HomeMy WebLinkAboutProduct Approval ^
RECA' -'D4`/ 1 � Y0�'
EXTERIOR RESEARCH&DESIG0°�C.
Certificate of Authorization#9503
—� 3S3CHRISTIAN STREET,UN[T#13
`' / —U—�N0�UU-���' U���� OXFORD CT 06478
^�� 0 K��U��K U 0 |»~mvu� '
|
PHONE:(2O3)262'9I4S
FAX:(2V3)252-9243
EVALUATION REPORT
Owens Corning Evaluation Report 037940.02.12-117
One Owens Corning Parkway F1.10674-1112
Toledo,OH 43659 Date of Issuance:02/06/2012
Revision 7: 04/18/2016
SCOPE:
This Evaluation Report is issued under Rule 61G20-3 and the applicable rules and regulations governing the use of
construction materials in the State of Florida.The documentation submitted has been reviewed by Robert Nieminen,
P.E. for use of the product under the Florida Building Code and Florida Building Code, Residential Volume. The
products described herein have been evaluated for compliance with the 5thEdition (2014) Florida Building Code
sections noted herein.
0ESCmmpx/mm: Owens Corning Asphalt Roof Shingles
KAosumG: Labeling shall be in accordance with the requirements the Accredited Quality Assurance Agency noted
herein.
COmT|muso ConxpoAmCs: This Evaluation Report is valid until such time as ihe named product(s) changes, the
referenced Quality Assurance documentation changes, or provisions of the Code that relate to the product change.
Acceptance of this Evaluation Report by the named client constitutes agreement to notify Robert Nieminen, P.E. if the
product changes or the referenced Quality Assurance documentation changes. Trinity|ERD requires a complete
review of this Evaluation Report relative to updated Code requirements with each Code Cycle.
ADVERTISEMENT: The Evaluation Report number preceded by the words "Trinity I ERD Evaluated" may be displayed in
advertising literature. If a'ny portion of the Evaluation Report is displayed,then it shall be done in its entirety.
INSPECTION:Upon request,a copy of this entire Evaluation Report shall be provided to the user by the manufacturer or
its distributors and shall be available for inspection at the job site at the request of the Building Official.
This Evaluation Report consists ofpages 1through Q.
Prepared by:
The facsimile seal appearing was authorized by Robe^wienninen,
NobertJN� �\em�neo P.E. �'
^ ^ ^ ' ^ �� ' ^c""wwo*o16.This does not serve.^""electronically signed
Florida Registration No.59umsFlorida DCA xxE1xma r.r~="'— . document.Signed,seated x been transmitted mthe
Product Approval Administrator and mthe named client
CERTIFICATION oFINDEPENDENCE:
z. Trinity|pKo/does not have, nor does it intend to acquire or will it acquire, a financial interest in any company manufacturing or
distributing products itevaluates.
a. Trinityl ERD is not owned,operated or controlled by any company manufacturing or distributing products it evaluates.
a. Robert wieminen,p.E.does not have nor will acquire,afinancial interest many company manufacturing vrdistributing products for
which the evaluation reports are being issued.
4. Robert Nieminen,p.E.does not have,nor will acquire,afinancial interest inany other entity involved inthe approval process ofthe
product. .
5. This isobuilding code evaluation. Neither Thnity|E8Dnor Robert Nieminen, P.c. are, inany way,the Designer vfRecord for any
project onwhich this Evaluation Report,o,previous versions thereof,is/was vsedfn,pe,mhdngu,desiongvidanceun|ess,etained
specifically for that purpose.
'
^
. ��
~^_~°
�
~~� U 8�0 VU \u~»^^���
ROOFING SYSTEMS EVALUATION:
`
1' SCOPE:
Product Category: Roofing
Sub-Category` Asphalt Shingles
Compliance Statement: Owens Corning Asphalt Roof Shingles,asproduced byOwens Corning, have demonstrated
compliance with the following sections of the Florida Building[ode and Florida Building Code, Residential Volume
through testing inaccordance with the following Standards. Compliance issubject tothe Installation Requirements
and Limitations/Conditions ofUse set forth herein.
