HomeMy WebLinkAboutREVISIONSpecial Inspection Plan
A
for {`FP°P 1010
Sands on the Ocean Condominium — Concrete
Restoration
at
3100 N AIA
Ft. Pierce, FL 34 VIEWED FOR
CODE COMPLIANCE
ST. LUCIE COUNTY
EOCC
Prepared By:
IME M BV
ENGINEERING, INC.
MOIA ROWLESVILLAMIZAR &ASSOCIATES
CIVIL • STRUCTURAL • SURVEYING
1835 20th Street -Vero Beach, FL 32960
772.569.0035 0 Fax: 772.778.3617
www.mbveng.com
En ineers Project Number: 18-0042
ermri AM9
IL.4 &v/
Qr No.6100
RQdolfo �illamizai,'}'.�s
�-IP5 STATE OF
FILE COPY
��-;?-2y! 2ozo
L PE# 61000
SI#7021620
SPECIAL INSPECTION PLAN
SCOPE OF WORK
The Special Inspector shall observe that the work is executed in substantial accordance
with the permitted Official Contract Documents. The Office Contract Documents are
defined as the permitted plans, recorded addenda, and the Specifications with all
amendments thereto, including the special Inspector Plan.
The scope of work for the present contract includes the balconies of the north-east and
south-east corners, from the 3rd floor to the 12`h floor and the slabs for the penthouses on
those corners.
I. DUTIES
The Special Inspector shall maintain a record of the progress, working conditions;
observations given to the Contractor and suspected deviations from the Office
Contract Documents. The reports shall be in writing and shall be made out promptly
at the end of the period covered. The Special Inspector shall furnish these reports
directly to the Building Official, Engineer of Record, and others as required.
II.
The reports may consist of any or all of the following:
a. Describe inspections and tests made with applicable locations
b. Indicate how non -conforming items were resolved
c. List unresolved items, parties notified, and method of notification
d. Itemize changed authorized by design professional in charge, if not included
in non -conforming items.
It is the duty of the Special Inspector to notify the Contractor, Building Official,
Architect/Engineer of Record and the owner, if the following events occur:
a. The use of materials, equipment, or workmanship which do not conform to
the Official Contract Documents or which may cause improper construction
which is not acceptable.
b. Work which is not being done in accordance with the approved Official
Contract Documents.
C. Faulty construction or construction performed without inspection and not
capable of being inspected or tested in place.
d. The request for interpretation from the Engineer of Record as required to
-- — -clarify_the_C-onstruction_Documents.
e. Observe that shoring and reshoring has been installed in accordance with
the Shoring/Reshoring Plans as submitted to the Building Department by
the Contractor. Such concrete or structural element which is dependent on
the shoring installed.
f. The Special inspector will verify proper placement of all concrete, and
reinforcement.
III. REQUIREMENTS OF THE OWNER
a. The owner shall arrange for necessary construction documents to be
furnished to the Special inspector during the progress of the work in a timely
manner. Such records shall consist of, but may not be limited to: concrete
cylinder test reports, soil density test records, mill records, shop drawings,
pile driving logs, etc.
b. The owner shall insure that the Contractor provide a shoring and reshoring
plan to the Building Department which is signed and sealed by an Engineer
registered in the State of Florida. Such registered engineer may represent
the form supplier.
IV. REQUIREMENTS OF THE CONTRACTOR
a. The contractor shall arrange for necessary inspections from the St. Lucie
County Building Department. Inspections performed by the Special Inspector
hired by the Owner are in addition to the mandatory inspections performed by
the Building Department.
b. The contractor is responsible for notifying the special inspector regarding
individual inspections required by the Building Department.
c. When required by the building official, the contractor is responsible for
retaining on the jobsite all special inspection records submitted by the special
inspector and providing those records for review by the building department's
inspector upon request.
V. RESPONSIBILITY
The Special Inspector does not surrogate the Building Official's or the Engineer of
Record's responsibilities. Further, it is not intended that the contractor's contractual
of statutory obligations are any way relived or foregone by the presence of the
Special Inspector. The Contractor has the sole responsibility for any deviations
from the official Contract Documents. The Special Inspector will not replace the
quality control personnel of the Contractor. All inspections will be in accordance
with the provisions of the Special Inspector Law.
