HomeMy WebLinkAboutEVALUATION REPORT - ASPHALT ROOF SHINGLESI
I
EXTERIOR RESEARCH & DESIGN, LLC.
Certificate of Authorization #9503
�("�(� '.. SCANNED 353 CHRISTIAN STREET, UNIT#13
I,R1(1 ! ..1 GRD.
BY OXFORD, CT 06478
St Lucie Count (203) 262-9245
EVALUATION REPORT y
vwens Corning Evaluation Report 037940.02.12-118
OnelOwens Corning Parkway FL10674-1113
Toledo, OH 43659 Date of Issuance: 02/06/2012
(746) 404-7829 Revision 8: 10/09/2017
SCOPE:
This Evaluation Report is issued under Rule 61620-3 and the applicable rules and regulations governing the use of
construction materials in the State of Florida. The documentation submitted has been reviewed by Robert Nieminen,
P.E. for use of the product under the Florida Building Code and Florida Building Code, Residential Volume. The
products described herein have been evaluated for compliance with the 6th Edition (2017) Florida Building Code
sections noted herein.
Owens Corning Asphalt Roof Shingles
9ELING: Labeling shall be in accordance with the requirements the Accredited Quality Assurance Agency noted
jein and FBC 1507.2.7.1 / R905.2.6.1.
NTINUED COMPLIANCE: This Evaluation Report is valid until such time as the named product(s) changes, the
`erenced Quality Assurance documentation changes, or provisions of the Code that relate to the product change,
ceptance of this Evaluation Report by the named client constitutes agreement to notify Robert Nieminen, P.E. if the
)duct changes or the referenced Quality Assurance documentation changes. TrinityJERD requires a complete
/iew of this Evaluation Report relative to updated Code requirements with each Code Cycle.
VERTISEMENT: The Evaluation Report number preceded by the words "Trinity) ERD Evaluated" may be displayed in
vertising literature. If any portion of the Evaluation Report is displayed, then it shall be done in its entirety.
;PECTION: Upon request, a copy of this entire Evaluation Report shall be provided to the user by the manufacturer or
distributors and shall be available for inspection at the job site at the request of the Building Official.
is Evaluation Report consists of pages 1 through 8.
:pared by: '
t J.M. Nieminen, P.E.
Registration No. 59166, Florida DCAANE1983
The facsimile seal appearing was authorized by Robert
Nleminen, P.E. on 10/09/2017, This does not serve as an
electronically signed document.
CERTIFICATION OF INDEPENDENCE:
1. Trinity ERD does not have, nor does It intend to acquire or will it acquire, a financial interest in any company manufacturing or
distributing products it evaluates.
2. Trinity ERD is not owned, operated or controlled by any company manufacturing or distributing products it evaluates.
3. Robert Nieminen, P.E. does not have nor will acquire, a financial interest in any company manufacturing or distributing products for
which the evaluation reports are being issued.
4. Robert Nieminen, P.E. does not have, nor will acquire, a financial interest in any other entity involved in the approval process of the
product.
15. This is a building code evaluation. Neither Trinityl ERD nor Robert Nieminen, P.E. are, in any way, the Designer of Record for any
project on which this Evaluation Report, or previous versions thereof, is/was used for permitting or design guidance unless retained
specifically for that purpose.
I
TRINITY ERD
ROOFING SYSTEMS EVALUATION:
1. SCOPE:
Product Category: Roofing
Sub -Category: Asphalt Shingles
Compliance Statement: Owens Corning Asphalt Roof Shingles, as produced by Owens Corning, have demonstrated
compliance with the following sections of the 6th Edition (2017) Florida Building Code and Florida Building Code,
Residential Volume through testing in accordance with the following Standards. Compliance is subject to the
Installation Requirements and Limitations / Conditions of Use set forth herein.
