The URL can be used to link to this page

Home My WebLink AboutEvaluation Report Asphalt Roof ShinglesLZo3 oast REVIEWED FOR CODE COMPLIANCE NEMO I etc. - ST. L U C I E COUNTY Certificate of Authorization #32455 353 Christian Street, Unit#13 BO C (P—, Oxford, CT 06478 (203) 262-9245 ENGINEER. EVALUATE TEST CONSULT EVALUATION REPORT Owens Corning Evaluation Report 037940.02.12-R11 FL10674-R16 One Owens Corning Parkway Toledo, OH 43659 Date of Issuance: 02/06/2012 (740) 404-7829 Revision 11: 12/11/2020 SCOPE: This Evaluation Report is issued under Rule 61G20-3 and the applicable rules and regulations governing the use of construction materials in the State of Florida. The documentation submitted has been reviewed by Robert Nieminen, P.E. for use of the product under the Florida Building Code. The product described herein has been evaluated for compliance with the 7th Edition (2020) Florida Building Code sections noted herein. LABELING: Labeling shall be in accordance with the requirements of the Accredited Quality Assurance Agency noted herein and FBC 1507.2.7.1 / R905.2.6.1 CONTINUED COMPLIANCE: This Evaluation Report is valid until such time as the named product(s) changes, the referenced Quality Assurance or production facility location(s) changes, or Code provisions that relate to the product(s) change. Acceptance of our Evaluation Reports by the named client constitutes agreement to notify MEMO ETC, LLC of any changes'to the product(s), the Quality Assurance or the production facility location(s). NEMO ETC, LLC requires a complete review of its Evaluation Report relative to updated Code requirements with each Code Cycle. ADVERTISEMENT: The Florida Product Approval Number (FL#) preceded by the words "NEMO Ietc. Evaluated" may be displayed in advertising literature. If any portion of the Evaluation Report is displayed, then it shall be done in its entirety. INSPECTION: Upon request, a copy of this entire Evaluation Report shall be provided to the user by the manufacturer or its distributors and shall be available for inspection at the job site at the request of the Building Official. This Evaluation Report consists of pages 1 through 10. Prepared by: .=^t rr1- Z Robert J.M. Nieminen P.E. D. n�� The facsimile seal appearing was authorized by Robert :,T o ;.,c`y ••r ..•M�,. Nieminen, P.E. an 12/12/2020. This does not serve as an Florida Registration No. 59166, Florida DCA ANE1983 ' ;'(+:..... . electronically signed document. CERTIFICATION OF INDEPENDENCE: 1. NEMO ETC, LLC does not have, nor does it Intend to acquire or will it acquire, a financial Interest in any company manufacturing or distributing products it evaluates. 2. NEMO ETC, LLC is not owned, operated or controlled by any company manufacturing or distributing products it evaluates. 3. Robert Nieminen, P.E. does not have nor will acquire, a financial Interest in any company manufacturing or distributing products for which the evaluation reports are being issued. 4. Robert Nleminen, P.E. does not have, nor will acquire, a financial interest in any other entity involved in the approval process of the product. 