HomeMy WebLinkAbout16ft wide +48-52 M MIAMI-DADE COUNTY
rimn PRODUCT CONTROL SECTION
11805 SW 26 Street,Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(RER) Miami,Florida 33175-2474
BOARD AND CODE ADMINISTRATION DIVISION T(786)315-2590 F(786)315-2599
NOTICE OF ACCEPTANCE(NOA) www.miamidade.eov/economy
DAB Door Company,Inc.
12195 NW 981'Avenue
Hialeah Gardens,FL 33018
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction materials.The
documentation submitted has been reviewed and accepted by Miami-Dade County RER-Product Control Section to be
used in Miami-Dade County and otherareaswhere allowed by the Authority HavingJurisdiction (AHJ).
This NOA shall notbe valid afterthe expiration date stated below.The Miami-Dade County Product Control Section (In
Miami-Dade County)and/orthe AHJ(in areas otherthan Miami-Dade County)reserve the right to havethis product or
material tested for quality assurance purposes.If this product or material fails to perform in the accepted manner,the
m a nufacturer will incur the expense of such testing and the AHJ may immediately revoke,modify,or suspend the use o f
such product or material within their jurisdiction. RER reserves the right to revoke this acceptance,if it is determined
by Miami-Dade County Product Control Section that this product or material fails to meet the requirements of the
applicablebuilding code.
This product is approved as described herein and has been designed to comply with the Florida Building Code,including
the High Velocity Hurricane Zone.
DESCRIPTION:Hurricane Master Model 824/811 Steel Sectional Garage Door up to 16ft:2in. Wide
w/Window Lite Option(DP+48.0,—52.0 PSF)
APPROVAL DOCUMENT: Drawing No. 98-05, titled 1124 GA. Roll Formed Steel Sectional Garage
Door",dated 02/23/1998,with revision N dated 07/20/2020,sheets 1 through 6 of 6,prepared by Al-Farooq
Corporation, signed and sealed by Jalal Farooq, P.E., bearing the Miami-Dade County Product Control
renewal stamp with the Notice of Acceptance number and expiration date by the Miami-Dade County
Product Control Section.
MISSILE IMPACT RATING:Large and Small Missile Impact Resistant
LABELING:A permanent label with the manufacturer's name or logo,manufacturing address,model/series
number,the positive andnegative design pressure rating,indicate impact rated if applicable, installation
instruction drawing reference number, approval number (NOA), the applicable test standards, and the
statement reading`Miami-Dade County Product Control Approved'is to be located on the door's side track,
bottom angle,or inner surface of a panel.
RENEWAL of this NOA shallbe considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials,use,and/or manufacture of the product or process.Misuse of this NOA as an endorsement of any product,fo r
sales,advertising or any other purposes shall automatically terminate this NOA. Failure to comply with any section of
thisNOA shall because for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami-Dade County,Florida,and followed by the
expiration date maybe displayed in advertising literature. If any portion of the NOA is displayed,then it shall be done
in its entirety.
INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official.
This NOA revises NOA#20-0107.05 and consists of this page 1 and evidence pages E-1,E-2,E-3 and E-4,
as well as approval document mentioned above.
The submitted documentation was reviewed by Carlos M.Utrera,P.E.
NOA-No. 20-0901.24
Expiration Date:July 21,2025
Approval Date: December 03,2020
Page 1
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
1. EVIDENCE SUBMITTED IN PREVIOUS FILES
A. DRAWINGS
1. Drawing No. 98-05, titled "24 GA. Roll Formed Steel Sectional Garage Door", dated
02/23/1998,with lastrevisionL dated03/05/2015,sheets 1 through 6 of 6, prepared by A1-
Farooq Corporation,signed and sealed by Javad Ahmad,P.E.
B. TESTS "Submitted under NOA#11-0414.13"
1. Test Report on Uniform Static Air Pressure Test,Loading and Forced Entry Test per FBC,
TAS 202-94, of "DAB 824 Sectional Residential Garage Door" prepared by Hurricane
Engineering&Testing Inc.,Report No.HETI-07-4267,dated 06/29/2007,signed and sealed
by Candido F.Font,P.E.
