5 51$" asufl 44. dio 5 O ping E+dcibri do s ping. Figure 15: 6-Nail Pattern, WeatherGuard HP I NEMO ETC, LLC Certificate of Authorization #32455 Four 1 " Spats -of Asphalt Roof Cement Cum Fmmw do cemento de tedro de asfalto de 1 p*da Figure 16: Mansard or Steep -Slope Pattern, WeatherGuard HP 7T" EDITION�(2020) FBC NON-HVHZ EVALUATION Owen Corning Asphalt Roof Shingles Evaluation Report 037940.02.12-1111 FL10674-1116 Revision 11: 12/11/2020 Page 9 of 10 ONEMOletc. 6.4 HIP AND RIDGE SHINGLES: 6.4.1 Installation of asphalt shingles shall comply with the Owens Corning current published instructions. ➢ Berkshire® Hip and Ridge Shingles with Sealant and DuraRidge° Hip and Ridge Shingles with Sealant require minimum two (2) nails per shingle. ➢ WeatherGuard® HP Hip and Ridge Shingles and ProEdge® require minimum four (4) nails per shingle. Refer to Owens Corning published information on wind resistance and installation limitations. 6.4.1.1 Berkshire° Hip and Ridge with Sealant and DuraRidge® Hip and Ridge Shingles with Sealant: Fig. A Prevailing Wind Direction 4 Direccon del viento predominante P Figure 17: Isometric View, Berkshire and 6.4.1.2 WeatherGuard® HP Hip and Ridge Shingles: Fig. A 4 41 Prevalling Wind �— Dlnxilon A Nails q q I I A it A 44 I I I I j j A I I I I 6" Exposure Figure 19: Isometric View, WeatherGuard HP Hip and Ridge rigure its: clan view, oericsnire anu uura1%1ugc Fig. C Hip & Ridge Shingle Fastening Top V lew Nails Nails 7" 2" 2" V �y Exposure Figure 20: Plan View, WeatherGuard HP Hip and Ridge NEW ETC, LLC Evaluation Report 037940.02.12-1111 Certificate of Authorization #32455 7T" EDITION (2020) FBC NON-HVHZ EVALUATION F1.10674-1116 Owens Corning Asphalt Roof Shingles Revision 11:12/11/20ZO Page 9 of 10