2. I STANDARDS:
Section Pro a Standard Year
1507.2.5, R905.2.4 Physical Properties ASTM D3462 2010
1507.2.7.1, R905.2.6.1 Wind Resistance ASTM D3161 2016
1507.2.7.1, R905.2.6.1 Wind Resistance ASTM D7158 2011
3.; REFERENCES:
Enti Examination Reference Date
UL LLC (CER9626) Physicals & Wind Resistance File R2453, Vol. 3 02/15/2007
UL LLC (CER9626) Physicals & Wind Resistance 20120516-112453 05/16/2012
UL LLC (TST9628) Physical Properties 06CA20263 04/18/2006
UL LLC (TST9628) Wind Resistance 11CA34308 02/18/2012
UL LLC (TST9628) Physicals & Wind -Resistance 4786093137 02/01/2014
UL LLC (TST9628) Wind Resistance 4786126532 02/10/2014
UL LLC (TST9628) Physical Properties Classification letter 02/13/2014
UL LLC (TST9628) Physical Properties Classification letter 10/02/2015
Miami -Dade (CER1592) FBC HVHZ Compliance Various NOAs Various
UL LLC (QUA9625) Quality Control Service Confirmation Exp. 05/16/2020
4,I PRODUCT DESCRIPTION:
4.1 Asphalt Shingles:
j 4.1.1 Classic* and Supreme* are fiberglass reinforced, 3-tab asphalt roof shingles.
4.1.2 Berkshire' are fiberglass reinforced, 4-tab asphalt roof shingles.
4.1.3 DevonshireT1 are fiberglass reinforced, 5-tab asphalt roof shingles.
4.1.4 Duration', TruDefinition* Duration, Duration* Premium Cool, TruDefinition* Duration' Designer Color
Collection, TruDefinition*Oakridge*, Oakridge* and WeatherGuard* HP are fiberglass reinforced, laminated
asphalt roof shingles.
4.2 Hi 3 & Ridge Shingles:
4.2.1 Berkshire' Hip &.Ridge Shingles, High Ridge, WeatherGuard* HP Hip & Ridge Shingles, ProEdge Hip & Ridge
Shingles and DuraRidgeT"I Hip & Ridge Shingles are fiberglass reinforced, hip and ridge asphalt roof shingles.
4.3 Accessory Starter Strips:
4.3.1 Starter Strip Shingle, Starter Strip Plus and Starter Shingle Roil are starter strips for asphalt roof shingles.
15. LIMITATIONS:
5.1 This is a building code evaluation. Neither Trinity IERD nor Robert Nieminen, P.E. are, in any way, the
Designer of Record for any project on which this Evaluation Report, or previous versions thereof, is/was used
for permitting or design guidance unless retained specifically for that purpose.
i
5.2 This Evaluation Report is not for use in FBC HVHZ jurisdictions.
5.3 Fire Classification is not part of this Evaluation Report; refer to current Approved Roofing Materials Directory
for fire ratings of this product.
I
Exterior Research and Design, U.C. Evaluation Report 037940.02.12-R8
Certificate ofAuthori otion #9503 e' EDITION (2017) FBC NON-HVHZ EVALUATION FL10674-1113
Owens Coming Asphalt Roof Shingles Revision 8:10109/2017
Page 2 of 8
I
TRINITY ERD
S.4 Wind Classification:
5.4.1 All Owens Corning asphalt shingles noted herein are Classified in accordance with FBC Tables 1507.2.7.1
and R905.2.6.1 to ASTM D3161, Class F and/or ASTM D7158, Class H, indicating the shingles are acceptable
for use in all wind zones up to Vasd = 150 mph (V,lt = 194 mph). Refer to Section 6 for installation
requirements to meet this wind rating.
5.4.2 All Owens Corning hip. & ridge shingles, Starter Strip Shingle and Starter Strip Plus noted herein are
Classified in accordance with FBC Tables 1507.2.7.1 and R90S.2.6.1 to ASTM D3161, Class F, indicating the
shingles are acceptable for use, in all wind zones up to Vase =150 mph (Vwt = 194 mph). Refer to Section 6 for
installation requirements to meet this wind rating.
5.4.3 Classification by ASTM D7158 applies to exposure category B or C, as defined in FBC 2609.4.3, and a mean
roof height of 60 feet or less. Calculations by a qualified design professional are required for conditions
outside these limitations. Contact the shingle manufacturer for data specific to each shingle.
5.4.4 Refer to Owens Corning published information on wind resistance and installation limitations.
5.5 All products in the roof assembly shall have quality assurance audit in accordance with F.A.C. Rule 61G20-3.
6.1 INSTALLATION:
6_1 Underlavment:
6.1.1 Underlayment shall be acceptable to Owens Corning and shall hold current Florida Statewide Product
Approval, or be Locally Approved per Rule 61G20 3, per FBC 1507.2.3,1507.2.4 or R905.2.3.
