HomeMy WebLinkAboutProduct Approval MIAMI-RADE MIAMI-DADE COUNTY
PRODUCT CONTROL SECTION
11805 SW 26 Street,Room 208
DEPARTMENT OF REGULATORY AND ECONOMIC RESOURCES(RER) Miami,Florida 33175-2474
BOARD AND CODE ADMINISTRATION DIVISION T(786)315-2590 F(786)315-2599
NOTICE OF ACCEPTANCE (NOA) www.miamidnde.2ov/economy
DAB Door Company,Inc. .
12195 NW 98'Avenue
Hialeah Gardens,FI,33018
SCOPE:
This NOA is being issued under the applicable rules and regulations governing the use of construction materials.The
documentation submitted has been reviewed and accepted by Miami-Dade County RER-Product Control Section to be
used in Miami Dade County and other areas where allowed by the Authority Having Jurisdiction(AHJ).
This NOA shall not be valid after the expiration date stated below.The Miami-Dade County Product Control Section(In
Miami Dade County)and/or the AHJ(in areas other than Miami Dade County)reserve the right to have this product or
material tested for quality assurance purposes. If this product or material fails to perform in the accepted manner, the
manufacturer will incur the expense of such testing and the AHJ may immediately revoke,modify,or suspend the use of
such product or material within their jurisdiction. RER reserves the right to revoke this acceptance, if it is determined
by Miami-Dade County Product Control Section that this product or material fails to meet the requirements of the
applicable building code.
This product is approved as described herein, and has been designed to comply with the Florida Building Code,
including the High Velocity Hurricane Zone.
DESCRIPTION:Hurricane Master Model 824/811 Steel Sectional Garage Door up to 9'4"Wide w/
Window Lite Option(DP+50.0,-60.0 PSF)
APPROVAL DOCUMENT: Drawing No.01-09,titled"Sectional Garage Door",sheets 1 through 5 of 5,
dated 02/01/2001,with last revision K dated 03/21/2016,prepared by Al-Farooq Corporation, signed and
sealed by Javad Ahmad,P.E.,bearing the Miami-Dade County Product Control renewal stamp with the
Notice of Acceptance number and expiration date by the Miami-Dade County Product Control Section.
MISSILE IMPACT RATING: Large and Small Missile Impact Resistant
LABELING:A permanent label with the manufacturer's name or logo,manufacturing address,model
number,the positive and negative design pressure rating,indicate impact rated if applicable,installation
instruction drawing reference number,approval number(NOA),the applicable test standards, and the
statement reading`Miami-Dade County Product Control Approved'is to be located on the door's side track,
bottom angle,or inner surface of a panel.
RENEWAL of this NOA shall be considered after a renewal application has been filed and there has been no change
in the applicable building code negatively affecting the performance of this product.
TERMINATION of this NOA will occur after the expiration date or if there has been a revision or change in the
materials,use,and/or manufacture of the product or process.Misuse of this NOA as an endorsement of any product,for
sales,advertising or any other purposes shall automatically terminate this NOA.Failure to comply with any section of
this NOA shall be cause for termination and removal of NOA.
ADVERTISEMENT: The NOA number preceded by the words Miami-Dade County,Florida, and followed by the
expiration date may be displayed in advertising literature. If any portion of the NOA is displayed,then it shall be done
in its entirety.
INSPECTION:A copy of this entire NOA shall be provided to the user by the manufacturer or its distributors and
shall be available for inspection at the job site at the request of the Building Official.
This NOA renews NOA#15-0317.02 and consists of this page 1 and evidence pages E-1 and E-2,as well as
approval document mentioned above.
The submitted documentation was reviewed by Carlos M.Utrera,P.E.
MlAMI•DADE COUNTY _ OA,No 16 0330 0I
hExpuatiou bate `August 9z 2021
Approval Date:June 23,2016 1
Q�/TIP Page 1
7
z
i
z
i
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
A. DRAWINGS
1. Drawing No.01-09,titled "Sectional Garage Door",'sheets 1 through 5 of 5,dated
02/01/2001,with last revision K dated 03/21/2016,prepared by Al-Farooq Corporation,
signed and sealed by Javad Ahmad,P.E.
B. TESTS "Submitted under NDA#09-0128.04"
1. Test reports on 1)Uniform Static Air Pressure Test,Loading per FBC TAS 202-94
2)Large Missile Impact Test per FBC, TAS 201-94
3)Cyclic Wind Pressure Loading per FBC, TAS 203-94
4)Forced Entry Test,per FBC 24113.2.1,TAS 202-94
along with marked-up drawings and installation diagram of a DAB 824 24 GA
Sectional Garage Door with Fixed Windows,prepared by Hurricane Engineering&
Testing,Inc, Test Reports No.HETI-08-2149A/B, dated 06/27/2008, signed and
sealed by Candido F.Font,P.E.