2. Test Report on Large Missile Impact Test per FBC,TAS 201-94 and Cyclic Wind Pressure
Test per FBC,TAS 203-94,of"DAB 824 Sectional Residential Garage Door", prepared by
Hurricane Engineering&Testing Inc.,Report No.HETI-11-3206,dated 02/10/2011, signed
and sealed by Candido F.Font,P.E.
3. Test Report on Tensile Test perASTM E8-08 of"Sectional Residential Door(skin)",prepared
by Hurricane Engineering & Testing Inc, Report No. HETI-11-T101, dated 01/29/2011,
signed and sealed by Candido F.Font,P.E.
"Submitted under NOA#05-0217.02"
4. Test Report on Large Missile Impact Test and Cyclic Wind Pressure Test, of"Sectional
Residential Door with Windows"prepared by Hurricane Engineering&Testing Inc., Test
Report No.HETI 03-1328,dated 07/15/2003,signed and sealed by Rafael E.Droz-Sella,PE.
5. Test Report on Uniform Static Air Pressure Test,of"Sectional Residential Door"prepared by
Hurricane Engineering&Testing Inc.,Test Report No.HETI 03-13 29, d ate d 0 7/15/200 3
signed and sealed by Rafael E.Droz-Sella,P.E.
6. Test Report on Tensile Test per ASTM E-8 of"Sectional Residential Door(skin)"prepared by
Hurricane Engineering&Testing Inc,Test Report No.HETI03-T078, dated 10/31/2003,
signed and sealed by Rafael E.Droz-Seda,P.E.
"Submitted under NOA#03-0210.04"
7. Test report on Salt Spray(Corrosion)Test per ASTM B 117 of a painted G-40 stee 1 panels,
prepared by Celotex Corporation,Test Report No.258592,dated 08/17/1998,signed by W.A.
Jackson,P.E.
C. CALCULATIONS "Submitted under NOA#14-0814.08"
1. Anchor verification calculations prepared by Al-Farooq Corporation,dated 09/22/2014 and
07/24/2014,signed and sealed by Javad Ahmad,P.E.
Carlos M.Utrera, P.E.
Product Control Examiner
NOA-No. 20-0901.24
Expiration Date:July 21,2025
Approval Date: December 03,2020
E-1
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
C. CALCULATIONS(Cont.)"Submitted underNOA#09-0128.01"
2. Anchor verification calculations prepared by Al-Farooq Corporation,complying with F.B.C
2007,dated04/05/2011,signed and sealed by Javad Ahmad,P.E.
"Submitted under NOA#09-0128.01"
3. Anchor verification calculations prepared by Al-Farooq Corporation,complying with F.B.C
2007,dated 12/18/2008,signed and sealed by Humayoun Farooq,P.E.
D. QUALITY ASSURANCE
1. Miami-Dade Department of Regulatory and Economic Resources(RER).
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No.13-0717.01,issuedto SABIC Innovative Plastics,for their Lexan
Sheet Products,approved on 11/28/2013 and expiring on 07/17/2018.
2. Notice of Acceptance No. 14-0311.08, issued to Insulfoam, LLC, for their Insulfoam
Expanded Polystyrene Insulation,approved on 08/14/2014 and expiring on 11/29/2017.
3. Notice of Acceptance No.11-0926.07,issuedto Dyplast Products,LLC,for their Expanded
Polystyrene Block Type Insulation,approvedon 11/10/2011 and expiringon 01/11/2017.
4. Notice of Acceptance No.11-0926.06,issuedto Dyplast Products, LLC, for their Dyplast
ISO-CI Polyisocyanurate Insulation,approved on 11/10/2011 and expiring on 01/11/2017.
5. Notice of Acceptance No. 10-1129.04, issued to Cellofoam North America Inc, for their
Expanded Polystyrene Block Insulation,approved on 02/24/2011 and expiring on 02/24/2016.
