HomeMy WebLinkAboutNOAMI'AMI•DADE __ SCANNED
BY NITAAII-DADE COUNTY
St. Luce Conntt, PRODUCT CO\TROLSECTION
11805 SW 26 Street, Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES (RER) Miami, Florida 33175-2474
BOARD AND CODE ADMINISTRATION DIVISION T (786) 315-2590 F(786)315.2599
NOTICE OF ACCEPTANCE (NOA) ,»yw.mtaotidade.eoc/economy
EGS International, LLC
3133 S.W. 25's Street
Pembroke Party FL 33009
.SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction materials. Tile
documentation submitted has been reviewed and accepted by Miami -Dade County PERA -Product Control Section
to be used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction (AHJ).
This NOA shall not be valid after the expiration date stated below. The Miami -Dade County Product Control Section
(In Miami Dade County) and/or the AHJ (in areas other then Miami Dade County) reserve the right to have this
product or material tested for quality assurance purposes. If this product or material fails to perform in late accepted
manner, the manufacturer will incur the expense of such testing and the AHJ may immediately revoke, modify, or
suspend the use of such product or material within their jurisdiction. PERA reserves the right to revoke this
acceptance, if it is determined by Miami -Dade County Product Control Section that this product or material fails to
meet the requirements of the applicable building code.
This product is approved as described herein, and has been designed to comply with the Florida Building Code,
including the High Velocity Hurricane Zone.
DESCRIPTION: Atlantic Series Aluminum Slitting Glass Door—S.M.I.
APPROVAL DOCUMENT: Drawing No. W04-80 Rev A, titled "Atlantic Series SMI 130 Alum Sliding Glass
Door", sheets I through 8 of 8, prepared by AL-Farooq Corporation, dated 09/10/04 and last revised on DEC 18,
2014, signed and sealed by Javad Ahmed, P.E., bearing tire Miami -Dade County Product Control Revision stamp
with the Notice of Acceptance number and expiration date by the Miami -Dade County Product Control Section.
MISSILE IMPACT RATING: Small Missile Impact Resistant
Limitations:
1. See Design Pressure (DP) ratings with glass types & Reinforcing in sheet 2. See DP ratings of anchor types in
sheet 3. Lower Design Pressure Ratings shall apply to entire system.
2. Positive (Exterior) DP shall be limited to sill heights per sheet I.
3. All SOD doors containing operable panel (X) require channel reinforcement (item #31) at Bottom Rails.
4. The frame area of alternate size unit shall not exceed the frame area of the tested approved unit per FBC
2411.3.2A (i) (1)
LABELING: Each unit shall bear a permanent label with the manufacturer's name or logo, city, state and series and
following statement: "Miami -Dade County Product Control Approved", noted herein.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there Ices been no
change in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials, use, and/or manufacture of the product or process. Misuse of this NOA as all endorsement of any product,
For sales, advertising or any other purposes shall automatically terminate this NOA. Failure to comply with any
section of this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami -Dade County, Florida, and followed by the
expiration date may be displayed in advertising literature. If any portion of the NOA is displayed, then it shall be
done in its entirety.
INSPECTION: A copy of this entire NOA shall he provided to the user by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official.
This NOA revises & renews NOA 012-0131.15 and consists of this page 1 and evidence pages E-1, as well as
approval document mentioned above.
The submitted documentation was reviewed by Ishaq I. Chmida, P.E.
j= -�- NOA No. 14-0807.18
MIAMFD Eeo Expiration Date: December 24, 2019
1 Approval Date: December 24, 2014
.t\ :
EGS International. LLC
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
A. DRAWINGS
1. Manufacturer's die drawings and sections (Submitted under files #12-0131.15 /#09-0520.08)
2. Drawing No. W04-80 Rev H, titled "Atlantic Series SMI 130 Alton Sliding Glass Door", sheets
1 through 8 of 8, prepared by AL-Farooq Corporation, dated 09/10/04 and last revised on DEC
18, 2014, signed and sealed by Javad Ahunad, P.E.
