HomeMy WebLinkAboutSunTek-SFA Glass Skylight (NOA-2010)M I®DADS
MM
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES (RER)
BOARD AND CODE ADMINISTRATION DIVISION
)F ACCEPTANCE
Sun -Tek Manufacturing, Inc.
10303 General Drive
Orlando, FL 32824
MIAMI-DADE COUNTY
PRODUCT CONTROL SECTION
11805 SW 26 Street, Room 208
Miami, Florida 33175-2474
T (786) 315-2590 F (786) 315-2599
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction materials.
The documentation submitted has been reviewed and accepted by Miami -Dade County RER- Product Control
Section to be used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction
(AHJ).
This NOA shall not be valid after the expiration date stated below. The Miami -Dade County Product Control
Section (In Miami Dade County) and/or the AHJ (in areas other than Miami Dade County) reserve the right to
have this product or material tested for quality assurance purposes. If this product or material fails to perform in
the accepted manner, the manufacturer will incur the expense of such testing and the AHJ may immediately
revoke, modify, or suspend the use of such product or material within their jurisdiction. RER reserves the right to
revoke this acceptance, if it is determined by Miami -Dade County Product Control Section that this product or
material fails to meet the requirements of the applicable building code.
This product is approved as described herein, and has been designed to comply with the High Velocity Hurricane
Zone of the Florida Building Code.
DESCRIPTION: ISFG Skylight System
APPROVAL DOCUMENT: Drawing No. STI -00000298, titled "ISFG", sheet I & 2 of 2, prepared by Sun -Tek
Manufacturing, Inc., dated August 07, 2007, last revision #A dated August 15, 2013, signed and sealed by James
D. Wells, Jr., P.E., on February 07, 2014, bearing the Miami -Dade County Product Control Revision stamp with
the Notice of Acceptance number and the expiration date by the Miami -Dade County Product Control Section.
MISSILE IMPACT RATING: Large and Small Missile Impact Resistant
LABELING: Each unit shall bear a permanent label with the manufacturer's name or logo, city, state,
model/series and the following statement: "Miami -Dade County Product Control Approved", unless otherwise
noted herein.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no
change in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials, use, and/or manufacture of the product or process. Misuse of this NOA as an endorsement of any
product, for sales, advertising or any other purposes shall automatically terminate this NOA. Failure to comply
with any section of this NOA shall be cause for termination and removal of NOA:
ADVERTISEMENT: The NOA number preceded by the words Miami -Dade County, Florida, and followed by
the expiration date may be displayed in advertising literature. If any portion of the NOA is displayed, then it shall
be done in its entirety.
INSPECTION: A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors
and shall be available for inspection at the job site at the request of the Building Official.
This NOA revises & renews NOA # 12-1011.15 and consists of this page I, evidence submitted pages E_1, E-2,
& E-3, as well as approval document mentioned above.
The submitted documentation was reviewed by Helmy A. Maskar, P.E., M.S,
MIAMI•DADE COUNTY NOA No, 13-1028,05
Expiration Date: 10/31/2018
•® Approval Date: 03/13/2014
o3/1 14- Page I
Sun -Tek Manufacturing. Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
1. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL #07-0425.04
A. DRAWINGS
1. Drawing No. STI-00000298-SHTIISHT2, titled "ISFG", sheet 1 & 2 of 2, prepared
by Sun -Tek Manufacturing, Inc, dated 06/04107 with last revision dated 08/07/07,
signed and sealed by Jaynes D. Wells, Jr., P.E.
B. TESTS (submitted under NOA # 02-0618.06)
1. Test Report on Large Missile Impact Test per PA 201, Cyclic Wind Pressure Test per
PA 203 and Uniform Static Air Pressure Test per PA 202 of `Insulated Glass Skylight
with Polycarbonate Inner Liner" prepared by National Certified Testing
Laboratories, Report No. 210-2760-1, 2 & 3, dated 01/22/02, signed and sealed by A
Portnoy, P.E.
C. CALCULATIONS
1. Anchor Calculations for attachment of skylight to curbing and curbing to decking,
dated 08113/07, signed and sealed by James D. Wells, Jr., P.E.
D. MATERIAL CERTIFICATIONS (submitted under NOA # 02-0618.06)
1. Test report on Rate of Burning per ASTMD635 of Geon 87416 White 141
Exterior, 0.137 inch, prepared by Commercial Testing Company, Report No. 01-
11293, dated 11129101, signed by J. Jackson.
2. Test report on Self Ignition Temperature per ASTMD1929 of Geon 87416 White
141 Exterior, prepared by Commercial Testing Company, Report No. 01-11292,
dated 11/29/01, signed by J. Jackson.