6_2 Asphalt Shingles:
6.2.1 Installation of asphalt shingles shall comply with the Owens Corning current published instructions, using
minimum four (4) nails per shingle in accordance with FBC 1507.2.7 or R905.2.6, with the following
exceptions:
➢ Berkshire` shingles require minimum five (5) nails per shingle.
> WeatherGuard` HP shingles require minimum six (6) nails per shingle.
A Devonshire"" shingles require minimum six (6) nails per shingle.
> Starter Strip Shingle and Starter Strip Plus require minimum five (5) nails per strip.
Refer to Owens Corning published information on wind resistance and installation limitations.
6.2.2 Fasteners shall be in accordance with the manufacturer's published requirements, but not less than FBC
1507.2.6 or R905.2.5. Staples are not permitted.
6.2.4 Where the roof slope exceeds 21 units vertical in 12 units horizontal, special methods of fastening are
required. See figures below for details.
6.2.5 Minimum Nailing — Starter Strip Shingle and Starter Strip Plus:
Felt undartayment
Self -adhered
WeatherLoco
underiaymed
)), RriPWile
located
from eave
Starter Strip shingle overhangs eaves and rakes % 44,
Research and Design, I.I.C.
ojAuthorizatfon#9509 6r" EDITION (2017) FBC NON-HVHZ EVALUATION
Owens Coming Asphalt Roof Shingles
� Haib (acated
Sdfaenling adhasba
Positioned alone can
starttr 9tr1p Plus ovatimps taros and rakes tl4-2 4"
Evaluation Report 037940.02.12.R8
FL10674-R13
Revision 8:10/09/2017
Page 3 of 8
'1.
6.2.6 Minimum Nailing — Classic® & Supreme:
Noma', Mansard or Aroa pare
Wind Arese High Wind dssvenea y
Arai par& viontos aormalos A►ems' vistas ht 'i
♦r . . .
5°Exposuro
Exposicibn.
6.2-7 Minimiim Nailino— Rarltchiram-
manaara rastenine Pattern
��TRRINITYJERD
Normal Mansard or Area pare
WindArtas High Wind desvarissV
Area pars vientos normal" Areas tvfantes faertas
.. ..
I
6OW Exposure
Esposlst6n
sears strip
LaibadosOWor
6-Nail, fastening Pattern
Research and Design, I.I.C. Evaluation Report 037940.02.12-118
of Authorkation#9503 6T" EDITION'(2017) FBC NON-HVHZEVALUATION FL10674-R13
Owens Coming Asphalt Roof Shingles Revision 8:10/09/2ov
Page 4 of 8
I
I
I
I
i
I
6.2.8 Minimum Nailing — DevonshlW":
1" I• 7 1 8+1. g" �l«— 8" 1 7"
arras
Expos
Expos exposure lcidn de 5.5/8 ping Sealant locationU6lcaci6n del sidlador
QOTRINERD�
Nails
r e 1 r
Ten V 5 ots of kphalt Roof Cement
zaanoaro n-Nau Fastening Pattern Mansard or Steep Slope Fastening Pattern
6.2.9 Minimum Nailing — Duration®, TruDefinition® Duration, Duration® Premium Cool & TruDefinitiono
Duration Designer Color Collection:
Standard Fastening Pattern
I
I
Extel for Research and Design, I.I.C.
Certificate of Authorization #9S03
6-Nail Fastening Pattern
Fastaahig for Stapes Gmater Thar* 21:12
4urNiHW1&M iiRgw WiflM;
./1p,4N
dr
Ysa"
Ft#TT"
k81t
i
y ¢j
01
1
rn"+'!po"afA�PluARoaRn9 gme�x
Mansard or Steep Slope Fastening Pattern
br" EDITION (2017) FSC NON-HVHZ EVALUATION
Owens Coming Asphalt Roof Shingles
Evaluation Report 037940.02.12-R8
FL10674-1113
Revision 8:10109/2017
Page 5 of 8
6.2.1 Minimum Nailing — TruDefinition Oakridge®, Oakridge®:
4 Nall Pattom
EWema con 4 claws
Ir
Ir
65..r8"6cposare rises 6:b�"���
61postotvndeSSl8Pri119 Cloves . Firpusrcldode.6r✓6pulg
Standard Fastening Pattern
i I—
QNTRINITYIERD
6 Nall iafam
Esoertia coo 6 claws
ir.
