The URL can be used to link to this page

Home My WebLink AboutEVALUATION REPORT - ASPHALT ROOF SHINGLESTRINITY ERD REPORT Owens Coming One Owens Corning Parkway Toledo, OH 43659 (740) 404-7829 EXTERIOR RESEARCH & DESIGN, LLC. Certificate of Authorization #950 353 CHRISTIAN STREET, UNiT#13 OXFORD, CT 06478 (203) 262-9245 .+vnitllvCL� Evaluation Report 037940.02.12-R8 BY FL10674-1113 St Lucie County Date of lssuance: 02/06/2012 Revision 8: 10/09/2017 SCOPE: This Evaluation Report is issued under Rule 61G20-3 and the applicable rules and regulations governing the use of construction materials in the State of Florida. The documentation submitted has been reviewed by Robert Nieminen, P.E.; for use of the product under the Florida Building Code and Florida Building Code, Residential Volume_ The products described herein have been evaluated for compliance with the a Edition (2017) Florida BmIding Code sections noted herein. DEspipnow Owens Corning Asphalt Roof Shingles LABEUNG: Labeling shall be in accordance with the requirements the Accredited Quality Assurance Agency noted herein and FBC 2507.2.7.1 / R905.2.6.1. CONTINUED COMPLIANCE: This Evaluation Report is valid until such time as the named product(s) changes, the referenced Quality Assurance documentation changes, or provisions of the Code that relate to the product change. Acceptance of this Evaluation Report by the named client constitutes agreement to notify Robert Nieminen, P.E. if the product changes or the referenced Quality Assurance documentation changes. TrinityJERD requires a complete review of this Evaluation Report relative to updated Code requirements with each Code Cycle. ADVERTISEMENT: The Evaluation Report number preceded by the words "Trinity) ERD Evaluated" may be displayed in advertising literature. If any portion of the Evaluation Report is displayed, then it shall be done in its entirety. INSPEcnON: Upon request, a copy of this entire Evaluation Report shall be provided to the user by the manufacturer or its distributors and shall be available for inspection at the job site at the request of the Building Official. This Evaluation Report consists of pages 1 through 8. Prepared by: Robert J.M. Nieminen, P.E. "'fi;�s { j� ` The facsimile seal appearing was authorized by Robert Florida Regis6atfan No. 59166, Florida DCAANE1983 �'••••�•�•"" Nieminen, P.E on 10/0912017. This does not serve as an electronically signed document Curnm ncm of IrmEmmt nce: 1. Trinityl ERD does not have, nor does it intend to acquire or will it acquire, a financial interest in any company manufacturing or distributing products it evaluates. 2. Trinity I ERD is not owned, operated or controlled by any company manufacturing or distributing products it evaluates. 3. Robert Nieminen, P.E. does not have nor will acquire, a financial interest in any company manufacturing or distributing products for which the evaluation reports are being issued. 4. Robert Nieminen, P.E. does not have, nor will acquire, a financial interest in any other entity involved in the approval process of the product. S. This is a building code evaluation. Neither Trinityl ERD nor Robert Nieminen, P.E. are, in anyway, the Designer of Record for any project on which this Evaluation Report, or previous versions thereof, is/was used for permitting or design guidance unless retained specifically for that purpose. -. , TRINfTY' ERD ROOFING SYsTENm EVALUATION: 1.; SCOPE: Product Category: Roofing Sub -Category: Asphalt Shingles Compliance Statemerrt: Owens Corning Asphalt Roof Shingles, as produced by Owens Corning, have demonstrated compliance with the following sections of the a Edition (2017) Florida Building Code and Florida Building Code, Residential Volume through testing in accordance with the following Standards. Compliance is subject to the Installation Requirements and Limitations / Conditions of Use set forth herein. 