"Submitted under NOA#09-0128.04"
2. Test report of Tensile Test per ASTM E 8,Report No. HETI 08-T182,prepared by
Hurricane Engineering & Testing, Inc., dated 12/23/2008, signed and sealed by
Candido F. Font,P.E.
"Submitted under NOA # 01-0516.03"
3. Test report of large missile impact test per PA 201 and cyclic wind pressure test per
PA 203 on"Sectional Residential Garage Door",prepared by Hurricane Engineering
&Testing,Inc.,Report No. HETI 01-974A, dated 01/29/2001, signed and sealed by
Hector M.Medina,P.E.
4. Test report of Uniform Static Air Pressure Test per PA 202 and Force Entry
Resistance Test on"Sectional Residential Garage Door",prepared by Hurricane
Engineering&Testing,Inc.,Report No. HETI 01-969,dated 01/18/2001, signed and
sealed by Hector M.Medina,P.E.
5. Test report on Salt Spray(Corrosion) Test per ASTM B 117 of a painted G40 steel
panels,prepared by Celotex Corporation,Test Report No.258592, dated 08/17/1998,
signed by W.A. Jackson,P.E.
i
Ot.PjAd iG
Carlos M.Utrera,P.E.
i
Product Control Examiner
NOA No. 16-0330.02
Expiration Date:August 9,2021
Approval Date:June 23,2016
E-1
i
i
DAB Door Company,Inc.
NOTICE OF ACCEPTANCE: EVIDENCE SUBMITTED
C. CALCULATIONS "Submitted under NOA #14-0814.04 11
1. Anchor verification calculations prepared by Al-Farooq Corporation,dated 09/22/2014 and
07/24/2014,signed and sealed by Javad Abmad,P.E.
"Submitted under NOA #09-0128.04"
2. Anchor verification calculations prepared by AI-Farooq Corporation,complying with F.B.0
2007,dated 12/19/2008,signed and sealed by Humayoun Farooq,P.E.
D. QUALITY ASSURANCE
1. Miami Dade Department of Regulatory and Economic Resources CRER)
E. MATERIAL CERTIFICATIONS
1. Notice of Acceptance No. 15-0915.08,issued to SABIC Innovative Plastics,for their Lexan
Polycarbonate Sheet Products,approved on 12/10/2015 and expiring on 07/17/2018.
2. Notice of Acceptance No. 14-0311.08, issued to Insulfoam,LLC,for their
Insulfoam Expanded Polystyrene Insulation,approved on 08/14/2014 and expiring on
11/29/2017.
3. Notice of Acceptance No. 11-0926.07,issued to Dyplast Products,LLC,for their Expanded
Polystyrene Block Type Insulation,approved on 11/10/2011 and expiring on 01/11/2017.
4. Notice of Acceptance No. 11-0926.06, issued to Dyplast Products,LLC,for their
Dyplast ISO-C1 Polyisocyanurate Insulation,approved on 11/10/2011 and expiring on
01/11/2017.
5. Notice of Acceptance No.15-1203.04,issued to Cellofoam North America Inc,for
their Expanded Polystyrene Block Insulation,approved on 03/17/2016 and
expiring on 02/24/2021.
"Submitted under NOA#05-0228.02"
6. Test Report on Accelerated Weathering Using Xenon Arc Light Apparatus Test per
ASTM G155 of"PVC Extrusion Material",prepared by Hurricane Engineering&
Testing,Inc.,Report No.HETI 04-A002,dated 09/27/2004,signed and sealed by Rafael E.
Droz-Seda,P.E.
7. Test Reports on Tensile Test per ASTM D638 of"PVC Extrusion Material",prepared by
Hurricane Engineering&Testing Inc.,Report No.HETI 04-T251,dated 11/29/2004 signed
and sealed by I.Ghia,P.E.
8. Test Report on Self-Ignition Temperature Test,Rate of Burn Test and Smoke Density
Test of"REHAU non-foam PVC extrusion material",prepared by ETC Laboratories,
Report No.04-761-15019.0,dated 05/06/2004,signed and sealed by J.L.Doldan,P.E.
F. STATEMENTS
1. Statement letter of code conformance to the 5a'edition(2014)FBC and of no financial interest
issued by Al-Farooq Corporation,dated 03/21/2016,signed and sealed by Javad Ahmad,P.E.
Off i�r2�l� i
Carlos M.Utrera,P.E.