E. STATEMENTS (submitted under NOA # 02-0618.06)
1. Code compliance letter issued by Product Technology Corporation. on 09127102,
signed and sealed by R. J. Quiroga P.E.
F. OTHER
1. NOA renewal request letter issued by Sum -Tek Manufacturing, Inc., dated 08116/07,
James Feudner.
2. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL #11-0601.02
A. DRAWINGS
1. Drawing No. STI-00000298-SHTI/SHT2, titled "ISFG", sheet I & 2 of 2, prepared
by Sum -Tek Manufacturing, Inc, dated August 07, 2007, last revision #A dated
October 14, 2011, signed and sealed by James D. Wells, Jr., P.E.
GTHelmy A. Makar, P.E., M.S.
Product Control Unit Supervisor
NOA No. 13-1028.05
Expiration Date: 10/31/2018
Approval Date: 03/13/2014
E-1
Sun -Tek ManufacturinLl,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
B. TESTS
1. Test Addendion for Test Report NCTL 210-2760-1, prepared by national Certified
Testing Laboratories, dated October 17, 2011, certifying the interlayer thickness,
signed by Mark Bennett, Manager of Testing Services.
C. CALCULATIONS
1. None.
D. QUALITY ASSURANCE
1. By Miami -Dade County Department of Permitting, Environment, and Regulatory
Affairs (PERA).
E. MATERIAL CERTIFICATIONS
1. None.
3. EVIDENCE SUBMITTED UNDER PREVIOUS APPROVAL #12-1011.15
A. DRAWINGS
1. Drawing No. STI -00000298, titled "ISFG", sheet I & 2 of 2, prepared by Sun -Tek
Man factitring, Inc, dated August 07, 2007, last revision #A dated May 03, 2012,
signed and sealed by Janes D. Wells, Jr., P.E.
B. TESTS
1. None.
C. CALCULATIONS
1. None.
D. QUALITY ASSURANCE
1. By Miami -Dade Cotmty Department of Regulatory and Economic Resources.
E. MATERIAL CERTIFICATIONS
1. None.
F. OTHERS
1. A compliance letter, prepared by J & L Wells Consulting LLC, dated April 25, 2012,
certify compliance with FBC 2010 edition, sign & sealed by James D. Wells, Jr., P.E.
2. Verification testing to be performed per letter from National Certified Testing
Laboratories, dated September 18, 2012, signed by Christopher Bennett.
(—Flekny A. Makar, P.E., M.S.
Product Control Unit Supervisor
NOA No. 13.1028.05
Expiration Date: 10/31/2018
Approval Date: 03/13/2014
E-2
Sun -Tel( Manufacturine Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
4. NEW EVIDENCE SUBMITTED
A. DRAWINGS
1. Drawing No. STI -00000298, titled "ISFG", sheet I & 2 of 2, prepared by Sun -Tek
Manufacturing, Inc., dated August 07, 2007, last revision #A dated August 15, 2013,
signed and sealed by James D. Wells, Jr., P.E., on February 07, 2014,
B. TESTS
1. Test Report on Large Missile Impact Test per PA 201, Cyclic Wind Pressure Test per
PA 203 and Uniform Static Air Pressure Test per PA 202 of "Instdated Glass Skylight
with Polycarbonate Inner Liner" prepared by National Certified Testing
Laboratories, Report No. 210-3915-01, dated 0812712013, signed and sealed by
Gerard Ferrara, P.E.
C. CALCULATIONS
1. Anchor Calculations for attachment of skylight Model ISFG to Decking, dated
1010312013, signed and sealed by James D. Wells, Jr., P.E.
D. QUALITY ASSURANCE
1. By Miami -Dade County Department of Regulatory and Economic Resources.
E. MATERIAL CERTIFICATIONS
1. Bill of Material and Components Die Drawings.
F. OTHERS
1. None.
Helmy A. Makar, P.E., M.S.
Product Control Unit Supervisor
NOA No. 13-1028.05
Expiration Date: 10/31/2018
Approval Date: 03/13/2014
E-3
w z
Z OR
N ZZQ❑ O W
8 ❑(O OQ ❑
q w do W6
� .-.
