HomeMy WebLinkAboutProduct Approval M I A M 1•DADE MIAMI-DADE COUNTY
PRODUCT CONTROL SECTION
11805 SW 26 Street,Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(RER) Miami,Florida 33175-2474
BOARD AND CODE ADMINISTRATION DIVISION T(780315-2590 F(786)315-2599
NOTICE OF ACCEPTANCE (NOA) www.miamidade.gov/economy
DAB Door Company,Inc.
12195 NW 98'Avenue
Hialeah Gardens,FL 33018
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction materials.The
documentation submitted has been reviewed and accepted by Miami-Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction(AHJ).
This NOA shall not be valid after the expiration date stated below.The Miami-Dade County Product Control Section(In
Miami Dade County)and/or the AHJ(in areas other than Miami Dade County)reserve the right to have this product or
material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, the
manufacturer will incur the expense of such testing and the AHJ may immediately revoke,modify,or suspend the use of
such product or material within their jurisdiction. RER reserves the right to revoke this acceptance, if it is determined
by Miami-Dade County Product Control Section that this product or material fails to meet the requirements of the
applicable building code.
This product is approved as described herein, and has been designed to comply with the Florida Building Code,
including the High Velocity Hurricane Zone.
DESCRIPTION:Hurricane Master Model 824/811 Steel Sectional Garage Door up to 9'4"Wide w/
Window Lite Option(DP+50.0,-60.0 PSI)
APPROVAL DOCUMENT: Drawing No.01-09,titled"Sectional Garage Door",sheets 1 through 5 of 5,
dated 02/01/2001,with last revision K dated 03/21/2016,prepared by Al-Farooq Corporation,signed and
sealed by Javad Ahmad,P.E.,bearing the Miami-Dade County Product Control renewal stamp with the
Notice of Acceptance number and expiration date by the Miami-Dade County Product Control Section.
MISSILE IMPACT RATING: Large and Small Missile Impact Resistant
LABELING:A permanent label with the manufacturer's name or logo,manufacturing address,model
number,the positive and negative design pressure rating,indicate impact rated if applicable,installation
instruction drawing reference number,approval number(NOA),the applicable test standards, and the
statement reading`Miami-Dade County Product Control Approved' is to be located on the door's side track,
bottom angle,or inner surface of a panel.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials,use,and/or manufacture of the product or process.Misuse of this NOA as an endorsement of any product,for
sales,advertising or any other purposes shall automatically terminate this NOA.Failure to comply with any section of
this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami-Dade County, Florida, and followed by the
expiration date may be displayed in advertising literature. If any portion of the NOA is displayed,then it shall be done
in its entirety.
INSPECTION:A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official.
This NOA renews NOA#15-0317.02 and consists of this page 1 and evidence pages E-1 and E-2,as well as
approval document mentioned above.
The submitted documentation was reviewed by Carlos M.Utrera,P.E.
NOA No.16-0330.02
MIAMI DADECOUNTY Expiration Date:August 9,2021
Approval Date:June 23,2016 i
pb�t4. BIL Page 1
i
z
r
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
A. DRAWINGS
1. Drawing No. 01-09,titled "Sectional Garage Door",sheets 1 through 5 of 5,dated
02/01/2001,with last revision K dated 03/21/2016, prepared by Al-Farooq Corporation,
signed and sealed by Javad Ahmad,P.E.
B. TESTS "Submitted under NOA#09-0128.04"
1. Test reports on 1) Uniform Static Air Pressure Test, Loading per FBC TAS 202-94
2) Large Missile Impact Test per FBC, TAS 201-94
3) Cyclic Wind Pressure Loading per FBC, TAS 203-94
4)Forced Entry Test,per FBC 2411 3.2.1, TAS 202-94
along with marked-up drawings and installation diagram of a DAB 824 24 GA
Sectional Garage Door with Fixed Windows,prepared by Hurricane Engineering&
Testing, Inc, Test Reports No. HETI-08-2149A/B, dated 06/27/2008, signed and
sealed by Candido F. Font,P.E.
"Submitted under NOA #09-0128.04"
2. Test report of Tensile Test per ASTM E 8, Report No. HETI 08-T182, prepared by
Hurricane Engineering & Testing, Inc., dated 12/23/2008, signed and sealed by
Candido F. Font, P.E.