-- Ff— I
E£it
—
�q k >}
y 3 d3
ca��kgaar ,:
SWO, Exposure clav�os 6 ii/W Exposure
Expositf6nek6Sl8put& lzpoadbnd66/Spul4
21:12
a mitt
rotm
it
Mansard or Steep Slope Fastening Pattern
6.2.1 Minimum Nailing — WeatherGuard® HP:
Exterior Research and Design, LLC.
Cer9ficol a ojAuthorbotion #9503
6-Nall Fastening Pattern
1 1
MnobiitdrVbW
S I'3" �4 •'•.'. • : s' Rye
crrw.wrn;..�A.vr�
6'H EDITION (2017) FBC NON-HVHZ EVALUATION
Owens Corning, Asphalt Roof Shingles
Evaluation Report 037940.02.12-RS
FL10674-R13
Revision 8:10/09/2017
Page 6 of 8
lf�'INITYIERD
6_3 Hip & Ridge Shingles:
6.3.1 Installation of Berkshire" Hip and Ridge Shingles, High Ridge, WeatherGuard@ HP Hip and Ridge Shingles
and ProEdge Hip & Ridge Shingles shall comply with the Owens Corning current published instructions,
using four (4) nails per shingle. Installation of DuraRidge"" Hip & Ridge Shingles shall comply with the
Owens Corning current published instructions, using two (2) nails per shingle. Refer to Owens Corning
published information on wind resistance and installation limitations, including the use of hand -sealing for
wind warranties.
6.3.2 Fasteners shall be in accordance with the manufacturer's published requirements, but not less than FBC
1507.2.6 or R90S.2.5. Staples are not permitted.
6.3.3 Minimum Nailing — Berkshire® Hip & Ridge and High Ridge:
[FIg..2 i To0flaw SW@1New
Has
- - Neils'
V Tppl:"aaronated r,.
a p Rece I
I
i
i
i
i
I "I
—4 '
air
6.3.4 Minimum Nailing — WeatherGuard® HP Hip and Ridge:
Fig. A �_..__ 9 v
PaYairocletrtgwpM
wind
3
A i t
I i
�E%pOselis � ..
Exterior
Exterior Research and Design, LLC.
Certificate 9 fAuthorization #9503
Fig. CAlp & Ridge Shingle Fastening
To""W
Fulls Nall '
r
EDITION (2017) F6C NON-HVHZ EVALUATION
Owens Coming Asphalt Roof Shingles
Evaluation Report 037940.02.12-118
F1.10674-1113
Revision 8:10109/2017
Page 7 of a
6.3.5 Minimum Nailing - ProEdge Hip & Ridge Shingles:
Prevailing
Wind Direction $e*ntSlrip
A*--' 6- Exposure
J
TRINITY ERD
Standard
Fastening
Patternit, Sleount
�• `�
71je V Exposure
6.3.6 Minimum Nailing — DuraRidgel" Hip & Ridge Shingles:
Note: The drawings below pertain to minimum, as -.tested attachment requirements. Refer to Owens Corning
published installation instructions for their minimum requirements.
Top.Yunx
Yuaert plan
T l- Ybduq�eriar I•I
I
i
I
i
C ib
u I
I
I_y
i
7. LABELING:
7.1 Labeling shall be in accordance with the requirements the Accredited Quality Assurance Agency noted
herein.
7.2 Asphalt shingle wrappers shall indicate compliance with one of the required classifications detailed in FBC
Table 1S07.2.7.1 / R905.2.6.1.
S. BUILDING PERMIT REQUIREMENTS:
As required by the Building Official or Authority Having Jurisdiction in order to properly evaluate the installation of
this product.
9. MANUFACTURING PLANTS:
Contact the named QA entity for information on which plants produce products covered by Florida Rule 9N-3 QA
requirements.
10. QUALITY ASSURANCE ENTITY:
UL LLC—QUA9625 (631) 546-24SB; Kanchi.Agrawala-Dokania@ul.com
END OF EVALUATION REPORT -
Exterior Research and Design, U.C. Evaluation Report 037940.02.12-R8
Certificate of Authorization g9503 67" EDITION (2017) FBC NON-HVHZ EVALUATION FL10674-R13
Owens Coming Asphalt Roof Shingles Revision 8: 10/09/2017
Page 8 of 8