O � 0 R 10o w O w o m V h'i�rrP fllll���� 0
9z o 0 w O- N cno 0 a m � uolSMad ww C F Cx. w
❑ V7 0 wo nw
❑
OQ !-Z O W W \ 1Qr� S
m> CjY33Gn (( W O
W =iGSe`r!I � p
m 6'1p<43 OL '�
vI
O
W
Z j Q
m <
W
o a U WFO o ❑< K
QO Z=- LL N
Q ❑ w mw J3 rw NO Q.,W f9 F
U' N QLL ! deW NO OOWDODy w N
y Wa ❑ ❑¢ o�y o¢ �U�zwmw ZS m
ZO mm 0a-JWp ON
Z ¢O �W F `0, m dOW F- u W6
JO 00 y0 w m0 g Z 02 OF -
K 05070Z20 W❑ o
U a' Z�Um�mQI-Z y
O Q w Z LL'O JQ LL'ZZ m
❑ �d y a ❑w W a aam 000 pJZo O
QO m Z o Oj WZ �� NOccwr— LLw WN(� Z
0' J OY ,2V5 mw w1Ji.w ZJJOB6F
Z_. WO ¢ yu di- 2 w ¢wU-Zm QK� O
3 m� $ ¢� ! Z� w~PxwDwtKN
6m� W ^� OY0 E w ❑OmOOQm3❑a
OS ^a Vow w o5 LL¢�w2�wm�°
N N h a�❑ ❑ oW2UrwoQw❑ u' o
L' u 8/S mw� LL. �¢�QzuQ,gx=a Zw %n
s I'Y Q❑W om
8 WJ2�OZJZOOW ❑
O ���Uomw 000
Z... `....'o.. LL
0 ISI! l T Z .
W
Q
om
V Z
w /❑ �¢
z I/ a ❑
oww
LL
2M 0Z¢ m
ro i y 0x O Z J 0 Z4 W,r �N
Y m aJ W-:z
mzw ¢JJLLy o
J m J O Fw OPWOW
wzw. // ..
W umi J
WP WOU Z❑� 00Lnd
Z
O CQ7U O �O ZOw0 W Z J m
>'Np .m. NN - M N .�a�0 O H
O 0, JJC
0 a zZ OIC=.g
gLL"O0
0 0 Z❑j w mw
'=
m Q mON WNN�ww J 00
❑ 55 V❑ ZZ 0 �mZ aN•yTVO
0 z 0 Q
L�O
� ®¢- Hyz93z
0�
QOi�Z; mnU 6cmO >o'NN K del 01 sovmwnS w a O UzW dooa wnNiwiw.v m.N.
e m
a s� a ym
wn o
r n w n � a ���Wy nnbbaaeeeeea aNn Z
QJrO �' Zvi m
O U•W KS4�jVI jdF �`3Z' zNV`i
O ^�y =?ry 6O(�AAAbAb aQANQAaA �U rNJLLpi
a
z
N OOO f//
W�. qq aOa aN bNNNOQeQ
L__ d 0
N J
}
< WW
N � O �/ w
LL 3
pw aa ............... �
N WO Obi xX Z W O
Fd� t�t OJ NW2; U� OJ �Q
W d� ZON¢U¢WW y N
LLi F rw-Na gjWU N W J I
WcLL°w
�$ � w� zo oa rcy ~� �°+$ i$W�'� o
wo ° ° C
Z Z. WZZz JJ O�yK NZpFZp mW O�WO" ,S5 �}F HIM r p O 6U O2° �� 2CpU N� OH? wW ry„ 3 Q
w5 w��
qZQ O N -° $E$ dj-0 OZ 2ZOJ ZW !� 'p< W OfwJ
VS R%NQ NQ t�OWjJ NN... W 6 0 M;4 m
a h w°F dd W E6' w
oI0 O
Is
60 Z° 9�Z 1.A...f O Zw M
ly VO < < U -i. Z Y UU
dI1013�v:runs a Z J 2
c ° w.6 jooN wnNIWIW.4 X Q W J �p rn
LL o 3¢ I L4 d O) N m
'O l. C
� N O�'OI J `N. .'C. O
w�W cUNmQ o
nl - 4;ci o W mo p
7,;
cym
6�o, Z
494'OS cE o� io m d 3
LLO L LLOZ LLO'L _ W A °' O �U z p
< 000'4-- LLO'L LLO'L LLO'L 000'b
440'Z _LL S
us
Iw-
,I �� y w ff8�o'i d"t' W 3
L7N az = ZE
:� lci4 $ r aDi w w z 5:
j U Z
K¢m WSf LL�1 W O Q
.•��a� KQU�SKOK WX
zo a o
W K N
JZJ�JZp ytlJ
�.� m J dp W Kr YU F
w- 0JJ pUZ' pQ
N m h Ojl=�Z=O Wp
a- UmmQZrZ
upi y. Zw -'piOO gmz-
�I.. �,�, S�Z
O 4jLI O� t�IOW�7Zy y p�Qr F
1 ~� pW b
W_
� ZN�m ZYZ F-J 0 a
i. owm
zmw�c9
1 CaZ�Qi.g2 m i Zw
6j =m MO-How 9
�QUeW?r�OZI-
0:
Z N_y
2 0
I
w
I
I
N
�
W
N
�
U�
F-
_�-
� R
�
LL
Z U
W W
°�
�
IN
y
N p
®w OF
�
N
LL
Z
`
N
F
I
a
I i
I