2' Sn\moARms:
Section Property Standardi Year
1507.2.5,R905.2.4 Physical Properties ASTM D3462 zoVy
1507.2.7.1,R905.2.6.1 Wind Resistance ASTM D3161 znoy
1507.2.7.1,R905.2.6.1 Wind Resistance ASTM o71su zonu
3. RepEnsmccS;
Entity Examination Reference Date
UiLLC<Csn96a6> Physicals QvvindResistance File n3us3,Vol.s 02/15/2007
UL LLc<ccm*oas> Physicals aWind Resistance 20120516n2453 05/16/2012
ULLLC(TSTyezn} Physical Properties 06CA20263 04/1*200*
VL LucOST96zx> Wind Resistance 11[x34308 02/18V2012
UiLLC(TST96ao) Physicals&Wind Resistance 478*093137 02/01/2014
UL Luc(TsT*6zo) Wind Resistance 4786126532 02Y10/2014
VLLLC(CSTeG2u) Physical Properties Classification letter 02y13/2014
VLLLC(TS7s6zV) Physical Properties Classification letter 10m2/2015
w1iami'oade(ccRzs9z} FaCxVVZ Compliance variuu,NOxa Various
UL LLC (QVA9625) Quality Control Service Confirmation,Ra4B Exp.08/28/2017
4' PRODUCT DESCRIPTION:
4.1 Asphalt Shingles:
4.1.1 Classico and Supremeo are fiberglass reinforced,3-tab asphalt roof Shingles.
4.1.2 Berkshire'are fiberglass reinforced,4'tabasphalt roof shingles.
4.1.3 Devonshine"°are fiberglass reinforced,S-tabasphalt roof shingles.
4.1.4 Duration*, TruDefini6un~ Ouration~, Duration' Premium Cool, T,uQeOnition~ Duration' Designer Color
CoUection, Truoe8nitiun~Oakridge~, Oakridge' and VVeatherGua,d~ HP are fiberglass reinforced, laminated
asphalt roof shingles.
4.2 Berkshire* Hip & Ridge Shingles, High Ridge, VVeatherGuard~ HP Hip & Ridge Shing/es, ProEdge Hip & Ridge
Shingles and Dum0dQeTm Hip&Ridge Shingles are fiberglass reinforced,hip and ridge asphalt roof shingles.
4.3 Starter Strip Shingle,Starter Strip Plus and Starter Shingle Roll are starter strips for asphalt roof shingles.
S. LIMITATIONS:
5'1 This is a building code evaluation. NeitherThnity\ERD nor Robert Nieminen, P.E. are, in any way, the
Designer of Record for any project on which this Evaluation Report,or previous versions thereof,is/was used
for permitting or design guidance unless retained specifically for that purpose.
5.2 This Evaluation Report isnot for use inthe HVHZ.
5.3 Fire Classification is not part of this Evaluation Report;refer to current Approved Roofing Materials Directory
for fire ratings ofthis product.
Exterior Research and Design,LLC. Evaluation Report oyryoum2.12-nr
uF1.10674-1112F1.10674-1112�����m���
Revision 7:04/18/2016
Page amu
TRINITY I ERD
5.4 Wind Classification:
5.4.1 All Owens Corning shingles noted herein are Classified in accordance with FBC Tables 1507.2.7.1 and
R905.2.6.1 to ASTM D3161, Class F and/or ASTM D7158, Class H, indicating the shingles are acceptable for
use in all wind zones up to Vasd=150 mph (V„it=194 mph). Refer to Section 6 for installation requirements
to meet this wind rating.
5.4.2 All Owens Corning hip&ridge shingles,Starter Strip Shingle and Starter Strip Plus noted herein are Classified
in accordance with FBC Tables 1507.2.7.1 and R905.2.6.1 to ASTM D3161,Class F,indicating the shingles are
acceptable for use in all wind zones up to Vasd=150 mph (Vuit=194 mph). Refer to Section 6 for installation
requirements to meet this wind rating.
5.4.3 Classification by ASTM D7158 applies to exposure category B or C and a building height of 60 feet or less.
Calculations by a qualified design professional are required for conditions outside these limitations. Contact
the shingle manufacturer for data specific to each shingle.
5.4.4 Refer to Owens Corning published information on wind resistance and installation limitations.
5.5 All products in the roof assembly shall have quality assurance audit in accordance with the Florida Building
Code and F.A.C.Rule 61G20-3.
6. INSTALLATION:
6.1 Underlayment:
6.1.1 Underlayment shall be acceptable to Owens Corning and shall hold current Florida Statewide Product
Approval,or be Locally Approved per Rule 61G20-3,per FBC Sections 1507.2.3,1507.2.4 or R905.2.3.