"Submitted under NOA # 01-0516.03"
3. Test report of large missile impact test per PA 201 and cyclic wind pressure test per
PA 203 on"Sectional Residential Garage Door", prepared by Hurricane Engineering
&Testing, Inc.,Report No. HETI 01-974A, dated 01/29/2001, signed and sealed by
Hector M. Medina, P.E.
4. Test report of Uniform Static Air Pressure Test per PA 202 and Force Entry
Resistance Test on"Sectional Residential Garage Door",prepared by Hurricane
Engineering &Testing, Inc., Report No. HETI 01-969, dated 01/18/2001, signed and
sealed by Hector M. Medina, P.E.
5. Test report on Salt Spray(Corrosion) Test per ASTM B 117 of a painted G-40 steel
panels, prepared by Celotex Corporation, Test Report No. 258592, dated 08/17/1998,
signed by W.A. Jackson,P.E.
Carlos M.Utrera,P.E.
Product Control Examiner
NOA No. 16-0330.02
Expiration Date: August 9,2021
Approval Date: June 23,2016
E-i
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
C. CALCULATIONS "Submitted under NOA #14-0814.04"
1. Anchor verification calculations prepared by Al-Farooq Corporation,dated 09/22/2014 and
07/24/2014,signed and sealed by Javad Ahmad, P.E.
"Submitted under NOA #09-0128.04"
2. Anchor verification calculations prepared by Al-Farooq Corporation, complying with F.B.0
2007,dated 12/19/2008, signed and sealed by Humayoun Farooq,P.E.
D. QUALITY ASSURANCE
1. Miami-Dade Department of Regulatory and Economic Resources (RER)
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 15-0915.08, issued to SABIC Innovative Plastics,for their Lexan
Polycarbonate Sheet Products, approved on 12/10/2015 and expiring on 07/17/2018.
2. Notice of Acceptance No. 14-0311.08, issued to Insulfoam,LLC, for their
Insulfoam Expanded Polystyrene Insulation, approved on 08/14/2014 and expiring on
11/29/2017.
3. Notice of Acceptance No. 11-0926.07,issued to Dyplast Products,LLC, for their Expanded
Polystyrene Block Type Insulation, approved on 11/10/2011 and expiring on 01/11/2017.
4. Notice of Acceptance No. 11-0926.06, issued to Dyplast Products,LLC,for their
Dyplast ISO-C1 Polyisocyanurate Insulation,approved on 11/10/2011 and expiring on
01/11/2017.
5. Notice of Acceptance No. 15-1203.04, issued to Cellofoam North America Inc,for
their Expanded Polystyrene Block Insulation,approved on 03/17/2016 and
expiring on 02/24/2021.
"Submitted under NOA #05-0228.02"
6. Test Report on Accelerated Weathering Using Xenon Arc Light Apparatus Test per
ASTM G155 of"PVC Extrusion Material",prepared by Hurricane Engineering&
Testing, Inc., Report No. HETI 04-A002,dated 09/27/2004, signed and sealed by Rafael E.
Droz-Seda,P.E.
7. Test Reports on Tensile Test per ASTM D638 of"PVC Extrusion Material',prepared by
Hurricane Engineering&Testing Inc., Report No.HETI 04-T251,dated 11/29/2004 signed
and sealed by 1.Ghia,P.E.
8. Test Report on Self-Ignition Temperature Test, Rate of Burn Test and Smoke Density
Test of"REHAU non-foam PVC extrusion material',prepared by ETC Laboratories,
Report No. 04-761-15019.0,dated 05/06/2004,signed and sealed by J.L. Doldan,P.E.
F. STATEMENTS
1. Statement letter of code conformance to the 5"edition(2014)FBC and of no financial interest
issued by Al-Farooq Corporation,dated 03/21/2016,signed and sealed by Javad Ahimad,P.E.
t�
Carlos M.Utrera,P.E.