2. STANDARDS: Section Property Standard Year 1507.2.5, R905.2.4 Physical Properties ASTM D3462 2010 1S072.7.1, R905.2.6.1 Wind Resistance ASTM D3161 2016 15071.7.1, R9052.6.1 Wind Resistance ASTM D7158 2011 3. REFERENCEs: i Entity Examination Reference Date UL LLC (CER9626) Physicals & Wind Resistance File R2453, Vol. 3 02/15/2007 UL LLC (CER9626) Physicals & Wind Resistance 20120516-112453 05/16/2012 UL LLC (TST9628) Wind Resistance 4786126532 02/10/2014 ULLLC(TST9628) Physical Properties Oassification letter 02/13/2014 UL LLC (TST9628) Physical Properties Classification letter 10/02/2015 Miami -Dade (CER1592) FBC HVHZ Compliance Various NOAs Various UL LLC (QUA9625) Quality Control Service Confirmation Exp. 05/16/2020 4. I PRODUCT DESCRIPTION: 4.1 Asphalt Shingles: 4.1.1 Classic and Supreme" are fiberglass reinforced, 3-tab asphalt roof shingles. 4.1.2 Berkshire are fiberglass reinforced, 4-tab asphalt roof shingles. 4.13 Devonshiren' are fiberglass reinforced, 5-tab asphalt roof shingles. 4.1.4 Duration., TruDefinition* Duration', Duration* Premium Cool, TruDefinition' Durations Designer Color Collection, TruDefinition*Oakridge, Oakridge and WeatherGuard* HP are fiberglass reinforced, laminated asphalt roof shingles. 4.2 Hip & Ridge Shingles: 4.2.1 Berkshire Hip & Ridge Shingles, High Ridge, WeatherGuard HP Hip & Ridge Shingles, ProEdge Hip & Ridge Shingles and Durallidge" Hip. & Ridge Shingles are fiberglass reinforced, hip and ridge asphalt roof shingles. 4.3 Accessory Starter Strips: 4.3.1 Starter Strip Shingle, Starter Strip Plus and Starter Shingle Roll are starter strips for asphalt roof shingles. 5. LIMITATIONS: 5.1 This is a building code evaluation. Neither Trinity(ERD nor Robert Nieminen, P.E. are, in any way, the Designer of Record for an g y project on which this Evaluation Report, or previous versions thereof, is/was used for permitting or design guidance unless retained specifically for that purpose. 5.2 This Evaluation Report is not for use in FBC HVHZ jurisdictions. 5.3 Fire Classification is not part of this Evaluation Report; refer to current Approved Roofing Materials Directory for fire ratings of this product. Exterior Research and Design, LLC Evaluation Report 037940.02.12-RS Certifriete of/lut wd-tioa l9503 6"i EDITION (2017) FBC NON-HVHZ EVAWATiON F1.10674-1133 Owens Corning Asphalt RoofShingles Revision 8:10/0912017 Page 2 of 9 \ y i� TRIMTY ERD 5_4 Wind Classification: 5.4.1 All Owens Coming asphalt shingles noted herein are Classified in accordance with FBC Tables 1507.2.7.1 and R905.7 6.1 to ASTM D3161, Class F and/or ASTM D7158, Class H, indicating the shingles are acceptable for use in all wind zones up to Vasd = 150 mph (V„It = 194 mph). Refer to Section 6 for installation requirements to meet this wind rating. 5.4.2 All Owens Corning hip & ridge shingles, Starter Strip Shingle and Starter Strip Plus noted herein are Classified in accordance with FBC Tables IW7.2.7.1 and R905.2.6.1 to ASTM D3161, Class F, indicating the shingles are acceptable for use in all wind zones up to Vasa =150 mph (V„n =194 mph). Refer to Section 6 for installation requirements to meet this wind rating. 5.4.3 Classification by ASTM D7158 applies to exposure category B or C, as defined in FBC 1609A.3, and a mean roof height of 60 feet or less. Calculations by a qualified design professional are required for conditions outside these limitations. Contact the shingle manufacturer for data.specific to each shingle. 