VI. LIMITATIONS
Unless otherwise provided in written requests, this Contact limits the Special
Inspector to provide services only with regard to the structural frame of the building
including foundation, primary and secondary framing systems, and all other items
included in the Inspection Plan. This Contract does not include inspection of any _
-safety provisions as fegnired by OSHA or other safety standards which apply
during the construction period. Nor does it apply to elements such as metal or
wooden balcony railings, fire protections, curtain walls, mechanical/electrical
systems. Architectural components, site work or other elements not contributing to
the capacity of the structural building frame.
THRESHOLD INSPECTION PLAN
A. The following is a description of the structural system employed for this
project:
1. Structure: Repair of reinforced concrete flat slabs, concrete columns and
beams, and various wall systems.
2. Others: Concrete waterproofing system.
B. Construction shall conform to the Permitted Documents as submitted to the
Building Department.
C. Approved Permit Drawings, the applicable Specifications and approved
Drawings submitted by MBV Engineering, Inc. shall govern the requirements of
this work.
D. Reinforced Concrete:
1. Concrete Quality
Verify that individual batch tickets indicate delivery of the approved mix as
specified. Determine the required type, quantity and frequency of tests to be
performed on fresh and hardened concrete. Provide or arrange for
communication of field testing results to the registered design professional
in responsible charge and to the building official.
2. Reinforcement
Verify that reinforcing steels are of the type, grade and size specified and
are in conformance with acceptable quality standards. Ensure that
reinforcing steel is free of oil, dirt and rust and that steel is properly coated
and/or sheathed as specified. Verify that reinforcing steels are located
within acceptable tolerances and are adequately supported and secured to
prevent displacement during concrete placement. Verify that minimum
concrete cover is provided. Verify that placement of reinforcing steel (or
ducts) complies with required spacing, profile and quantity requirements,
as indicated by_both the approved..plans__and.installation -drawings.-Verify-
that-hooks, bends, ties, stirrups and supplemental reinforcement are
fabricated and placed as specified. Verify that required lap lengths, stagger
and offsets are provided. Verify proper installation of approved mechanical
connections per the manufacturer's instructions and/or evaluation reports.
Insure that all welds of reinforcing steel and other weldments are as
specified and have been inspected and approved by an approved welding
inspector.
3. Concrete Placement, Protection and Curing
Verify acceptable condition of the place of deposit before the concrete is
placed. Verify the methods of conveying and depositing concrete avoid
contamination and segregation of the mix. Verify that concrete is being
properly consolidated during placement. Verify that, concrete is protected
from temperature extremes, and determine that proper curing is initiated.
E. Other Miscellaneous Inspections
1. Inspect for any holes drilled in slabs, walls, columns, or any other structural
component without prior approval.
2: Check for any exposed reinforcing steel bars at face of reinforced concrete
member.
3: Maintain a correction list indicating the areas where discrepancies were
noted and status of repair.
4. Send a copy of the daily inspection report to Engineer, Building
Department, Owner, General Contractor, and others, as requested by the
owner.
5. Visually inspect all concrete surfaces for any cracks. Notify the Engineer of
Record immediately if any cracks are found.
Submission:
1. General: Various submissions to the Threshold Inspector will be required. All
submissions shall be reviewed by the Contractor and the Engineer of Record prior
to transmittals to the Threshold Inspector. Submit one copy for this record and
review. Review of submissions by the Threshold Inspector. Submit one copy for
his records and review. Review of submissions by the Threshold Inspector does not
relieve the Contractor of the Subcontractors of their obligations for performance.
The intent of the review of these submissions is to confirm that off -site fabricated
components comply with the Approved Permit Documents.
2. Items required for the Threshold Inspector: The Threshold Inspector shall be
provided with copies of all correspondence related to the construction of the project,
all shop drawings, all deviations from the contract documents, all test reports, a full
set of the Contract Documents, and any other items he may deem necessary to
perform his duties.
