HomeMy WebLinkAboutNOASCANNED
BY
MIAMI•DADE St. LUCIe CO(1Pttxmll-DARE COUNrY
M PRODUCT CONTROL SECTION
DEPARTaIENT OF REGULATORY AND ECONOMIC RESOURCES (RER) It 805 SW 26 Stied, Room 208
BOARD AND CODE ADhIINISTRATION DIVISION T (786) 315-2590 F (786) 315-2599
SCOPE:
This NOA is being issued tinder the applicable rules and regulations governing the use of construction
materials. The documentation submitted has been reviewed and accepted by Miami -Dade County RER'-
Product Control Section to be used in Miami Dade County and other areas where allowed by the Authority
Having Jurisdiction (AHJ).
This NOA shall not be valid after the expiration date stated below_ The Miamk-Dade County Product Control
Section (In Miami Dade County) and/or the AHJ (in areas other than Miami Dade County) reserve the right
to have this product or material tested for quality assurance purposes. If this product or material fails to
perform in the accepted manner, the manufacturer will incur the expense of such testing and the AHJ may
immediately revoke, Modify, or suspend the use of such product or material within theirjurisdiction. RER
reserves the right to revoke this acceptance, if it is determined by Miami -Dade County Product Control
Section that this product or material fails to meet the requirements of the applicable building code.
This product is approved as described herein, and has been designed to comply with the Florida Building
Code, including the High Velocity Hurricane Zone.
)JESCRIPTION: Extruded Alumiutun Tube Mullion — L.M.I.
APPROV -L DOC'UMENI': Drawing No. M04-04, titled "Aluminum Tube Mullions", sheets 1 through 9
of 9, dated 04/26/04, with revision G dated 07/14114, prepared by Al-Farooq Corporation, signed and sealed
by Javad Ahmnd, P.E., bearing the Mianti—Dade County Product Control Revision stamp with the Notice of
Acceptance number and expiration date by the Mianui—Dade County Product Control Section.
RATING: Large and Small Missile Impact Resistant
L—)MELING: Each unit shall bear a permanent label with the manufacturer's name or logo, city, state,
model/series, and following statement: "Miami -Dade County Product Control Approved", unless otherwise
noted herein.
RENEWAL of this NOA shall.be considered after a renewal application has been filed and there has been
DO change in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change
in the materials, use, and/or manufacture of the product or process. Misuse of this NOA as an endorsement
of any product, for sales, advertising or any other purposes shall automatically terminate this NOA. Failure
to comply with any section of this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami -Dade County, Florida, and
followed by the expiration date may be displayed in advertising literature. If any portion of the NOA is
displayed, then it shall be done in its entirety.
INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its
distributors and shall be available for inspection at the job site at the request of the Building Official.
This NOA revises and renews NOA# 12-0308.37 and consists of this page 1 and evidence pages E-1 and
E2, as well as approval document mentioned above.
The submitted documentation was reviewed by Manuel Perez, P.C.
�2
NOA No. 14-0731.0
MIAMtDADE COUNTY 6 • f 1 d
,..., i — lj{gt(�fI. Expirruionbate: Sial er16,2019
Approval Date: September I8, 2014
Page 1
ES Windows, LLC
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
A. DRAWINGS
1. Manufacturer's die drawings and sections.
(Submitted wider NOA No. 04-071Z01)
2. Drawing No. M04-04, titled "Aluminum Tube Mullions", sheets I through 9 of 9,
dated 04/26/04, with revision G dated 07/14/14, prepared by Al-Farooq Corporation,
signed and sealed by Javad Ahmad, P.E.
B. TESTS
1. Test reports on: 1) Air Infiltration Test, per FBC, TAS 202-94
2) Uniform Static Air Pressure Test, Loading per FBC TAS 202-94
3) Water Resistance Test, per FBC, TAS 202-94
4) Large Missile Impact Test per FBC, TAS 201-94
5) Cyclic Wind Pressure Loading per FBC, TAS 203-94
6) Forced Entry Test, Type "D-A" fixed window, Grade 10, Level LV
1 per ASTM F 588-04, Side -Hinged Door Systems per AAMA
1304-02 and per FBC 2411.3.2.1, TAS 202-94
along with marked -up drawings and installation diagram of windows mulled together,
prepared by Fenestration Testing Laboratory, Inc., 'rest Reports No. FTL-3810, dated
05/16/03; FTL-3819, dated 06/09/03 and FTL-3820, dated 06/09/03, all signed and
sealed by Joseph Chan, P.E.
(Subrnifted under NOA No. 04-0712.01)
C. CALCULATIONS
1. Anchor verification calculations and structural analysis, complyinwith FBC-2010,
dated 09/01/09 and updated on 07/10/14 to comply with FBC 51 Edition (2014),
prepared by AI-Farooq Corporation, signed and sealed by Javad Ahmad, P.E.
(Subuitfed parliatly under NOA# 09-0825.03)
D. QUALITY ASSURANCE
1. Miami -Dade Department of Regulatory and Economic Resources (RER)
E. MATE, RIAL CERTIFICATIONS
1. None.
ManyeYP ez, P.E.