Product Control Examiner
NOA No. 16-0330.02
Expiration Date:August 9,2021
Approval Date:June 23,2016
E-2
z'%J'x an•cuv.STEEL- TDP F.-RE 5-1/2'X 2-3/4•x 0.1' �U g;
7-1
/2- STEEL PLATE wITH ONE V -te US w/NOT
�e
END ROLLER HINGE -- FASTENED END STILE WITH NEWER 'y
W/(e)/1/X 5/8'SMS ,'0 �(6)/14 N TO J/40""""0""""DDDR
'SELF DRILLING SCREWS TO BE INSTALLED AT
WITHOUT OELAON SLEEVE(STO.) CENTER STILE
WITH DEIRON SLEEVE(OPTONAL) CENTER STILE O r
®B zz �G
—
Be a
�. Coo
,
a
Oz�
I Ca:x
}I p0ao<�
7-1/2'X 2-1/4'X.071• ;
1 STEEL CE
WMER HINGE �, 1 ml ¢w
(4)i14k 5/B'SMS I t B Ixp Ia wjw 6.
e
�. WITH DRRON SLEEVE±OP110NAt) p g LL 2 po_di
LOCK I m J
2/DOOR Z -
N G.E Q W pmlf
I•W X.15•THK.
I r I i
STANDARD LOCK — -== �-
SPRING LOADED SLIDE BOLT(BOTH SIDES) - Q
FASTENED W/(!)/14%1/Z'S.MS.
-- 5/11 MIN.LOCK ENGAGEMENT O
CONFORMS TO SECTION 1009 REGMONG GARAGC ODORS
I I a o x
IxnR,c CIXalsrs
OF,
e s• 2 s�EGTata z sLcnpxs v sa DIA-1. RAFT 1YPE OPTIONAL-vENr L-A o o z ;(
8 NICO-PRESS SLEEVE
Y Krr 4 sErnORSI - W'MIN.5 TO SAFETY FACLOR / t• (J)5-WIDE AT 7.O.C.W%. I -OPTIONAL RUSH FACE
a `' P'E1:ING AREA NOT TO EXCEED L_CpLON'AL DESIGN WOOD GRAIN DESIGN N In h
Y a- e 3 SECTORS x1' I} 1 20 IN
1 SECTIONS Ia'1 SECTION 2t EL PUTE 4 tI i^-- NAx.DOOR WIDTH
T efl STE
]SECfgNs 19'1 SECTIONS 21• WITH(2)I14%5/8'SMS e - 9'-4" O
W-P z gcnaa te'3 sEcnaRS zr ___�'_
e•-e• s sE1e• !sErnoxs 2,• BRACKET BRACKET INSIDE ELEVATION
9' it•-
sEVora te'- STD.
UFT DOOR LOW HEADROOM RAISED PANEL EM3055ED DOOR
5 5£GM1RS 1e DOOR OPTION
S=]' rnoNs la''.a SfcTORSiit• 7-7/9'
e'-p• ]SECTORS ta'.J SECTDNe 21'
iN z sErnora le'.sEcnpxs zl WITH )111 DAB DOORS INC. W
10-J' t SEITOx le' S SECTIONS 21• CENTER STILE WITH(4)/14%3/♦•SOS Hurricane MOsterm Model 824/811 }} }y}
tD'-a a sf0 D. 21'- Max.S:ze 9'-4"X 16'-0"RIO TU V
SEGNONS le'I SEcnaN 21• OUTSIDE /14%J/!'SELF IXtILDNG SCREWS MAY BE USED 1Mth Window Lite Option
_ 11, cllora la•2 SELnoxS 21, -DLE'I ENO STILE IN UEU OF i14%5/B'SM5
5 EE RS 1r3 SECTIONS 21' -
I•-a'_ 3 SOMNS le•4 MCTIORS 21• THIS PRODUCT IS RATED FOR LARGE MISSILE IMPACT DESIGN PRESSURE RATING + 50.0 PSF
II•-9' 2 SECTIONS 1e•5 SECTORS it• 'V LOCH BAR GUIDES - 60.0 PSF
12• 1 SEGIIOFa •e SEGTbNB 21• `INSTALLED ON END STILE - e 3$w
u'-3• TV--r - WRN(a)/14 X 5/e'SMS GENERAL NOTES PRODUCT RENEWED -
2
e_sECIbRS te•2 RC,IONs t• B xR camRlYing wIN N�FlRridx z_
12•-S• s -omS,a•3 SEO.S H. ART X SW LOCK flM 1. THIS PRODUCT HAS BEEN DESIGNED AND TESTED TO COMPLY WITH THE BMgtling Cotler
IS 4 sacnDRS le•4--21• ENGAGES IN TRICK REWIREIIWS OF THE 2014(5TH MOTOR)FLORIDA BUILDING CODE INCLUDING NO".. 18-0330.02 I�
! ]• ]SECTORS
uril,SECM ON EACH SIDE OF DOOR RIGH VELPCITY HURRICANE ZONE(I-,7 1 IIT/2P Q
expiration 06109l202� A'I-�
3 e' 2 BFLTORS le SFL1X1N8 RI1 2. ANCHORS SMALL BE AS LISTED5PACE0 AS SHOWN ON DETAILS.
