HomeMy WebLinkAboutProduct Approval W
ST.LUCT, COUNTY BUILDING DIVISION
REVIEWED FOR CO LLANCE
AM vVED RY
RECEI _D JUN 2 TrA
PLANS A10 FE T BE XXX 0111 XOB
MIAMFp1ADE OR NO V�SPECTION WILL BE MADE.
MIAMI-DADE COUNTY
PRODUCT CONTROL SECTION
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(RER) 11805 SW 26 Street,Room 208
BOARD AND CODE ADMINISTRATION DIVISION T(786)315-2590 F(786)315-2599
NOTICE OF ACCEPTANCE (NOA) ivww.mianfldade.eov/econom
PGT Industries,Inc.
1070 Technology Drive
North Venice,FL 34275
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of Construction
materials. The documentation submitted has been reviewed and accepted by Miami-Dade County RER -
Product Control Section to be used in Miami Dade County and other areas where allowed by the Authority
Having Jurisdiction(AIIJ)
This NOA shall not be valid after the expiration date stated below.The Miami-Dade County Product Control
Section (In Miami-Dade County)and/or the A14J(in areas other than Miami-Dade County)reserve the right
to have this product or material tested for quality assurance purposes. If this product or material fails to
perform in the accepted mariner, the manufacturer will incur the expense of such testing and the AHJ may
immediately revoke, modify-, or suspend the use of such product or material within their jurisdiction. RER
reserves the right to revoke this acceptance, if it is determined by-Miami—Dade County Product Control
Section that this product or material fails to meet the requirements of the applicable building code.
This product is approved as described herein, and has been designed to comply with the Florida Building
Code, including the High Velocity Hurricane Zone.-
DESCRIPTION:Series -SH;;200!!�'Alifmiii'u6it-Single dung' i An, (7) A
w N`4
APPROVAL DOCUMENT:Drawing No.Ml)-SH200-01,titled"Single Hung Window Installation"
sheets I through 8 of 8,dated 05/11/11,with revision B dated 05/20/15,prepared by manufacturer,signed
and sealed by Anthony Lynn Miller,P.E.,bearing the Miami-Dade County Product Control Revision stamp
with the Notice of Acceptance number and expiration date by the Miami-Dade County Product Control
Section.
Missmi&IMPACT RATING:None
LABELING: Each unit shall bear a permanent label with the manufacturer's name or logo, city, state,
model/series, and following statement: "Miami-Dade County Product Control Approved", unless otherwise
noted herein.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been
no change in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change
in the materials, use, and/or manufacture of the product or process. Misuse of this NOA as an endorsement
of any product, for sales, advertising or any other purposes shall automatically terminate this NOA. Failure
to comply with any section of this NOA shall be cause for termination and removal of NOA. '
ADVERTISEMENT: The NOA number preceded by the words Miami-Dade County, Florida, and
followed by the expiration date may be displayed in advertising literature. If any portion of the NOA is
displayed,then it shall be d6he in its entirety.
INSPECTION: A copy of this entire 140A shall be provided to the user by the manufacturer or its
distributors and shall be available for inspection at the job site at the request of the Building Official.
This NOA revises NOA#11-1013.12 and consists of this page I and evidence page E-1,as well as approval
document mentioned above.
The submitted documentation was reviewed by Manuel Perez,P.E.
SMIAMI-DADECOUNxpirNOA No.15-0528.22
-7rtr -31 Eation Date: September 01,1016
19
Y-7 Approval Date: August 06 2015
Page 1
PGT Industries,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
A. DRAWINGS
1. Manufacturer's die drawings and sections.
(Submitted under NOA No. 11-0614.01)
2. Drawing No. MD-SH200-01,titled"Single Hung Window Installation"sheets I
through 8 of 8,dated 05111/11 with revision B dated 05/20/15,prepared by
manufacturer, signed and scaled by Anthony Lynn Miller,P.E.
B. �FSTS
Test reports on: 1)Air Infiltration Test, per FBC,TAS 202-94
2)Uniform Static Air Pressure Test, Loading per FBC,TAS 202-94
3)Water Resistance Test,per FBC,TAS 202-94
4)Forced Entry Test,per FBC 2411.3.2.1,and TAS 202-94
along with marked-up drawings and installation diagram of series SH-200 aluminum
single hung window,prepared.by Fenestration Testing Laboratory, Inc.,Test Report
No. FTL-6479, specimens 1 thru 26, dated 03/28/11, signed and sealed by Marlin D.
Brinson,P.E.
(Submitter)tinder NOA No. 11-0614.01)
C. CALCULATIONS
1. Anchor verification calculations and structural analysis, complying with FBC-5t'
Edition(2014),dated 05/22/15,prepared by manufacturer,signed and sealed by
Anthony Lynn Miller,P.E.
2. Glazing complies with ASTM E1300-04
D. QUALITY ASSURANCE
1. Miami-Dade Department of Regulatory and Economic Resources (RER).
E. MATERIAL CERTIFICATIONS
1. None,
F. STATEMENTS
1. Statement letter of conformance, complying with FBC-5th Edition (2014), dated May
21,2015,issued by manufacturer,signed and sealed by Anthony Lynn Miller,P.E.
2. Statement letter of no financial interest, dated May 21, 2015, issued by manufacturer,
signed and sealed by Anthony Lynn Miller,P.E.
G. OTHERS
1. Notice of Acceptance No. 11-1013.12,issued to PGT Industries for their Series"SH-
200"Aluminum Single Hung Window-N.I.,approved on 12/08/11 and expiring on
09/01/16.
LAfinue ez,P.K.