Product Control Examiner
NOA No.16-0330.02
Expiration Date:August 9,2021
Approval Date:June 23,2016
E-2
3
i
F
3
7-1/2'x 3-X 0.71•DALV.STEEL TOP rO RE 5-1/2"X 2-3/4'X 0.1' �V
END ROP
+rR RULE __ STEEL ATE wm ONE 5/16-18 US w/NOT /]�
FASTENED TO ENO STILE IFRH
OPTIONAL DOOR VIEWERVIEWERW j
Ynmour DERON SLEEVE(sro.) (6)d14 x 3/4•Sar°aetnm s:aers TO BE INSTA=LLED
TNM DETRON SLEEVE(OPTIONAL CENTER STILE Z y R
r O O 1 CEMER SIVE O
\, I Ir
D OZ - 011
DA -- M ac $
7-1/r X 2-,••%. 1- ------ - --- ( ILII I --- °�
M STEEL ER MD:GE
W/(4)/f4 X 5/9'SLLSIf
WITH DEIRON SLEEVE(OPTIONAL)
LOCK
z/DDDR
11 r W x.15•TIAL LATCH °I •_
STANDARD LOCK
SPRNG LG]ED SLIDE BW(BOTH SIM) - - - m
FASTENED W/(4)114 x 1/3•SATSux
0
�. reLOLN%ONFORMS TSEI �a REGAMIAL G5R OCORs
UFE;�
OOoe MGM fLNSSiS D 1' f ry r z N
K I
e'-6' 1 52TAN5 16']SttTONS 11 159 OMA GALV.AIRCRAFT TYPE i °
6-A• ,SkL1WN e' J SFcnOns 21' E.E A MCJ-PRESS stF,NE OPIpWy,VEff L.�A U'Q Z(;
W/MIN.5 TO 1 SAFETY FACTOR 1 `,'A (»5•W10E AT 7'O.C.MAX OPTIf1NAL FLUSH FALE
4 SDCmfS]t'- I y O
Y-5. 4 _ O OPE ANO MFA NOr 70 E%C® COLONIAL DESIGN WOOD GRAIN DESIGN M+
Y-6• a YL110N5 te•- l+ 120 SO.W. m m
6•X 3'x 0.1•
T-9' 4 SEC1185 10'1 SCCTIOY 21' SRFl PLATE \`I NAY.DDDR WT1fH 0•"S C
0' J SEOICfs"..31 SLcif0Y5 21 Wim(2)114 x 5/a-sys ° J
e•-r S SELIKiS 19• SEmI � 9i• o
e•-W 1 SEORON 1e• 1 SECR0V5 11' __-_
e•-s• s sEnoNs]1•- BRAcxET steA^KLT INSIDE ELEVATION
e o sicnorci9•- STD.LIFT DOOR LOW HEADROOM RAISED PANEL EMBOSSED DOOR
s•-r 5 s[cnoxs+e•1 srnoN x1• DOOR OPTION
IT
s'-0.' 4 sLrnANs 1e•Ix sEcnoRs 21•
s•-s• sE :9')J sELOQY3 zr 7-7/a•X 3-t/E'x.010• o "
t 1 sEATOAS te'4 sErnONS 21 STEEL PATE DAB DOORS LNC.
IW-3' 156IICN te' s sr2flAv5 3, [LIMIER STILE WITH(4)114 X 3/4'505 n 0 D.
1o'-e' a sEclkAs at'- H4rrea a Koster Model 624/x11 0,
10'-9• a StL00N5 Te'1 SEL7x4!]I' OUTSIDE 114 X 3/4'SELF DRRLNS SCREIVS MAY BE USEDI M..SSe 9'-•'X i6'-0°H""'
tt' 0 5FL'nONS 1e'I2 SCLI16`8]t• IIANDIE- ENO STILE OI LIEU OF 114 X 5/9-SMS With Window(;to Option _ $
11'-0' •52110N5 16.13 STCI°•S 11• -_
1'-6' 3 znroNs,e 4 SEcnaNs z+• TJS PRODUCT LS RA7m FOR TARGE MISSILE IMPACT DES(GN�PRESSURE'i(Wi1NGe+$PO�F$F
11'-9' x gL110 S le'S SEC00M]t' ° LOCK BAR GUMES 1 - "y �.E3DD{P$F` O� -
1 SECOOAS tr 6 ScmA 21• INSTALLED ON END SIRE
12'-3• T sEcnors z+"- Wren(4)114 X s/e•SMS GENERAL NOTES PRODUCT RENEWED .S a
12'-C 0 SEOMNS 1T 2 SU—S 11COm61Y1nR pifN TM Flotlda
S SRn0f4 10'J 5¢718.5 31' 4 taT%.SN IDOc 8M t THIS PRODUCT HAS BEENDESIGNEE AND TESTED TO L01L LY WIN THE 6u°difg�C'O�d
13' 4 SFDrA11s 10'♦527tNs 21 ENGAGES IN TRACK REOLVEV7A OF TY 2014(5m=FLORIDASL4DM CDCE Bx]NORNG NOA-No. 16-0330.02
IJ'-r J 5'TOMB 1e'S 5[CnANs 2,' ON FACN SMD-OF DOOR HIGH VELOCITYKKiVIE HURZONE
(RNQ).
