HomeMy WebLinkAbout1308-0399- NOABY
Luels Cc
MIAMhMIAMI-DADE COUNTY
PRODUCT CONTROL SECTION
DEPARTMENT OF PERMITTING, ENVIRONMENT, AND REGULATORY 11805 SW 26 Street, Room 208
AFFAIRS (PERA) Miami, Florida 33175-2474
BOARD AND CODE ADMINISTRATION DIVISION T (786) 315-2590 F (786) 3I5-2599
NOTICE OF ACCEPTANCE (NOA) www.miamidade.goy/uera�
Trulite Window & Door Solutions, LLC
8130 NW 7e Avenue
Medley, FL 33166
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction
materials. The documentation submitted has been reviewed and accepted by Miami -Dade County PERA -
Product Control Section to be used in Miami Dade County and other areas where allowed by the Authority
Having Jurisdiction (AHJ).
This NOA shall not be valid after the expiration date stated below. The Miami -Dade County Product Control
Section (In Miami Dade County) and/or the AHJ- (in areas other than Miami Dade County) reserve the right
to have this product or material tested for quality assurance purposes. If this product or material fails to
perform in the accepted manner, the manufacturer will incur the expense of such testing and the AHJ may
immediately revoke, modify, or suspend the use of such product or material within their jurisdiction. PERA
reserves the right to revoke this acceptance, if it is determined by Miami -Dade County Product Control
Section that this product or material fails to meet the requirements of the applicable building code.
This product is approved as described herein, and has. been designed to comply with the Florida Building
Code, including the High Velocity Hurricane Zone.
DESCRIPTION: Series 11580" Aluminum -Single Hung Window — N.I.
APPROVAL DOCUMENT: Drawing No. W96-38, titled "Series 580 Alum Single Hung Window (N.I.)"
Sheets 1 through 5 of 5, dated 10/10/96 with revision H dated 12/23/11, prepared by Al-Farooq Corporation,
signed and sealed by Javad Ahmad, P,E., bearing the Miami -Dade County Product Control Revision stamp
with the Notice of Acceptance number and expiration date by the Miami -Dade County Product Control
Section.
MISSILE IMPACT RATING: None.
LABELING: Each unit shall bear a permanent label with the manufacturer's name or logo, city, state,
model/series, and following statement: "Miami -Dade County Product Control, Approved", unless otherwise
noted herein.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been
no change in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change
in the materials, use, and/or manufacture of the product or process. Misuse of this NOA as an endorsement
of any product, for sales, advertising or any other purposes shall automatically terminate this NOA. Failure
to comply with any section of this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA. number preceded by the words Miami -Dade County, Florida, and
followed by the expiration date may be displayed in advertising literature. If any portion of the NOA is
displayed, then it shall be done in its entirety.
INSPECTION; A copy of this entire NOA shall be provided to the user by the manufacturer or its
distributors and shall be available for inspection at the job site at the request of the Building Official,
This NOA revises NOA # 10-0518.11 and consists of this page 1 and evidence pages E-1 and E-2, as well
as approval document mentioned above.
The submitted documentation was reviewed by Manuel Perez, P.E.
NOA No.12.0118.16
Expiration Date: November 14, 2012
Approval Date: March 15, 2012
Page 1
Trulite Window & Door Solutions, LLC
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
A. DRAWINGS
1. Manufacturer's die drawings and sections.
2. Drawing No. W96-38, titled "Series 580 Alum Single Hung Window (N.I.)" Sheets 1
through 5 of 5, dated 10/10/96 with revision H dated 12/23/10, prepared by Al-Farooq
Corporation, signed and sealed by Javad Ahmad, P.E.