I]a' I SF-1e' SE OUTSIDE KEYED LOCK(OPTIONAL) ANCHOR EMBEDMENT TO BASE MATERIAL SHALL BE BEY D— cr
e SECTIONS 21 PING SHOWN DRESSING OR STUCCO. MIxmF-0 tl Protluat Cenbol L / t �'
]• a sID:Tba le FLI1Dn15 ,• ALTERNATE LTO OCK BAR LOOSPRING LOADED SLIDE BOLT 3, ALL BOLTS NUTS AND WASHERS SHALL BE ZINC PLATED CARBON STEEL - Oaei y1. I
e• FL'TKM
s SEYIIORS le Sz." LOCKS SHOWY ABODE 4. ANCHORING OR LOADING CONDITIONS OTHER THAN THOSE SHOWN Iv
e• SECTIONS le'S SECTORS 21TMSE OETNLS ME NOT PARE OF TRIS APFROJAL II.a FLiIORS fe•6 SFLigNs 21' S. A LOAD WMTON INCREASE IS USED IN DES.OF ANCHORS INTO WOOD ONLY. drawing no
5 3' 2 SECTOxS 1e•.T SECTMINB 11 __ 1�l�a lOAION
I eFCTroX fa' a SECTNINS it' DOOR RSTED IN ACCO�ANCE MM THE REOUIREIIENTS OF -OJ
15'-9' 9 SECTIONS 21'- BUII➢1�2D;TAS-201 k TAS-20.1 FOR mmZ ANDIV 14 / AQ
snpxs zl �ONA1. A
sheet 1 Ot 5
24 CA STEEL PANEL I 4
3/16'A'_UM_G T
1 r
RAPS BENT OVER PMEL �Q
9�
CLc�
I/2'PUNCHED HO!ES�I V >N
A21'SIL PANEL O d p<S
005 DE OF DOO Q'S b0 Y
LL z p{L
STE2 iRACN BRACKET EAS'ENEO SOLID BRA55 DOOR VIEWER p
TO WOOD JAMB WITH BYSCHEAGE SECURTTY HARDWARE'
5/16'X 1-5/8'VG SCREW INSTALLED IN 9/16'DIA.HOLES IN CENTER STILE ENo STIP
(N BRACKE
P
ONE PERR BRACKET
POSITIONED AT EYE LEVEL O
ANCHORS AT TRACK BRACKET o i
TO—STOP MOUI DING A)•/9'Oa_aONEA-BdT BI'Pow£R5
FOR CONNED N OF WODO BUCK BT DOOR INSTALLER Q Q
2'MIN.EMBED INTO CONCRETE C]
TO MASONRY SEE NOTE ON I-]/BMIN.EE DSAE (J I
/11 X 3/B'SMS 3E4•X 2'X 2-1/2%18 GA.STEEL
HIN
6 PER GE Np STllf.CONNECT TO PN1EL5