IS-6' 2 iC7W16 10'9 5TT8s 21' 2 ANCHORS SMALL BE AS LISTED.SPACED AS SHOYM ON DETAILS. EwPMaOen OBI09120,'
iJ-x 1 SECTgN Iff 2 SECi°x5 21' OLI)SIDE KEYED LOCH(OPTIONAII ANCHOR EMBEDMENT TO BASE WATER-SMALL.BE BEYOND IYALL
14' Ie SECMIs 21'- LOO(OAR LOCNUNG SHCWN DRESSING OR STUCCO. By
IC T• a SECiKTS 1e"3 S611DI5 2f ALTERNATE TO SPW4G LOADED SLIDE DOLT 3 ALL BOLTS,KM AND VASVFAS SMALL.K IDN[PLATED CM9TN STEEL Prod4el�n4W LL Ls a k
1•'-6' 5 SDTOAS tr,SDTNVS 31 LDOOS SHOWY ABOVE V-
4. ANCHORING OR LGADING CONOTIONS OTHER THAN THOSE SHO"IN `TY:• �. '+r .T} $ 8 L U
1'-Y =§4
0'S SD:M.S 21' THESE DEALS ARE NOT PART OF THS AEFROVAL6'6 SrtM°NS Sr5. A LOAD°6mICN ENDRIASE 6 USED N DMCN Or MKM016 INTO 600]O L drewin no.
B'T SCCIXNS St' ' 9' a 5[C110N5 Z1TOM IN AOOHOAA E INH TF£RCOVREYERS a ROLA DMOF'1'- OHO CODE TAS-2m,W-201 s TIS-20T POI HNR '•••• • GO�-09
e•4 SECD8N5 I1' ASM E198Fi-09/0.514 E1995-09.
/ A�1 sheet 1 °}5
24 w 51&1 PANTE
]/te•KIIY RNEfS i � 1
FLAPS BENT OVER PANEL, F i
a` �o
DOE
1/2•PUNCITFD HOLES V C .m�j rk
.024'STL PANEL 0 4'O.C. !, C 0
OUTsm OF 000 NN Q d ¢ '..,
I 1
v o
STEEL TRACK BRACKET FASTENED SOLID BRASS DDOR VINER
TO wow JAMB ATTH BY'SCHLAGE SECURITY HARDWARE'
5/18'x 1-5/8•LAG'e" WSTALLED IN 9/16'ODA. EN
HOLES IN CENTER STILE
(MLT THREADED) END LE K EO
ONE PER BRACKET POSITIONED AT EYE LEVEL p i
AFCIIORS AT TRACK BRACKET: 0 n
OPTDNAL STOP YOUIDU:C W�
FOR CONNECTION OE W4//Di�:
BY DOOR INSTALLER LEN.S'BED INTO CCCNCREIE V Q
TO MASONRY SEE NOTE
!lax 5/e•Sld9 1-7/a•UK EDGE 06'VNCE
e PFR HINGE ]/4'x 7'x 2-1/2'Y 1e w SIECLHtO S1Fv Rr 1Nn7Y Z r VZi m
END STR[CONNECT 70 PANELS XTfll m
1/2'x 1-5/4•X.059•FORMED STEEL FIRS Arm 5/16•ALUM HIM 1-1/4'YN CL_°kD DlTO CONCRETE OR RLLED GLOCK < YL- 1
SOUTr1ERN PINECUfD TO fAV0.0.`m SECURED TO SEE DEMI.ABOVE 1-3/e'WI%EDGE DISRVCE ORO D..METE 2 IX
0.55 S.G. ENS STILE VATH 5/I6•FOP KMS 0 12'D.C. 4•AR EDGE DISTANCE oR0 FILLED BDt= UI O Z
1-7/8'x 2-5/8'X D45'STEEL EDGE CONCRETE rE.5000 M YIN. OGWED ANO RNETED S.xN�--r C-90 GRJLrr FILLED BLOCK rm-2=PSI MON.
TO PANEL w/(4)5/le'RMErs 1 1/2WN. 1 POP!ALTS s: I`
114 X 5/8•S.N.S. X11_7/I6 O
i.
-5/1s•, i @ @ 5 E
/.R
1.9•X 2.19'X 11x.102' Q IYA A WN B w tue
STEEL TRACK BRACKETS SNEET 8R4O(ET-1. u[4 W
SEE SHEET]FOR SPACING
OLS§4F
"WEEL 1/4-20 SS BCT @ NUT7-1/2'X.071•GLV.
