HomeMy WebLinkAboutProduct Approval APR 1 2016
RECE("
MIAMI-ffinDE FILE COPY PRODUCT CONTRINHANU
-I)
ADOL E SECOUCTIONTYN
EMMEW
11805 SW 26 Street,Room 209
DF,PARTAIENT OF REGULATORY AND ECONOINHC RESOURCES(RER) Miami,Florida 33175-2474
BOARD Ain CODE ADIVIINISTRATION DWISION T(786)315-2590 F(786)315-2599
NOTICE OF ACCEPTANCE (NOA) wwwaniamidade.govieconomy
DAIS Door Company,Inc.
12195 NW 9814 Avenue
Hialeah Gardens,FL 33018
SCOPE:
This NOA is being issued'under the applicable rules and regulations governing the use of construction materials.The
documentation submitted has been reviewed and accepted by Miami-Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction(AHJ).
This NOA shall not be valid after the expiration date stated below.The Miami-Dade County Product Control Section(In
Miami Dade County)and/or the AHS(in areas other than Miami Dade County)reserve the right to have this product or
material tested for quality assurance purposes. if this product or material fails to perform in the accepted manner,the
manufacturer will incur the expense of such testing and the A14J may immediately-revoke,modify,or suspend the use of
such product or material within their jurisdiction. RER reserves the right to revoke this acceptance, if it is determined
by Miami-Dade County Product Control Section that this product or material fails to meet the requirements of the
.applicable building code.
This product is approved as described herein, and has been designed to comply with the Florida Building Code,
including the High Velocity Hurricane Zone.
DESCRIPTION:Hurricane Master Model 824/811 Steel Sectional Garage Door up to 9 -4"Wide w/
Window Lite Option(DP+50.0,-60.0 PSF)
APPROVAL DOCUMENT: Drawing No.01-09,titled"Sectional Garage Door",sheets I through 5,of 5,
dated 02/01/2001,with last revision.I dated 11103/2014,prepared by Al-Farooq corporation,signed and
sealed by Javad Ahmad,P.E., bearing the Miami-Dade County Product Control revision stamp with the
Notice of Acceptance number and expiration date by the Miarni-Dade County Product Control Section.
ARSSILE IMPACT RATING:Large and Small Missile Impact Resistant
LABELING:A permanent label with the manufacturer's-name or logo,manufacturing address,model
number,the positive.and negative design pressure rating, indicate impact rated if applicable,inistallation
instruction drawing reference number,approval number(NOA),the applicable test standards,and the
statement reading'Miami-Dade Count),-Product Control Approved' is to be located on the door's side track,
bottom angle,or inner surface of a panel.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance;of this product.
TE IMNATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials,use,and/or manufacture ofthe product or process.Misuse of this NOA as an endorsement of any product,for
sales,advertising or any other purposes shall automatically terminate this MOA.Failure to comply with any section of
this NOA shall be cause for termination and removal of NOA. 4
,ADVERTISEMENT: The NOA number preceded by the words Miami-Dade County, Florida, and followed by the
expiration date may be displayed in advertising literature. If any portion of the NOA is displayed,then it shall be done
in its entirety.
INSPECTION: A copy of this entire NOA shall be provided to the tiger by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official.
This NOA revises NOA A 12-0110.06 and consists of this page I and evidence pages E-1 and E-2,as well as
approval document mentioned above.
The submitted documentation was reviewed by Carlos M.Utrera,P.E.
NOA No.14-0814.04
EMA LVAQE� Expiration Date:August 9,2016
�M _CQUNTY%
Approval Date:Febriiary 5,2015
Pagel
DAB Door Company,Inc
NOTICE OF ACCEPTANCE: E,17MENCE SUBMITTED
A. DRAWINGS
1. Drawing No. 01-09,titled"Sectional Garage Door", sheets 1 through 5 of 5,dated
02/0112001,with last revision I dated 11/03/2014,prepared by At-Farooq Corporation,
signed and sealed by Javad Ahmad,P.E.