6_2 Asphalt Shingles:
6.2.1 Installation of asphalt shingles shall comply with the manufacturer's current published instructions, using
minimum four (4) nails per shingle in accordance with FBC Sections 1507.2 or R905.2, with the following
exceptions:
➢ Berkshire®shingles require minimum five(5)nails per shingle.
➢ WeatherGuard HP shingles require minimum six(6)nails per shingle.
➢ DevonshireTM shingles require minimum six(6)nails per shingle.
➢ Starter Strip Shingle and Starter Strip Plus require minimum five(5)nails per strip.
Refer to Owens Corning published information on wind resistance and installation limitations..
6.2.2 Fasteners shall be in accordance with the manufacturer's published requirements, but not less than FBC
1507.2.6 or R905.2.5. Staples are not permitted.
6.2.4 Where the roof slope exceeds 21 units vertical in 12 units horizontal, special methods of fastening are
required. See figures below for details.
6.2.5 Minimum Nailing—Starter Strip Shingle and Starter Strip Plus:
Felt underlayment Deck Feltundecayment pact Self4dhered
Self-adhered
WeatherLocl& underhymaM
underlayment
edge
Drip edge e g Dripedge
e
S �.
Nails locatedlooted
2=3"from eave 2'-3'Som ave
Install fust Self-searing adhesive Sa$4aaGrre edhesh�
Starter Strip positionedelongeave IWAfirstStarter StripMs positionedelongeave
shinglewith ••. with6'removed ,.• .
6"removed \\
Starter Strip shingle overhangs eaves and rakes r/.='/4" Starter Strip Plus overhangs caws and rakes 1/4'-314"
Exterior Research and Design,I.I.C. Evaluation Report 037940.02.12-R7
Certificate of Authorization 119503 FL10674-R12
Revision 7:04/18/2016
Page 3 of 8
TRINITY I ER®
6.2.6, Minimum Nailing—Classic®&Supreme:
Normal Mansard or Area para Normal Mansard or Area.pan
WIM Areas High Wind desvenes y Wind Areas High Wind desvmas y
Area pan vientas normates Aress viontos/cones Area pare vientos normales Areas vidntoa 11ue►tas
+' TAI r. r z• iB z + r (A) +• +• z• BI x. +.
6"
owe
6 51ir Exposure
Fxposie idn MWosieidn
6.2.7 Minimum Nailing—Berkshire®:
Seahin strip Sealant strip
;ta ttn do saRadar la tka de sdlador
e Yz•" 9 Yf 9 Ell 8Yt" 8Yt"
s
s
r
Standard Fastening Pattern 6-Nail Fastening Pattern
Sealant strip
!a tka do sallador
*, .As*h
8 siooflngcernent
&4ighto do'tcoho de esfatto
Mansard or Steep Slope Fastening Pattern
Exterior Research and Design,U.C. Evaluation Report 037940.02.12-117
Certificate of Authorization#9503 FL10674-R12
Revision 7:04/18/2016
Page 4 of 8
TRINITY I ERD
6.2.8 Minimum Nailing—Devonshire"':
7" 1 8" i 8" �i 8" F 7"
— •••••• r r � r
Expgodcn dexposure-5/8 ping Sealant IVA on
Ubicedbn del seUedor
Ten 1"S ots of Asphalt Roof Cement
Standard 6-Nail Fastening Pattern Mansard or Steep Slope Fastening Pattern
6.2.9 Minimum Nailing—Duration®,TruDefinition® Duration, Duration® Premium Cool &TruDefinition® Duration®
Designer Color Collection:
4-Nan Fastening Pattani O-Nan FasUntng Pattem
Uu
f
nar+otasWilnYuu.dm� svrWanradnmp auw@n
naa 1YP" "?a.Tmem
r +z Ltr +^ 12* I +r .
ol
Standard Fastening Pattern 6-Nail Fastening Pattern
Fastening for$lopes Gmater Van 21:12
fa.N.n["wina wkkh
Put roi.
r 12* I +r r
F11",
rac r spas aa.P�w+.00ertp C.m"rt
Mansard or Steep Slope Fastening Pattern
Exterior Research and Design,I.I.C. Evaluation Report 037940.02.12-R7
Certificate of Authorization#9S03 FL10674-1112
Revision 7:04/18/2016
Page 5 of 8
�J\TRINITYJERD
6.2.1 Minimum Nailing—TruDefinition'Oakridge®,Oakridge®:
4 Nail Pattern 8 Nail Pattern
Esquema eon 4 clavus Esquema ion 6 davos
7° 1°
6 5/8"Exposure_
9/0 P4. CNiais `6e 6/$ping. Nail.s
;
66/8''Expasure. 66/8".Exposuie
&PCdc7pn de 6618 ping E�rpcsiadri Qe L 618wg.