CENTER NNGE 7-1/2'X 5'X 071• P g=
77/16- FTSECTION B-f3 END RO;LER HINGE R a
INTERIOR SIDE 1D2'DIA z sW STEEL ROLLERS(SrDJ PRODUyC1nT RENEWED I
STEM GA RX 2 1/B•X 1•(A,W¢Nm) 1.82'CVL x 30'NRDN ROLLERS(or%wN B.Udl mg.-i��Plwida
2.75•DIA X.50.511FL ROL1EFi9(OPDONAL) 7Lxi12
fASTwf7.TD TO TTNACKXFlAT62•(� 2.75'Wl%50'NYIDN ROLLERS(OPRONAL) NOR.-Nv. 76-0330.02
w/1/4-2D x s/B'mus lm. WITH 5.5T"° eapnnTm 00!092021 S :¢
SLATTED YS @ IDCK MLR
G .(�' drawing A(1O. j
Br "... yODN
4 IQ�N1141 eheel 0}§
2 X 2 x I/8'NORM ANGLE f• tai
2• _ /-'GP TOPES 5/16"X 1-5/8'LAG SCREWS INTO WOOD OF HOS.TRACK SUPPORT. SP W3LED 10 HORL TR CK V
I/ 2-3/4•%5-1/Y x 3•%.1G- 5/16-SLEETS N CNORS CENTER SUPPORT RmO.ON DOORS W H TWO WIj=AT 1-1/2"A-Ar. /� S
CALV.STcE1 WDM 1-1/4'EUdJ1 RAO Y/3CNRT QEED.IC 8 FT.IN HE)GHi. PIgST AT 3"O.C. ted I
TDP ROVER 6(6)0 T ON F5/.SDE 3 PER(L'iA[NET II A— REST AT 8'D.C.
_ EAs1tl'EO W/(6)d 1+z s/9•sxs. - _ H l CGWECIID r0 flAD BPAO�T a+'0.E ^ o
Aso THIL GLLV.STEEL AOIVS1ASLEE M]TOGS :SMNT GgpL7116Y_e CH.R�II n N
LID FASTENED TO BTdCI4T 2-1/2'X 4-1/4•x 13 C0.STEEL PLATES A—J (2)1/4-20%5/8'WLT a M•T F'°
W/55116WS18eX 3/4'NEX HEAD __ WELDED 70 1-1/2"x 1-1 FASfE M ANN/GLE -- Q 6 4
TOP 8RAC4 WTTH(4)1/4-20 SS.60.T a N� -- FOWL TRACK I.ENGM=OPENWG HZO(r PLUS 12' O O a
(STANDARD) a g g
BpAcm 0
TOPCWroNAL) YYOCAL
TRAGX O
LOPE HwR0DU DOOR 14 CA GAIN.STEEL TRACK 2-I/6-x 1'%.090• (.)O m
W NDRwRu REwcnxmfFAT SECTION A-A f7 xei}t
1/2"X 1-3/4'X.059'FORYED STEEL
GLUED TO PANEL AND FASTG:O TO 2"%5-1/2' .101• i Cl d 3j
•a CALV.SEE. W C LL m
(2)
VERTICAL STOP NETWITE! FASIFHm W 4) 1+x S/8'S.VS. (Y W 2
(2)J/16'POP RNEIS 4cP RdLun DOOR C TDR
leW HIADRDOY COOK CPTIOx DDDR LSECTION HEIGHTS BRACKET PIACEITEN75
HOPoZOATAL REINEORCFT!(M r H-MNTI1ST 2ND 3RD 4TH5THI BI 1 ICE 1 83 I B4 1 85 1 B6 I E7 I 88 Q W
%1-]/4'%A39'FORMED STEEL I !;-3 IB'18'18"TB"N/A 7'TO 2 11-3/9 23' 1 3a' 45' 56' 6Y -
GLUm TO PANEL AND FASTCIE TO
STILES 1YTF1 6'-6'121'18 18' TO 2'11-3/4" 2.T'
(2)]/16"POP RA'E1� 7'-D' 21'Ii'21'2I'N/AIT"TO 2-111-3/4-1 23' 34- S5' 56' 6Y -
7'-6' 18"18'18'18'18.1'b 2'I1-3/4' 23' 34' 15'
5/16'VEEN:C RIB 8•_-
O
1711,1'1
118'21't'TO 2'11-314• 23 34' 15 S6' 67'
1.82'DIA X.50"RULERS rr '-SECDONS ARE NUMBERED STAX104 AT THE BOTTOM ¢ m
Q W/•K CAL X 4-1/+'SNDJ r FOR DOORS MORE THAN B ff.HIGH.VSE ADDITIONAL TRACK BRACKETS AT 10.O.C. G n
O OPTIC—LNSDIAMNS: 3
TTY•OYP-ST FRDQ1Z c I I N I�1,S QQ ti
EPS-EIC
PO ANOm nlYREOIE 1.s'X 2.18'X 3]"X L90' F A I
a
09,M Its 1.0 PCF O STEEL TRACK SRAOQT5 E> _
N.OA dl1-0928.07 n 21/16-HRRi Z TO W$ 1
t OR L6VILLIED TO TRACK Wt t - Q in
50-25 POLr-I6aCYANURATE )1/4'BOLTS a IVM I o 0 3 h
DEIMN a 20 PGF i
G( N.OA 011-0926.60 0.