Product Contro .1haminer
NOA No.15-0528.22
Expiration Date: September 01,2016
Approval Date: August 062015
TABLE 1: TABLE 2:
z Monolithic Glass Types PRODUCT REVISED
Maximum , Design Pressure(lbs/ft)for Glass Type A, Fin&Flange Frame m atwplying,vilh the Florlde
Window Sash Height A 118"Annealed rm"I"' IN'
Height' (see Figure A,this sheet) Maximum Window Width' B 1/8"Tempered 'A 1411,-810141 -09 P2
18-V8" 26-11T 33" 37" 41" 45" 49" 53.1/8" E pIr nDatc
_ C 3116"Annealed
23" 11-9118"{Equal Ute} +55,0 -90.4 +SSA -90.0 +55.4 -90.0 +55.0 -90,4 155.0) 84,0 +65.0 -94.0 +55.4 -94.4r+41.3 -41.3
p 3/i8"Tempered Miami ado product
under 18.9116" +55.0 -90.0 +55.0 -90.0 +55.0 -76.2 +65.0 +65.5 +55.0 -57.3 +60.2 -50.2 +44.8 -44.8 E 114'Annealed
37 18-9/16"(Equal Lite) +65.0 -90.p +55.0 90.0 +55.0 84.2 +65.0 -74.5 +55.0 X8.6 +55.0 51.0 +55.0 -57.70 F 114"Tempered
oterl8-8/18" +55.0 -90.0 +55,0' -90.0 +55.0 -76.2 +55.0 -65,5 +65.0 -57.3 +50.2 -50.2 +44.8 44.89 c-
under l5-7l8" +65.0 -90.0 +55.0 -87.1 +55.0 -73.4 +55.0! •83.8 +55.0 56.8 +50.0 -SU +44,8 144,80
TABLE 3: }
15.718"thru 19-3116"3 +55.0 -90.0 +55.0 -90.0 +65.0 -78.7 +55.0 -68.0 +55.0 -58.5 +51.1 -51.1 +45.9 45.93 ? e �-
38 318" 19-1/4"(Equal Lite) +56.0 -90.0 +55.0 -90.0 +55.0 -82.7 +55.0 -72.6 +65.0 53,5 +55.0 -57.9 +54.2 -54.2 +51.5 51.6 Insulated Glass Types O Q Q�
o%er 19-114" +65,0 -90.0 +55.0 -87,1 +55.0 -73.4 +65.0 -663.8 +55.0 -56.8 +50.0 540 +44.8 -44.8 +40.0 40.0 G 1!8"Annealed,1/4"Airspace,1/8"Annealed Z N
under 19-9116" +55.0 -81.5 +55,0 -72.3 +65.0 •61,3 +55.0 55,3 +60.5 50.6 +45.8 46.8 +42.0 42A +38.7 -38.7 H 3116"Annealed,3116"Airspace,1/8"Annealed O
19.6/16"thin 22-518"3 +55,0 -90.0 +55.0 -87.9 +55.0 -74.0 +55.0 -6x4.3 +55.0 58.9 +50.1 -50.1 +44.8 44.8 +40.0 -40.0 1 1/8"Tempered,114"Airspace,118"Tempered Q R.
45" _1J12
22.06"(Equal Lite) +55.0 -90.0 +55.0, -90.0 +55.0 -78.8 +55.0 58.1 +55.0 -56.5 +51.1 -51.1 +46.0 -48.0 +41,4 41.4 J 3118"Tempered,3/16"Airspace,118"Tempered Il.) ti! }
over 22-9116" +55.4 -81,5 +55.0 -72.3 +55.0 51.3 +55,0 55.3 +50.5 -50.5 +45.6 45.8 +42.0 42.0 +38.7 -38.7 i- CO
under 20.1/8" +55.0 -71.6 +55.0 -62.8 +55.0 -55.4 +50.3 -50,3 +45.9 45,9 +41.7 41.7 +38.9 -38.8 +36.2 -36.2 LL
!rte y = y O
20-1/8"thru 24-1/2"a +65.0 -90.0 +65.0 -82.5 +55.0 -69,6 +55.0 -61.6 +65,0 55.4 +49.3 49.3 +44.0 44.0 +40,0 -40.0 V 0 C} �
4g" FIGURE A:SASH •"tom•' N
24.9116"(Equal Lite) +55.0 -90.0 +55,0 -90,0 +55.4 -76,4 +55.0 -66.5 +65.0 -57.8 +50.4 50.4 +45.0 -46.0 +40.1 -44.1 CROSS SECTtON O 8 O W d
(WITH MONOLITHIC Z z N
over 24-9116" +56.0 -71.6 +55.0 52.8 +55.4 -55.4 +50.3 -50.3 +45.9 45.9 +41.71 41.7 +38.9 -38.9 +36,2 -36.2 GLASS) a` x Z r
under20-13118" +55.0 -87.8 +55,0 -59.9 +53.3 -53.3 +48.5 -48.5 +44.1 44,1 +40.2 40.2 +37.6 -37.6 +34,8 -34.8 � Z
20-13/16"thru 24-11/18"' +55.0 -89.6 +65.0 l -80.3 +65.0 -67.7 +65.0 -60.6 +64.2 54.2 +49.0 49.0 +44.2 44.2 +40.0 40.0 �II O
(t)
5Q 518" 1 O C1`1 W 2
24-314"(Equal Lite) +55,o -80.6 +55,0 t -90.0 +55.0 -75,4 +65.0 55,7 +56.0 -57,4 +50.3 -50.3 +44,9 44.9 +39.9 -39.9 �R - (�
over 24-3/4" +55.0 -87.8 +56.0 -59.9 +53.3 53,3 +46.5 -48.5 +44.1 44.1 +40.2 -40.2 +37.6 37.6 +34.8 -34.8 i` �r O 2 N
under 24-15/16" +55.0 -56.0 +43.8 43.8 +41.9 41,9 +39.1 -39.1 +36.0 -35.0 +32.6 -32.6 +30.0 30.0 +27.6 •27.6 II O L 2
24.15/16"thru 30-5/B"3 +56,0 i -75.0 +55.0 i 56.0 +65.0 57,4 +51.9 -51.9 +47.4 47.4 +43.2 43.2 +39.8 -39.9 +37,3 -37.3 Ii SASH -y (} W O
VISIBLE LIGHT I •-� $g