5.4.4 Refer to Owens Coming published information on wind resistance and installation limitations. 5.5 All products in the roof assembly shall have quality assurance audit in accordance with F.A.C. Rule 61G20-3. 6.' INSTALLATION: 6_1 Undedayment- 6.1.1 Underlayment shall be acceptable to Owens Coming and shall hold current Florida Statewide Product Approval, or be Locally Approved per Rule 61G:Z0-3, per FBC 1507.23,1507.2.4 or R905.2.3. 6_2 Asphalt Shinfales: 6.2.1 Installation of asphalt shingles shall comply with the Owens Coming current published instructions, using minimum four (4) nails per shingle in accordance with FBC LW7.2.7 or R905.2.6, with the following exceptions: ➢ Berkshire shingles require minimum five (5) nails per shingle. ➢ WeatherGuard HP shingles require minimum six (6) nails per shingle. ➢ Devonshire"' shingles require minimum six (6) nails per shingle. ➢ Starter Strip Shingle and Starter Strip Plus require minimum five (5) nails per strip. Refer to Owens Corning published information on wind resistance and installation limitations. 6.2.2 Fasteners shall be in accordance with the manufacturer's published requirements, but not less than FBC 1507.2.6 or R905.2.5. Staples are not permitted. 6.2.4 Where the roof slope exceeds 21 units vertical in 12 units horizontal, special methods of fastening are required. See figures below for details. 6.2.5 Minimum Nailing — Starter Strip Shingle and Starter Strip Plus: Felt undedayment Deck Self -adhered Weathed odd underlayment Drip — edge - I 'P edge Na,'Islaeated Y--3" from eave Install rust Self -searing adhesive Starter Step shingle with positioned along eave 6. removed Starter Strip shingle overhangs eaves and rakes F3 nnder6pmerH r• Deck Sd td erect WeatherLockD maedayment Ddp--- Drip edge tJa� bated r 3' ham eave p aiM eave iutal rbu Star strip Pla, rnth 6'ttagved Shrtar Strip Plrs overhangs saves and rakes 1/4 =3/v Exteria� Research and Design, LLC -Certffliw Elyditration Report 037940.OLi2-RS afAutl+oranacrrY95o3 6"' EDITION (2017) FBC NON-FiVt¢ EVALUATIONFL10674R13 Owens Coming Asphalt Roof shingles Revision 8:10109/2017 Page 3 of 8 6.2.6 Minimum Nailing—Uassice &Supreme- Homrat Mlmperd or Aroo para vrmd Areas Hgh Wind desysrr.s y Area pare vientas norm:/es Axe" ri;. fames r r r r lg r r �r it Exposftrd 4Pxposore n 6.2.7 Minimum Nailing —Berkshire*: aianaara rastening rattern TRINITY `ERD ea per& UArees WMb dUmmord oretetwne yy Area pars vienws nornraka Areas viarrtoa fnarras r r rz• r i 5 SW Exposure ftwsici6o s®ahnt strip L2sbde:d a . may.- . aW ave- avc• 6-Nail Fastening Pattern Exterior Research and Design. LLC. Evaluation Report 037M.02.12-R8 +1 off+ raetion W_.M 6r" EDITION (2017) FBC NON-HVHZ EVALUADON FL10674-R13 Owens Corning Asphalt Roof Shingles Revision 9:10/09/2017 Page 4 of 8 TRINITY' ERD 6.2.8 Minimum Nailing —Devonshire"': �• 1 7• 1 8" 1 $n -1- 8A ! 7n i 1" �• lJrUM 55/8• exposure Seafara bmtGn ExposWn de 5 518 pulp u6irautin del seQ66, Naas sue• --- - - = - -= -= -- -- ��.: Ten 1" Spots of AvW Hoof Cement Standard 6-Nail Fastening Pattern Mansard or Steep Slope Fastening Pattern 6.2.9 Minimum Nailing — Duration°, TruDefinition° Duration, Duration° Premium Cool & TruDefinition• Duration Designer Color Collection: 4-Nan Fastening Pattern ""iawI p am'19M 1L3L11DkW 1- 17, tr t FIT 5-Sfi' Standard Fastenine Pattern aWj S.SR- 641an Fastenhg Pattern SutltuDfasteritq era ti� 7- 7T I 1T s-�ecwo,.r • c+as�.o .•c..e.