CR
-§ - O�EhSTn�ED40.T N MERE
DO
• A
n.OA d15-1203.01
DETrsm�0.92 PCF
NOA d14-011.08 I q t
O11 GALV.Sl
ROLLER FASTENED
W/(4)114 X I SY
QC
s/e•Sus
VW.X24'ROLL FORMED I=PANEL 6f I y
DRAWNG 0UAL1Y C-40
VJT.nm STRENGM-3+IED TRACK CONFlGURATON
WTTH PRIMER AXI P-:D-QN m $
POLTSTER PAINTED TOP COAT
. APPLIED TO BOM SIDES OF STEEL '1 '
�f 13CAL U HIGH U STANDARDLIET LOW HEADROOM
m� DOUBLE TRAGIC b'8=a�
AVAILABLE TRACK OPTIONS
I 12 G0.GAILY.STEEL
\11N
04 BRACKET FA%l
608Mil \\ fPffA i
W/ d14 X 5/6'SUS
PRODUCT
gRENEWED ••' �
J tIDTTOM BULL OPOONS Ng1493o. 76-0330.02
SEE SHEET 4 d
cIWMa1TTa1 taowo9lzo2� •D� ,y, •ac- .", ',
drawing no.
A20f8O!•.: 01—09
BOam a ProOuet Con W1 .$''••._..
BECTON A-A �Y�r��i� sheet 3 of 5
[S 10 4 taays \\t\Irr3 V yd M 6612 a Z/t356 D9 X WG) ®'fIf had GYM(-)bOBf31Nl n1m:XNn
N4a-0 NaPard W if,a!Wl rm-L/t19d DS%.we)-BIM'wd ami tf)tl mDa IB1W9
60—LO e
-a, 6uaDly ' dO 'Nau3dsM Noon 1Wxuo aaal%w
LZOZ160)80'f`a pd'g AS mioacdr aw mvmraa-D Lm r=TWISN %uooD%00M
'ON-WONa�
30 1LMMN3 ON NIM SONWMS JUGHM M MMWId3N NOM HUd
���low�av momma sa of 1NoddnS M 3NII MLS DWwddRT191S 30�07a
S NNDIA 9Ml Qllw AAMA M U3:IIOtf1 NO MOM 40 H33klaa NOHOnHL4XAl M3.N HOA
031W3N3N 101100Hd
b �In nl\\a
� 3ONVI5ID 3Om'NV).L/1-L
One maA N n.f/!-1 NDM'313ICN0] u nom Oa'00.8o
i 'ua 3S3'ran.f'a38n3 Nln.YIt-t NO TMA)lN M. lI13 S h'0 C
E E=S�s �� 1m5"DI A7if�M-Qj !0 DNdIdS NILN M./.B L8315 OL1.6/C
u v o c '? A J A75S35E�uH iP 4� 3oNVmi G3:YT.L
m u--' 0711075 3[35 ItTA lv SOAM las(C)/M Mara lUn.i/1-z NUM 71�LNOo sd 000C olv�0.fx
ION)IJgI 9 5'� l I/ 310*'INO]of WM3M10J ]O Ot¢ria OSA I've KiLnN��c
'ON S &.9 SMOL-f 1 L M 'ONdO 9000 WeY'TO JN 1V '%M 70.Zl!tl
S31VN}]tlH!of m 'll `SMO NOW M 7D.ZI 1V saue 13Tu
'd•8 NJYtlI Mie'((..m /1-Z%.9l/1 3OAYL4f1 39m NW-C
ry 17 11 X.!0113U
.9/i_L OXOI ST SLVOPNB 1W � mala'yIn.f/C-1 NLM'313tl =6e 000:O1M'O0.91
PER T1115'Am 10 Ll i a'iA 11P.L/t-1 A1q•Il1'M%SOii C3TTU MONO Wd 7U.VL
l0 ONI:Vas ILLMI SealOd.As a3ddV1.f/l
9 k' .r/l-1. 31^1N Ti35�OO 3OMVVW 3Sm•Mn.L/1-z
m 9 a , MEA'yR1 f/C-t�A 313tl�+OS 6d OOOC OIM'OV.al
MW
i _ 3 meA .a/l-L N1M TWA%:019 03TL!L 9 DNk O'0.9l
a ' l0 ON.NLM,OSIS,Afi NOS/No .f/t
IF•--�11 •I N1J0 So ms YO TYM 00 A!MOA11 CaLY3:BN MSMd
1 QI
OWN"S/ a 1M6 HN4m SEhn OMtl d 5 9%i m1V3Nl 3 9i}d
�� 1510 3003 1fIN v 83NS1^A HIMJ •l
2 j D NW 6d OML�wJ JUDl3 mlA!UIONO 09y st10N 1N0 yl/s ..� �•
{g,,N TB'1 ISd MDC=•J 31snNDa