5. This is a building code evaluation. Neither NEMO ETC, LLC nor Robert Nieminen, P.E. are, In any way, the Designer of Record for any project on which this Evaluation Report, or previous versions thereof, is/was used for permitting or design guidance unless retained specifically for that purpose. m2018 NEMO ETC, LLC FILE COPY ONEMOletc. ROOFING SYSTEMS EVALUATION: Product Category: Roofing Sub -Category: Asphalt Shingles Compliance Statement: Owens Corning Asphalt Roof Shingles, as produced by Owens Corning, have demonstrated compliance with the following sections of the r Edition (2020) Florida Building Code through testing in accordance with the following Standards. Compliance is subject to the installation Requirements and Limitations / Conditions of Use set forth herein. 1507.2.4, R905.2.3 1507.2.5, R905.2.4 1507.2.7.1, R905.2.6.1 1507.2.7.1, R905.2.6.1 Entt .,_ Owens Corning PRI(TST5878) UL LLC (CER9626) UL LLC (CER9626) UL LLC (TST9628) UL LLC (TST9628) UL LLC (TST9628) UL LLC (TST9628) UL LLC (TST9628) UL LLC (TST9628) PRI (QUA9110) PRI (QUA9110) Pro ,,,e _ .-Standard _ ..Y.ear Physical Properties ASTM D1970 2015 Material standard ASTM-D3462 2010 Wind Resistance ASTM D3161 2016 Wind Resistance ASTM D7158 2019 Ekariiination Declaration ASTM D1970 Physicals & Wind Resistance Physicals & Wind Resistance Physical Properties Wind Resistance Physicals & Wind Resistance Wind Resistance Physical Properties Physical Properties Quality Control Quality Control Reference ,, Equivalency Declaration OCF-382-02-01 File R2453, Vol. 3 20120516-112453 06CA20263 11CA34308 4786093137• 4786126532 Classification letter Classification letter Service Confirmation Florida BCIS . Date 08/06/2019 10/24/2017 02/15/2007 05/16/2612 04/18/2006 02/18/2012 02/01/2014 02/10/2014 02/13/2014 10/02/2015 04/05/2020 Current 4. •ODDESCRIPTION: ti -' TABLE 1: ASPHALTtSHINGLE COMPONENTS ; f Type Product r Plant(s) Material Standard; Description = Starter Strip Shingle H-TX, OR Accessory -', Starter Strip Plus MN, OR ASTM D3462 starter strips for asphalt roof shingles '"Sta_rter SRS TopShield Starter MN, OR Starter Shingle Roll NH ASTM D1970 mineral -surfaced, fiberglass -reinforced, self -adhering SBS modified bitumen starter ,'- Supreme' GA, CA, CO, I -TX, NJ, OH, TN, OR, IL ASTM D3462 fiberglass reinforced 3-tab asphalt roof shingles Berkshire' MN ASTM D3462 fiberglass reinforced, 4-tab asphalt roof shingles Duration' Premium CA, OR ;'- halt`,, ' Shingles; ASTM D3462 fiberglass reinforced, laminated asphalt roof shingles Duration 'Premium COOL CA TruDeflnition' Duration' IN, CA, CO, I -TX, FL, NJ, OH, MN, OR, GA, IL,TN TruDeflnition' Duration Designer Color Collection Oakridge' GA, IN, CA, CO, H-TX; I -TX, FL, NJ OH, TN TruDeflnition' Oakridge' H-TX, I TX WeatherGuard' HP TN NEMO ETC, LLC Evaluation Report 037940.02.12-1113 Certificate of Authorization #32455 7- EDITION (2020) FBC NON-HVHZ EVALUATION F1.10674-1116 Owens Corning Asphalt Roof Shingles Revision 11:12/11/2020 Page 2 of 10 ONEMOletc. TABLE'1 ASPHALT SHINGLeCOMPONENTS'" Type r Product Plant(s), Material,.', Description Standard,, Berkshire' Hip and Ridge MN ' Shingles with Sealant DuraRidgem Hip and Ridge MN Hipand '" ..' fiberglass reinforced, hip and ridge Shingles with Sealant ASTM D3462 asphalt roof shingles ProEdge® GA, CA, OH, OR Shingles- ; , WeatherGuard' HP Hip and TN =' •:,': Ridge Shingles 5. LIMITATIONS: 5.1 This is a building code evaluation. Neither NEMO ETC, LLC nor Robert Nieminen, P.E. are, in any way, the Designer of Record for any project on which this Evaluation Report, or previous versions thereof, is/was used for permitting or design guidance unless retained specifically for that purpose. 