B. TESTS "Submitter)under NOA#09 0128,041,1
1. Test reports on 1)Uniform Static Air Pressure Test,Loading per FB'C TAS 202-94
2)Large Missile Impact Test per FBC,TAS 201-94
3) Cyclic Wind Pressure Loading per FBC,TAS 203-94
4)Forced Entry Test,per FBC 24113.2.1,TAS 202-94
along with marked-tip drawings and installation diagram of a DAB 824 24 GA
Sectional Garage Door with Fixed Windows,prepared by Hurricane Engineering&
Testing,Inc,Test Reports No.IlEi TI-08-2149A/B, dated 06/27/2008, signed and
sealed by Candido F.Font,P.E.
"Submitted under NOA#09-0128.04-11
2. Test report of Tensile Test per ASTM E 8,Report No.HETI 08-T182,prepared by
Hurricane Engineering & Testing, Inc., dated 12/23/2008, signed and sealed by
Candido F.Font,P.E.
"Submitted under NOA#01-0516.03"
3. Test report of large missile impact test per PA 201 and cyclic wind pressure test per
PA 203 on"Sectional Residential Garage Door",prepared by Hurricane Engineering
&Testing,Inc.,Report No.HETI 01,974A,dated 01/29/2001, signed and sealed by
Hector M. Medina,P.E.
4. Test report of Uniform Static Air Pressure Test per PA 202 and Force Entry
Resistance Test on"Sectional Residential Garage Door", prepated by H-unieane
Engineering&Testing,Inc.,Report No.HETI 01-969, dated 01/18/2001,signed and
sealed by Hector M.Medina,P.E.
5. Test report on Salt Spray(Corrosion)Test per ASTM B 117 of a painted G-40 steel
panels,prepared by Celotex Corporation,Test Report No.258592,dated 08/17/1998,
signed by W.A. Jackson,P.E.
Al
;0 1
Carlos M.Utrera,P.B.
Froduet Control Examiner
NOA No. 1"814.04
Expiration Date:August 9,2016
Approval Date:February 5,2015
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED.
C. CALCULATIONS
1. Anchor verification calculations prepared by Al-Farooq Corporation,dated 09/22/2014 and
07/24/2014,signed and sealed by Javad Ahmad,P.E.
"Subinitted udder NOA#09-0128.64"
2. Anchor verification calculations prepared by Al-Farooq Corporation,complying-with F.B.0
2007,dated 12/19/2008,signed and sealed by Humayoun Farooq,P.E.
D. QUALITY ASSU1t.ANCE
1. Miami Dade Department of Regulatory and Economic Resources(RER)
E. MATERIAL CERTIFICATIONS
1.. Notice of Acceptance No.13-0717.01, issued to SABIC Innovative Plastics,Tor thou
Lexan Sheet Products,approved on 11/28/2013 and expiring on 07/17/2018.
2. Notice of Acceptance No. 14-0311.08,issued to Insulfoaw,LLC,for their
Insul&-m Expanded Polystyrene Insulation,approved on 08/14/2014 and expiring on
11/2912017.
3. Notice of Acceptance No. 11-0926.07, issued to Dyplast Products,LLC,for their Expanded
Polystyrene Block Type Insulation,approved on 11/10/2011 and expiring on 01/11/2017.
4. Notice of Acceptance No. 11-0926.06, 'issued to Dyplast Products,LLC,for their
Dyplast ISO-Cl Polyisocyanurate Insulation,approved on 11/10/2011 and expiring on
0111112017.
5. Notice of Acceptance No.10-1129.04, issued to CeIlofoarn North America hie,for their
Expanded Polystyrene Block Insulation, approved on 02/24/2011 and expiring on 02/24/2016.
"Submitted under NOA#05-0228.02"
6. Test Report on Accelerated Weathering Using Xenon Arc Light Apparatus Test per
ASTM G155 of"PVC Extrusion Material",prepared by Hurricane Engineering&
Testing,Inc.,Report No.HETI 04-A002,dated 09/27/2004,signed and sealed by Rafael E.
Droz-Sella,P.E.
7. Test Reports on Tensile Test per ASTM D638 of"PVC Extrusion Material",prepared by
Hurricane Engineering&Testing Inc.,Report No.HETI 04-,251,dated 11/29/2004 signed
and sealed by L Ghia,P.E.