1/2'X 1-3/1'%.059'MAIMED STEEL RMS ANO 3/16'ALUM RNEiS 1-1/1 Y.N.EMSED INTO CONCRETE OR PLLFO BLOCK to m
SOUTHERN PINE GLUED TO PANEL AIW SECURED TO SEF D—L ABOVE 1-5/B'MN EDGE DISTANCE INTO
CONCRETE Z K Q
0 55
E. E. DIST' ENO SD1E WITH 3/te'POP RNER O 12'O C. 1 M N EDGE DISTANCE IMO RLLm BLOCK O 3
CONCRETE fc 3000 PS IAN. Z=R
1-7/e'%2-5/8'X 015'STEEL
[DENIER 5Th£,G.11E0 ANO RNEIED DST CE C 90 GRN ITLIFD BLWN f'm 1000 PSI MIN. Q N Q"
•` • i i i0 PAN¢w/(a) 0.VEI5 POP 1-11\
I I/2'MN `11HX 5/13 -S.M.S. 1
E 7
Lc ANCHOR TYPE A OR B
1.9'X 2.19'x 3.3"%.102' -(1)PER eNACKETSTEELTRACN BRACKETSSEE SHEET 3 FOR IRACNI—NO
SEE SHEET 3 GORSPACING1/1-20 55 BCLT k NUT]-1/1'%.O]1'GALV.STEELCENTER HINGE ]-I/2'%3'X.0]1'
SECTION 9-9 END ROLLER HINGE
]/16''DS I�
'I:SIALLm ON ROLLER SMAR
INTERIOR SIDE 1.ez'ou X.30'STEEL ROLL£F5(STD.\ PRODUCT RENEWED `•), xY�N<E':V
$1E TRAGK I/e'X t'($TANCARD) LE2'DIA.X SO'NYLON ROLLERS(OPDONAL) mpl Ing KrlM the PbAtle ] c
2.75'DIA X.50'STEEL ROLLERS(OP110HAL)', gmlebg�etl. rom,.0'- _ �• s
12 Glx 3-s/1B'%1-1/Y(pPTIpNAl) 2.75'DIA.X.5D'NYLON ROLLERS(oPDONQ) MOA-N^. 76j1330.D2 * LI 1*_is
EA6TdE0 TO TRACH%AYES - L6 I
W/1/x-20 x s/e'muss Ho. wrlH s'srEM P�phwnon 08/09/2021 1 in
r
SLOT'ED M.S.R LWK NUT 9 _ �I drawl g no
Bliem .Plotlaol eoeem2 om°^:•',A� Lo-1
''�`S3jONAL�1t+'
I1Trll 111\p ,sleet 2 01 S
2 x 2 X 1/@`ROR.L ANGLE _. --
�� POP RNEs 5/16"x 1-5/8'LA.SCREWS INTO WOOD OR x01 TRACK SUPI'DI 530T'VdOFD i0 RORIL 4. G V
2-3j4'X 5_1/z'X 3'X sC4' 3 tT.B2.Niw ExtlEEO,NG BA N DOORS w^IH INC,WF1A6 AT 1 1/2'APART