5.2 This Evaluation Report Is not for use In FBC High Velocity Hurricane tone jurisdictions (i.e., Broward and Miami - Dade Counties). 5.3 This Evaluation Report pertains to above -deck roof components. Roof decks and structural members shall be In accordance with FBC requirements to the satisfaction of the Authority Having Jurisdiction. 5.4 This Evaluation Report does not include evaluation of fire classification. Refer to FBC 1505 for requirements and limitations regarding roof assembly fire classification. Refer to FBC 2603 for requirements and limitations concerning the use of foam plastic Insulation. 5.5 Wind Classification:_ Refer to Section 6 for installation requirements to meet wind classifications TABLE2A:'WINpCLi45SIFICA710NS,,ASP,HALTSHINGLES; +, Product :' ' FBC Table.1507,2.7a or R905 2 6.1• Supreme' Berkshire' Duration' Premium Duration' Premium COOL TruDefinition' Duration ASTM D3161(F) & ASTM D7158(H) TruDefinition' Duration' Designer Color Collection Oakridge TruDefinition' Oakridge' WeatherGuard' HP 5.5.1 Classification by ASTM D7158: ASTM D7158, Class H applies only to exposure category B or C and a building height of 60 feet or less. Calculations by a qualified design professional are required for conditions outside these limitations. Contact the shingle manufacturer for data specific to each shingle. NEMO ETC, LLC Evaluation Report 037940.02.12-Rii Certificate of Authorization #32455 7T" EDITION (2020) FBC NON-HVH2 EVALUATION F1.10674-1116 Owens Corning Asphalt Roof Shingles Revision 11,12/11/2020 Page 3 of 10 ONEMOletc. &:,RIbGE 4z ; ., �„ ,, ,_ ; „5• :._, ' .: .. „TABLE �B"W1NDCLASSIFICATIO,NS,.STARTER_'STRIPS*ANDhHIP � Type Table3S07:2 7:1 or ft905 2 61 Starter Strip Shingle Starter Strips Starter Strip Plus ASTM D3161, Class F SRS TopShield Starter Berkshire' Hip and Ridge Shingles with Sealant DuraRidge° Hip and Ridge Shingles with Sealant Hip &Ridge f ASTM D3161, Class F ;Shingles= `=` ProEdge® WeatherGuard' HP Hip and Ridge Shingles r 5.5.2 Refer to Owens Corning published information on wind resistance and installation limitations. 5.6 All components in the roof assembly shall have quality assurance audit in accordance with F.A.C. Rule 61G20-3- Refer to the Product Approval of the component manufacturer for components that are produced by a Product Manufacturer other than the report holder on Page 1 of this Evaluation Report. 6.1.1 Roof deck, slope, underlayment and fasteners shall comply with Flit iSU/./- / MIU.LL ano the snmgie manufacturer's minimum requirements. 6.1.2 Underlayment shall be acceptable to the shingle manufacturer and shall hold current Florida Statewide Product Approval, or be Locally Approved per Rule 61G20-3, per FBC Sections 1507.2.3,1507.2.4 or R905.2.3. 6.1.3 Fasteners shall be in accordance with the shingle manufacturer's published requirements, but not less than FBC 1507.2.6 or R905.2.5. Staples are not permitted. 6.1.4 Owens Corning asphalt shingles are acceptable for use in reroof (tear -off) or recover applications, subject to the limitations set forth in FBC Section 1511 or R908 and published installation instructions. 62,,; • ACCESSORy;STARTERS, ,,. - r ��. ,%» ;, r z _ �° :=�_... 