8. Test Report on Self-Ignition Temperature Test,Rate of Burn Test and Smoke Density
Test of"REHAU non-foam PVC extrusion material",prepared by ETC Laboratories,
Report No.04-761-15019.0,dated 05/06/2004, signed and sealed by J.L.Doldan,P.E.
F. STATEMENTS
1. Statement letter of code conformance to the 5`s edition(2014)FBG and of no financial interest
issued by Al Farooq Corporation,dated 05/13/2014,signed and sealed by Javad Ah nad,P.E.
Carlos M.Utrera,P.E.
Product Control Examiner
NOA No.14-0814.04
Expiration Date;August 9,2016
Approval Date.February 5,2015
. E-2
?'%J`X.0]1`GALV.STC0. TOP FDOURE 5-1/2'X 2-3/4'X 0.1'
7-1/
STEEL PLATE W@1 ONE 5/16-Le MS P!/NUT 1'!
END ROLLER HINGE __ PA51p,ED TO
END SALE W71N
W/
(6)i14 x 5/8•SMS :O- (6)714 X 3/4'SELF DRILLING SCREWS TO BBEININSTALLED
�rEa 1
WITHOUT BECKON DIFEVE(ST.,) ecHTEa SIE£ Z w
WBB Bg'ON s.EkvE(0PDONAL) `\`.
-- o D j DEM R STnE i_A F
S3 1:
D g n.4
1 0 ' 1 t OHo
'1-T/2•x2-t14'x o]T` - --_ ! i �I— —'fi1'ry ���z gg$
0 GALIV SREL CENTER TINGE ` r- �. I ��ll o"
w/(4)714 x 5/6'sms T 3 F�
_ EL
`\ WITH DEtRON stEEVE(OPlRfNAL) B `• I B ,x T S LL
v A �
LOCKoa
2/DOOR -� - S o
it' `a`Af •1'w X.15'THK.LATCH ? "_ "'
I STANDARD LOCK -- �—L_¢,'� V
SPRING LOADED SOME DOLT(BOTH SIDES) _ _ - '= 0 'a
FAST
ENTD W/(a)N4 x 1/2'SAI-S,
OCK ENCA
L
i[ONFONMS T0-SECTIpN IOOB REGARDING GM1RAGE BOORS.
Baan{nSGNf COTbLSIS OF Ory
a'-a' 2 SEODONS la'2 S=W13 21' 158 DUL GAIN.A!ACRAFT IME + - OPRONAL 4f N! I• A O O 3 aj h
-r 1 5EO110H ta' 5¢TWN'a 2) tnCO-PRE55 SLEEVE 1`5tA ,`i 5'170E AT]'D.C.MAX OPTIONAL FLUSH FACE ] O Z
5Y MIN.5 74 L SISETY FAGFOR+' {33}} W p
Y +SER ,21 - p 1 (0;AE WG ARFA MDT TO EXCEED w000 GFWN 061GN Y{
2•�• _ .- _ j 120 SO.IN. COLONIAL DESIGN I+T C
T«4' S SECnWtG it- 6'X S'X D.L' m J
7-r SIB 1 srrnoN 21' S7EFL PLATE 1l) 0 ! l MAX DOOR WIDTH _z s¢Rvt9 srWITH(2)714 x5/D'SMD I SECMNs 21^W-6 4 SECIYOHS 2'- BRACKET y `DRACKLT INSIDE ELEVATION
0' 0 s¢ttONs teat- STD.UFT DOOR LDOW EADRDOM OOR OPTION RAISED PANEL EMBOSSED DDDR
sFGRONS tr11 SE'anON 21' o
scrnnes la• x 3-118'X.010"
c R
s'-9' 3 s¢nalts ia•3 sEcnons 1' srEEt.PLATE DAH DOORS INC.