30.9116"(Equal Lite) +55.0 -87.9 +55.0 -75.8 +55.0 56,6 +55.0 -59.7 +53.5 -53.5 +48,7 48.7 +43,9 43.9 +39.9 -39.9 HEIGHT I( HEIGHT (n
ober 3"116" +55.0 67.8E+41.2
59.9 +63.3 53.3 +48.5 48,5 +44.1 44.1 +40.2 40.2 +37.6 -37.8 +34.8 4 -34.8 SASH HEIGHT-3.9116' Ill
under25-3/4" +54.7 -54.7 41.2 +40.3 40.3 +37.e -37.8 +34.6 -34,6 +31.3 -31.3 +28,9 -28.9 +26.5 -26.563" 2",V'lhru 31-518"' +65.0 -72.0 -63.2 +55.0 55.7 +60.5 -50.5 +46.1 -46.1 +41.9 41.9 +39.0 •39.0 +36.3 -36.331-9/16"(Equal Lite) +56,4 -83,9 ) 71.7 +55.0 -64.8 +55.0 -58.2 +62.4 52.4 +47.8 47,9 +43.3 43.3 +39.7 -39,7over31-9116" +55.4 57.8 •59.9 +53.3 -53,3 +48.51 48.5 +44.1 44,1 +40.21 40.2 t37.6 -37.6 +34.8 -34.8 j! _ $•
under 29-3/4" +53.3 53.3 +39.7 -39.7 +39.1 -39.1 +36.7 1 36.7 +-33.74 -33.4 +30.3 -30.3 +28.0 -28.0 +25.8 -26.8 �0 d $
o:x
73" 29.314"thru 36.5/8'' +55.0 -61.0 +52.0 52.0 +48.2 48,2 +44.0 44.4 *40.1 40,1 +37.0 -37.0 +34,1 -34.1 +31.4 -31.4 j{ oa z
36-8116"(Equal Lite) +56.0 -68.3 +55.0 -56.3 +52.1 52.1 +61.5 -61.5 +47.0 47.0 +42.7 42.7 +39.6 -39.6 +37.0 -37.0
over 36-9/16" +55.0 -67.8 +55.0 -56.3 +52,1 -52.1 +48.5 48.5 +44.1 44.1 +401 40.2 +37.6 -37.6 +34.8 -34.8
under 31-3/4" +53.3 -53.3 +39.7 59.7 +39.1 -39.1 1+36.7 -36.7 +33.4 -33.4 +30.3 -30.3 +28.0 -28.0 +25.8 -25.8 a \11111 I r 1 1 j f
78" 31.3/4"thru 39"' +55.0 -58.3 +48.0 -48,0 +45,2 45.2 141.2 4i.2 +37.9 -37.9 +34.8 -34.8 +31,7 -31.7 +29.6 -29.5
NOTES
39-1119'(Equal Lite) 155.0 62.5 +50.8 -50.8 +46.3 46.3 +45.2' 45.2 +44.2 44.2 +40.3 40.3 +37.7 -37.7 +34.9 -34.9 %p
1)USE THIS TABLE FOR ALL WINDOWS THAT ARE GLAZED WITH 118'
'Tip trrtlp dimensions for flange windows shown.For fin windows or buck dimensions,subtract 1". r
ANNEALED GLASS(TYPE A). ��,, � p•,
O%erall sash height.For clear daylight height,subtract 3-9116". _ r w C, a -gar
a 2)FOR SIZES NOT SHOWN,ROUND UP TO THE NEXT AVAILABLE WIDTH _ ;y ya ;c c"1 r,� 0:•'-
Site range includes the standard Pro-View(3•over-2 configuration)for the given Window Height. OR HEIGHT OIMENSRON SHOWN ON SHE TABLE. f Y:•us o
For overall sash width,subtract 2-15/16"from the buck dimension. j L 7d
,
r`,
TABLE 4; TABLE 2:
I'IiODUC!REV166D
2 Monolithic Glass Types os complying wuh rhe r9mrdr
MaximumDesign Pressure(lbslft)for Glass Type B-J, Fin 8 Flange Frame Bnilding Cnde
Window Sash Heights A 1/8'Annealed AccePlance Nn) 22
(see Figure A,this sheet Maximum Window Width'
Height' 9 ) B 1/B"Tempered
191/8" 26-1/2" 33" 97" 41" 45" 49" 53-1/8" � 3116"Annealed i;y -
Miwni ode Product Cmc
23" 11-9116"(Equal Lite) +55.0 -90.0 +55.0 -90.0 +55.0 90.0 +55.0 -80.0 +55.0 90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 p 3116"Tempered
under 18.9116" +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -84.3 +55.0 -78.0 +55.0 -72.9 E 114"Annealed
3T' 18-9/16"(Equal Lite) +55.0 -90,0 +55.0' -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -81.1 +55.0' -73.4 F 1/4"Tempered
over 18-9/16" +55.0 -90.0 +55.0 -80.0 +55.0 -90,0 +55.0 -90.0 +55.0 -90.0 +55.0 -84.3 +55.0 -78.0 +55.0 -72.9
under 16-7/8" +55.0 -90.0 +55.0 -90,0 +55.0 -90.0 +55.0 -90.0 +55.0 -88.6 +55.0 -81.8 +55.0 -75.0 +55.0 -88.5 TABLE 3:
15.718"thru 19-3/16"3 +55.0 -90.0 +55.0 -00.0 +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -87.9 +55.0 -78.8 +55.0 -71.2 Insulated Glass Types 0 �o 9
38-318"
19-1/4"(Equal Lite) +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -80,0 +55.0 -87.9 +55.0 -78.8 +55.0 -71.2 1/8"Annealed,1/4"Airspace,1I8"Annealed O 1 Z N