B. TESTS (Submitted under files #12-0131.15 /#09-0520.08)
1. Test reports on: 1) Unifonu Static Air Pressure Test, Loading per FBC, TAS 202-94
2) Large Missile Impact Test per FBC, TAS 201-94
3) Small Missile Impact Test per FBC, TAS 201-94
4) Cyclic Wind Pressure Loading per FBC, TAS 203-94
along with marked -up drawings and installation diagram of an aluminwn sliding glass door, prepared
by Fenestration Testing Laboratory, Inc., Test Report No. FTL-5728, dated 10/10/08, signed and
sealed by Carlos Rionda, P.E.
2. Test reports on: 1) Air Infiltration Test, per FBC, TAS 202-94
2) Uniform Static Air Pressure Test, Loading per FBC TAS 202-94
3) Water Resistance Test, per FBC, TAS 202-94
4) Small Missile Impact Test per FBC, TAS 201-94
5) Cyclic Wind Pressure Loading per FBC, TAS 203-94
6) Forced Entry Test, per FBC 24113.2.1, TAS 202-94
along with marked -up drawings and installation diagram of an aluminum sliding glass door, prepared
by Fenestration Testing Laboratory, Inc., Test Report No. FTL-4183, dated 05/18/04, sighed and
sealed by Edmundo Largespada, P. E.
along with marked -up drawings and installation diagram of an aluminum sliding glass door, prepared.
by Fenestration Testing Laboratory, Inc., Test Report No. FTL-2652, dated 05115/00, signed and
sealed by Aldo P. Gonzales, P. E.
3. Additional reference test report FTL 1622, per SFBC PA 201,202 & 203-94, issued by
Fenestration Testing Lab, signed & sealed by Late gilbert Diamond, P.E. along with addendum
letter dated 05/01/98, issued by Fenestration Testing Lab.
C. CALCULATIONS
1. Anchor verification calculations and structural analysis, complying with FBC-2014, prepared by
Al Farooq Corporation, dated 07/23/14 and last revised on DEC 03, 2014, signed and sealed by
Javad Ahmad, P.E.
2. Glazing complies w/ ASTME1300-02 & -04
D. QUALITY ASSURANCE
1. Miami Dade Department of Regulatory and Economic Resources (RER).
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 12-1231.08 issued Eastman Chemical Company (MA) former Solutia
Inc. for "Saflex CP T`r - Saflex and Saflex HP Composite Glass Interlayer w/ PET Core",
expiring on December 11, 2018.
F. STATEMENTS (Submitted under files # 12-0131.14)
1. Statement letter dated 07/14/14, compliance to FBC2014 (Sr^ edition) and No financial interest,
prepared by Al Farooq Corporation, signed and sealed by Javad Alunad, P.E.
2. Lab compliance as part of the above referenced test report.
G. OTHER
1. This NOA revises & renews NOA #12-0131.15, expiring on DEC 30, n 4.-j�-
lshhdgq 1. Chanda, P.E.
Product Control Examiner
NOA No.14-0807.18
Expiration Date: December 24, 2019
Approval Date: December 24, 2014
E-1
rneoucrntvns(r
w.vb�wen.rt.w``
anDE OPEIONCS:
MO. NE9R . PMIEL MOTH
- BDTJ'
DLO. ROO1 . PM NEW
- 8r
PEML N[Crt . OOOR HEanf - 2'
SEE SN[ET 2 row OEOOI L OE Tf OF DESMED GLAWREWf.
16No PORE 6N SNEEI J SLIEm A OR OPTON YYRN CMW
WOOrO NOQ< TXW OESCa EDWS R[a6®.