To 2 s¢IIONs Ie'4 sEenoxs zP CENIER SOLE WITH(4)714 X 3/4'SDS Hurricane MasterW Model 824/611
l0•-3• 1—noN 121 s s¢noxs 21'
to'-G G 5¢nONs 21'- OLRSTDE 1(14 X 3/8'SELF ORAL IHC SCREWS%UY BE USED Moc Sine w Lt X 16'-C"onHigh c g
i-v' a sEcnor+s ia'I s¢noN 21' HANDLE END STILE IN ULU OF 714 X 5/e'SM5 With Window UTc Opllon o 41&
II a SLO410N5 la'2 SECnO}IS 21'
u-a• sEan 1a•3=rorAN+s 2r DESIGN PRESSURE RATING-+50.0 PSP
11'-s' sccn Ns te'4 sOCndiG 21' THIS PRODUCT IS RATED FOR LARGE MISSILE IMPACT «.«
11'-g' 2 SECnONS te'S'SECnON3 21' LOCK BAR GUIDES - 60.0 PSF
17 SEmays iE•6 s£CnoNs m^ INSTALLED ON END SIDE a g
12v- T s¢noxs zr- WITH(4)714 x 5/6'SMS GENERAL NOTES
-e• a s¢nONs 1e^s s4xno%s zs' A AOT x.aw LUCK BAR
}SECIONS ta' SEanONs 2f^ L INS PRODUCT HAS DEER DESIGNED AND TESTED TO COAU'LY WTM THE
lY 4 SITONS Ie 4 S¢T10NS 21' ENGAGES W TRACK RIDARR£MUDS OF THE TIDRIDA 61EWHO COOS CHIC)REIN FDRIOn(2014)
I]•-3' }5¢DONS la'S SEC1IaN5 21 ON EACH SIDE OF DOOR INCLUDING BCH VELOCITY HURWCARE ZONE(HWN2), 4 f
1J•-5' 2 SEcnOHs ta'6 sTttpts zI' B ANCHORS SMALL BE AS LISTED,SPACED AS SHOWN ON ITEDU . t 9a VAVAD AHSMO RSp}0=111VISIOD
I!•-a' I sEC110N IS
OUTSIDE KEYED LOCK(QPTIONA 1 ANCHOR EMBEDMENT TO BASE MATERIAL SHALL DE BEYOND YUlL CAR. MtanyiyiywM147yI{y
M PE 70592
14' SECnONS 21'« LOCI(WR IOCNWG SHOWN DRESSING OR SNCCO. CAN, >B DUTdV.Luft
t4'-3' a S£CRONs 16'3 SEC71t1N5 2S' A13EFAM TO SPRING LOADED SLIDE BOLT 3, ALL DO1TS,N41'TS AND 59A5HER4 SNAtI eE 21Np PIATED CARBDN STEEL. 4LMPtaf�FbI TT'
1411 }SEenOMS IS.4 SCCfI0N5 2l' LOOKS SHOWN ABWT 4. ANCHORING OR LOAD04G CONDRIDNS OTHER THAN THOSE SHOWN IN S � 2 A
u'-9' 4 SEWONS I6'S 5¢TgNS sl THESE GETAM1D ARE NOT PART OF rfl APPROVAL 2014 B]
TS 3 5¢RONs 18'a SEC[ICNS 21 S. A L6t0 Bix{AROH HCRTASE IS USED W DESIGN OF ANCHORS INTO Ra00 Ot0.Y. PnpM[aAW drat+ing n0.
15'-3' 2"ONS
1e•7 SECINWS 21'
15-a' I""ON la' B SECnONS 21' ODOR TESTED IN ACCONAU!"WITH THE REOURUIEHTS OF FIaRbA Q�—09
13'-r 9 S¢nORS 21•- BAMS WOL TAS 202.TAS-201&7AS-203 FOR HOG!ANO
I6• a aEC4101G ta•4 SECSNNS 2i' AS1Y EBBS-05/ASTM Ef996-69. sNC4L •I OL Jr'
24 GA STETS.PANEL �v
3/16'ALUM RNETS I
Z w
1
RAPS BENT OVER PANEL-\ Q i,
(K 0 F
D
,0&'STL PANEL 1/2'PUNCHED HOLES $C
0 4'O.C.