over 19-114" +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -88.5 +55.0 -81.8 +55.0 -76.0 +55.0 58.5
I I H 3116"Annealed,3116"Airspace,1/8"Annealed O �
under 19-9/16" +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 56.5 +55.01 -80.2 +55.0 -73.2 +55.0 56.3 +55.0 ;59.7 H ,
1 1/8"Tempered,114"Airspace,1/8"Tempered p
19-9116"thru 22-518" +55.0 -90.0 +55.0 -90.0 +55.0 -80.0 +55.0 -90.0 +55.0 89.1 +55.0 -78.5 +55.0 -70.0 +55.0 Iff
45" ' J 3116"Tempered,3116"Airspace,118"Tempered W W
22-9178"(Equal Lite) +55.0 -90.0 +55.0 -90.0 +55.0 -00.0 +55.0 -90.0 +55.0 -89.3 +55.0 -78.5 +55.0 -70.0 +55.0 -83.0 Ur (D
over 22-9116" +55.0 -90.0 +55.0 -9D.0 +55.0 -90.0 +55.0 -86.5 +55.0 50.2 +55.0 -73.2 +55.0 -66.3 +55.0 -59.7 Z Z (n LL
under 20-1/8" +55.0 -90.0 +55.0 -90.0 +55.0 -85.0 +55.0 -81.8 +55.0 -75.7 +55.0 -69.2 +55.0 X2.8 +55.0 -57.7 2 2 Z O
20-1/8"lhru 24-117'3 +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -84.8 +55.0 -74.2 +55.0 -65.9 +55.0 -59.1 FIGURE A:SASH U U -7 O co
49" CROSS SECTION O O In
24-9116"(Equal Lite) +55.0 -00.0 +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -84.8 +55.0 -74.2 +65.0 -65.9 +55.0 -59.1 (NTH I.O.GLASS) Z Z W a �
over 24-9118" +55.0 -90.0 +55.0 -90.0 +55.0 -86.0 +55.0 51.8 +55.0 -75.7 +55.0 -89.2 +55.0 -62.8 +55.0 -57.7 Z "F-
under 20-13116" +55.0' -00.0 +55.0 -90.0 +55.0 -83.5 +55.0 -79.1 +55.0 -74.0 +55.0 57.3 +55.0 -81.9 +55.0 -56.8 `- Z
I In C9
20-13116"thru 24-11/18"3 +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +65.0 -90.0 +55.0 -83.2 +55.0 -72.7 +55.0 -64.5 +55.0 -57.8 ill it 0 N L Z
505/8" 24-314"(Equal Lite) +65,0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -90.0 +55.0 -83.2 +55.0 -72.7 +55.0. •84.5 +55.0 -57.8 fi O �t o a 2 0
over24-314" +55.0 -80.0 +55.0 -90.0 +55.0 -83.5 +55.0 -79.1 +55.0 -74.0 +55.0 57.3 +55.0 -61.9 +55.0 -58.8 it I 8 Z W N
under 24-15118" +55.0 -87.9 +55.0 -75.6 +55.0 -65.7 +55.0 -82.3 +55.0 -60.0 +55.0 -56.5 +53.2 53.2 +49.5 -09.6 11 Ij O -j
II SASH V Q)
24-15116"thru 3D-5/8"3 +55.0 57.9 +55.0 -75.6 +55.0 -74.1 +55.0 -74.1 +55.0 -74.1 +55.0 -65.5 +55.0 -57.5 +51.1 -51.1 VISIBLE LIGHT II 11 HEIGHT (n W Z_ •�
81 30.9/16"(Equal Lite) +55.0 -87.9 +55.0 -75.8 +55.0 -74.1 +55.0 -74.1 +55.0 -74.1 +55.0 -65.5 +55.0 57.5 +51.1 -51.1 HEIGHT ii II m rc (n
over 30-9/16" +55.01. -87.9 +55.0 -75.8 +55.0 -74.1 +55.0 -74.1 +55.0 -74.0 +55.0 -85.5 +55.0 -57.5 +51.1 -51.1 SASH HEIGHT-3-9116-
under 255/4" +55.0 -83.9 +55.0 -71.7 +55.0 52.0 +55.0 -59.9 +55.0 -57.8 +54.5 -64.5 +51.3 -51.3 +48.3 -08.3 ii ® 0 NN
63" 26-314"1hru 315/8i 3 +55.0 -83.9 +55.0 -71.7 +55.0 59.4 +55.0 -69.4 +55.0 59,4 +55.0 -64.5 +55.0 -56.5 +50.2 -50.2
31-9/16"(Equal Lite) +55.0 -83.9 +55.0 -71.7 +55.0 59.4 +55.0 -69.4 +55.0 -89.4 +55.0 54.5 +55.0 -56.5 +50.2 -50.2 LA
over 31-9118" +55.0 -83.9 +55.0 -71.7 +55.0 59.4 +55.0 •69.4 +55.0 -69.4 +55.0 -64.5 +55.0 -56.5 +50.2 -50.2 II II d o
under 29-3/4" +55.0 -68.3 +55.0 56.3 +52.1 -52.1 +51.5 -51.5 +51.5 -51.5 +51.5 51.5 +60.0 -50.0 +46.4 -06.4 n 1
29-3/4"thru 38-518"3 +55.0 58.3 +55.0' -56.3 +52.1 -52,1 +51.5 -51.5 +51.5 51.5 +51.5 -51.5 +51.5 51.5 +40.4 -46.4
73"
36-9/16"(Equal Lite) +55.0 -08.3 +55.0 -56.3 +52.1 -52.1 +51.5 -51.5 +51.5 -51.5 +51.5 -51.5 +51.5 51.5 +46.4 -06.4
over 36-9116" +55.0 -68.3 +55.0 -50.3 +52.1 -521 +51.5 -51.5 +51.5 51.5 +51.5 -51.5 +51.5 51.5 +48.4 46.4 vvvvvil1111111111
under 31-3/4" +55.0 -62.5 +50.8 50.6 +46.3 48.3 +45.2 -45.2 +45.0 45.0 +45.0 45.0 +45.0 45.0 +45.0 45.0 � ......'