Product Control Vxanfliwr
NOA h . 4-0731.06
Expiration Date: SeptembeF 16, 2019
Approval Date: ,September 18, 2014
E-1
ES Windows, LLC
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
F. STATEMENTS
1. Statement letter of conformance, complying with the FBC - 5" Edition (2014), and
of no financial interest, dated July 10, 2014, issued by Al-Farooq Corporation, signed
and sealed by Javad Ahmad, P.E.
2. Laboratoiy compliance letter for Test Reports No. FTL-3810, dated 05/16/03; FTL-
3819, dated 06/09/03 and FTL-3820, dated 06/09/03, issued by Fenestration Testing
Laboratory, Inc., all signed and sealed by Joseph C. Chan, P.E.
(Submitted under NOA No. 04-0712.01)
G. OTHERS
1. Notice of Acceptance No. 12-0308.37, issued to ES Windows, LLC for their Series
Aluminum Tube Mullions — L.M.I., approved on 05/31/12 and expiring on 09/16/14.
"Ilall
Mauuel Perbz,-V E.
Z— Product Control xntgqiner
NOA No. 1� & 1.06
Expiration Dale: Seplentber 16,2019
Approval Date: September 18,2014
E-2
MULLION SYSTEM IS RATED FOR LANCE MISSILE IMPACT.
AND CAN BE USED WITH ALL MIAMI—DADE COUNTY APPROV'ED
IUPACi AND NON—IUPACI' RESSEANT PRODUCTS.
RECTANGULAR ALUMINUM TUBE MULLIONS
USING MULLION PROPFRTIFS ONIY
NOTES.
THIS PROOTCT HAS'BEEN DESIGNED AND TESTED TO COMPLY WITH THE
REOUREMENTS OE DIE FLORIDA OUMINO CODE INOWDING RICH 'VEEIOCIN
HURRICANE EWE (NAM,
ALL GUEINO PRODUCTS USED WITH THESE MULLIONS MUST MEET THE
APPLICABLE DUMNO CODE REQUIREMENTS LE: WIND LOAD, WATER
INRLIRADON. FONCED'ENTRY RESISTANCE, SAFEGUARDS VC.
WOOD BUCKS BY OTHERS, MUST HE ANCHONED PROPERLY TO IRANSTN
ACIDS. TO HE STRUCTURE.
ANCHORS S BE AS USTED. SPACED AS SHCIAI ON (MUAS. EMBEOMEIO
i0 EASE LATERAL SKN.L HE OEMM) WALL COADING MUCCO. TIE ETC.}
ANCHORING CONDITIONS OTHER THAN THOSE SHOWN IN D65E OETAILS
ARE NOT PANT OF DYS APIRWAL
A LBN CURUYIN.RTCR SE IS. USED N DESIGN OF ANDAR!I WTO W0.T ONLY.
LATERAL$ INCLWWG BUT NO; UNITED TO SREL/IACTAL SCREWS. THAT
COME LIDO COMACT WITH OTHER DISSILIIVF LATERALS SHALL MEET THE
RECNRELENTS OF TIC FLORIDA BLOC. GOOF.
INSTRUCTIONS:
_ uSE CNARTs AN] OWNS AS FOLLOWS.
DETERMINE OLSLM LOAD REQUIRED PER ASCE T
MR YANIICUUR OPW W4,
STEP i USE. MVW-OADE COUNTY APPROVED CUEING PRODUCTS
MEETING A➢CX LOAD REQUIREMENTS.
STEP 3 USE CONNECTION TO MUIUON AS PER PRODUCT
APPROWL
STEP UATIC WANTS ON S+EEI J SELECT MULLION SIZE WTH
4OEQ1'RATING LORE TILER OESIGN LOADSPECIRED
WISTEP I ALINE.
USING ANCHOR TIRES CN SHEETS 5 IHRU S MA ANCHOR CHAAT5
.STEP 5 ON S Vtl 4. SELECT NICHDR TYPE WITH DESIGN RATING
HOPE DUN THE GESCH LOAM SPECTIIED 01 SIM L ABDVL
MULLIONS CONTAINING TYPICAL GLAZING PRODUCTS
HORIZONTAL OR VERTICAL
SEE WINDOW OR DOW APMCPIAL FOR FASIWERS SEES AND SPACING
FU. PE
CAN,
Q4.
Gmwmg IN.
M04-04
yix a� bp'�x
ali➢ 33 � � - G= �-f
V
mco
.a _ P
98.
L
3S r
ev
x
a, -Liu
30� -'a
1
9c o R'
via xsw ro -I _.-
ALUMINUu1 TU6 E MULLIONS ' AL-FAROOQ CORPORATION � ,
O s ! ""-- F'NGiNEERS&PRODUCT DEV¢ovmwr
E.S.2NA 72 A, LLA >zss s.w e�nve
a o ous.ac sRuno cow aom re 5220 N W 72 AVM BAY L4
- p I' MNMI� RARIOA 33190
O sr rm c wse m, xw nn ¢ca cs'mns MIPMI FL 33166
wmr c n ,EL tsua Ssa.aauD c�x.�sos�aGze�ae
6i4 n}5 _ FM. (IDS) 62n-)])]J � - "- - UU110R\40c 096'N
oz_'+i
DSNS
zm�IlyyII����
A�F[?