B. TESTS
1. Test reports on: 1) Air Infiltration Test, per FBC, TAS 202-94
2) Uniform Static Air Pressure Test, Loading per FBC TAS202-94
3) Water Resistance Test, per FBC, TAS 202-94
4) Forced Entry Test, per ASTM 588, TAS 202-94
along with marked -up drawings and installation diagram of a series 580 eyebrow top
aluminum single hung window, prepared by Fenestration Testing Laboratory, Inc.,
Test Report No. FTLr,5343, dated 10/09/07, signed and sealed by Carlos S. Rionda,
P.E. (Submitted under previous NOA#09-0316.10)
2. Test reports on: 1) Air Infiltration Test, per FBC, TAS 202-94
2) Uniform Static Air Pressure Test, Loading per FBC TAS 202-94
3) Water Resistance Test, per FBC, TAS 202-94
4) Forced Entry Test, per ASTM 588, TAS 202-94
along with marked -up drawings and installation diagram of a series 580 radius top
aluminum single hung window, prepared by Fenestration Testing Laboratory, Inc.,
Test Report No. FTL-4443, dated 01/26/05, signed and sealed by Edmundo
Largaespada, P.E. , (Submitted under previous NOA#09-0316.10)
3. Test reports on: 1) Air Infiltration Test, per FBC, TAS 202-94
2) Uniform Static Air Pressure Test, Loading per FBC TAS 202-94
3) Water Resistance Test, per FBC, TAS 202-94
4) Forced Entry Test, per AAMA 1302.paragraph 5 3. L l to 3.1.5
along with marked -up drawings and installation diagram of a series 580 aluminum
single hung window, glazed w/ 3/16" temp. glass, prepared by Fenestration Testing
Laboratory, Inc., Test Report No. FTL-3879, dated 08/28/03, signed and sealed by
Joseph Chan, P.E. (Submitted under previous NOA #02-0507.06)
4. Test reports on: 1) Uniform Static Air Pressure Test, Loading per FBC TAS 202-94
2) Water Resistance Test, per FBC, TAS 202-94
along with marked -bp drawings and installation diagram of a Series 580 Aluminum
Single Hung Window, glazed with 1/8" ann. glass, prepared by Fenestration Testing
Laboratory, Inc., Test Report No. FTL-3861, dated 08/07/03, signed and sealed by
Joseph Chan, P.E. (Submitted under previous NOA #02-0507.06)
Manuel Peer*P.E.
Product Contro Exa finer
NOA No. 1 - 118.16
Expiration Date: November 14, 2012
Approval Date: March 15, 2012
E-1
Trulite Window & Door Solutions, LLC
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
C. CALCULATIONS
1. Anchor verification calculations and structural analysis, complying with FBC-2007
and FBC-2010, dated 02/24/09 and updated on 01/04/12, prepared, signed and sealed
by Javad Ahmad, P.E.
2. Glazing complies with ASTM E1300-04
D. QUALITY ASSURANCE -
1. , Miami -Dade Department of Permitting, Environment, and Regulatory Affairs (PERA).
E. MATERIAL CERTIFICATIONS
1. None.
F. STATEMENTS
1. Statement letter of conformance, complying with the FBC-2010, and of no financial
interest, dated January 4, 2012, signed and sealed by Javad Ahmad, P.E.
2. Florida Dept of State; listing of Trulite Window & Door Solutions, LLC (Foreign
Limited Liability Co.), managed by Arch Intermediate Holding, LLC, Tamarac, Fl.,
dated 02/03/10.
3. Certificate of registration of name change from "Trulite Residential Windows, LLC"
to "Trulite Window & Door Solutions, LLC" issued by State of Delaware on 10/28/11,
signed by J.W. Bullock.
4. Certificate of registration of name change from "Arch Windows, LLC" to Trulite
Residential Windows, LLC" issued by State of Delaware on 07/27/11, signed by J.W.
Bullock.
5. Florida Department of State, listing of Arch. Window, LLC (Foreign Limited Liability
Co.), managed by Arch Intermediate Holding, LLC, Tamarac, Florida, dated 01/22/10.
6. Certificate of registration of Arch Windows, LLC (Delaware) in State of Florida dated
02/04/10, managed by Arch Intermediate Holding, LLC.
G. OTHERS
1. Notice of Acceptance No.10-0518.11, issued to Arch Windows, LLC dba AWP for
their Series "580" Aluminum Single Hung Window — N.I., approved on 08/25/10 and
expiring on 11/14/12.
Manuel P ez, .E.