76" 31-3/4"lI1N 39"3 +55.0 62.5 +50.6 -50.8 +46.3 48.3 +45.2 -05.2 +45.0 45.0 +45.0 -05.0 +45.0 45.0 +45.0 -05.0 NOTES ��rV, '•.��` wa
39-1/18"(Equal Lite) +55.0 52.5 +50.8 50.8 +46.3 -46.3 +45.2 -05.2 +45,0 -45.0 +45,0 45.0 +45.0 -45.0 +45.0 45.0 1)USE THIS TABLE FOR ALL WINDOWS THAT ARE GLAZED WITH GLASS _ o P1.4:w g
TYPES B-J.NOT APPLICABLE WITH 1/a'ANNEALED GLASS(TYPE A). _ z:h m l r O
1 Tip-to-tip dimensions for flange windows shown.For fin windows or buck dimensions,subtract 1". = z;< '^ O-;E a
2 2 FOR SIZES NOT SHOWN,ROUND UP TO THE NEXT AVAILABLE WIDTH OR,: �-•W O V 1N 4: -2 nl
Overall sash height.For clear daylight height,subtract 3-8118". ) j y rij`z a
HEIGHT DIMENSION SHOWN ON THE TABLE. : y•. (ij`
3 Size range Includes the standard Pro-View(3-over--2 configuration)for the given Window Height.
For overall sash width,subtract 2-15/16"from the buck dimension. ��yfyy" •.
r,1'11�Ir1111P 1`�
INSTALLATION DETAILS FOR FLANGE FRAMES CONCRETE/CMU CONCRETE/CMU
OPTIONAL ADDON EMBEDMENT PER ANCHOR PERANCHOR TYP.ANCHOR
INSTALLATION FLANGE AHEAD, 13 REQUIREMENT 3 REQUIREMENT TYPE.
OPTION I SILL&JAK48S EMBEOMENTAND
CURVED HEADER 1/4*MAX 41 27 EDGE DISTANCE
INSTALLATION INTO WOOD ----------------- EDGE SHIM 12 61 PER SUBSTRATE,
SEE TABLE S.
2),SEE NOTE 2,THIS SHEET. DISTANCE THIS SHEET.
=>
EMBEDMENT
TYP.ANCHOR
36 —JEMBEDMENT
-11/4"MAX 114"j j EMBEDMENT EDGE
1 TYPE.
SHIM MAX AND EDGESHIM DISTANCE DISTANCE
TYP.ANCHOR TYPE, E PER
EMBEDMENT AND SUBSTRATE --------
SEE TABLE 5:
1'465' EDGE DISTANCE 32
PER SUBSTRATE, THIS SHEET.
I 43 64 EXTERIOR INSTALLATION
' INSTALLATION
SEE TABLE 5,THIS I -
SHEET, OPTION I INSTALLATION OPTION 3
"BIBLE STRAIGKTHEADER OPTION 2 VISIBLE LIGHT WIDTH INSTALLATION ANCHORS
LIGHT INSTALLATION ONTO SUCK WIDTH THROUGH IX BUCKSTRIP
HEIGHT INSTALLATION INTO MASONRY.