OFFICE USE ONLY:
DATE FILED:
REVISION FEE:
[:w
LOCATION/SITE
ADDRESS:
PERMIT #
RECEIPT #
r
PLANNING & DEVELOPMENT SERVICES
BUILDING & CODE REGULATION DIVISION
2300 VIRGINIA AVENUE
FORT PIERCE, FL 34982.5652
RECEIVED
(772)462.1553
FEB 19 2020
APPLICATION FOR BUILDING PERMIT REVISION
PROJECT INFORMATION
ST. Lucie County, Permitting
DETAILED DESCRIPTION OF PROJECT
CONTRACTOR INFORMATION:
STATE of FL REG./CERT. #:
BUSINESS NAME: is7filr
QUALIFIERS NAME:
CITY: (/l�4GCl�oi,
PHONE (DAYTIME):
STATE:
OWNER/BUILDER INFORMATION:
NAME:
ADDRESS:
CITY:
PHONE (DAYTIME:
ST. LUCIE CO CERT. #:
ZIP:
I
STATE: IZIP:
FAX:
ARCHITECT/ENGINEER INFORMATION:
NAME
ADDR
CITY:
PHON]
SLCCC
Revisec
I firma W%Fl ■
OFFICE USE ONLY:
DATE FILED: 130� g0
REVISION FEE: 1 5 • d a
LOCATION/SITE
PERrMT # \ '� \ a - G3A �,
RECEIPT # ( Sq to a4l
PLANNING & DEVELOPMENT SERVICES
BUILDING & CODE REGULATION DIVISION
2300 VIRGINIA AVENUE
FORT PIERCE, FL 34982-5652
(772)462-1553
APPLICATION FOR BUILDING PERMIT REVISIONS
PROJECT INFORMATION
DETAILED DESCRIPTION OF PROJECT
l? p VTQlrn]V Q -
CONTRACTOR INFORMATION:
STATE of FL REG./CERT. #: GGC. Ohl b33 ST. LUCIE CO CERT. #:
BUSINESS NAME: ti4-eck4-u-rF - C o ry
QUALIFIERS NAME: RabelI 5-M
ADDRESS: 7-1. -z&
CITY: O'ke a /x2heg STATE:
PHONE (DAYTIME): 7)Z zjS G(e 51
OWNER/BUILDER INFORMATION:
Rl:\u'1�1
ADDRESS:
CITY:
PHONE (DAYTIME:
STATE:
ARCHITECT/ENGINEER INFORMATION:
FAX:
FAX:
ZIP:
ZIP:
NAME: _ - -- - - — - -- - --- - - --- —-------------
ADDRESS:
CITYi STATE: ZIP`.
PHONE (DAYTIME): FAX:
SLCCC. 9123109 .
Revised 06/30/17 REVISIOM
IN
W t \V-,qV'r\
OFFICE USE ONLY:
DATE FILED: 13d� il0
REVISION FEE: 'I 5 • d
LOCATION/SITE
PERMIT # 1 k \ b - a3A
RECED?T # STD A Z1
PLANNING & DEVELOPMENT SERVICES
BUILDING & CODE REGULATION DIVISION
2300 VIRGINIA AVENUE
FORT PIERCE, FL 34982.5652
(772) 462.1553
APPLICATION FOR BUILDING PERMIT REVISIONS
PROJECT INFORMATION
oA 41Lo. Dena n 51 Db
DETAILED DESCRIPTION OF PROJECT
RElaSIONS:
,rnell ieer i'Llissr_A
CONTRACTOR INFORMATION:
STATE of FL REG./CERT. #: GGC 66033
BUSINESS NAME: Cc ry
QUALIFIERS NAME: eabel4 ST&MY-
ADDRESS: /?a, 4-40 2&
CITY: Ma 0. b2 STATE: L
PHONE (DAYTIME): 77Z Z#r QFo 31
OWNERBIJILDER INFORMATION:
NAME:
ADDRESS:
CITY:
PHONE (DAYTIME:
0
A, i3,4c
ST. LUCIE CO CERT. #:
ZIP:
FAX:
STATE: ZIP:
FAX:
ARCHPTECT/ENGINEER INFORMATION:
NA —ME., - - -
ADDRESS:
CITY: —
PHONE (DAYTIME): _
SLCCC: 9123109
Revised 06130117