5/16 SLEEVE ANGHOR6 CENTER SUPPORT REDO.0
9ET ON EAC�SIDE
CAL'.STEEL WITH 1-1/+"EM4ED IMO MASONRf F IN HEIGHT flg5i AT 3'OC
TED TO
GOP ROUER ASTENDENK.fCnE.STEEL
10 N.CKLTSIABLE- _ 2 iT2'x14-1/%-1x11ZGA.TGA.EEL PLAFL5 -� ......—.— ,. CCN+}CTO42O XA11N;T Ulm D.
tll wf 3jtc 1A X Sf4 I NU➢ WELDED p t /Z j
M.SCREWS k NUTS FASTENED TO TRACH
TOP&RAGKt WIN(4)1/4-20 SS.BOLT k NUTS -- Epftrj,iH l(tEHGiti=OP[hrNG NiGHi FiUS 12•_ ry'"
(STANMRD) ._ W
TDP BRACKET 'ER.C L TPAGX-, U
i (oPnONAL 2_1/5'x 1'x,M' a¢
Law HF.DPO).DOOIIiS '—'y�{ETL'-{T�'�ryT 14 CA GAL'STEEL TRACK SECTION A-A I('2¢K
u 1/2-XN1-aEWP:s 0"9*ti \ '_-----�'LI-1-�� O a C p
= 1/2`X 1-3jE x.ass•FORMED STEEL 2'k 5-1/2'x.104• O d
HUED TO PANEL AHD FASTENED TO DALV.S',EEL {j: ?O
n, VERTC L�WIN GASTtNEO Wf()/14%5je'$.M.S. 1 Q
(2)aft@' PNE 5 TOP ROLLER @R.o FOR s SECI`1TCHtS BRACKET—CEMENTS D,W N
I.CW NUOROpN DUOP Op DON GpoR of e
FpAIONTAL 1YDNR]RCEMEM T I HEuM'1I,2NO 3RD 4TH 5N 31 B2 r �1.-
ST
B@ 2 psX 1-3/4"X Ass'FORMN1@ N/A1 TO 223i0 PANEL ANp FASTENED TO @ 6'121'2 1@'21'N/A 1 TO 2 i-3/4 21snLEsWITH ) E ..... fRNETs ] O'121`21 21.71N/A 1 TO 2�11-3 23-6' 1B'1B 1B'1@'1@ 1 TO 2 11-3/9 23 34 65 56 fi]
/SfiS"VE£(Wa RIB -- 9'-D' 21"18 10'18'I2t i TO 2 11-07 23' 3+ 5- SS 67 J8-i 4`
ROLLERS
—SECTIONS ARE NUMBERED SIAR.1NG AT THE BOTTOM K
.50"
v FOR DOORS MORE THN4 8{t.H4GN,USE ADDITIONAL TRACK BRACKETS AT 10'O.C. I I(
ryry /W/.+4 OSA.X 4-1/4'sOEM
A:/ OPYIONAt INSUUTq NS� U p +C 4
1.9^x 2.19^x a.i x.09D• Z h vi
tP5-EXPANtl.0 POLY511RENE 1 _ 3
ROA, -1.05 P07 STEEL TRACK @RACKETS
r_
ROA,/11-0926.01 mI EHIGH
DO NCT U N
ItY?4,, vA CONNECTED IU TRACK WITH r
MRSI5 FOL2.0 P YANURATc )1/4"BOLTS k NUTS. p
DENsm=2.0 PCF
ORA jtt-0428 tiff f N O Jt�
n BY'CELLOFMM NORTH ANFAIG' Q N=W
ROA 93 PCF
' - N OA '-
-
13Y FOAV �C' -- -
OFHS
_ M.OA 1+ x1105
ROUEN DIN S1A
W/W/(4)111.D/.'SMS
MIN.
MIN.D24' OLL FORMED STEEL PMEL �s'la�Wi3
lj g Ii
;
DMWINO aUAI C-40 k 00
MNJ.HELD s EHGTH-l4 Ks TRACK CONML}RATItSN v Ef4
WYM PRIMER AND BAKED-ON
POLYSTER PANTED TOP CMT 1
APPLIED TO BOTH V..OG STEEL
aE' —A
V I
RTIC I TFT ,HIGH UFf STANDARD UFf �QY+'HEADROOM �2;w
& DOUBLE TRACK -
°i' Mill TRACK OPTIONS �_ '
I cA.GALY.s¢rL A,51 TINT,
- T@1/(4)BRAaKET FASTENED
/(4)oil RA X T FA SVS //�,--T
PRODUCT REttEWED
mpl in:with Ih.Fbri4 -
III aRBmn@�aa
4C,I SEAL
d' -SEE SHEET 4 - Cxpirovone b08/09i2D21
:irrp no.
WB.m prodVct COWMoI .. 09
....
$f'CTION A-A sheet 3 of 5 5
REINFORCEMENT r yrU
J IN• 1/R %1-]/4'%.OSB' of
FORMED STEEL 1!6 o
E /e%t' V
DISI. saF ORLIJNO satFwsI-
A'
..-_
-- OR in
DRILLING SCREWS Z z O
3 m J/I6"'NNE%'STEEL PoVETS OR
MULTGPoP W/DOME HfM J/16''PNF'STEEL RI—S
S= \W G AT 4B'O.C. MULTCRIP w/DCME HEIR H
REIN—DEMENT AT 4e"D.C. O
1/Y X 1-3/4'%
- FORMED STEEL IL
1/4"Du LAc sDREN3 1/4'DIA uc SCREWS :(DD
WOOD BU Ai fi'igOM ENDS WOOD BU AT 6'FROM ENDS N
AND 19"O.L.M%. I,I AN 19'O.C.MAX.