"Submitted under NOA#05-0228.02"
6. Test Report on Accelerated Weathering Using Xenon Arc Light Apparatus Test per ASTM
G155 of"PVC Extrusion Material', prepared by Hurricane Engineering & Testing, Inc.,
Report No.HETI 04-A002,dated 09/27/2004,signed and sealed by Rafael E.Droz-Seda,P.E.
7. Test Reports on Tensile Test per ASTM D638 of"PVC Extrusion Material',prepared by
Hurricane Engineering&Testing Inc.,Report No.HETI 04-T251,dated 11/29/2004 signed
and sealed by 1.Ghia,P.E.
8. Test Report on Self-Ignition Temperature Test,Rate of Burn Test and Smoke Density Test o f
"REHAU non-foam PVC extrusion material",prepared by ETC Laboratories,Report No. 04-
761-15019.0,dated 05/06/2004,signed and sealed by J.L.Doldan,P.E.
F. STATEMENTS "Submitted under NOA#14-0814.08"
1. Statement letter of code conformance to the 51 edition(2014)FBC and no financial interest
issued by Al-Farooq Corporation,dated 05/13/2014,signed and sealed by Javad Ahmad,P.E.
Aknli
Carlos M.Utrera, P.E.
Product Control Examiner
NOA-No. 20-0901.24
Expiration Date:July 21,2025
Approval Date: December 03,2020
E-2
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE:EVIDENCE SUB
2. EVIDENCE SUBMITTED IN PREVIOUS NOA#20-0107.05
A. DRAWINGS "Submitted under NOA #17-1018.11"
1. Drawing No. 98-05, titled "24 GA. Roll Formed Steel Sectional Garage Door", dated
02/23/1998, with revision M dated 10/03/2017, sheets 1 through 6 of 6, prepared by
AI-Farooq Corporation, signed and sealed by Javad Ahmad, P.E.
B. TESTS
1. None.
C. CALCULATIONS
1. None.
D. QUALITY ASSURANCE
1. Miami Dade Department of Regulatory and Economic Resources (RER).
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 17-0221.06, issued to Insulfoam, LLC,for their Insulfoam
Expanded Polystyrene Insulation, expiring on 11/29/2022.
2. Notice of Acceptance No. 16-1108.04, issued to Dyplast Products, LLC, for their
Dyplast ISO-CI Polyisocyanurate Insulation, expiring on 01/11/2022.
3. Notice of Acceptance No. 15-1203.04, issued to Cellofoam North America Inc, for
their Expanded Polystyrene Block Insulation, expiring on 02/24/2021.
4. Notice of Acceptance No.15-0915.08,issued to SABIC Innovative Plastics,for their Lexan
Sheet Products,expiring on 07/17/2018.
F. STATEMENTS
1. Statement letter of code conformance to the 6th edition (2017) FBC, prepared by Al
Farooq Corporation, dated 12/23/2019,signed and sealed by Javad Ahmad,P.E.
G. OTHER
1. This NOA renews NOA#17-1018.11.
Carlos M.Utrera, P.E.
Product Control Examiner
NOA-No. 20-0901.24
Expiration Date: July 21,2025
Approval Date: December 03,2020
E-3
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
3. NEW EVIDENCE SUBMITTED
A. DRAWINGS
1. Drawing No. 98-05, titled "24 GA. Roll Formed Steel Sectional Garage Door", dated
02/23/1998, with revision N dated 07/20/2020, sheets 1 through 6 of 6,prepared by Al-
Farooq Corporation, dated 11/16/2020,signed and sealed by Mal Farooq, P.E.
B. TESTS
1. None.
C. CALCULATIONS
1. None.
D. QUALITY ASSURANCE
1. Miami Dade Department of Regulatory and Economic Resources(RER).
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 194129.06, issued to Insulfoam, LLC, for their Insulfoam
Expanded Polystyrene Preformed Block Type I Insulation, expiring on 11/29/2022.