6.2.1 Installation of Starter Strip Shingle, Starter Strip Plus and SRS TopShield Starter shall comply with the Owens Corning current published instructions, using minimum five (5) nails per strip. Fait undedayment Seff-adhered WwthetLz undarloyment D& Dtip Wag StarterStrip"of@owrhwaseaves and miu W-Mii I F.twnaa,urmMt = unQerlaymtnt rr r D*adea J.. edea r' r' ,, r eStlouted P-Mmoul tnidl6atStatta6ulpPF+a SvMaaGn �e WhhCnmoYad--� �non�°ab�tlY. su*r Fin ovuhaneauveeaoduta11 -914' Figure 1: Minimum Nailing, Starter Strip Figure 2: Minimum Nailing, Starter Strip Plus NEMO ETC, LLC Evaluation Report 037940.02.12-Rii Certificate of Authorization #32455 7- EDITION (2020) FBC NON-HVHZ EVALUATION FL10674-R36 Owens Corning Asphalt Roof Shingles Revision 11:12/11/2020 Page 4 of 10 ONEMOjetc. 6.2.2 Installation of Starter Shingle Roll shall comply with the Owens Corning current published instructions. Drip edge Starter Shingle Roll adhered directly to underlayment and primed drip edge Self-sealing adhesive positioned along eaves Figure 3: Starter Shingle Roll ;6:3 `-' ASPHALTSHINGLES , , 6.3.1 Installation of asphalt shingles shall I comply with the Owens Corning current published instructions, using minimum four (4) nails per shingle in accordance with FBC 1507.2.7 or R905.2.6, with the following exceptions: ➢ Berkshire' shingles require minimum five (5) nails per shingle. ➢ WeatherGuard• HP shingles require minimum six (6) nails per shingle. Where the roof slope exceeds 21 units vertical in 12 units horizontal, special methods of fastening are required Refer to Owens Corning published information on wind resistance and installation limitations. 6.3.1.1 Supreme: Normal Wind Areas Area pare vlentos normal" t•T 17• i 5"Exposure Exposic/dn Mansard or Area pare High Wind desvanea y Areas vlentos fnartes rt. 2' (B Z. 1. Figure 4: Minimum Nailing, Supreme (Standard Size) Normal Mansard or Ana pare Wind Areas High Wind deavanss y Area pore vlentos normeles Areas vlantos footles iz tAl 7217• r1� z• (61 •11 • • • • • • • • • • a Wa° Exposure Exposloidn Figure 5: Minimum Nailing, Supreme (Metric Size) NEMO ETC, L LC Evaluation Report 037940.02.12-Ri1 Certiftate of Authorization #32455 P EDITION (2020) FBC NON-HVHZ EVALUATION FL10674-R16 Owens Corning Asphalt Roof Shingles Revision 11:12/11/2020 Page 5 of 10 6.3.1.2 Berkshire®: Seala�d drip LGtlradoPik der L1° j'- Figure 6: 5-Nail Pattern, Berkshire ON EMO I etc. Sealant strip Let6adirsellador �lu 8 8 W t.. Figure 7: 6-Nail Pattern, Berkshire rigure o. inansara yr steep awpe raa�eny vc�nanu e NEMO ETC, LLC Evaluation Report 037940.02.12-1111 CertiJkate of Authorization #31455 7" EDITION (2020) FBC NON-HVHZ EVALUATION FL10674-1116 Owens Corning Asphalt Roof Shingles Revision 11:12/11/2020 Page 6 of 10 ONEMOjetc. 6.3.1.3 Duration® Premium TruDefinition® Duration Duration® Premium COOL & TruDeflnition' Duration' Designer Color Collection: 4-Nall Fastening Pattern SureNail®fasteninyarwwldth Nall, 7ypieal 1" 12" 12" 1^ e r,a 4, Figure 9: Standard 4-Nail Pattern, Duration 6-Nall Fastening Pattern SuraNa�lfashnlnp araa Wldth Nall, Typical. 12^ ....[>+ms arda7Smit4Y1-'C'.^`� :"" '..:♦.arm S4o-m- Figure 10: 6-Nail Pattern, Duration Fastening for Slopes Greater Than 21:12 sureNaN fastening area width Nall, Typical 1" 12" 12" " -.fxren�rmmauvNm :.,.w_:.::�4. rnsuu;uw�swawe,a . *. cnrmosuw�.'v.:..-.