WOOD 2X.NO ANCHORS ANCHORS DIRECTLY TIP-TO-TIP WIDTH
REQUIRED AT HEADER. INTO MASONRY. HORIZONTAL SECTION A-A
Ii 29
114*MAX.SHIM TABLE 5: EGRESS FORMULAS
#12 STEEL Anchor Min.Edge Min. (EQUAL-LITE)
41 SELF-DRILLING Anchor Anchor Substrate Distance Embedment WIDTH:TIP-TO-TIP WIDTH-4*
SMS(G5)SEE Group HEIGHT:TIP-TO-TIP WiDTHP2-"116"
2.751' 9 TABLE KiHls A 1/4'410 SS CroleFlex Ungmuted CMU,(ASTM C-00) 1-314"/ 1.1/4'
SHEET P.T.Southern Pine(SG-.65) 9118" I-Wal
BUCK EXTERIOR USE EITHER VISIBLE LIGHT FORMULAS
HEIGHT
LATCH(#20)OR INSTALLATI\0N4-R #12 Steel SIMS Aluminum,6033-TS min. 316' 118*1 (EQUAL LITE)
BOTTOM LOCK OPTION 4 Screw(G5) Steel Stud,Gr.33 min. 3fEr 0.0346(20Ga), WIDTH(SASH):TIP-TO-TIP WIDTH-5-1/16"
TIP-TO-TIP (#11).TESTED INSTALLATION B A36 Steel 3/8' 1/91, WIDTH(FIXED):TIP-TO-11P WIDTH-4*
HEIGHT 11 UNIT LOCATION: ANCHORS P.T.Southern Pine(SG=45) 1. 1-318" HEIGHT:(TIP-TO-TIP HEIGHT-7-1/16')12
035 - 6-5/8 FROM - —
VENTDIRECTLY INTO'END. 1/4"410 SS Crelai'lex Concrete(min,3,35 k9l) 1. 1.t II
64
METAL. Ungrouted CMU,(ASTM C-90) 1-T4' 1-1/4*
VISIBLE 7 3 P.T.Southern Pine(SG-.65) 21-31'8"
LIGHT 1. 1_31
HEIGHT 11 11 34 DADE APPROVED MULLION, C 114"Steel Utracon Concrete(min.2.0 ksi) -31W
a
ALUMINUM,STEEL FRAMINGEXTERIOR Ungrouted CMU,(ASTM C-9D) 22-1/2r4 1-1/4"
11 STEEL STUD.SEE SUBST MIMIMUM OF 3 THREADS BEYOND THE METAL SUBSTRATE.
PROPERTIES,TABLE 6 THIS 4'
SHEET, f
NOTES
1)USE ONLY SUBSTRATE-APPROPRIATE ANCHORS LISTED ON TABLE 5 OF THIS SHEET.FOLLOW EMBEDMENT AND EDGE DISTANCE LIMITS.ANY INSTALLATION OPTION
SHOWN MAY BE USED ON ANY SIDE OF THE WINDOW.
2-2W 31 20
2X WOOD 2)MASONRY ANCHORS MAY BE USED INTO WOOD AS PER TABLE 5,THIS SHEET,ALL WOOD BUCKS LESS THAN 1.12'THICK ARE TO BE CONSIDERED 1X INSTALLATIONS.
BUCKSTRIP 2 IX WOOD BUCKS ARE OPTIONAL IF UNIT IS INSTALLED DIRECTLY TO SUBSTRATE.WOOD BUCKS DEPICTED AS 2XARE 142"THICK OR GREATER,IX AND 2X BUCKS PRODUCT REVISED
SEE NOTE 2�: (WHEN USED)SHALL BE DESIGNED TO PROPERLY TRANSFER LOADS TO THE STRUCTURE.WOOD BUCK DESIGN AND INSTALLATION IS THE RESPONSIBILITY OF THE a.,complying with the FlOrldfi
TE Building Code
THIS
Amptute NO I-F-Os
'. T
HIS SHEE ENGINEER OR ARCHITECT OF RECORD.
-1 3)VISIBLE LIGHT WIDTH OR HEIGHT(ALSO j lax ItiOnDate l-Ig
N" k.YNIV Rovi3ad By. GO* R*vlmln. i rf.
REFERRED TO AS DAYLIGHT OPENING)Is ()jk 411 F
MEASURED FROM BEADING TO BEADING. I. -4
E NSj•-- JJ 10/10/11 2014 UPDATE 1,.ft'l C.0101
T 1/4"MAX SHIM R-f#.d W. Date: Rovidan:
NO ANCHORS No.60705
CONCRETE PER SC 05/20/15 TABLE I
REQUIRED IN
H
FAME SILL REQUIREMENT 'T FLANGE FRAME INSTALLATION DETAILS or"Ra03S` OWSKI
TEO
FLANGE ANCHOR
F
1070 TECHNOLOGY DRIVE True:
N.VENICE. FL 34276 SINGLE HUNG WINDOW INSTALLATION 6/11/11
P.O.BOX 1529 1
VERTICAL SECTION B-B AAII�- NOKOMIS;FL 34274 Sorfes1h(Od.l., -S..104 Sh.0h R*7--
CERT. O���
A LY, "ER"'P.E. SH-200 NTS 4 OF )0-01 B
T <
m S 0 0 N N lOC A 6 V e • =5
T r!r A A S m y m o - . > m
m 2E T m-r �_ - r
A x N Z 9 S 0 m n y
Y
P (p+ P p N T
mz Ol m m m n
m _
vp N D m m S T m 2 a 2 .yp� N Pao a B p s v m p f �_ P a o