LOM DESIGN PR6WR6 EROV CLASS OR ANCHOR CNNEIS
tTl APPLY TO ENfaE SYS1flL
TWS vRC01CI �.15 BEDI aCROfIID MD RsnD TO camy m ra
iaP m n�mOOE O=NG OOm eallmaP Moan
1� OR IDY TNOG =KS Or pp1111aOpp55,, m OE /NaIDRD) PROPMY
TOTRMOFfR suss TO Im BIRDCIIAE
Axoro.Rf 5%U1 OE AS (BriD. WP m SNOYN ON OR/a9. AI✓DI0R9
aoantiwr ro BAa uvova saL a mrwm wu o�.ma a sruoon
AICWIUnI oa Lowx caxOmOia nm snarN a TIO'.SE DETA34 iwE
rom vAm m nos �vrRacu.
A LOAO a1R.tlCa P S Utm a m OF AXO PRO MO My..
WJWALS aaDOao Our NPr 1W110) ro SOM1tlS TNT
Of MIS m a�mPe. suu uOn ra
6M bO11011®rt a AMQ
(TESTED 9ZE)
ON(002O ONO (PC." onxeleuml
ND ---
APPLCAOU CORM ROAQRE DDB TO BE REnLVED
BY 1NL
ALL MR P6l lU MT BE m AOWIO a m
EOS 2RTALUION WBriUmONO.
ALL SEALN TO BE TREDOO SPEOTROI 2.
r�gn,.wo xo
�. DA 4ve
am.m2 ".
W04-80
B SY SSS i SSTSYT
Eta S S T
S S T S S t iutT9zT99z
i S S T
S STSSL i SS 2111
W
iitt5b5be�ttiSo6ob66��-g5ob8bbtE=glb
mbbo5eb=��b�bbbbe
9
�bbbtt
sbbbbbg
"sbbbbbb'esbb€bbeYem
b
bbbb
oja�{�eXxbaeojj::je{jb�jb�gb
e:55bb65bb
biibbbbbgbobbbbbbbbbb
7bGbk
kPba:
kb jb�bb
kb aj�n(:(b
b'Z
k6
bblbbbES6Li55S60
jg5 o
jb(kb
}g�j�a;{kpjo�
pbbbbR��
bb?'g
�
T85L�SS"^YS&d�SS: $5�
X g
rw=.p
>Qt it FFF6
6�
�bje�gg#bbbebbgGkgbkgkb—�
m�
' 4bbbbbbb b bbbbbbbb
no C+9�
5x uuuUiiii
�;3
LD
�m
�ogx
mt0
S�bN
NIui
3/B' 141t fro. in
awv atrt �
�
w c
e �
G
m
AI1.'dCMO91 ImWet sma wm
A4FAR000 CORPORATION
aNgEM.
t1C�oct�7133 SW. 2WH SIPEEfPQA2R01�
Owl,
PS FL 77009ort
1R l�0 Yw-Iwt rYt (GSQ Oex-tSDjrt101-BCFeS
mx to m momtn
MINOR TAN wagTr - DSP TYPICAL ANCHORS: SEE OUN. DCR SPAC910
AIDED MCI 1 '4' TY A'C — AT HIM — — — — -- — — —
IUDab A® T 4, IYPE'A'- tf4- 0% Ln TRImN BY'ELC0' (Fn y.l W. F7.tb M)�
aura. am. 1iYR
IW41 W0114 ww II 01® NtSt � n0t wf INTO 26Y WOOD SUCKS OR WOOD STRUCTURES
BRIM IAGa Om ({) Co.0) m. (1) I i-1/2' MIX PENETRATION INTO WOOD
W9 . M. (.1 M. (-I M. 1.1
31 INA Ina Ib.O I 1-1 IBM BUCKS D I O CONCRETEI
b I= 1390 I3aD I-1/4' MIN. ENDED IMO mNCRETE
b 1x7 1=7 1.10.0 I TYPE 'B'- 1/4_ 0 e 1.1118CON BY 'FTm' (Fw17) m. I1,-155 M)
30-1/4 1174 1172 I= DIRECTLY INTO CONCRETE
42 1112 1112 130A I 1-3/4' MI. EMBED I
a 114 1065 INS t n0 TYPE 'a'- 1/4' DIA RFIC pRR11N0 SCRFWB
m %A %A ISn0 (ONOC N
54 P24 0.4 taco I INTO YMIIL-ONE COUNTY APPROVED MULLIONNSS (1/B' INK. MIN.) I
b 903 9A3 127.9 IMO METAL STRUCTURES
m 853 N63 Iv.) I STEEL : 1/8' THK. MIN. (FY - 36 KSI UN
w 1R0 M2 t=7 ALUMINUM 1 1/8' TKK. MEN. (6063-T5 MIN.)