Product Control ftaWfner
NOA No.12-0118.16
Expiration Date: November 14, 2012
Approval Date: March 15, 2012
E-2
FALSE MUNTINS
(SURFACE APPLIED)
MAY BE USED \
w a
p O
M �
G _
3
n o
z
3
V
N J
SERIES 580 ALUMINUM SINGLE HUNG WINDO
DESIGN LOAD RATINGS FOR THESE WINDOWS TO BE AS PER
CHART SHOWN ON SHEET 2.
APPROVAL APPLIES TO SINGLE UNITS OR SIDE BY SIDE
COMBINATIONS OF S.H./S.H. OR S.H. WITH OTHER WINDOW
TYPES IN MODULES OF TWO OR MORE WINDOWS USING
MIAMI—DADE COUNTY APPROVED MULLIONS IN BETWEEN.
LOWER DESIGN PRESSURE FROM WINDOW OR MULLION APPROVAL
WILL APPLY TO ENTIRE SYSTEM.
REQUIREMENTS OF THE FLORIDA BUILDING CODE�INCLUDING�HIGH�V0.0CITY
HURRICANE ZONE (HVHZ).
WOOD BUCKS BY OTHERS, MUST BE ANCHORED PROPERLY TO TRANSFER
LOADS TO THE STRUCTURE.
ANCHORS SHALL BE AS USTED, SPACED AS SHOWN ON DETAILS, ANCHORS
EMBEDMENT TO BASE MATERIAL SHALL BE BEYOND WALL DRESSING OR STUCCO
ANCHORING OR LOADING CONDITIONS NOT SHOWN IN THESE DETAILS ARE
NOT PART OF THIS APPROVAL.
A LOAD DURATION INCREASE IS USED IN DESIGN OF ANCHORS INTO WOOD ONLY.
MATERIALS INCLUDING BUT NOT LIMITED TO STEEL/METAL SCREWS, THAT COME
INTO CONTACT WITH OTHER DISSIMILAR MATERIALS SHALL MEET THE
REQUIREMENTS OF THE FLORIDA BLDG. CODE SECTION 2003.8.4.
C II II
n n
48 1/2-
D.L OPG.
50 11/16-
50
TOP CORNERS OF DAL OP
ARCH TOP WOWS.
TO BE SECURED 13
BY SCREWS
OR SPOT WELDING I`
,I
11 ��
II II
II II
II II
n
-1
H H
I I 11
B �
II' II
iV
11 II
11 I
Q II II
1 •
INSTALLATION OF TWS PRODUCT IN THE HVHZ AREA REQUIRES THE
USE OF APPROVED SHUTTERS OR EXTERNAL PROTECTION DEVICES
COMPLYING WITH HVHZ REQUIREMENTS.
INSTALLATION OF *IS SYSTEM OUTSIDE THE HVHZ AREA SHALL MEET
THE APPLICABLE RrQUIREMENTS FOR WIND BORNE DEBRIS PROTECTION.
48 1/2"
D.L. OPG. \
50 ll/IB'-
'D
Z ^ i
o
Qf N a
0
Od 8
a�
�Q
O$ v
vo
c, o
0 IL
0 o�
LLQ W3LL rn
z rri
�Z
Q W 22
z y
j
to
z ¢ to
rn Ad M
m 3 to N
it n
4
�2 w
g �G co M
MONOLITHIC GLASS 11U = "
J
NON IMPACT
b
o
.o
$
9i
i7r: jAVADAHIIAD
IL. PRODUCT
REVISED
FU6F� i 70592 r,
C,AN. 538
oomPlYlog��Oft
. DC.Id"ulg
• pccep4mce
• A&Zptlon��
Code
No �O
g
$
a�
• BY.
12012
P� d
drawing no.
W96-38
a
z
x
O
z
m
W
I
I
T�l
a TV;
�5g
ygrl
��_
rxr-
Zm
ozo
m
� to
O 0
m
az
x
I
C7
2
��yA
tb
��y
yyg
�Z N
A
4 ip
Ill N+
N pN�
to A Nm �
'am
G m
m
to a N ..