�-. .s 8-tIs. 5.518" erAnw" w.r 2 Four 1" Spots urAsptiaitRoofing.Cement Figure 11: Mansard or Steep Slope Pattern, Duration NEMO ETC, LLC Evaluation Report 037940.02.12-Rii Certiftate of Authorization #32455 7Te EDITION (2020) FBC NON-HVHZ EVAWATION F1.10674-1116 Owens Corning Asphalt Roof Shingles Revision 11:12/11/2020 Page 7 of 10 6.3.1.4 TruDefinition'Oakridee®, Oakridge®: 4 mail Pattern squemiwit444-w's ir, ss*Exposum C131FOP, v0paig. Figure 12: Standard 4-Nail Pattern, Oakridge 6.3.1.5 WeatherGuard® HP: to -MEMO jetc. SNalj Patteff Esquema con 6 davas Nalls 01311" Ekpas rd.dU.'GG/ePU19- ovepurg. Figure 13: 6-Nall Pattern, Oakridge Fastening for Slopes Greater Than 21:12 suretimim fastening area width. Nall,TypIcal 12" 12' Four I" Spots'ofAsphoft Roofing Cement Figure 14: Mansard or Steep -Slope Pattern, Oakridge 6 Nal Pattern Esquem con 6 clavos Mail 6 lir from bottom of shiftgiq clove, a 6 lie do la 5 53' Exposing 6 Fptenem we Infaflof nob lqa ExposicOn do 5 5J8 ptdg. 6 stiletadores 12' 1 12 Pd 14 2 lip* 177, 7 Na W= Four l' Spots of A?hek goof Cement Castro pantos do temixito do tads do aslafto de I potadir Figure 25: 6-Nall Pattern, WeatherGuard HP Figure 26: Mansard or Steep -Slope Pattern, WeatherGuard HP NEMO ETC, LLC Evaluation Report 037940.02.12-1111 Certificate of Authorization #324SS 7TH EDITION (2020) FBC NON-HVHZ EVALUATION FL10674-RI6 Owens Corning Asphalt Roof Shingles Revision 11: 12/11/2020 Page 8 of 10 NEMO I etc. 6.4.1 Installation of asphalt shingles shall comply with the Owens Corning current published instructions. ➢ Berkshire' Hip and Ridge Shingles with Sealant and DuraRidge® Hip and Ridge Shingles with Sealant require minimum two (2) nails per shingle. ➢ WeatherGuard' HP Hip and Ridge Shingles and ProEdge® require minimum four (4) nails per shingle. Refer to Owens Corning published information on wind resistance and installation limitations. 6.4.1.1 Berkshire® Hip and Ridge with Sealant and DuraRidge® Hip and Ridge Shingles with Sealant: Fig. A Prevailing Wind Direction t— Direccifin del viento predominante Nails A Clavos I I I I A I I I I rbqpcia nndeE A Figure 17: Isometric View, Berkshire and DuraRidge 6.4.1.2 WeatherGuard® HP Hip and Ridge Shingles: Fig. A 4 T PreVapUlg VJNd 4_ Direction A , A Halls ; q 1 1' I I A I w w �osu� Figure 19: Isometric View, WeatherGuard HP Hip and Ridge Fig. B Top View Vista superior Nail 2 " �8 ClaVo r a '�.' , ' e Owasss;Cvrnirrg*irk B st , I I I� dl ml I I I Figure 2 3: Plan view, Berksnlre ana uuramloge Fig. 0 Hipp&Ridge Shingle Fa* ing TopVkw Nail9 Nails T' V, 1" P S' 'Exposure I Figure 20: Plan View, WeatherGuard HP Hip and Ridge NEMO ETC, LLC Evaluation Report 037940.02.12-Ril Certificate of Authorization#32455 7- EDITION (2020) FBC NON-HVHZ EVALUATION FL10674-R16 Owens Corning Asphalt Roof Shingles Revision 11:12/11/2020 Page 9 of 10 6.4.1.3 ProEdee®: Provailing Wind Direction SoelentStrip f 6` Expo' CaverExpossd Fasteners with Root cement Figure 21: Isometric View, ProEdge As required by the Building Official or product. ONEMOjetc. Standard F"toning Pattern ty Saslant ,• �= 61 Exposure Figure 22: Plan View, ProEdge rity Having Jurisdiction to properly evaluate the installation of this 8 MANUFACTURING PLANTS: Contact the named OA entity for manufacturing facilities covered by F.A.C. Rule 611320-3 QA requirements. Refer to Section 4 herein for products and production locations having met codified material standards. 9. QUALITY ASSURANCE ENTITY-. PRI Construction Materials Technologies, LLC—QUA9110; 813 621-5777; bwilson@pricmt:com_ - END OF EVALUATION REPORT - NEW ETC, LLC Evaluation Report 037940.02.12-RSl Certificate of Authorization H324SS 7" EDITION (2020) FBC NON-HVHZ EVALUATION FL10674-R16 Owens Corning Asphalt Roof Shingles Revision 11:12/11/2020 Page 10 of 10