b Ina Ib.O I=3GS L — —(STEEL IN CONTACT WON ALUMINUM m BE PLATED OR PAINTED) 1
b IMJ IIU 1360 — — — — — — -I
39-1/4 I10] 1f0] 1]0.0 r —� 81� - —
VO I TYPE'B'- 114' dA La MOON BY'!1m' (Fu.ln K9. FY-10 Wit)
43 INS INS Ina
DIRECTLY IN. CONCRETE
45 wa w3 Ia0.0
50 91.4 61.1 Ina L ——1-3/1' MIN. EMBED — — — — _ — —
w w3 NSa 1213 _ — — —
(- — — — — — —AT le ug-177 in Mlm no �
TT'PE 'A'- 1/P dA IRTRMCON Bf 'Rm'
I INTO 29Y WOOD BUCKS OR WOOD STRUCTURES30
1-1/2- MIN. PENETRATION INTO WOOD
I THRU HIT BUCKS DOD CONC. OR MASONRY I
ANCHOR TYPES A. D. C APPLICABLE AT HEAD 1-1/4' MIN. EMBED INTO CONC. OR MASONRY
ANCHOR TYPE B APPLICABLE AT SILL I TYPE 'B'- 1 /4' n e1 /4' n e KII�eCDN RF 'A d1'R! 'A dl' (Fi.-1n K51. Fy-15! KS' I
DIRECTLY INTO OONC. OR HLLEO BLDCKS'
I 1-J/1' MIN. EMBED INTO CONCRETE I
awRVETlonaeN 1-1/4' MIN. EMBED INTO MK-MW BLOCK
n4aeDOLt•1O4 W1IM1 I I
M15Ry CON TYPE 'C'- 014 Ova OR CL] F MIMIC Ft'RFVS (W 5 ORD
nvu�K - a7. g I UHO M91YI-BADE COUNTY APPROVED MULLIONS (1/B' THK. MIN.) I
5 ) 9 IN1O METAL STRUCTURES
F 7 I STEEL : 1/8' 7KK. Nw. (FY JB K51 MINI
I
: 1/B' 1HK.43
L — —(STEEL IN CONTACT WITH ALUMINUM TO BE PLATED OR PAINTED)J49
dH�EDGE�51
CONCRETE - 3-1/2' "
RIIO W000 SIRUCIUIIE .1'MRL
INTO METAL STRUCTURE . 3/4.
WOOD AT HEAD. SEL OR JAMBB SO . OAS WIL
CONCRETE AT HEAD, SILL OR JAMBS f9 . 300D PSI MN.