2211x' cf
OUTSIDE OF DOORN Q y.XG
I a�zpp
-c
STEEL TRACK BRACKET FASTENED SOLID BRASS DOOR VIEWER
TO Y1D00 UA/IB WON fR''SCHIAGE SECURITY HMDWARC'
5/16'x 1-s/B'lA0 scREW INSTALLED IN 9/16'DIAL HOLES IN CENTER STILE 1
(FlRLY THRUOED)
ONE PER BRACKET POSITIONED Al EYE LEVEL w0 WILE j To
OPTIONAL STOP MOULDRIG ANCRORS AT TR4CIE Ak. G Oo n
FOR CONNECTION OF WOOO BUCK lTY DOOR INSTALLER / A)SAe•nu PuwFn_BOIT tW'Pa0.FRc' L�", i
TU MASONRY SEE NOTE ON SHEET 4 2 MIN.ELISED DIM CONCRETE1-7/e'MDL EDGE DISTANCE
GO,
114 x 5/8'SMS ¢-O
6 PER HINGE 3/4'x 2'X 2-1 2'X 18 GA.STEEL g A/A•RIA Htn IFAF BY'M N U! _= +
END STILE,COWN`ZT TO PANELS WITH )
SOUTHERN FINE .. 1/2'X 1-3/4'x.059'FORMED STEEL FLAPS AMD 3/I6'ALUM RNEIS 1-1/4'W!L EMBED INTO CONCRETE DR FILLED BLOCK
OS5 S.G. CLUED TO PANEL AND SECURED TO SEE DETAG ABOVE I-G/8'IVH.EDGE DISTANCE INTO CONCHS[ Z,� O
FDC OI.T' w0 STILE WTI"3/16'POP RIVETS 0 12'O.C. 4'MN.EDGE DISTANCE INTO FILLED BLOCK O
•p' ' U O Z
A'. 1-7/8'%2-5/8'X.045'STEEL CONCRI3E Fc.3000 PSI MIN. W;O N=
1 fCENTER WILE.CLUED AND RIVETED -067µC£ C-90 CROUT FILLED BLOCK I'm-2000 PSI MRL v,:co A
TO PANEL W/(4)J/16'RIVETS -SII Q
MIN. I I POP RMETS .•. 1 O S
1 yfa x 5/6'S.Ms.
4/HINGE " 1
1-J/I-I {� p
ANCHOR TME AOR IT c€ I d l
19'x 2.19'x 3.3'X.102• -
STEEL TRACK BRACKETS (1)PER BRACKEIT " NIIIH
SEE
SHEET 3 FOR7.T'
SEE SHEET J FOR BRACKET SPACING % I
ISs BOLT h NUT ^(d7-1/2'%A71'GALV.STEEL d IT:CENTER HINGE 7-I/2'X3'%.071'7/16'PUSHNUI - w0 ROIIFA HPIGE ON ROLLER SHAFTCNIINTERIOR SIDE 1.62'OLl%SO'STEEL ROl1TRS(SfO. CML PRWUCFiGVLSEDfA2'OV.%SO'TIYLONROLLERSPTIONALjVp"
0592TANCARD) 82'(GPRGNAL) Z75.01A%SO'STEEL ROLLERS(OPTI 0p1� k
FASTENED TO TRACK PLATES 2.75.TO.x.50'NYLON ROUTERS(((OPTIONAL lb IpAx��I o E <
W/1/4-20 X 5/8'TRUSS NO. WON S'STEM
SLoNED LOCK Mif 20'14 Byso rrlj� droWl
01-09
6h66L_2-f 5
• " 6
2 X 2 X 1/8'NORM ANGLE t
/FOP R('tET6
5/16--X 1-5/8'VA SCREWS IMO WOOD OR HOR17 TRACK SUPPORT. SPOT BELDED TO NOPQ.TRACK t" V
(y All Yj// 2-3/4`X 5-1/2'x J'X.104" 5/16'SLEEVE ANCHORS CENTER SUPPORT REOD.ON DOORS WITH TWO WELDS AT 1-1/2'APART pp`A
ROLLERV.STEEL 00 EACH SIDE E74 EEDING 6 FT.IN HE ARn AT 3'O.C.Top •Y j
WRH i-tj4"ERa-c0 IMO MASONRY
REST AT 91 OC-7
FAS