-11a2tA/1
O�
m7p.7
i^e;m
s<
z2o
-vlm
�'nt
e�
=kyLS
�SI�I=-L1.5
rlN:€v
_
aio"��,:
_
L e
b
c
rC- D 0
n
ZmmZ
m
A_Z
I I.
L o-
uIm
e
L m
I u Y{u14
m^
b
bb
S,.o o
b b
�
v
bl
pl�ti
mOZ.
1. 1
I
c
ri_Cr_
z..,t-
•b
�OKI
i
°'
o
ul I
b
I b
ZD
I
o
Z
D`
o
L
e b
u 4
4
b
o blb
b b:b
b'b
m
i
m
u �•
uIm
o x' -
o
v"rii
`n _'ulople
u u
o
�. --
p
y
K
O
Dr
u Liw•h
L
blb b
cx
(
r b.b
o olu
I o
bIb Ib
b
m
b ab'
b•�b
I'O e
O a
Deb b
b
bo b
q p
m
m
p
r
o
a b
=�olc-eslo'vier.i--aloes'saoaHil.
o
0 0lo
a o_o
_
a
b
elgs�g!eso;s�s.
b
n
m
N
ao0
G
o o b
b
olb
b
bluc
r
I.I�I
IIII
..
Illil.1111
1
11i'._
r
r_
mulu�
I
�o.
i_o
•:
u
Im
J
I'. b
I
a
U
�.J III Lei�[ui in b
1
1'�4
Fn
�'o
�'b
ib
Lm. a
_
,u
bi
ply
Ulu.
m�li
1
Y.u`_.0
u
I
mlel
VI
.;u w,S m ml6
'bit
IsN
-
m
o z
mle
m
_13
t
mti
o
:lUle
U
mi4lm
e o
m L:N n�bl4 Lia�u
I
b
m,o
..
PH9-_
o 0
S I
u
b
b o
-�e'�m
uo
x
w5
NI
Ii1l
11.
I�1
(IIII
III lil
II
I'V I III
a }�' n
jF8
I
11
1 I
I1
Irll a
:'
rl
Ibu
L
IIIII
I
1
1 101
1 11,
1 1 1'I
111
v �6'6
III
uR
2'.2 DSO
enA�
�
no
` I.
n
� I
III(.
I
j
i
Flo
I
I
IIII blbk
II
eU
a
s
T £
III
i
•v lu
a
u
1
_
aka
U a;
m
4�alm.x
I
I- ex
. I�vn �
L
:
�:m
Y
_gym
ulw.
awl
eI-'-
mio'o
^.
F• va
2
_
uiLlb
via
,:
N
bib
o'e
�i�lu
-
a
o
�e
-•O
(� tc
a is w
nsa
es
degcrvDt -
ALUMINUM TUBE MU1110N5� AL CORPORATION a
O
u -N
~
v
}P°0'
em, pc
on_
°i' ^c"
g ono ru nor roc
_ enelnesrs srnoouerocvamrmenr
ES. IN LE123s sW.IITAVE
o I
�ur 4
c
cvig.wmxrzn
r-cc I-
5220 N W �2 AVE, BAY 4 mlaml. ttionlonas>.oa G.
O
MIAMI iL 3 166 �Igog]xasvoo ac poraezcooe �`
e
oJl
a K
� �_(]W) 6N-9P5 GhX (]O9) 6]._PA] �f' _ ____MUWON\k04-C�FSV
4
L C t41 !eC
6 h 746m di-- tal-la (=) 'wi sttt-,Zg (;W
III 99l£f ' IJ 'IWYM
I "WWW I if Ave 3AV U WN oz��
Orn 'SMOGNIM -S-3
na� v
boobvzl-lv
a
00 SNO;IlnN 3elu mNIKrI-N,
-:z
q
V;
k�
F! E
0
1pl
IL.;j
z
n
na
zjmmjSi
nil
n
> 7 . . .
. . .
-1
eio
Mtk
!qldqM*l
g
I i�
I q
A li
1 2
1" 14 n
R R
a nlnn,n n A
=;G„
RIB'S
Rl.ln
z
�2 F
g * g
-
11N
g 0mIS
31-
ZIM-1-12 J.- z
T
I
7 7
1.
ON
;n
I
211 5!
ZIP% C6
41
�4�
-i
j.
9 11
6�,
.6,
I
01,1-i
3;8 5;
s .9 �14!v
6. si 2 51 2 Z
19
70�1--N
i
�6 Z 0 Uj
- - - - - --- -
w m
-:o I <
g
;ilt
OliO*Pl�
Mq
0-� 1
-19
A
1
1
-1�
ml
R -1212 -,o ZN
a-0
1
.1; W� 0
z wz 0 D,-
e F, L� !z Pz
n
1 .1
d-
njn
-6
iv
q
2 .7
Z6 P-:
U
G! 0
�z Z�m
'0
Z. OZ2
-1 77
A