O
A
tv
W
v Ia
v N
? N
A W
v
C
a
m
�•
I
I I
I o
o I
I I
I
1 1
1
1 1
o
o I
�Gi o
m o
o .P
lWn m
•.x-I
b b
b
N b
b
,f.+
+
o
0 o
bo b
b io
in b
.oA
is o
o V
l3-I' g
o=
a.
Wb--,
1
aNVmGW
A 0
0 1
V O
0 m
O A
m Ql
yyISM—
O 0
jN
OCVl
m
Z
I
I I
1
0
I
b
I I
1:�
O O
I
G
I I
J O
m
o I
O
I l
o 0
b
0 1
J m
o 0
o m
lu 9
0 0
0
n
O
b
0
O <A
O C
O o
J O
O G
O
o=
O.�
m
I
I I
1 A
J
Y I
I I
A m
V
V
01
O I
b
I I
A mm
V a
Ol
0 1
1 1?
WW m
O
m
O I
4 !n
V m
V W
N O
pl W
O m
(T V
N m
m m
0 0
00 �
0
m Ill
y
C
O
Z. O
O
Of
a
O (Y
b� G
O Z.
V f/
O G
C v
I
O
LI m
A 0
0 puj
O fN
+ O
Q N
O
a 0
0 0
p01
V
p
YO
4 0
ap O
A
m Ai
0
Z. O
O N
,iG1l
W V
IJ O
O O
IWd V
N m
O
G
O
b b
N b
0 C
0
O m
t!l Co
m O
0
O v
r�y
I*� Z
�•3
O
W m
P.Imll
W
O N
I+ N
Op N
}}
IWlI O
m A
,mO O
W V
p WW
(.,
W IWO
>>
41 O
OOi lVn
rI.,
A J
�l
I
4 b
N m
p
.+ +
W W
Go O
m
A 1-1.
m
l
j y
!D
mm
O o
0 0
pp l
0 0
0 0
0 0
Pp
0 0
0 0
0 0
0 0
0 0
0 0
0 0
0 0
0 0
0 0
0 0
Z
Z
O,
O
O O
O O
O C
O G
C O
O C
O O
O O
O O
b D
O 0
0 0
0 0
0 0
0[O-
O
y+
o
m V
Ol
N O
m'
N
_
N ppfl
V pppp
m N
N m
V
m
m N'
to
m
N
N
m
O
f7l Co
O u
A
to N
C V
�mll
m+
V
N b
b A
b
G 4
N V
a O
O b
N+
O V
m
G G
tlIl W
Ol J
N
b A'
O
m
m 4l
m b
N
0
N
4
N INT
i0 O
N
b I
m N
m
0
m a
0 0
m m
0 0
0 0
m o
0
0 0
o gl
,g' o
pl
o O
°i
o 0
O1
0 0
$' o
0 0
0,
b
b b
b b
o b
b b
o b
o b
o o
b b
b b
b b
o b
c b
b b
o 0
o b
o'o
o b
y
O
t00 M
O W
N Ill
Sn 14-
m
b
W Omi
"
mm
G W
fJ J
N
b
V
4
m
L,
UI
m
m
0
m V.
fp
0
m
b m
m
b V
b Z
0
a
0-
g
n
g N
L
n
* a
laati: ,0-to-ae
revisions:
no a e
es0ri ion
l SERIES 580 ALUM SINGLE HUNG WINDOW (N.I.)
AL-FAROOQ CORPORATION
a
to E
scola 7�2' _ ,•
E 02207
H
GENERAL REN9oN
TRUUTE WINDOW & DOOR SOLUTIONS, LLC
ENGINEERS & PRODUCT DEVELOPMENT
1
F 26.09
UPDA7FD i0R 2007 F8C
8130 N.W. 74TH AVE.
u' 35 S.W. 87 AVE
MUUYiI. FLORIDA 33174
(.rl o
dr. hy. HAMID
G 05.06.10
H 1273.11
YANUF. NAPE REVISM
WNUF. NAME REV6ED
MEDLEY, FL. 33166
TEL.(SM 2648100 FAX.(305)262-6978
P
chk q^.
TEL (305) 887-2W FAX (305) W3-1309
COMP-ANL\W96-3a