IODD W/(B 6O®14%5/8^SYS. _ J PEA$RACIfET 11 i A T, NNNECIID TO FLAG BRAEJTET AHGLC
040 TM CALM.STEEL ADIUSTAXE Wf Tip ,SHq31r BCUI&MIT
SLIDE FASTENED TO BRACKET 2-1/Y X 4-1j4'X 13 C0.r4%
TEkl PULES (2)TO-20 X 5/8, FAROC WITH �
A— (2)1/4-20 X S/9'BOLT
Y!/5I16-18%3/4'HEX NERD _ Yf40E0 70 1-112•%1-1
14 GA ANGLE -- �
K SCREWS 8 NUM FASTENED TO TRUCK
TOP BRACKET WITH(4)1/4-20 SS SO
&NUTS -- I1oRl2.TRACK IENGTII m OFCNR70 HEIGHT PWS 12' Q
(STAN-0) -
TOP BRACKET
VER
RM TRACK O h
((OPAONN pp
�. LOW HEADROOM� - ii CA LACY.5142 TRACK 2-1/rx i'%.490' A 'N
SECTIONA-A dad'
rc S NOAISAMAL REINFORCEMENT
mss"
Q a Q p
1-3/1`X.D59'FORMED STEEL 2"z sale'x Abe O 0
m GLUED TO PANEL AYD FASTEANED TO
UIY.STEEL Q+y� D
YLT4RTAL SRIIS WRH FASTCACO W[A4)8 14 S.M.S. 15 n
(2)3116'POP RUM %PORDO BRACKET FOR .uu�l'i{A-
lOYt HG4R00M WOR OPTION O.
HORIZONTAL REINFORCEMENT aRACKEf PLACEMENTS
`SECTION HOCHTS � Q
t/2'%t-3/4`X 459'FORMED STEEL HEIGHT,IST ND D 47H SIH RY 82 133 54 05 a5 07 88
CUUEO TO PANEL AND FASTENED i0
VEW I 51RE6 WITH = 6'-0` 18'16.1H"18 N/A 1'TO 2'IT-3/4' 2J" 34' 45" 56• 67' _
(2)JIt6'POP RIVETS 6'-6" 21'18 t$'21' IA I-TO 2"11-3f{' 2d` 74'_ 45" 86" 67' _—
MEETING
TnB Y 21`21"21"21' A 1'TO 2"iI-3/4" 23' 34' 4S' SF" -i-7-
-0, -
T-s•'
Ir I6.19`IS•is"r TO 2`11-3/4" 23` J4' 45' SG^ 67• 78-1/4,
1.82"DIA.X SO'ROLLERS 18"18"i8' 2`ii-314' 2Y 34' W 56^ 67• 78-1/4" Of
.� �Y!/A4 DA.%4-1/4'STEM "-SEOTIONS ARE NUMBERED 6TARTMC AT THE 80Ti0M O n
s i FOR DOORS MORE THAN 8 FT.KOH,USE ADDITIONAL TRACK BRACKETS AT t0'D.C. O n
OPTIONAL INSULATIONS
BY'DYFED T PRDDDGTS 11[' vii m G S
FPS-E%P.4YDE0 P9lYSTYRENE t.9'X 2.i9'X 33"X A90' < Z F V!
FLOADENSITY-1.05 PGF STEEL TRM:K BRACKETS
KOA 911-O928A7 2-J/16'KGH m 0 T
' OR _� CONNECTED TO TRACK WITH /
150-25 POLY-SSOaANUPATE - }1/4•DOLTS k NUtS. zD O'> e
z x DENSITY-2.0 PCF _
-.-NAA it t-0026A6 O Z SSq
v� OR � W may.{a
y HY'M t 0F0AJ NIRIN AVISIC0 P) m
DENSITY 1PCF — aE!2
.03 ._.
M.OA JT-1119A4 r �_
OR
A+'IBSJIIEQA1L11.0 '� O
DEN31tt m DR2 PGF
N.OA jm-0311.0$ 2;
U 14 CM CALM.STEEL.
ROLLER AONGES FASTENED AA W
W/(A)914 X 5/8'SMS
WIN. 024'ROLL FORMED STEEL PANEL 33.
DRAWING DUAN C-40
MIN.'40-0 STRENGTH-34 KSI 5
-- 11"PINNED AND BAKED-ON CRACK cONF16L,RATtON FIs e,v
POLYSTER PANTED TOP COAT
APPMEO TO BOM SIDES OF sma.