y z� Z ZA S m O O _ _ A i +p, e p per', m �i L^ L.�• m N _ e >Za IF
rxrl S? O y> [T m n e °t r m ' C�m•' m C:` C N m m } m C r m m - C
0 _ m ; - _
-mi OA : C. n m
a $p N O 5 N m n m
O 2
Z. m yza - u N N Above MR B
A SIC Z m o oz a ? N N NIq
Below MR
A -mi 0 �r ' m r3 N u w N N W -F—.MR
m
0 O w- ^• N Bela.MR v m
m m � N N N •.' " m
A z N V Fp C T V w N N N N u N N N N N N N N Above MR m
0 m z .0 T c
u D z p n o N w N N "—MR n
x
n m m e c m n w N N Above MR v
Belau MR
a
O c N w N u N N Above MR m
O Z D N N N N N V W N N N N N Belau MR m N
= e w N N w N N Above MR 3
N N N V W N N N N N N N Below MR v
N V W N N W w N N N Above MR 3
CN N w N N - W A W N N W N N N u N Bela.MR Y
= N W W N w N w w N w w N N I N W N Above MR 3
N Below MR 'm �
_ m o
N N Above MR a D
N W N N N w N N N w N N N N Below MR a �'
r. o
c
a N uw N Above MR m
w
w W a a N W a a N W + a N W a a N W W a N W w w N N
w N N + w w N e N Belau MR D m
W I W W w a N W a N w W w W Above MR F.aW. C
w W N N N N w N N N N N N Below MR o,
N N Above MR 3
N N N W
\ N N N u N N W N NZ N N u N N N N N Balow MR
m
u w u w a u N Above MR o
N W W N p w u N a w N N N N Bele.MR > g m
N Above MR O =
\ N N w .1_1N Below MR
N w w�wlw N w NIN N Above MR a
3 N N N N N N N .1. Bet-MR
v w . w W > wN Above MR
W + w N Below MR
Above MR b
>=>z
oo :Z",0 "20"*r wW N N w
N Below MR
000sm w
om mp Zp�w'm� w 1" NIN - W N w W N N N Above MR 3
A�>y�Z0 0� W w N N Below MR 9
T x N u a w - N Above MR O
g
N N a N Below MR >
w w A i N w N W V u N W N Above MR
Below MR m '
/ w w w ► N w u N N w N Above MR c
N N N B..MR
r0 u W A w w N u N w w N Above MR a
m u w N N a v u N a w W N + w N N Below MR
D
z W
JA
bove MR aw a w Nu elwvMRwN Nbove MR a
elow MR
D n
� mm
x u m
z-Oi cS'1
�OrtA'
�zD
N
mN
RevxQ W. Duce: Revmon: Oram B3^ a m D C •c
Y LYNN'M��`,,� o JJ 10/10/11 NO CHANGE J ROSOWSKI ; _; a 0
Z. .JGENSF'••.fC,p Rau iea W. Doe: Rev
lo Gate: •e m cci
r...y
N0.58705 SC 05/20/15 NO CHANGE 05!11/11 °o
® Deeeript u
ANCHOR SPACING
�C•-. STATE OF :'([�` 1070 TECHNOLOGY DRIVE TV.:
�.
' FC ORIDN,_•' �_; N.VENICE, FL 34276 SINGLE HUNG WINDOW INSTALLATION
.......NAL
.....
s P.O. BOX 1529
S/phIAL �.� NOKOM IS;FL 34274 /gaper: Soale: Sheet: Drv.N9 No. B S, -
/.!L"tll"I P.E. CERT. OF AUfH. #29296 SH-200 NTS 6 OF 8 MD-SH2O0-01
P.Ef!58705
PRODUCTREVISED
m canplying wide We Florida
Building Cale
6 AccepbmceNol 05 ,ZQ
LM'mean Dale �(p
ANGLED/CURVED ANGLED/CURVED
By
ASSEMBLY 0°CORNER
ASME SEMBLY nd;�unl aac ,odnelca�a
FRAME
90°CORNER ASSEMBLY s
FRAME � " e Y m
ASSEMBLY ♦ c/) .—
O � Q
21 21 O
6 ` �O m O
Q Q _
1'WEEP 3 1'WEEP 50 51
ENOTCH ACH END \ NOTCH® 0 G
1V EACH ENO `X"
1 11 W LLI Q
2 5 U) LL
b0 51 FLANGEFRAME U V � Z �'0
MITERED FRAME :,O :,O O
50 51 SHOWN,FIN
WITH FRAME MITERED FRAME FRAME SIMILAR
WELDS AT WITH FRAME_ }
SCREW BOSSES WELDS AT Z Z
SCREW BOSSES 03 Z 9 f—
LU
ASSEMBLY_DETAILS FOR ASSEMBLY DETAILS FOR ASSEMBLY DETAILS FOR o o m 0 Z
FLANGE FRAME CORNERS FIN FRAME CORNERS FRAME TO MEETING RAIL o .. Q Z
o a = .N
W LU
m� -1 w (D
� U) A C)
1/2'NOM. _ 1/2'NOM.