2. Notice of Acceptance No. 17-1207.04, issued to Dyplast Products, LLC, for their
Dyplast ISO-CI Polyisocyanurate Rigid Foam Insulation, expiring on 01/11/2022.
3. Notice of Acceptance No. 18-0918.06, issued to Plaskolite, LLC, for their TUFFAK
Polycarbonate Sheets,approved on 01/15/2018 and expiring on 8/27/2022.
F. STATEMENTS
1. Letter of conformance to FBC 2020 (7th Edition) and FBC 2017 (6th Edition),
prepared by Al Farooq Corporation, dated 07/15/2020, signed and sealed by Jalal
Farooq,P.E.
Carlos M.Utrera, P.E.
Product Control Examiner
NOA-No. 20-0901.24
Expiration Date:July 21,2025
Approval Date: December 03,2020
E-4
JBJ 0L0Z OL 031VOM ¢2.0L"G0 H (1
6rOS0-B6 3` `J ,� ZGL6-L9£ (SO£) Xed 91OZ-L9Z (008) 761 o - "ta''w' 8 d
YL68N.'9L(4O8)'Xtl! Otm Se(SOE)naL `SUapJD Da DI .�„d GtOZ 0[031YOM [t'500+ % c
860�£ 'Id 9 4 H ( o
J.x;ta sMi 3erma o%k_._ €'roto i : auv[ ..tq ..p
(asss N ral ecies vcuaold'Ewmw an Vµ_. _.__. — � .-
?! V 4}66 �M'N 961Zt [xis st€u 3�%.++a o%� at-to et u '
ozz 31lns'3o%wa J3sNns Ores 'oul 1,UALuoO food gya 0 "; OD
1Nawdalm3a ioncoud v Sa33NIDN3 __ -_ - __- I ubl tJ082 Z D OU --� � b
�.. NOLLVt�OdtiOo b00?11V�-IV }J'�1a 39V2 J 1dN011035 13315 03172bj-nob N �Z;
l _
cao swat s rryt >
1HJI3i aDoo.D-.et /yi_„�.,
z i 114013H i1000.0-,8
.tz w � �� 8g � s: '.�j r
yy�� dd
a WWWW o� JJ tf111W
Z.i
AW5
lit
m
Ccj
iL
N(NFO�D2syN�m�z0$LL�
c W�mWa
6rW 1,1 YmX
Za< N
oF Y(�
13
OgwO�cO�JW�
.
`LC'mow\cl'\
®A
—_�nODE�
6
VW2 0�Z T
13
O ° /~ O® l
133
Vohz .9Zm0
N.
�Ng2o
8G.
5
E I 7 VTI ui Ia a 0 CEO 00 N w
Ck. W
tw- N VfW cl- O61
wV 1(Oq y � Z^ n 3 WO VDU OD3_� KJ
00
O�Vat� CL mi. WO
YyD- .. ............._......—.....-......... dfOZ W Olt 0:w
_O�0Z`=J'�SI�®
a V O O e 01,
h11 N °` �iN I H� t N � N N N Ct N • N - t�
ts r, � \w n v�i �4^ x d x yl N.y f f € r.n,lr f E -r to (�-N R i I I Ens♦1»m n f R r»o'n» 1+
���� --" ��� ~M�,r� mc�a iomoo����o;obb$�»&ob nl'k+s�nm�itoaam �Hm(3a'mf'atiaoa€(-
N �,n cJ
3� ^ \ � - -� 1 nY✓t fl v0»Y R N;-tl pt€R »♦RNA^OO N-a.G
ifs*1. ,��I dt 4pI Q11 t IE^�! t 1�1 1 I IYr11 1'lei in
I
............ ---- -------------
UZ(5-Z92 (900 :--j 910Z-LqZ (we) :w!
SM't owt ema"-c WOO Xvj 001 0 2LM� 13 'SU;)PJDD 4D;-IE)!H LLGZ 01
..........
x)"D
10"ITISIS Vat 'QAV L412 AN 96LZL ..........
mc Wins'23NIda au 'Xuodw ;1 �,-v
-1 (01 0"SIHI 3DNVH�012A3a xonookia t .0-j.%i:/1
l
t4ost!