pp MI N
W'STPoPAWNINUM w�P ADAPTER Q 6 poo H
d
RUBBEA W'STRIPPING RUBBER WSTRPPING
]00 1 J4B .M o j J
___LLLLL���222fff��22ff LLLL��JJJJ _� Q w m E k'
BOTTOM SEAL OPTIONS
OPTION'A' OP110N'B'
WOOD BUCK CONN'CTION TO W000 SUBSTRATE (W000 SPEaFlC GRAVO SG-0.55 MIN.) o
THE INSTMIATON--S S—N—stows 2%6—woad BUCK AnAUHUEM
IM WOOD 51RUGi11 FOR
IF THESE METHODS ARE FDMCWED NO ADDITIONAL CAICLRATI0N5/DESIGN Q LL
WILL O REREPI FOR DESIGN TI GAFAGE DOOR NICHORAOF —
FOR GOON REPLACEMEM APPUGT%)NS WIM NO ENGINEER OF RECORD,INGTAL1AnON MAY 9E __ aHOR SPAcw Q U r
VFAInED IND MPRMED BY THE BUILDING OFFKC UPON INSPECTION. ANCHORS AN SLRIM.TUREO EMBED- PACING.GE OST. GZ z Z n
3 D IHEC SILEVE 8Y HILT WftG. 1-1 4 B 1-5 S
3/B,
NEC SIEENE RV NEII IrLLED BLOCK4" ¢ N m
___]B'OrNABOLT BY'I CONC. 1-I 2' B'_ 2' o Of 3
STEEL STRUCTURE BY OTHERS J 6'OTNABOLT BY'IiW f1LLED BLOCK 1-1 Z e' Z-1 4' O Z
5/16"%1-5/B" MUST SUPPORT J 9 POWER-BOLT RY POWERS CONL. 2' D' 1-]B L~1H p'O w n
lAG SCREWS BY DOOiNC LOA05 IMPOSED J B SLEEVE-ALL BY SIMPSONS CONC. 1-I 2 1-)B
R SYSTEM
AT 12"O.C. CONCRETE 1'P.IED PSI
5/16'dA.BOBS C-90 GROUT HLLED BLOCK!m-2000 PSI MIN.
WOOD BUCK CONNECTION TO MASONRY rAr 1 cERuINJT U �
PRE55URE TTEAIED 2X6 SYP W000 JAM5S.1.SHALL BE ANCHORED TO WE_DISi, i
GROUTED RLINFORGCD MASONRY BLOCK WILL OR LONA COLUMN WITH
1/4'ULTRIOON BY'ELCO'YFTH SPA W OF u
16'O.C.INTO GROUT F D BLOCK WALL,WITH 2-t/ .L.B. b p
t6'O.C.
INTO IWO P9 EMCRETE,WITH 1-3/4'MIH�EMBED I _ 1-1 4ME 2
2-1/P uW.EOCE DIST.wcE 1-1/2' •-1/z' — cCN� E -
1/I'
PER BY'POWERS WIOH SPACING OF / =0 8
14"O.C.INTO MOUT FILLED BLOCK WNL WTM t-1/Z'M:N.EMB. 12 G0.GALV.SifEl-- Z-1 R'X 1"%14
16'O.C.INTO]WG PSI CONCRETE,WIM 1 FMBED Mi BRACKETS 3]'LONG
J"WN.EIfCE wsANaE 1/16"%2-I/Z GALJ STEEL TRACK
ILFT WELDS �I� AT f2 O.C.IN DOW OPNG. FASTENED TO TRACK PUTES
CONRE%BY'ELCO'OR AT 12'O.C.1lV(. „`//I` AT IB'D.L.ABOJF GOON OPNG. W/(Z)I/!-ZWS/B'TPU55 H0. p
LEC BY'RW WIM SPACWG OF CONNEC'ED TO COM ANGLF SLOTTED M.S.h LOCK NUT ,. -
z4'o.c.INTO 30W Pv CONCRET WTTH 2-1/2'MIN.EMB. w/(J)svaT wE.s AT a.LIH SIDE
2'WN.OWE DSTNHCE CONnNI Ic 0.SIE IAACN flEYERSE TRACK fONTNI10l A4G��TRAfx fr v I?