Ogtl �i
VF1ITI.AC t tiFf }jj�H IiF7 STANDARD LiF1' LOW HEADROOiA '� R
DOUBLE TRACH
AVAILABLE TRACK OPTIONS i-
En9n JAVAO ANvw PtOL1UCFRBYam
12 GA GALL.STEEL. ENlt � tHNEAoiWa •S 1 3
BOTtOM BRACKET FASIFNID FLAP ]0592
W/(4)914 X 5/B'SN5 sie WtmaN,�
O 80ITOM SEAL ���� R�nnun4cnraF i-6 no.
FM ae PLATE'SAM o 48'D.C. 01-09
-cT10N A-A AND 0 OR WEATHERSTRIPPING Dhc01 3 d 5
'OCE - 1p
(ASL q
n`u 2 i-1tY MUT. I Py
i E DISE. ([
i 1
Ifi'00.LAG SCREYP^u 114'OU.IAC SCRtiRS a K
DRY �-AT 6"EADM ENOB F
OD B LAT b"fA0L ENDS n
WOOD BU 1 AND 19'O.C.LLMC AND
,9'0.0.LIAR V a
n
a was
It ao�ff
tc
OPTION'A' OPTION
WQOO BUCK CON TronoN TO W000 SURSTRATE (WOOD SPECIFIC GRAVITY SO-0.55 MW.) o
n
THE INSEIDI ATOM I ERIDOS SHOWN ABOVE SHOWS 2X6 BYE WOOD BUCK ATTACHMENT
TO WOOD STRUCTURES.IF THESE LOHODS ARE FOLLOWED NO ADBITIOAAL CAlCUMONS/DESIGN U <�
WLL BE RCOIAREO FOR DESION OF GARAGE DCOR ANCXORARE. ANCHOR ---
FOR DOOR fU ACEMENF MPLM;A71ONS PATH ND ENGINEER OF RECORD,INSTALLATION MAY BE 5➢fdNG 4 Z
VERIFIED AND APPROVED BY THE SUILOINT OFFICIAL.UPON USPFCROlL ANCHORS SiDUC1URE EMBED SPIN G EDGE DLRI. r.0
J 8 HLC SIEEYE BY 0.11 CONC.
3 'HSC SLEEVE BY'Ht1 1112£0COBLOCW
J 'pYNABDLT BY NC. ^t 2 p' o ¢3 45
STEEL STRUCTURE BY OTHERS yLe_DYNABO}T BY RW HILLb OCK 1-1 2 w 2-1
b/iG%!-Sf8' 3 B POWER-ti9LT Hi'POWE COKG 2' B' 1-0(8 p
UO SCREWS BMVVr Y DOOR
20445 ILNOSEb J B SLELVE-ALL BY SMP5ON5 CON
AT 12"O.C. /J��\\\\ CONCRETE rc=3000 PA IAN.
DO
H A H BDL75 FBO CFOUI fULED AtOCK rm v 20OD 951 NM. b
WOOD RUCK C�j'CTION TO MASONRY ARK WASHER A Nur
+�.°. �AT 72'O.C.U)X. EDGE DIST.
PRESSURE TREATED 2%6 SYP WOOD WHICH SHALL BE ANCHORED TO
CROITIED REINFORCED YA^uOHRY BLOCK
px WA WALL OR CONC.COLUMN WIM I
TIr UtTRACON 8Y'ELCO'WiTR SPACUIC of {} O �•
16'O.C.INTO GAOUf OMED BLOCK WAIA,.WAN 2-1/4-ION.EMBED LLLddd u = p
1S'qC.DIfO 300a PSI CONCRETC.YAIH 1-3/4'UDL EMBED 1-1 4-X 2-T X 14 CA q P s�
f / //�2 1 5 !
2-1 2'LRS.EDGE DUfANCE T_7/z` t-i/z' CONT.STEEL MR=
124'TAPPER OY'POYMIS'WTH SPACING OF _92 CA.CAV.STEELm a L�
74-0.0 INY GROUT FILLED BLOCK WALL,WITH 1-1 2'WN.EMBER FIAT BRACKETS tY LONG 2-i�8'X 1"X 14 CA B
Rr O.C.DOD 30GR F5f CONCRETE.INTH 1-3/4•br1 EMITTED 1/16•X 2-122 {
J'MUL EDGE DISTANCE EILIET WCIDS W AT Iz'OC.W bOOR OFNG. FAST.STEEL.