C-90 HOMOW/fRUE0 HIM AT JAMBS fm . 3000 PSI YOL
•m
ro
MINOR
TAN
Mum
- M
AnN
1176
'A'
'e'
A V
p and
IB19t
"0"'
pm
Kim
tla0
1117aC1
nun
RUM
11�'b
elan
! Om
01®
ITYn
slot 9m
_
O
O
+i
1{i
.QT
g
((
i-o
W. (0)
M. -
N
m. (4)
W. -
m. (4)
M -
w
b
b
m-1/4
13
15
N
54
b
m
N4
IRO
INS
Ina
_
Imo
Ina
Inn
Ina
ImA
IRO
IRO
bOA
Ina
14"
14"
14"
INA
I=
NOa
Iw
1=0
MOD
ISOA
ISOa
Uw)
Ix1
Ix{
Ix1
tVA
tno
II7A
w
b
b
39-1/4
42
15
b
51
35
m
99
117A
150E
17A
Im0
1mA
INS
$
$
ii
�j -n0
@@
aa
rA
{{
O
_
G
]
A'
3 0
S
a
n a
ISDA
1NOD
1R0
1574
1%]
ISOA
1{O3
1493
1193
ISaD
IRO
130,0
IRA
I30O
Iba
I%.7
197.7
1bA
ISS.I
tx1
Ix1
I VA
TVA
IV.a
34
b
SO-1/4
43
b
m
W
Be
m
9N
Imo
I=
ISOA
INS
Ina
IWO
IN.?
Ix)
ImA
1412
1442
IRO
IRO
Ina
ISOA
1!!J
1x7
I.bO
Iva
I=
IRA
I154
1155
I=
�
p
p
R
iml
I14.1
I3
100.1
109.7
II7A
u
b
35
w-I/1
NS
Im
130.a
Ina
1ba
1300
1300
VOA
Vn0
IJ0.0ALUMINUM
Ina
Wl�
Inam
1=0
I3n0MID
10.4
TVA
94
R
b
IN
I360
Ina
IRO
1Ra
Ina
IaUD
gW04-�O
IJDA
IRC
IROb-I/4
VS]
1x3
Ianatl
11n9
IINA
IROb
1%.7
107.7
130)m
Iw.7
10A7
IRONS
13N)959
M
I.
933
%a
117a62014
9IOO1 OI
Tr
O
PA S
I
SEALANT
ALL JOINTS AND FRAME CONNECTIONS SEALED
WRN
WNRE/ALUMINUM COLORED SIUCONE.
MAJOR INTERLOCK STILES TOP AND BOTTOM ENDS MU D
WITH EXPANDING URETHANE TOM.
ALL WSTNU110N ANCHOR HEADS TO BE SEA'FII
k EXPOSED ANCHORS TO BE CAPPED WITH ALUM.
SUITON COMA
IYEEPROLES:
W1 a 3/16'N X J/fW WEEP SLOTS
AT QUARTER POINTS OF FALL PANEL
WZ a O/B' WEEP HOLE AT 6' FROM ENDS
E . �
AND CENTER OF EACH RAIL
�iam
WOOD BUCKS NOT BY EGS M. MUST SUSTAIN
LOADS IMPOSED BY GLAZING SYSTEM ANO TRANSFER
THEM TO THE BUILDING STRUCTURE.
11C(�1 B
W04-BO
M a eT Rl
...
Amu
■
11�I■III
1�1
fit,
-
�1
-
.
fi��
O
i�
,m3 grg P
r fi
Y u'
3 '
c
,
�'mfE LL9F •' _ P
e` g
n amc s-+a-ar a ^^K OWE MO W Im wec MM V= now AL FAR000 CORPORATION 8
O .ma ,?.r r nnsn vo�mamors EGS INnEIM ONILL, LLC omo®reewemueroavraowm+r
a &W.WAW
3
c Im e. N+ ro o m.,v� wvm m m� roc 133 S.W. 251)1 SYFiEET snAM1, cwlmgasus �.
• ,m, a—..w mm PEMBROKE PARK, FL 33009 m.mrolasralm racposla®w1e
�m O P an en m (m) oss-,u, m (os.) sss•,sn �a�-BOE6
AL
30001
0
In �
uuou
PeSROKE PARK. FL 33009
is W c ,"l FN (�) W-Iw
�n00000000000�
AL,FARooa CORrow+now
u�msms awowetocvaawmn
f24l SW.HIAWi
eaAw.wmnmaav�
I