GLASS STACK r GLASS STACK N m
114"AIRSPACE 3/16'AIRSPACE
1/8 ANNEALED OR _ 3116-ANNEALEP OR _..{ _ 118'ANNEALED OR 3/16'ANNEALED OR ::j _ } U
TEMPERED GLASS r TEMPERED GLASS I I TEM EREDLGLASS I� TEMPERED GLASS 11B'ANNEALED OR TEMPERED GLASS TE ANNEALED OR
SS �'�i
TEMPERED GLASS TEMPERED GLASS �t
I � x 5
I 60 1 III 61 I 62 I I I 63 I j I I 64
40 —�i I 41 III 42 III 43 !i I 43 II !j da o
318'NOM. jl �^ 3/6'NOM. Iljl 316'NOM. I I 318'NOM. it II 316'NOM. a Z
GLASS BITE I I ! I GLASS BITE I I ]VI 36 p
GLASS BITE I I GLASS BRE I GLASS BITE
}F 36
38 36 I 38 33 32
\\111lI1 11111 4
7 7 7
i
.7 �w06p'���"Id
1/8"GLAZING DETAIL _3_/_16"GLAZING DETAIL 1/4"GLAZING DETAIL 1/2" I.G. GLAZING DETAIL 1/2"I.G.GLAZING DETAIL = T w � • `No O g�
_ _
"--' GLASS TYPES H&J
GLASS TYPES A 8 8 GLASS TYPES C&D GLASS TYPES E&F GLASS TYPES G&I ��1:�y6 0)`�a
////11111111\11
Item PGT pGTPart# Description
# Dwg.# - 2.000'
1 2703E 62703EW Flange Frame Head
2.00°• .962"
2 27518 627516W Flange Frame Slll �r � 236J-7 -G." -3 2781 62781W Flange Frame Jamb osz • 1.125•
4 2713 62713BW Integral Fin Frame Head 2.6002.000• .DSD`
5 2714E 62714EW Integral Fin Fmme Sill 050•6 2782 62782W Integral Fin Frame Jamb 869" .062'7 2706 62706DW Sash Bottom Rail 1 oso• 52• J ��.869•
.osz• osz• 1
8 2707 62707CW Sash Top Rail i1 s00 o6z. os2
oso .062•
9 2739 62739W Fixed Meeting Rail O FLANGE FRAME HEAD r .oso•
10 2709 62709CW Sash Side Rail � 6063-TSALUMINUM 1 2.056'
11 274gB 742740AW Sash Bottom Lock O FLANGE FRAME SILL O FLANGE FRAME JAMB O INTEGRAL FIN FRAME HEAD
6063-T6 ALUMINUM 6063-T6 ALUMINUM 6063-T5 ALUMINUM
12 2785 62785W Sash Stop
13 134 66615 Addon Flange
20 1226 61226DW Vinyl Bulb,Flex PVC 70 f- .976• -I
21 1662C 71662CW Head/Sill Gasket,Polyethelyne z.oss -- 3.225• �}r I
22 1270 7PA0118 Open Cell Foam Pad os°• "c-
0
T 11.187"
1.125' � .050• J 050
'
23 2772 72772SHK Fixed Meeting Rail Plug Gasket,Rigid PVC I� - - .062•
24 4066 64066G Wstp.,187 X.230 Fln Seal 1.607' 1.898'
25 2784 72784W Sash Side Rail Gasket,Polyethelyne 075. _.oso 2.000 1.229' osz oso
26 1078 7121 UM Balance Take-out Clip 1.1zs• 975 50' osz 13 ADDON FLANGE
27 Varies per Size Balance 1 °sz 6063-T6 ALUMINUM
28 2711 4280OW Sash Cam,Nylon 050 1 o
082•
926•
29 1096 71096W Sweep Latch,ZJnc 2.o5s" .050• .800'
30 1016 7858W W #8 X.025 Ph.FI.SMS Latch Screws O INTEGRAL FIN FRAME SILL O INTEGRAL FIN FRAME JAMB O SASH BOTTOM RAIL O SASH TOP RAIL
6063-T6 ALUMINUM 6063-T6 ALUMINUM 6063-T6ALUMINUM 6063-T6 ALUMINUM
31 1267 71267N Selling Block 1/8"x 1/2"x 1",EPDM
32 6DURAK316 Duraseal-3/16' --I'r- .062•
33 6DURAK14 Duraseal-1/4" _
34 Sash Bottom Lock Spring osz
865'
35 Screen Cloth,Fiberglass 1.662' 1.187•
36 Dow Coming 899 Silicone Glazing Sealant .062• .oso _ 039' 628'
40 1625 616258 Glass Bead(1/8"Glass) 674 1
41 2719 627198 Glass Bead(3/16"Glass) -� 926' �- .0621- 1.167•
Colo
42 1263 61263B Glass Bead(1/4"Glass) O FIXED MEETING RAIL 10 SASH SIDE RAIL 11 SASH BOTTOM LOCK RAIL 12 SASH STOP PRODUCT REVISED
43 1253 6VT48B Glass Bead(I.G.) 6063-T6 ALUMINUM 6063-T6ALUMINUM 6063T6 ALUMINUM 6063-T5 ALUMINUM as complying with the Florida
Building Code
50 781 PQA #8 X 1"QUAD Pn SMS Acceplonce No
51 781PSTX #8 X 1"Sq.Pn Twin Fast SMS-410 S.S. 11 I i i l i Bxplretion Date, 1261G
52 1184 781 LHPQA #8-15 x 1 LH Twinfast Screw Zinc \�`�ON{LYNN M/�����i,� Revised By. Dote.
Revision: 6y
53 1186 781LHPQX #8-15 x 1 LH Twinfast Screw 7Jnc(S.S.) A� '�1cENSF''•.F� , JJ 10/10/11 NO CHANGE Miami odo Ptodocic-trol
:' ••,k ReWaed ey: Dole: R-Ition:
54 78X1PFTFUA #8 X 1"Ph FI u/cut SMS __ No.56705 SC 05/20/15 NO CHANGE
55 78XIFPAX #8 X 1"Ph FI-Stainless Steel = ® Oasr✓fplkn: Drawn ey:
60 1/8"Annealed or Tempered Glass o'.C(�1�I a=
61 3/16"Annealed or Tempered Glass %-P :IT�I d lu; BOM &PART DETAILS J ROSOWSKI
62 1/4"Annealed or Tempered Glass FLORIOP•' (,�? 1070 NVENICE. FLC3427� Title: Date:
63 1/8"-114"Alr-116"An.or Temp.I.G. FS;S/ONA1It NOK.O. BOX
L134274 SINGLE HUNG WINDOW INSTALLATION 05!11/11
64 1/8"-3/16"Air-3116"An.Or Tamp.I.G. A.LY.Nl.tLI R,P,E. SeHOB�MoQi1' ScelSheet: D awlny No. Rev:
P.E.q 58705 CERT. OF RUTH. 129296 SH-200 NTS 8 OF 8 MD-SH2O0-01 B