1-1 Z 1-1 "ONM �4lCSA, l8 TN-3A'3L B C AL45 tlW0 l8 'O'0.il 1V
-mAi 9 L-1 .B .L 7HM Ia 110a-N.3.VDd 9 C 03so h1 SO\91 3W moHn 150TH
SSw3n>5 On U5
s 2 p N m m 2nL^n 11315
O ♦l-Z .9 Z l-t JWIa D3P(f A8 LWBVNM.9 C
m M .e L l-1 'SNCS AtO A8 I'�OaMLO.9 C
u Il1H.A8 3A3315 TM.9 C
B•S-1 ,a f l-t ':Nm TH A8 3A3315 011olt+ e c
ty1 'ISa 3003 OtiOXdi 039A 3Gn1O1N15 S3MXaM/ NON33d5M HOBO TL1110 M Sllfl3 3HL An O3 AMVl CAY G Lf
C) 9 OnTJVdS Npa.\V 33 AM rCLLViTv1911'ONOS3tl]0 OHOW 3 ON KOM 4\JO h5 M 11lTitTiV1,O M!'OJ
ONVNOHDNV 0000 3'Jt'tPo:1]0 h tL X NO]UZWISH 38 OL
m N'YS30/SNp1Vll1S1Y]IVN S M ON AS On
S 3NV sAOSY 1 3531E Al'S3ML_IV Nl Ol
4 O lN3RAYlltl Y�la MOM dLS 9rtL SMDNs 3N]aV N90H5 SOONL3W NOIItlTTl1SM 3LL
fNm ss'O.SS Annvao ZU03ds DOOM)IMMEJASo _ H
m 0
:H-FbLdS �AB�S
o �Dsc1— Li osn—y
g py=D arc
r 40"all 0. tts•
ON W ONEdY15M 8s11(IN omwo LSR icsaH
a�@ 0
AoO lr 0 03."ear en _-_ WnN^I111V 1 I
A 1--
H31dVOV d L"
o 2.�C I 1Ml'0'O.sl cm ' l ne aMM xrn�O.51 aw !ft 1 I ne DaaM
-D 0 9 sma 0MA.9 1V San"W.9 1V
iI SM3!!JS DVI VIO,1/l '� SH3lI]s OYI YO.Y/l �
O
u^o O O 1AM
3315 m�jl X,al
u 3 n 70.BY 1V lA][3rH03lfltl j i £
L
3.00/M'Imlon 70 S
Qa11 ..LV g N
C•�' SL'UQI 13315
'Um..91/c Of311 3NM/M-mO n
0 3115!9 SOM 1 .X3N8..91/C o s '=O 3 m
c Z .sm-DNIl1UJD J1S HO I 'NW.Z/l-1
.1 xo ONT20 fL35
.I%9/ jm
.950'X•IA
i-L C.3fv/M .f C
4
*PLASTIC COMPLIES W.TH l�wEE
oocR PAra CHAPTER e6 OF FBC W q
24 M(M24)STEEL M. SEE EVirENCE PAGE
LtI "v
1.70 1.725 F g
D`D
-7/I6'CIA nASNFR I t,1µ MCI y
D pf 4
( is x 3/4•SMS 21 3/4' IIz a
ITTD S/9'{AOU DmS .W .176�i
1--,fiaD a a a
,UID 7'O.G YNC NOW.NNM 0 a O
� *�IQR FRAME * M7FRIOR FR4b!E
Ili! 11\ (a)is x]/a•Sld i to RIGID PIC ONE F:ECE INJECTION 16GID PJC ONE PIECE IA.IECTION Q B
A FROV ENDS -1
AND 6-1/2'O.G L•Ax. g D 010.
.175 i.062 DCEP
GAOOJE
IIII 1/4P mvtSONAIE l 4
INNO✓AF
TIYE csr 1 V Q LL
AOA mW.
oIli Z�FE6 atl
J �f III e p
IIII V Q Z S gi
.D
III 1 O
IIII
In x.0620a - g
cRocvE
Ii I mil (4)is i 3/4•sus ON
RAISED PANEL EM
0 1_3/5-FK.ENDS INSIDE ELEVATIs q
BOSSED DOOR YfITi(OPTIONAL WINDOWS
ASID 6-1/2.0.0.MAA
C WINDOW LTTES CAN BE IN ANY LOCATION 14 DOOR SECTION
OI I /fix GM sus
B % f D-I/FROY ENDS O R5 X.082 DEEP all.aw 4-1/z•aG uAx. Gx 3/.'Susu 3/a•m ves -- -
AMI
7'0L W. - -_ ---
PRODYOT RENEWED `J
FlOrlda
NOAH. 16-0330.02
P' EXTERIOR E pI,.0 oD 06)002021 *—,t;,
zs at(024)slm M
DOOI1 P(= 15/16'Uu1 OL ppG BY OP drawing M.