ULMHodbloo bo LI M 3DYd1w13 IM UN o
UM aU N m8 io tZ
E.5
3 12 1
.... .......
o
R�
IF=
=4=
TT
8.yo90-26 30YHY0 4Z6-Z9C (SX) ;"A 9LOZ-Lsc (009) ;I.j 6 u-)
Ow"m oi 0
'SUQPADO I
9LO2� 'IJ 4DOIDN 11aDmmD �Aq
il-M
In
(Regg 'wrd) '9AV 14186 A N 96 L 133�s sw
00""Oz"Oe,
ore nins'miso 13SNnS 09EG -oul 'AuDdwoo .100(] BV(] j '33HS SM 30 OD
IN3Wdo13A3a loncoud IP"33NION3 ...............
:WOE Gs-cz-zo
NOIJLVM2!d MOO bOOMVzf-IV *W.-30YM�WN011319 13M 03YWOJ 71U NO �z i. SUO!SIAIGJ
I I
g i, hL
ri '04 S.
z
'i LLI:t
< IZ
ix
--4
........
FF it '0 Ed .. I. W is spNy
a go C5Fn 0.0
06
01
0
z t7,
0
fY
KJ
m oxxx
th
U,
H7 • c
-ffi LL
'z !k
0 z zo
L)
z
w.2
—41=—
FO Om
CD
3
0,i
0 0
to.
of
_.-._
evoso-ss ovaa� ! rzczs-asc (sos) :o, sloz-esz (ooe) I!- gee ozoz a M MIM zozca N e W. o
...... uoz oL aalvmdn u'cool..ry °c 7n
eceeaescsosl xvd oossvezcsoe�13i i 9LOp4 'I� 'suap�o� Uoaio!H I o�aav roueo w:s T so'sa i olavi :�cn m O
(asss 'N'r3) ec'cse volaol�'Iwvlw - - 'any 4486 'M•N S6t L l "' g r
�" 133M5 Stott 3° M�CN si'LO':1 ]1
OZZ 3u(Is'3AItl013SNf1S 09E6 •oUI 'duodwo'J JOo(] g/Q 'AU MN IVM!: _ t 0,W8 C !•; (p
1N3WdO13A30 LOI70OUd 9"A3NION3 ....- UOI aUJ5�. !�' u' o
Q. l NOI1VHOdkfOO i)OO21V.I-lV 't10 39YiN9 dN0lta35 13315 030W3 110a 'vo fZ suoisina� ee-tz-zo :woaf U,
1tiE
,J��nin3rv�\`<�ay�'~�uo � U m m mom m co ti � =t6.:� ���• $�
���\�g"o<�c�n „�•, cYio m `,�°.r'Di v1Oi N N o %�,� :ej��ti,
V•��
< g v
..... .... ......_..._ N
-IR
Gs s ., '� «Yii r7i Iii u c N e
N
s Q r
` k 4L3 WIL
•; NON o B
ap-7t N N N Q Q 0 9� -i lE
xNX = Mim N vea m✓b
ct
N mam WmM Z
<
v o n
O�
yy11 N�
p�MZZ�
'" � La`313H i10o0
1HO13H ONIN3d0
z
X yI x p
3 N �
� 9 gQEg 88 o d
p xul S myOg ZZ �a�n O
y�x Ov� m K W� wpp kpU
Ax
mo W�LL Kmpx� � Z LL LL m �(n W N
G M�"
gym ? xz q� d a � y-�g
na
XIiI F� m �i oxo � xw-~n 4_
N h SfV=qq� b N OWO zO =O C— O
Sio '8'i °m3 1o1Fa� p
®
IT f(L' N a
W W
'r-----13M'd.lz
__,.____......................._...........-............................-.._.....-........__. -
8V099-96\39"V9 ._ , ) z4z6-z9f (500 XD! 9W-t9Z (009_ ) :I'i �w�of a3lrodn'- 'ozm N
/ CLBPZ9t(am)')(Vd 00T9'b9Z(900 ewco li 'Su3 .!D DB D� J6d LIOt OL Q31WM° Lt t001 w C
03Wv NpidO tYi5 w01106: 6)'SO't!) 1 Mt)Yl J(y'ry
r+7 (ssss 'N'ri) eLveevarama Iwvlw 'PAV 4496 'M'N S6tZt -sm�rwo�93U aaa naa Lo<< x
I oaz 311(7S'3nlao lasNns Dace •ou) 'Auodwoo food 13ya aasxw saoNSNv ;l g e0 r'
1N3Wd0l3A3a 1D(laatld 9S1i33NIaN3 ._ ._ ........_................_._IIOi��r a 8D O
ar l NoLmiodmoo 00ouvd-1y J`a0 30VM IMU03S-GAS 03rMA 1108-V5>L :suoislnaa ee-fZ-ZO :nop v
��i\tl� I )rrrrr
W io oo oo yx •V�
F gr Pi S� = E !