�mc:eras FIT F� F1 F� n FatenWg far5bpes GreaterThan 21_12 r-nz+.typl l vav Mansard or Steep Slope Fastening Pattern 6-Nail Fastening Pattern Exterior Research and Design. LLC Evacuation Report O37940.0L12-R8 armrca6eofAutLotiurtiang4518 6'" EDcnON (201T) FBC NON HVHZ EVALUATION FLID674R13 Owens Coming Asphalt Roof Shingles Revision 8:10/090017 Page 5 of 8 i 6.2.1 Minimum Nailing —TruDefinffion Oakridge•,Oakridgee: 4 Nail Padam Espema corn 4 d2ws Tr XS: 55/v Evas uv �� 55/B" E:posune FYpesiaarde55/8p+dg Cyys Exposccnde35/apidg Standard Fastening Pattern 6.2.1 Minimum Nailing —WeatherGuard" HP: - p:7RINIlY � ERD 6 Nail PaMm fsqu®w con S davos Ir 1' T 11615 &rpaucaa de55/Sptd¢ Fapusidoude 56/6pi1y. (-Nail Fastening Pattern F�r—=Mitlf. Exterior Research and Design, LLC Eva4rati n Report 037940.0212-R8 C eofAudkwholk e8950 67}f EDff*N PD17) FBCNON4W9EVAWATION FL10674-R13 Owens Coming Asphalt Roof Shingles Revision & 10/0e/2017 Page 6 of 8 TRINITY; ERD 6_3 Hip & Ridge Shingles: 63.1 Installation of Berkshire Hip and Ridge Shingles, .High Ridge, WeatherGuard HP Hip and Ridge Shingles and ProEdge Hip & Ridge Shingles shall comply with the Owens Coming current published instructions, using four (4) nails per shingle. Installation of DuraRid&m Hip & Ridge Shingles shall comply with the Owens Coming current published instructions, using two (2) nails per shingle. Refer to Owens Corning published information on wind resistance and installation limitations, including the use of hand -sealing for wind warranties. 6.3.2 Fasteners shall be in accordance with the manufacturer's published requirements, but not less than FBC 15072.6 or R905.2.5. Staples are not permitted. 6.3.3 Minimum Nailing —Berkshires Hip & Ridge and High Ridge: Fig.1 4 vFea w11d �04 i 1 1 1 I 1 �—� ExPosue — Fig. 2 TePv_ Sdevies "a. "is r Teplarewal r I Piece r 1 I I It 1 vl cl al 1 VI 1 1 I 1 6.3.4 Minimum Nailing— WeatherGuard® HP Hip and Ridge: Fig. C Hip & Ridge Shingle Fastening Top View Ram U2ft T' r r r ` r �R Exterior Research and Design. LLC Evatoabm Report 037940 OZ.IZ-Rii C." EDITION (2017) RC NON-HVHZ EVALUATION FUQ574.R13 Owens Coming Asphalt Roofshingtes Revision 8: 20/09/2017 ' Page 7 of 9 6.3.5 Minimum Nailing - ProEdge Hip & Ridge Shingles: Prevaiing Wind Direction stbmS* f--' 6' 6qmw Fasten 7V Covtr Etpe:ed Fasfiners.rith Roof Genet TRINITY; ERD Standard Fastening Pattern r-1 I_r 11 �r ,�• 1 Sealant 1'�• 6'E=p ame 6.3.6 Minimum Nailing— DuraRidge" Hip & Ridge Shingles: Note: The drawings below pertain to minimum, as -tested attachment requirements. Refer to Owens Coming published installation instructions for their minimum requirements. Top Vie. Vw en plan r TMap�tior t ow�,acmvgsa.waa I I I`C 0 1L1bop � 6 V I 1� I 7. LABELING: 7.1 Labeling shall be in accordance with the requirements the Accredited Quality Assurance Agency noted herein. 7.2. Asphalt shingle wrappers shall indicate compliance with one of the required classifications detailed in FBC Table 1507.2-7.1 / R905.2.6.1. S. BUILDING PERMrr REQUIREMENTS: As required by the Building Official or Authority Having Jurisdiction in order to properly evaluate the installation of this product. 9. MANUFACTURING PLANTS: Contact the named QA entity for information on which plants produce products covered by Florida Rule 9N-3 QA requirements. 10. QUALITY ASSURANCE ENTITY: UL LLC— QUA9625 ; (631) 546-2458; Kanchi.Agrawaia-Dokania@ul.com - END OF EVALUATION REPORT - Exterior Research and Design, LLC of AWWdW ve Viso 6TM EDITION (2017) FBC NON-HVHZ EVALUATION EvaAwoao FFL10174R13 Owens Corning AsphaR Roof `hkcks Revision & 10/09/201.7 Page 8 of 8