24 G(.024)STEEL Y01. cIAZNG BRENoun PnOuel Covtml Ogq%,.:3•�ztr 01—1
SON x>mx I IOPoAI`; rah $pft
These Tables Are For GARAGE DOORS IN
One and Two Family Dwellings
Garage Doors Installed In Buildings with a
Mean Roof Height of 30' or Less Located in Exposures B,C or D
Table R301.2(4)
COMPONENTS AND CLADDING WORST CASE DESIGN PRESSURE [PSF]
❑160 EXPOSURE B 9'x 7' Door =+26.7 -30.2
r-11 60 EXPOSURE B 16'x 7' Door =+ 25.6 -28.5,
❑160 EXPOSURE C 9'x T Door = +32.4 -36.6 (1 story and max 15'
M1 60 EXPOSURE C 16'X 7' Door = + 31.0 -34.5 mean roof height)
❑160 EXPOSURE C 9'x 7' Door = +37.4 -42.3 (2 story and max 30'
❑160 EXPOSURE C 16'X 7' Door = +35.9 -39.9 mean roof.height)
❑160 EXPOSURE D 9' x 7' Door=+39.3 -44.4 (1 story and max 15'
M1 60 EXPOSURE D 16'x 7' Door=+37.7 -41.2 mean roof height)
❑160 EXPOSURE D 9'x 7' Door=+44.3 -50.2 (2 story and max 30'
M1 60 EXPOSURE D 16'x 7' Door=+42.5 -47.14 mean roof height)
®150 EXPOSURE B 9'x 7' Door = +22.8 -25.8
F11 50 EXPOSURE B 16'x 7' Door =+21.8 -24.3
❑150 EXPOSURE C 9'x 7' Door=+27.6 -31.3 (1 story and max 15'
❑150 EXPOSURE C 16'x 7' Door= +26.4 -29.5 mean roof height
❑150 EXPOSURE C 9'x 7' Door=+32.0 -36.2 (2 story and max 30'
❑150 EXPOSURE C 16'x 7' Door= +30.6 -34.1 mean roof height)
❑150 EXPOSURE D 9'x 7' Door = +33.6 -38.0 (1 story and max 15'
❑150 EXPOSURE D 16'x 7' Door =+32.1 -35.8 mean roof height)
❑150 EXPOSURE D 9'x 7' Door = +37.9 -42.9 (2 story and max 30'
❑150 EXPOSURE D 16' x 7' Door = +36.2 -40.4 mean roof height)
Notes:
■ Secure existing bucks per the Product Approval or Design Professional
Instructions prior to installing the door. Have product approvals
available at the time of inspection.
■ Glazing in Garage doors must comply with R301.2.1.2 (Glazing must
be impact resistant or shuttered)
These Tables Are For-GARAGE DOORS IN
One and Two Family Dwellings
Garage Doors Installed In Buildings with a
Mean Roof Height of 30' or Less Located in Exposures B,C-or D
Table R301.2(4)
COMPONENTS AND CLADDING WORST CASE DESIGN PRESSURE [PSF]
❑160 EXPOSURE B 9'x 7' Door =+26.7 -30.2
❑160 EXPOSURE B 16'x 7' Door =+25.6 -28.5
❑160 EXPOSURE C 9'x T Door = + 32.4 -36.6 (1 story and max 15'
❑160 EXPOSURE C 16'X T Door = + 31.0 -34.5 mean roof height)
❑160 EXPOSURE C 9'x 7' Door = +37.4 -42.3 (2 story and max 30'
0160 EXPOSURE C 16'X 7' Door =+ 35.9 -39.9 mean roof height)
❑160 EXPOSURE D 9'x 7' Door=+39.3 -44.4 (1 story and max 15'
❑160 EXPOSURE D 16'x 7' Door=+37.7 -41.2 mean roof height)
❑160 EXPOSURE D 9'x 7' Door=+44.3 -50.2 (2 story and max 30'
❑160 EXPOSURE D 16'x 7' Door=+42.5 -47.4 mean roof height)
OEM* ®150 EXPOSURE B 9'.x 7' Door = +22.8 -25.8
F11 50 EXPOSURE B 16'x 7' Door = + 21.8 -24.3
❑150 EXPOSURE C 9'.x 7' Door=+27.6 -31.3 (1-story-and max 15'
n1 50 EXPOSURE C 16'x 7' Door=+26.4 -29.5 mean roof height
❑150 EXPOSURE C 9' x 7' Door=+32.0 -36.2. (2 story and max 30'
n1 50 EXPOSURE C 16'x 7' Door= +30.6 -34.1 mean roof height)
n1 50 EXPOSURE D 9'x 7' Door = +33.6 -38.0 (1 story and max 15'
❑150 EXPOSURE D 16' x 7' Door =+32.1 -35.8 mean roof height)
❑150 EXPOSURE D 9'x T Door = +37.9 -42.9 (2 story and max 30'
❑150 EXPOSURE D 16' x 7' Door = +36.2 -40.4 mean roof height)
Notes:
■ Secure existing bucks per the Product Approval or Design Professional
Instructions prior to installing the door. Have product approvals
available at the time of inspection.
■ Glazing in Garage-doors must comply with R301.2.1.2 (Glazing must
be impact resistant or shuttered)