J/6'HUG SLEEVE BY'HILT WIT-4 SPACING Of TG- D�� I2-SffEE iO CONCRETE AND flLl£D BLOCX - S=0 0
6"O.C.INTO GROIFT FILL.BLOCK WALL,WITH 1-1/4'MIN.EMBED,4'MIN.MICE DIST. -
6'O.C.INTO IWO Ps CDNCRM—1-1/4'—EMBED AVD
2-1/2' N.FDGE DISTANCE ALTERUATE IRAC9 INSTA ATION
PREPPI7ATION OF JAMBS BY OTHERS ........... 4 f
PRODUCT RENEWED N J A�
FOR NEW CONSTRUCTOR EHGNEEP OF RECORD OR AR[HRER TO VERIFY a mpM.9 wIN tlIR Flerltla 1 13
ADEGU C OF SUPPtlrtNG STHUCNRE TC SUPPORT LOADS NPOSED 8Mitdln8 GptltF
BY DDDR SYSTEM. ND9t.Ne. 16-0330.02 g �
FOR DOOR REPLACELE.NT W RETROFR BUILDINGS WITH NO ENGINEER OF
RECORD,DOOR INSTN1AT-NIAY BE RENEWED AND APPROVED BY ExPIrABPn tw 08709!2021 ,
BUIIdNC OFFICML UPON INSPECTION. tl�OwinB n0.
By
MA%NUM WERKN(4)LDAD PER-IB:(9.33'X 50 PSr)/2=2W.3 Lbs Per R Mlaml Preduel CeFFbW i S .•�•�.r'�II I 01—O9 J
—WE.
INTERIOR(-)LEAD PER JAMB (9.M'X W PST)/2 279.9 lbs P Ft. ' iS�UNAL 6r.A� ,sheet_4 at 5
suo —r'2JO V 3
*PLASTIC COMPLIES WRH
DOOR PANEL CHAPTER 26 OF FBC `w o
z.cA(o24)sreEL uw. SEE EVIC ENCE PAGE
O
I.)26 E Z
r)/I6'Du.wwsnER ti4a I y y&
p.
I oGh� 1
Oo"m
09%3/4'SNS 21
1uA1(4 —.eooME� a o s�+
raou ENDS FRAa�p o
O AND]'O.L.YA%. WOw'.MID1H
� *EXTERIOR FRAME * INTERIOR a yd6�a
18''/9- RIGID PVC ONE PIECE INJECPON RIGID PVC ONE PIECE INJECTION-31r
ux LLi _a
O 11 111-1/ERO.0 ENDSANO 6-1/2'O.C. Ir Q w n
- 1506 IEYAN ' oAl
OI J!%.062 DEEP
RY
3
I 80NATE
—.wNOryPA
I
n�
of
i
i of of
S w _- o 0 Zt6
"El ED
r il,
.1)e x.062 DEEP % ai
GROOVE
(4)y ./4- INSIDE ELEVATION al e g
a x sus
e t-J/B'TROu ENDS RAISED PANEL EMBOSSED DOOR WITH OPTIONAL WINDOWS
AND a-I/Y o.c.uAx. O WINDOW LITES CAN BE IN ANY LOCATION IN DOOR SECTION -
/a x 3/4'sus C
O 3/' .179%.082 DEEP
B I AND 4-18/2TA'O.O`ENDS-L.NA%. GROOVE n o$N
J8 x 3/i u o
O J/9'TROY EN05 __
Ano)•L.c.
-_-_ -'-_ PRODUCT RENEWED sv '
J Bufltllny Cnd,wiM eN.Fb'Id.
/tfi'DIA—ER
NoA o. 16-0330.02
DOOR PANEI EXTERIOR
24 ( /6 E.plr.Nnn D 06109!2027 5}�L *- 8j•J
D. 2x GA(024)SfFFL YIN. ml no
drawin
PAND_ LUfiIN — 0.L OPG. MY' Q 9 O^
24 GA(.024)STEEL
NIN. ZING TE P uct pentrol pp�pN.� J
EEIOfdAL
sheet 5 of 5