Standard Fastening Pattern 6-Nail Fastening Pattern
Fasteniop for Slops Greater Than 21:12
fuae140a MbnlnerW WM
r rIl1YP�
P 12' I 7Y
64 e•sva
Flo. 0
tour t•3"oPASPW RO"CA
Mansard or Steep Slope Fastening Pattern
6.2.1 Minimum Nailing—WeatherGuard®HP:
deal#>i1d�Vlow
.. {}� .as. .•.•.t•.
�••' •:} f; Piraliir�MmambIYI!ice
Ciwiw i4'AhWi,46 die
Exterior Research and Design,I.I.C. Evaluation Report 037940.02.12-R7
Certificate of Authorization#9503 FL10674-R12
Revision 7:04/18/2016
Page 6 of 8
\\J
TRINITY I ERD
6_3 Hip&Ridge Shingles:
6.3.1 Installation of Berkshire' Hip and Ridge Shingles, High Ridge, WeatherGuard® HP Hip and Ridge Shingles and
ProEdge Hip&Ridge Shingles shall comply with the manufacturer's current published instructions,using four
(4) nails per shingle. Installation of DuraRidge'" Hip & Ridge Shingles shall comply with the manufacturer's
current published instructions, using two (2) nails per shingle. Refer to Owens Corning published
information on wind resistance and installation limitations, including the use of hand-sealing for wind
warranties.
6.3.2 Fasteners shall be in accordance with the manufacturer's published requirements, but not less than FBC
1507.2.6 or R905.2.5. Staples are not permitted.
6.3.3 Minimum Nailing—Berkshire®Hip&Ridge and High Ridge:
Fig.1 4 Fig.2
I— PruAling Md
Dlretltan A TopYiew SSdeKea
NaYs—�� A Nape Nally .
4
To IV L"aaltlmtad. Z. 4
P i 4• ,pace 11
9
I
P I I I I I
6. EI
�B�osma sl
I
I
I
I
I
6.3.4 Minimum Nailing—WeatherGuard®HP Hip and Ridge:
Fig.A v 4
Fig.'C-Hip&Ridge Shingle Fastening
P�vol Y/l7tl Top,Ylew
—Dlroe! A
A
Nails
I
p ; I NPlla Nally
z' z„
I I ¢ 4•
Rposura
B. Erposuro
Exterior Research and Design,U.C. Evaluation Report 037940.02.12-R7
Certificate of Authorization#9503 FL10674-1112
Revision 7:04/18/2016
Page 7 of 8
'
"
�
10
8 p�U�0 U U I ��
'-"^u�
63.5 Minimum Nailing'PnnEdgeHip&Ridge Shingles:
Standard
Prevailling Fastening
Wind Diroallion 2,,bt Strip Pattern
6-Exposure
Fasten Thl 6*ExImsure
Rod
6.3.6 YWinimumNaiUnQ—DuraRidgeTmHip&RidgeShingles:
Note:The drawings below pertain tuminimum,as-tested attachment requirements. Refer toOwens Corning
published installation instructions for their minimum requirements.
on darrimb djvmk 1.
2 cAm
Gig
7. L4Bsumm:
7.1 Labeling shall be in accordance with the requirements the Accredited Quality Assurance Agency noted
herein.
7.2 Asphalt shingle wrappers shall indicate compliance with one of the required classifications detailed in F8C
Table 15U7.2.7.1/R9O6.2.61
8. 0u|mm|mG PERMIT REQUIREMENTS:
Asrequire dhy the 8ui|din�Official or Authority H vinQ Jurisdiction in order to properly evaluate the installation of
this product.
9, MmNWpuuTUmumG PLANTS:
Contact the named OA entity for information on which plants produce products covered by Florida Rule 9N`3 QA
requirements.
10' QUALITY ASSURANCE ENTITY:
ULLLC—QUA9626;(414)24O'64U9;
- END OFEVALUATION REPORT-
am/u�mnnen��om»y«n��1�nv
c�enm,mm�ea�h�"uoos/��uc .
����n�
a����xmm��mmu�o
Revision n04118/on1a
Page 8*/o