cv
O
. � I 9Dm � M ZO OLL 0 0
z G ^mWv E. o im
I u aac4# CE-=
�0 9 v n m
99 aa�� o
x�� =o dmmz w mf
gtt . w
O
D
� xy
<
¢w
o� o + g o w
NawO m Zm 3m W gS Wt
2 w 6
o¢� gLLm a °d Y
' C,o' w
#O 03M
U
Nhi
r• \ j _..., gN�rr $ �� i- cpi o�Q �puy �2 z�i q9
Im
Z< o
Waw
-# w In�j mot- opp'Td �rpp i�88 w o
KSo OSG �'• Oi/� OOO(w� �d UZ
O #4.> FO ZU�Ow m�Ma m�YJs �VnW FOR,
y°5���
In 8/1-t �oOR W�
u
1Vtli • a Qzz
3sans v) pd� dd�
Doom w o
dU \'VwN �`m a,n hhrvM nm.N °<m�sm 3
BVa5Q�88�39VlN9 i� LLL6-LSf (SO£) :xnA 9tOZ-L9L (0m) :10i
BLBV"bYL(206)"%vi » Otmn t90E7'l31 •SU8 JO DB O! '�LIOZ OL 03LV04R Lt'CO Oi H k C �i r-
H t OEE "Id P 4 1 H �. t o
" y 4386 �M'N S6lZl � '�swu ��" at-so i _aaal L9 0 � O
(ssss u r�) eLtie¢vaao I�Iwvnw an to
S1N3rvw0O Y3tl tl3d'A3tl s{LOt: x
ozz 31ins'3f\Ia0135Nns 09e6 •oul 'Kuodu o poop gyp 133E5 51H1 30WHO ON V9t'EO �__• lit
LN3wdO13A3G ionOoa v SLl33NIDN3 a O ou
Pr NOIJV2lQdsl00 b0OUVAT; '?1Q 39Y2iYJ NNQII33S 13315 0311NO3 110H y�4L 1 :suoislnoJ( as-fz-zo :q9p a�
Ri yd Off N v
Cjz
ILL
G E
0 09 Q a L�Llltllll\\\\
IL
tp� ry p
O U
W i}i d Z VIOf
>
! O _
N a z
w ¢ I 'a O Z w- i'_"`�'-� I U j
aow ` omm g
ZZ
ONW WU II W dI
� I
Q .._ J n I 11
Qzi
DL C)LO El
� I N o
I <z _ �J7
1 '
3
IN �O/) >
mg L
.,,:
0.l.4
•Xvn,8/S Ot C a Li
�J
1HOGH 'MQM i
Xvry ..a/t ate
0
c�
rt
o Eo
z
�tJ M N li.• ir01 V7 yy�p
���{{ � ry�0 X\ O {Qi�O OW � p Xn�poZZ �j3
D o ®Td _m0
6 _-__ _ _ _
-
i —
O NORi31X3
•xo •ra