TRACK PLATES
J//B'CDNftEX ER''EILO'OA AT 12.O.C.FLLX. AT 1B•UD.0ABOVE BOOR LE W//(2)T/4-20%5//B"TRUSS N0. ,.
3/e"LDT t '2Mr'a SPACING DF CAMNECffO lit COM.ANGLE
SI02IED M5.&tkCK NIA v {
24"-O.C.ROO 300 WITH WITH 2-1/2"WN.EMBED W/(3)SPOT WEEDS AT EACH SIDE `a
2'MDL EDGE DISTANCE COMRIL(p Ic ANG1F TR4(�'( R[yFgCC TRACK CONTINUOUS TRACK
_R�la<a
3/B'itLC OE DIS DY'tDCtf'r'IRN SPApt(C OF io WtmO ROCK Q,.''f(Fj,-a Tn CONCRFi R inicR BLOCK
86'0.G IMP J 0 P�51 4N�UETE.WAIBM 1-1/4"W 1 liW EMBED ULFURS'4'MRL EDGE(I.E.
2-i/2"NAI.EDGE D&COOE AL4rERNATE TRACK INSTA AXON _
E",JA
PREPARATION EAM
OF BS RY OTHERS VAo PELODEICE'C�ITErmsWWtalw716ft 4 T'
+ swT:r 4
FOR NEW CONSTRUCRON CNGINEER OF RECORD OR AACHAECF TO VERIFY FLA.PE+706A2 1
ADEQUACY OF SUPPORTDIO 57RUCTURE TO SUPPORT LOADS NPOSEO
BY CODA SYSTEM. IYUY } 2Vt1 � � 8'A 5
FOR DOOR REPLAMENT W RETROFO BUILDINGS WITH NO BROKER OF -�
RECORD.DOOR INSTALLATION MAY BE REVIEWED AND APPROVED BY
BUILDING OFRCOL UPON INSPECTION- I�VODeAeheNnCbn¢si dsoWTRg
AUXIUUM EXRIEOR(t)LOAD EEA JAMB n(9.33'X SO PM/2:2=3 LW per FIL 01-09
MtdOMtk3 RRER',OR(-)LOAD PER JAMB.(8.33'X 60 PSF)/2..279.9 Lac per FL sheet 4 0/5
PLASTIC COMPLIES WITH r7l
CHAPTER 26 OF FOC
SEE EVIDENCE PAGE
24 OX(.024)SIM Un, 6
IF 11,125 2nc
7/16-UIX CARVER
4 0 SS
IL
cy
_21
11 lax,11 AIR,I.
It to Ila, RICID PVC ONE PIECE INJECTION RIGID PVC ONE PIECE HIJECTION
% 14 ak3R'sus
ma
FROM ENDS 4
I
,IIS Y
I
AND 6-1/2 O.C,'IJAX. MAD.AIL a
.175 X.062 DEEP
IIII GROOVC
it o
1/4-POLYMISCRIDE LE)WI
-BY AMC INNOVATIVE PLAMICS' A'
flet ?jG;S
'13-07=1
2IIII .-x
to
z on:xg g
4 0
o-
1111 1111 140 S
E] ED E] ED,
11
.175 X.052 DEEP 7GC
111 1M �qg
GROOVE
14) 11
(4)JR� F/X 34GlIS INSIDE ELEVATION ROM(I
US
RAISED PANEL EMBOSSED DOOR WITH OPTIONAL WINDOWS
AND 6 1 M C X. WINDOW LITES CAN BE IN ANY LOCATION IN DOOR SECTION 2
0 x 3/4 sus
175
AND 4-1/2MOMC ENDyS ROM
314'1111
ARD/'3a•ERDN CRUS
-----------
f s FIA PC
7/16-UK wmm ----------- 705512
0 R PARE.
EXTERIOR I J4
24 (.02�)MM OR.- I
7::i DEL=m draniag DD.
24 Gk(.024)SIM 101. GWWG EfTE01-09
VRNCDW VAVUH