STATE: ZIP:
FAX:
aRm"EV I ION
N r • •
OFFICE USE ONLY:
DATE FILED: PERMIT#
REVISION FEE: RECEIPT#
PLANNING&DEVELOPMENT SERVICES
BUILDING&CODE REGULATION DMSION
2300 VIRGINIA AVENUE
FORT PIERCE,FL 34982.5652
(772)462-1553
APPLICATION FOR BUILDING PERMIT REVISIONS
PROJECT INFORMATION
LOCATION/SITE "-T>')"q
DRESS:
Qiif �51�4'�i
DETAILED DESCRIPTION OF PROJECT
REVISIONS:
CONTRACTOR INFORMATION:
STATE of FL REG./CERT. #: ST. LUCIE CO CERT.#:
BUSINESS NAME:
QUALIFIERS NAME:
ADDRESS:
CITY: STATE: ZIP:
PHONE(DAYTIME): FAX:
OWNER/BUILDER INFORMATION:
NAME:
ADDRESS:
CITY: STATE: ZIP:
PHONE (DAYTIME: FAX:
ARCHITECT/ENGINEER INFORMATION:
NAME:
ADDRESS:
CITY: STATE: ZIP:
PHONE(DAYTIME): FAX:
S*
SLCCC: 9/23/09 Rrmv I ION
Revised 06130/17
v�
'I ,STACK 2 STACK 3 II .STACK 4
STACK 5lUw z oQO
41 1
p
�- ]
1 SGD
STACK1 E: �� � STACK
C a a /
I I 1 NW SW
PH-A6 !!
E CATWALK 1 CATWALK;, o
NW STAIRSJI
II SW STAIRS ( N o Co LU
L
O N �
d
9 wJ O Z
I li � � Q � � � Q
q FLOOR NUMBER: I ;
FLOOR NUMBER:
ROOF z
PA z — STACK 9 STACK 8 _ _ o
II o
ci
W U W
NOTE: 44
E • TILED FLOOR
__. . 111mu� Caob) <
m STACK 10 STACK 7 — W N cy) � �v <
04
J 0 m M r-
KEY MAP FOR PENTHOUSE FLOORS U.
a a `
} I = 2 r J J <
L�LL
o Uj w w
I ;
LEGEND: N m � w
SGD y !
I SLAB FULL DEPTH REPAIR (SF) M O = X Co
SLAB PARTIAL DEPTH REPAIR(SF) ':' 00 d LL
� W
SLAB EDGE REPAIR (UP TO V WIDE) (LF) >
SLAB UNDERNEATH REPAIR (SF)
COLUMN REPAIR (CF) C-0 V
w
TILE REMOVAL (SF) Z :5 N
HANDRAIL -H- p> . C) v
-� . : - . USHUTTER REMOVE & REINSTALL (LF): q
i ® PITCH CORRECTION (SF) z
00
I I I I I I STUCCO WALL REPAIR (SF) W-0 g w
I � g -
RUST SPOTS (EA) O W O
�- SGD ' SGD LL 11 UNDERNEATH CRACKS (LF) -C- Z ai w
SGD
j w Z
wi: � � CRACK REPAIRS (LF) -G� � t
W� I W i _ SLIDER REMOVAL& REINSTALL (LF) -sue -® ' m
PH-66
PH-C6 w; PH-D6 SLAB COATING REMOVAL (SF)
®— LW O
OVERHEAD STUCCO REMOVAL (SF)
SLAB WATERPROOFING SYSTEM (SF)
FLOOR NUMBER: FLOOR NUMBER: o FLOOR NUMBER: o -° w Z
II N U) O
P B zf PC z P D z �---
II I OU
M a U)
NOTE.
LLI Z Q
ZU) —
NOTE: • TILED FLOOR � � -'-
• TILED FLOOR I � - a
I >- w
01 yl y � co Z
O
I !
m
—21
SGD -� SGD SGD
O_
Z 0
O
U �
O �
W Z ma
~ O ' �
O0UZ
#ifv _Q3YE Z r o
CODE
REVIEWED FOR (A O 0 M ``
COMPLIANCE
W
ST. LUCIE COUNTY Z
BOCG Q o
st�rrr O
LL
�y gy4�E1V,�`4.
} NO 6100 k
e` .
LF VI M 00 ZARSTQTE P.E#6. 1000
5
osAV-
a0r 11b SHEET
C
e 7�O Cqlifq# .,Ct
N Permlmittlng Departent
St. Lucie Cou •
O
OF 4
06
18-0042
1 RMIT SET